What 979 owners told NHTSA about the 2015 Ford Focus Bev

My car is not currently drivable. It has stalled on the freeway which is unsafe. I had to drive it to a dealership with my car stoppable multiple times. I’ve had it at a Ford dealership and they are unwilling to pay for the clutch. The clutch had an extended warranty through Ford and I ran out of the extended warranty by 20K due to being able to take it in sooner due to it being my only car and the pandemic. I feel that this is on Ford due to it being a safety concern and not being drivable. They had an extended warranty because the clutch on these specific models has been faulty and I already had it replaced 5 years ago. I feel I should be compensated at least for the clutch and they are refusing.

NHTSA ODI 11464209

When taking off from a stopped position, such as stop sign or light, car stutters/stalled like jumping. It only does this in first gear, once it has shifted into second it continues to shift fine. However, once back in first gear it does it again. I fear that it will stall completely in first or power way down as I’m pulling into traffic, very likely causing a collision. This is a continual/daily occurrence. The date I specified for date of incident is just a general idea of when this started.

NHTSA ODI 11463990

The contact owns a 2015 Ford Focus. The contact stated that while attempting to accelerate the vehicle, the vehicle failed to shift into gear as needed. The vehicle then stalled with the check engine warning light illuminated. The vehicle was diagnosed with transmission failure by several independent mechanics. The vehicle was taken to the dealer and diagnosed the vehicle with transmission failure. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 90, 000.

NHTSA ODI 11463052

Transmission slips jerks shakes when trying to take off. It will not pick up speed until it's in third gear,. This car is not a manual it's an automatic transmission. It was taken to a Ford dealer and we were charged money and told that it was fixed. This Is a 78-year-old womans car. She was unaware that the vehicle had an issue. The car only has 62,000 miles on it and is a 2015. And it also has a warning light that comes on when you drive with the AC on or on hot days or if you drive longer than a few miles a warning light comes on and tells you to pull over and that the car is overheating. Both of these items I'm listing are very dangerous especially when getting on an interstate or pulling out in traffic. I don't know if it's an electrical issue with the overheating light coming on but the radio has also stopped working. The transmission definitely has a safety issue. I'm afraid of driving very far because of these two issues.

NHTSA ODI 11462782

Violent shaking, not starting , feels like it’s switching gears while driving. Was told may be clutch b actuator motor , started as soon as purchased car and has worsened. Rpm randomly revving

NHTSA ODI 11461939

The contact owns a 2015 Ford Focus. The contact stated while driving at various speeds, the vehicle stalled with the check engine warning light illuminated. The contact stated that the vehicle failed to operate as designed with the fuel tank half empty. The vehicle was taken to a dealer and diagnosed with a defective canister purge valve and provided an estimate. The contact was also informed that her vehicle had been serviced under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) and that she no longer qualified for a free repair under the recall. The manufacturer was notified of the failure but offered no assistance. The contact was then referred to the NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 30,000.

NHTSA ODI 11461788

after fueling the 2015 ford focus.Car is very hard to start and when it does start engine runs rough spits and sputters.Check engine light is on had diagnostic done, code was evap problem. was told problem was canister purge valve. no recall that i know of on this issue. this is very concerning because my wife drives this car hauls our grand kid and very elderly mother this should be a recall. THIS IS ALSO A VERY SERIOUS SAFTY ISSUE!!!!!!!!!!!!!!!!!!!!!!!!!!! thank you.This is not the first time this has happened. fifth to sixth times. ford needs to man up on this issue.

NHTSA ODI 11461095

The contact owns a 2015 Ford Focus. The contact stated that while operating the vehicle, the vehicle would inadvertently lose motive power. On several occasions, the vehicle would not immediately restart. Additionally, while idling the RPM would erroneously increase; and after refueling, the vehicle would occasionally not restart. The vehicle was taken to the local dealer who diagnosed that the canister purge valve was faulty and needed to be replaced. The vehicle was not yet repaired. The contact indicated that the vehicle was previously serviced under the NHTSA Campaign Number 18V735000 (Fuel System, Gasoline). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 143,000.

NHTSA ODI 11460633

The contact owns a 2015 Ford Focus. The contact stated that while his daughter was driving at various speeds, the vehicle would stall with the check engine warning light illuminated. The contact stated that an unknown dealer was notified of the failure and informed his daughter that vehicle was included in an unknown recall. The contact’s daughter was informed by the dealer that parts for the recall were on back order and she was advised to leave the vehicle in their possession however, the driver declined. The manufacturer had been notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 88,000.

NHTSA ODI 11459915

The contact owns a 2015 Ford Focus. The contact stated while driving approximately 40 MPH, the vehicle lost motive power and stalled. The contact stated that the check engine warning light was illuminated. The contact shifted into neutral and restarted the vehicle. The contact took the vehicle to a certified mechanic who diagnosed that the evaporator system had failed. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA. The approximate failure mileage was 35,000.

NHTSA ODI 11459201

Car studdering and shuts off. Transmission seems to get hot and causes car to shut down. After a few minutes can restart car and go again. This seems to happen more if the car stops and goes alot.

NHTSA ODI 11458920

The contact owns a 2015 Ford Focus. The contact stated that while his daughter was driving at an undisclosed speed, the steering wheel was difficult to maneuver. The vehicle was taken to an independent mechanic who diagnosed the vehicle with steering rack failure. The mechanic informed the contact that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.

NHTSA ODI 11457790

I was driving down the highway and my door locking latch and cable failed. The door came open going 75 MPH.The defective dealership part I found out is the subject of recalls on other Ford Focus year models but my model was left off the recall. This is a huge safety concern as my door is unable to lock at all times including highway driving.

NHTSA ODI 11457382

The contact owns a 2015 Ford Focus. The contact received notification of Customer Satisfaction Program Number: 19N08 (Transmission Clutch Warranty Extension). The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. Additionally, the vehicle was not able to reverse. The check engine warning light and transmission failure warning message were displayed. The vehicle was taken to the dealer, but the dealer informed the contact that there was no recall associated with the VIN and she had to pay out-of-pocket for the repair. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

NHTSA ODI 11457320

1. Fluctuating fuel gage. 2. Car stopped while driving on highway multiple times. 3. Rough Idle and hard to start. DTC code P1450 is displayed. I went to the Ford dealership for 18S32 Recall and I was charged over $ 400 for recall to be performed. I did show them the Safety Recall Notice-18S32. There was not a crash but I went from Middle lane on GSP to right most lane and a nice lady slowed down to let me pull over to the shoulder. This could have been an accident. How can Ford dealership refuse to perform this recall and charge customers over $ 400? I will have to scan and upload the bill tomorrow.

NHTSA ODI 11457160

I received a P1450 Code on my Ford Focus ST Accompanied with a CEL, after researching there seems to be a issue with the purge valve and not displaying gas levels correctly. It is available for inspection, I am concerned regarding this issue because I want my fuel levels to display correctly, and if I stall on the road I want to be able to reactivate my car without any issues. The issue is reported on a engine code recording device. There was a Check Engine Light.

NHTSA ODI 11455970

When moving forward from a stopped position, the front tires shake/stutter which requires you to let up on the accelerator and move forward at a lesser speed to stop the shaking/stuttering. Also while the engine is warming up, the transmission is slow in changing gears, and in some cases it doesn't feel as if they change at all.

NHTSA ODI 11455471

The transmission control module was the first to be replaced when the car began to shudder upon acceleration from a complete stop. Took to Ford Dealership where it was replaced under recall warranty. In 2020, was driving on highway and merged to an exit when at a red light then green car would not move forward. Car was turned off and on and nothing. Was stuck in the middle of an exit ramp for about an hour until I messed with the clutch and made a popping noise and began to move. Took to Ford dealership and the power train clutch was also replaced. Notified that there was a recall on that part again. Thought problem was fixed, car began to shudder again. It is 2022, the shuddering is really bad again. Took to ford dealership once again, car no longer falls under warranty because of mileage (I am just over 100,000 miles) and it is the dual powershift clutch again (the same one on recall) just almost two years later and they want almost $3000 to replace.

NHTSA ODI 11454608

The contact owns a 2015 Ford Focus. The contact stated that while driving approximately 10 MPH, the key fob was inadvertently touched and the rear lift gate erroneously opened. The contact indicated that the fob was not pressed twice as needed to open the hatch. The cause of the failure was not determined. The manufacturer and local dealer were notified and the contact was informed that the vehicle was not included in the NHTSA campaign number 16V698000 (Latches/Locks/Linkages, Structure). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 15,000.

NHTSA ODI 11454715

My vehicle is having issues regarding the clutch and transmission module. This issue has been going on every since I bought my vehicle new in 2015. The last time they fixed the issue (free) was in May of 2020. When I went to the dealership where I bought my car and where they have replaced this issue, I was told that they will have to charge me to diagnose the problem. I told them that they never charged me before and the issue it’s having is the same so why today are you charging me? They said that it’s because it could be the clutch issue that’s not covered. However they have fixed the clutch issue before in which that time was May 2029. The for recall for my vehicle is 18V169000 to be fixed up to 150,000 miles my vehicle has 102,000 miles. Another recall that I looked up is 18S07 which is regarding the clutch. Website https://www.cars.com/research/ford-focus-2015/recalls/ So why will they not fix my car when both recall # say they will be fixed at no charge to me.

NHTSA ODI 11453715

My car‘s check engine light came on, then the whole car suddenly shut off while I was driving down the highway. After getting it restarted, I filled it with gas and after beginning to drive it, the car shut off again. I have run a code on the check engine light and it stated that the EVAP hose needed to be replaced. I called the dealership and they said that it was likely the CVP as this caused the same issue and multiple vehicles were having to have them replaced.

NHTSA ODI 11453246

Two part lug nuts experience swelling over time and make removal of the lugs very difficult and may result in the lugs not being adequately tight when the wheel is put back on. The dealer confirmed that this is a known problem and when they repair this issue, they use an after market lug that is not a two part lug, and therefore doesn't have the swelling issue. I was not aware of this problem till my most recent annual inspection and when I expressed surprise, the dealer mechanic stated that even though Ford is well aware of this issue, Ford will not cover this item and its the owner's problem.

NHTSA ODI 11453269

My vehicle began making loud rubbing noises when turning and then in addition, progressed to having trouble steering. I took it to a shop that advised me that I needed a new rack and pinion steering system. I took the vehicle home and when I went to get return to the garage to have it replaced, the car would not turn at all except with extreme force; I had to have it towed. I had to pay for an entire new rack and pinion steering (and labor) and for the front end to be aligned after. I checked and even though there are numerous complaints, there is no recall.

NHTSA ODI 11453136

The contact owns a 2015 Ford Focus. The contact stated while her son was driving approximately 20 MPH and depressing on the accelerator pedal, the vehicle started to shudder. The contact stated no warning light was illuminated. The driver was able to continue driving to his destination. The contact took the vehicle to the local dealer, where it was diagnosed with needing the transmission clutch assembly to be replaced. The vehicle was not repaired. Upon investigation, the contact became aware that the vehicle was serviced under NHTSA Campaign Number: 18V169000 (Power Train) in 2019 under the previous owner. The manufacturer had been informed of the failure. The failure mileage was approximately 130,000.

NHTSA ODI 11452703

While returning from vacation, my transmission failed with only a displayed message that the transmission was hot and to stop for 5 minutes. I immediately pulled off the highway and parked the car for 15 minutes. The message cleared and I proceeded to drive about another 15 miles and the car lost power to the transmission while in traffic on the interstate. I had to make a lane change and pull off the road. Fortunately I was close to a vehicle repair facility so I drifted to the facility. They immediately evaluated the problem and I was told the transmission had completely failed, which apparently is an issue that Ford was aware of during manufacture. This failure could have caused a crash because I had to switch lanes with perfect timing to prevent an accident. The repair facility contacted a Ford Technician about a mile away who came and tested/evaluated the transmission and confirmed that it had a total failure. From the first warning message until the complete failure was within a ten minute period after allowing the first warning message to clear from the 15 minute cooling period. I am still waiting on parts and repair bills as of 02/09/2022. They will be forwarded as received. This will be the 3rd transmission installed on this vehicle.

NHTSA ODI 11451278