What 295 owners told NHTSA about the 2015 Ford F-250 Supercab

The truck has “death wobble“ or steering oscillation. When travelling on any road between 55 and 75 miles per hour, the truck will shake violently when you cross a bridge, train tracks, or imperfections in the road. You must nearly come to a complete stop as quickly as possible. It is difficult to turn or stop while this is happening. My vehichle has been well maintained and only has 105k miles. The death wobble started at 32k miles and Ford said this was normal. This is very dangerous and unsafe.

NHTSA ODI 11518393

I drove thru a groove in the pavement at bridge at 60 MPH and it started shaking violently, I almost lost control of the truck.

NHTSA ODI 11515396

The contact owns a 2015 Ford F-250. The contact stated while driving 50-65 MPH, the vehicle experienced the death wobble, almost causing the contact to lose control of the vehicle. There was no warning light illuminated. The contact depressed the brake pedal and came a complete stop. The contact was able to continue driving; however, the failure reoccurred several times while driving. An unknown dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 92,000.

NHTSA ODI 11510996

On 4 separate occasions over the past 2 months, the vehicle began to shake violently at highway speed, 60-65 mph, after going over a minor rough surface of roadway, The first 3 were on state highways, with the most recent and most violent on US67 heading north through Duncanville TX. The shaking is uncontrollable until speed is reduced well below safe travel speeds and caused me to get to the shoulder and exit the highway at the first opportunity. I first thought it might be a bad shock/strut, but just read about a known condition called “death wobble” which perfectly describes the phenomenon I experienced.

NHTSA ODI 11509623

Truck will begin doing the Death Wobble on the highway with speeds around 60-65 mph. Cab and steering vibrate vigorously causing loss of steering control.

NHTSA ODI 11509295

While driving between 50 and 60 mph the steering wheel begins to violently shake until you slow below 50 MPH. This is known as the Death Wobble.

NHTSA ODI 11499198

I have experienced a "death wobble" on 2 occasions in 4 weeks. The truck's front end uncontrollably bounces when driving on the freeway causing me to have to immediately let off the gas and gently brake causing a dangerous situation not only for me and my family but potentially for others on the road.

NHTSA ODI 11496979

When driving over speeds of 50mph or after driving over bumpy/ wavy roads, the truck starts shaking violently. It was bouncing so hard it almost shook the steering wheel out of my hands. I had to completely stop and pull over off the left side of the interstate. This has happened multiple times.

NHTSA ODI 11495868

I was driving at approximatelly 60mmph when the left front end starte shaking and vibrating so bad I could not keep it on the road. Luckly it was a two lane road with an emergency lane. when I came to a stop the vibration and shakinf stopped. I took it to the ford dealership. They told me I needed frontsuspension tie rods, ball joint assy shock absorbers drag links . Plus $1,156 dollars labor. Told me the truck was fixed to come and get it. They test drove it 5 miles. I picked it up. I had an appointment to go to. I went to it, and on my return the truck did the same thing on my return, this time it pushed me into the right hand lane, barely missing a car beside me. The drive stopped and asked me wht the hell as going on.. I explained and he said you better get the damn thig fixed. This was a Friday night. I parkd it and took it back to the dealer Monday morning. They did not beleive me. I took the tech on a drive, it happened right where it happened to me. I drove back a different way to the dealership to avoid the freeway. I happened again on this road. They went back to work on it. This time they installed a dual steering stabilizer, another $842 dollars, no charge for labor after i bitched. As a 30 year degreed mechanical engineer with years of buying and having machines and equipment repaired I beleive the first fixed the effects of the issue and then with the stabilizer hopefully fixed the cause. There was no warning it just happened out of the blue. I haveread up on th death wobble, and feel lucky I did not get killed.

NHTSA ODI 11495499

I was driving at approximately 55mph when my Ford F-250 started violently shaking. I had a difficult time steering it and almost crashed.

NHTSA ODI 11494674

Violent shaking in front end (commonly referred to as “ death wobble”) usually associated with hitting a rough spot in road. Happens between speeds of 50-60 mph. Ford replaced steering stabilizer under a service bulletin and it did nothing to help. Tires have been replaced and tire rotation is done every 5,000 miles. Ford acts like there is no problem but there is a serious and dangerous one. This has been a problem with the truck since it was bought brand new in 2015

NHTSA ODI 11491878

I have been experiencing what is known as the Death Wobble. The death wobble is a violent shaking that happens to the front end of many Ford F250 and F350 Super Duty trucks. It typically occurs at speeds over 50 miles per hour. It can also happen after going over bumps or grooves in the road. To stop the shaking, drivers must quickly slow way down or even stop completely. In addition to the shaking potentially causing the driver to lose control of the truck, slowing or having to stop on fast-moving highways also puts both truck occupants and other vehicles at risk. I have taken this Vehicle to NTB for repairs and even had new tires put on in the event that was the issue. They have replaced all the steering linkages, tie-rods, ball joints, etc dealing with steering to no avail. I have taken this pickup back into the repair shop on 10/24/2022 once again as this has made me have to stop on major freeways to get the wobble to stop. This is putting me and others in danger.

NHTSA ODI 11490544

The contact owns a 2015 Ford F-250. The contact stated that while driving approximately 60 MPH, the vehicle suddenly experienced a death wobble causing the vehicle to violently shake and vibrate. The contact indicated that the failure occurred while driving on a smooth and level roadway. Additionally, the vehicle had not driven over any bumps in the roadway prior to the failure. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 103,000.

NHTSA ODI 11489250

after hitting grooves or holes in the road the vehicle vibrates violently, known in the industry as the Ford Death Wobble. It's getting progressively worse. It makes lane control very difficult and often times requires immediate braking which causes a hazard on the highway to those following behind in addition to sudden lane departures caused by pulling forces.

NHTSA ODI 11489266

I was driving 65mph on I16 to get on I75 in Macon, GA. The truck started shaking as if I had blown all four tires. After taking it to a repair shop, I was told it is called a "Ford Death Wobble."

NHTSA ODI 11487613

The vehicle violently shakes at speeds above 60mph. I must abruptly slow down on highway or come to a complete stop. This is dangerous to me and other drivers.After further research I have found this issue has caused serious injury and death.

NHTSA ODI 11486971

Death Wobble again after repair at 200,000 miles at local Ford dealer.

NHTSA ODI 11485982

When I hit any kind of bump in the road, especially when you change lanes the truck shakes so violently you have to slow down to about 10 miles an hour to get it to stop. This has been happening for years & on a few occasions it almost caused an accident. On one occurrence it was so bad the truck shook me off of the highway. This is an ongoing issue, I have tried many repairs to try to alleviate this problem with no luck.

NHTSA ODI 11481984

The contact owns a 2015 Ford F-250. The contact stated that while driving at various speeds, the contact experienced the death wobble. The contact stated that the vehicle shook violently after driving over and unknown object on the roadway. The contact stated that he had previously taken the vehicle to an independent mechanic for repairs to address the failure. The contact stated that several front-end components were replaced; however, the failure returned over time. Neither the dealer nor the manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 100,000.

NHTSA ODI 11480953

Unable to steer, vehicle was wobbling almost losing control while on highway vehicle began to bounce side to side.

NHTSA ODI 11467790

The contact owns a 2015 Ford F-250. The contact stated that while driving approximately 60 -75 MPH, the vehicle experienced the death wobble. The contact would aggressively apply the brakes to reduce the speed to 25 MPH. The contact took the vehicle to the dealer who replaced the drag linkage, track bar, tie rod ends, stabilizer, and bushings. The failure had progressed since the repairs. The manufacturer was not made aware of the failure. The approximate failure mileage was 135,000.

NHTSA ODI 11462742

The contact owns a 2015 Ford F-250. The contact stated while driving and exceeding 55 MPH, the vehicle would shake abnormally. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who diagnosed the vehicle with an unstated linkage failure. The vehicle was repaired. The contact stated that the failure had reoccurred. The manufacturer was not notified of the failure. The approximate failure mileage was 37,000.

NHTSA ODI 11462560

The contact owns a 2015 Ford F-250. The contact stated that while driving at high speeds, the vehicle experienced the death wobble. The dealer was made aware of the failure; however, the vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 110,000. The VIN was unavailable.

NHTSA ODI 11462050

For about the last 12 months, my truck has what they call the death wobble. This is happened continuously at speeds of 40 to 60 miles an hour and sometimes even takes me off the road and I have to pull over and stop. In addition, I believe the brakes went out due to the continuous wobbling

NHTSA ODI 11461757

DEATH WOBBLE. I experienced the death wobble for the first time a few days ago on a road that I drive twice a day. This road has bumps in the road when you are heading west, but I was heading east and have never experienced any kind of steering issue when traveling that direction. The truck started shaking as the front springs and shock absorbers were fighting against each other. The steering wheel was uncontrollable. The only way to stop the wobble was to slow down to a near stop. Ford needs to issue a recall on this issue, as it is a safety hazard to the driver, passengers, and other vehicles on the road.

NHTSA ODI 11457670