What 267 owners told NHTSA about the 2015 Chevrolet Malibu Hev

MY VECHICAL WAS IN MOTION DRIVING THRU AN ENTRANCE TO AN ARBY'S RESTAURANT . I HERD A LOUD NOISE N FELT LIKE MY VECHICAL WAS DRAGGING WITH A PULLING MOTION. WHEN I STEPPED OUT I WALKED AROUND TO THE FRONT N MY BUMPER WAS COMPLETELY PUSHED IN AND FOLDED INTO AN INWARDS POSITION. I PULLED WITH MY HAND FROM THE BOTTOM OF THE BUMPER AND PULLED IT OUT ALMOST IN ITS ORIGINAL POSITION BESIDES SOME OF THE PLASTIC PEICES N FASCIA BEING CRACKED. WELL UPON FURTHER LOOKING AT IT WHAT HAD HAPPENED WAS THE PLATE OR COVER AS U WILL THAT IS SUPPOSED TO PROTECT UNDERNEATH THE ENGINE AND RADIATOR PORTION OF THE VECHICAL CAME DETACTCHED FROM THE MOST INWARD POSITION OF THE VECHICAL( THE POINT CLOSEST TO THE CENTER OF THE CAR) HIT THE GROUND N FOLDED UNDER NEATH MY CAR SMASHING IN THE LOWER PART OF MY BUMPER. ONCE I LOOKED UNDER THEIR THIS PIECE IS ACTUALLY CONNECTED TO THE BUMPER IN ONE PIECE WHEN IT SHOULD BE DETACHED. THIS VECHICAL IS A VERY BAD DESIGN AND IS EXTREMELY LOW TO THE GROUND AND WHAT MAKES THIS BAD IS THIS PIECE IS CONNECTED DIRECTLY TO THE BUMPER WHICH WAS ALMOST COMPLETELY RIPPED OUT IN THE PROCESS. CURRENTLY I HAVE THIS END PIECE ZIPPED TIED TO MY FRAME AT THE POINT OF WHICH IT BECAME DETACHED. I APPROACHED THE DEALER ABOUT THIS ISSUE N THEY LAUGHED AT ME LIKE I DID THIS WHEN CLEARLY IT WAS FROM THE COVER OR PLATE THAT SITS BELOW THE ENGINE. THIS PART IS A 79 DOLLAR PART BUT THEY WANT ME TO REPLACE THE WHOLE FASCIA N BUMPER WHICH THEY QUOTED AT AROUND 1500 DOLLAR. NOW IF MY BOTTOM FRONT HITS ANY DRIVEWAY OR ENTRANCE WAY CAUSE OF THE TWO LOW OF A DESIGN THIS PART CAN COME DETACHED FROM THE FRAME AND RIP MY BUMPER RIGHT OFF CAUSING A MAJOR ACCIDENT OR SAFTEY SITUATION. TY! FOR LETTING ME VOICE MY CONCERN NOT SURE U CAN DO ANYTHING ABOUT IT. BEING KNOWLEDGEABLE ABOUT CARS WHICH I'M GUESSING U R IT'S THE PIECE DIRECTLY UNDER MY ENGINE N I ATTACHED DIRECTLY TO THE BUMPER.

NHTSA ODI 11030022

I PURCHASED A CERTIFIED USED 2015 MALIBU LTZ FROM A CHEVROLET DEALER IN JANUARY 2017 WITH BRAND NEW GOODYEAR EAGLE RS-A TIRES INCLUDED. TODAY, AUG 16, 2017 (AND WITH JUST UNDER 10,000 DRIVEN ON THEM), I NOTICED A BULGE COMING FROM THE OUTER WALL ON ONE OF THEM. THE TIRE SPECS ARE: P235/50R18, 97W. THIS IS CONCERNING TO ME BECAUSE IT IS A SAFETY ISSUE. PICTURES ATTACHED.

NHTSA ODI 11015838

THE SEAT IS STUCK IN PLACE. I CANNOT MOVE IT FORWARD OR BACK

NHTSA ODI 11012981

I HAVE ENJOYED MY MALIBU BUT I HAVE A ISSUE FROM THE DAY I PURCHASED IT. THE PLASTIC COVER OVER THE SEAT CONTROLS WAS TORN WHEN I PURCHASED THE CAR THE COVER HAS GOTTEN WORSE AS TIME HAS GONE BY AND TO BE HONEST HAS BECOME A HAZARD I TORN A PAIR OF SLACKS ON THE EXTREMELY SHARP PLASTIC PIECE AND I AM VERY CAREFUL GETTING IN AND OUT OF THE CAR BECAUSE OF THE PIECE. DRIVERS SIDE SEAT CONTROL COVER PIECE. THERE IS A DEFECT IN THE SEAT DESIGN THERE IS A METAL TUBE RUNNING FRONT TO BACK YOU CAN SEE IT IN THE PICTURES IT CRACKED THIS COVER AND WILL CRACK ANY NEW COVER THAT REPLACE THIS COVER. THIS IS A DESIGN DEFECT PLEASE FIND OUT IF IT IS COVERED FROM CHEVY. THERE ARE MULTIPLE COMPLAINTS LISTED ON THE INTERNET FOR THIS EXACT PIECE CRACKING

NHTSA ODI 11011454

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DRIVER SEAT BASE BOARD SEPARATED CAUSING WIRES TO BE EXPOSED. THE CONTACT ALSO MENTIONED THAT THE DRIVERS SEAT SETTING SYSTEM WAS NOT AFFECTED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO HAVE A DIAGNOSTIC PERFORMED. HOWEVER THE CONTACT SPOKE TO TERRY CULLEN CHEVROLET DEALER IN THE STATE OF GEORGIA AT PHONE NUMBER: (770-986-4444) AND WAS ADVISED THAT THE VEHICLE DID NOT HAVE ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000.

NHTSA ODI 11010902

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. WHEN THE CONTACT EXITED THE VEHICLE, THE REAR WINDOW SHATTERED SPONTANEOUSLY. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE TOP QUALITY BODY SHOP WHO INFORMED THE CONTACT THAT THEY WERE NOT THE ONLY VEHICLE OWNER WHO EXPERIENCED THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 24,000.

NHTSA ODI 11000046

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. THE CONTACT STATED THAT THE AIR BAG SERVICE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO LUMBERTON CHEVROLET BUICK GMC CADILLAC (LOCATED AT 500 LINKHAW RD., LUMBERTON, NC) WHERE IT WAS DIAGNOSED THAT THE COMPUTER NEEDED UPDATING. THE COMPUTER WAS UPDATED; HOWEVER, AS SOON AS THE CONTACT LEFT THE DEALER, THE AIR BAG WARNING INDICATOR ILLUMINATED AGAIN. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER SEVERAL TIMES, BUT THE DIAGNOSTIC RESULTS WERE UNKNOWN. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT MENTIONED THAT THE PREVIOUS REPAIRS WERE COVERED UNDER A WARRANTY, BUT THE FAILURE PERSISTED AND THE WARRANTY HAD EXPIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.

NHTSA ODI 10992943

A CAR CAN NOT HAVE TWO BATTERIES CONNECTED TO THE ENGINE AT THE SAME TIME AND BE STREET LEGAL. THAIS CAR HAS THAT AND THEY ARE MISMATCHED BATTERIES AS WELL. MY CAR WAS STOLEN BY TOM LEHOUSKY. HE SOLD IT AT TROPICAL CHEVROLET FOR $15,000 AND KEPT THE MONEY.

NHTSA ODI 10971432

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. WHILE PARKED AND EXITING THE VEHICLE WITH THE KEY DISENGAGED, THE INTERIOR LIGHTING AND RADIO REMAINED ON. ALSO, WHEN THE KEY WAS ENGAGED IN THE IGNITION, THE VEHICLE WOULD FAIL TO START. THE CONTACT WOULD SOMETIMES HAVE TO MAKE SEVERAL ATTEMPTS TO START THE VEHICLE. THE FAILURES OCCURRED ON SEVERAL DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE FAILURES COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 6,000. ..UPDATED 06/08/17 *BF

NHTSA ODI 10967761

BOLTS SECURING REAR SUSPENSION MAY BE LOOSE ONE OR MORE BOLTS SECURING THE REAR SUSPENSION COMPONENTS MAY NOT HAVE BEEN TIGHTENED PROPERLY DURING VEHICLE ASSEMBLY. LOOSE SUSPENSION BOLTS CAN RESULT IN SUDDEN CHANGES IN THE VEHICLE HANDLING CHARACTERISTICS.

NHTSA ODI 10954299

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. WHILE DRIVING 45 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING. ALSO, THE RPMS INCREASED WHETHER THE VEHICLE WAS PARKED OR IN DRIVE. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 20,534.

NHTSA ODI 10944578

THE CAR WAS STATIONARIED, IT WAS ABOUT 28 DEGREES OUTSIDE. MY CAR WAS ON AND OFF IN BETWEEN AN 8 HOUR PERIOD. AS I AM A LOCAL DRIVER FOR A COMPANY OUT OF AUSTIN, TX. JANUARY 7TH AT ABOUT 12 MIDNIGHT I STARTED FEELING NAUSEOUS, THEN IT QUICKLY WENT TO CRAMPS THINKING I WAS HUNGRY I TRIED TO EAT. MEANWHILE I VAGUELY SMELLED SOMETHING BUT COULDN'T MAKE OUT THE SMELL INSIDE THE VEHICLE. AT ABOUT 2AM I WAS REALLY BAD OFF WITH NOW A TERRIBLE HEADACHE THAT WAS BEYOND A NORMAL HEADACHE. I KEPT WORKING TILL 3 AM JAN 8TH. AS I CLOCKED OUT I WAS FEELING DISTANT AND DIZZY. I RETURNED TO THE CAR AND DROVE HOME WITH A FOGGY FEELING. I BARELY MADE IT UP OUR 3 FLIGHTS OF STAIRS AND STOPPED HALFWAY. AS I FELT I WASN'T GETTING ENOUGH OXYGEN. I CAME INSIDE OUR HOME AT 3:15. AND AT THAT TIME EXPLAINED TO MY HUSBAND MY SYMPTOMS I STARTED BREATHING IN AND OUT AS MUCH POSSIBLE ENOUGH AIR COULDN'T COME QUICK ENOUGH. MY BODY WAS TIRED I TOOK MEDS FOR MY HEAD AND DIZZUDLY FELL ASLEEP. MY HUSBAND INFORMED ME THAT HE CHECKED THE CAR AND UNDER THE HOOD HE COULD SMELL AN ODOR AND UPON CHECKING HE COULD HEAR A WHIZZING FROM THE BATTERY." THE BATTERY HAD BEEN RELEASING FUMES BACK INTO THE CAR HE SAID". WHICH WAS CAUSING ME TO INHALE CARBON MONOXIDE POISON. ALL THE SYMPTOMS I WAS FEELING CHECKED OUT AS I RESTED SUNDAY JANUARY 8TH. HE CHECKED MY OXYGEN LEVELS AS I WAS OK NOW! STATING THE OBVIOUS IT COULD HAVE BEEN DEADLY I WAS VERY SHAKEN AND BARELY MENTALLY THERE BUT DIDN'T REALIZE IT. AS THIS WAS MORE THAN TRAUMATIZING FOR ME AND OUR FAMILY WE ARE NOW REACHING OUT TO INFORM AND WAIT TO SEE WHAT ARE NEXT STEPS ARE!

NHTSA ODI 10943835

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. WHILE DRIVING 40 MPH MAKING A RIGHT TURN, THE CONTACT STRUCK ANOTHER VEHICLE. THE DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED, BUT FAILED TO FILL UP. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 17,440

NHTSA ODI 10936331

AT 8:00 P.M. I STARTED MY CAR TO WARM UP. IT WAS 27 DEGREES OUT AND WHEN I TURNED MY HEAT ON, NO AIR WOULD BLOW OUT. THE CAR WAS IN PARK. AFTER I LET IT WARM UP FOR ABOUT 15 MINUTES, I NOTICED THE AIR WOULD STILL NOT BLOW OUT. I SHUT MY CAR OFF AND TURNED IT BACK ON AND THE AIR STILL WOULD NOT BLOW OUT. THE LIGHT ON THE KNOB INDICATING IT WAS ON, WAS NOT LIT UP. ALL OTHER ELECTRICAL FUNCTIONS WERE WORKING FINE IN MY VEHICLE. ONCE I STARTED DRIVING FOR ABOUT 10 MINUTES, ALL OF A SUDDEN THE AIR KICKED ON AND STARTED BLOWING OUT. AND FUNCTIONED FINE FOR THE REST OF THE DRIVE. MY CAR HAS 20K MILES ON IT AND WAS PURCHASED ABOUT 6 MONTHS AGO. *TR

NHTSA ODI 10934007

"TAKATA RECALL" DURING A SIDE IMPACT COLLISON AT 45MPH , THE SIDE AIR BAG DID NOT DEPLOY (NO AIR BAGS DEPLOYED) AND THE STABILITRAK WAS DISABLED . AN ERROR MESSAGE OF SERVICE STABILITRAK APPEARED DURING THE ACCIDENT

NHTSA ODI 10908609

CPSC: AIRBAG: 2015 CHEVROLET MALIBU: CONSUMER STATED THE AIRBAG DID NOT DEPLOY AFTER A COLLISON DURING A SPEED OF 60 MPH. *SS

NHTSA ODI 10902921

I PURCHASED MY VEHICLE ON MARCH 2015 OFF THE SHOWROOM FLOOR OF A CHEVROLET DEALERSHIP. ON JUNE 18, 2016 MY CAR CAUGHT A FIRE WHILE IT WAS PARKED AND I WAS NOT IN THE VEHICLE. I HAD BEEN SITTING IN THE CAR WITH THE AIR BLOWING FROM THE DEFROSTER FOR ABOUT 30 MINUTES. I DROVE TO THE STORE AND CAME BACK HOME. I GOT OUT OF THE CAR AND STOOD ON THE PORCH TALKING TO MY FAMILY. WITHIN IN 10 MINUTES OF ME EXITING MY CAR, IT WAS ON FIRE. I RAN TO THE CAR AND COULD SEE THAT THE FIRE WAS COMING FROM RIGHT ABOUT WHERE THE WINDSHIELD ENDS AND WHERE THE HOOD OF THE CAR BEGINS, RIGHT WHERE THE WINDSHIELD WIPERS ARE. I CALLED THE FIRE DEPARTMENT WHO PUT THE FIRE OUT. THEY USED THE JAWS OF LIFE TO PLY THE HOOD OPEN AND CUT THE MAIN WIRE TO THE CAR. I THEN CONTACTED THE GM MANUFACTURING COMPANY CHEVROLET AND STARTED A CLAIM WITH THEM TO DO AN INVESTIGATION ON MY VEHICLE AS TO WHAT HAPPENED AND WHY TO THIS BRAND NEW CAR. ESPECIALLY CONSIDERING THE FACT THEIR WAS NO ONE IN THE CAR AT THE TIME IT CAUGHT FIRE, THANK GOD AND AS TO NO ONE COULD OF STARTED THE FIRE BECAUSE I WAS STANDING OUTSIDE THE ENTIRE TIME. THE ALLEGED INVESTIGATION TOOK ABOUT A MONTH AND A HALF TO COMPLETE. I RECEIVED A CALL A WEEK PRIOR TO GM CHEVROLET MANUFACTURING MAKING A DECISION FROM ONE OF THEIR REPRESENTATIVES ASKING ME HAVE I EVER GOTTEN THE WINDSHIELD WIPER MOTOR REPLACED BEFORE. I STATED TO HER NO I HAVEN'T AND REMINDED HER THAT THE CAR WAS PURCHASED NEW OFF THEIR SHOWROOM FLOOR AND THAT I HADN'T HAD ANYTHING REPLACED OR ALTERED ON THAT CAR. ON JULY 29TH I WAS CALLED BY A GM CHEVROLET REPRESENTATIVE AGAIN TELLING ME MY CLAIM WAS BEING DENIED BECAUSE OF A WINDSHIELD WIPER ISSUE. I STATED TO HER THAT I WOULDN'T HAVE ANYTHING TO DO WITH THAT. SHE THEN CHANGES THE REASON AND STATES THAT GM CHEVROLET REALLY CANT DETERMINE WHAT HAPPENED AND THEY WERE DENYING MY CLAIM. THEIR HAD BEEN SEVERAL RECALLS ON GM CARS

NHTSA ODI 10896661

MY IGNITION KEYS (BOTH) SOMETIMES STICK IN THE 'START' POSITION WHEN STARTING. SOME DAYS THEY STICK SEVERAL TIMES AND SOME DAYS THEY DON'T. IT DEPENDS ON HEAT AND HUMIDITY. GENTLE PRESSURE EASILY RETURNS THE KEY TO THE 'RUN' POSITION. WE ALWAYS NOTICE THIS WHEN IT HAPPENS AND WE TURN THE KEY TO THE 'RUN' POSITION. BUT IF IT IS UNNOTICED IT COULD RELEASE WHEN HITTING A BUMP IN THE ROAD AND GO PAST 'RUN' AND INTO THE 'ACCESSORY' POSITION, SHUTTING OFF THE ENGINE. THIS HAS BEEN HAPPENING SINCE THE CAR WAS NEW IN APRIL, 2015. THE DEALER CLEANED THE KEY AND LUBED THE IGNITION SWITCH BUT THE PROBLEM CONTINUES. THE DEALER WILL NOT REPLACE THE IGNITION SWITCH BECAUSE THE KEY DID NOT STICK WHILE THEY HAD THE CAR. THIS PROBLEM OCCURS OFTEN (ABOUT 10% OF THE TIME) WHEN THE WEATHER IS HOT AND/OR HUMID. IT OCCURS RARELY WHEN THE WEATHER ID COOL/DRY.

NHTSA ODI 10895271

THE VEHICLE ROLLED BACKWARDS INJURING OPERATOR AFTER IT WAS PLACED IN PARK. OPERATOR MOVED THE AUTOMATIC TRANSMISSION LEVER FROM DRIVE INTO PARK. THE DOORS UNLOCKED AUTOMATICALLY. KEYS WERE IN THE IGNITION. VEHICLE WAS TURNED OFF. OPERATOR EXITED THE VEHICLE. VEHICLE ROLLED BACKWARDS DOWN THE SLIGHT >3% DRIVEWAY. GMC HAS INSPECTED THE VEHICLE AND DONE A DOWNLOAD OF THE ECM. THIS VEHICLE IS DANGEROUS BECAUSE IT EITHER DOES NOT FULLY ENGAGE IN PARK BUT RELEASES THE DOOR LOCKS OR IT SPONTANEOUSLY COMES OUT OF PARK OR SOME OTHER FAILURE MECHANISM.

NHTSA ODI 10872164

I HAVE FELT FROM THE BEGINNING THAT THIS CAR HAD POOR HEADLIGHTS. SINCE PURCHASING THIS CAR I HAVE AVOIDED DRIVING IT AT NIGHT BECAUSE THE HEADLIGHTS ARE NOT SUFFICIENT FOR ME TO DRIVE SAFELY AT NIGHT. I HAVE COMMENTED AS TO THIS CONDITION TO MY DEALER AND HAD THE HEADLIGHTS ADJUSTED AND THAT MAY HAVE IMPROVED THE SITUATION SOME. I HAVE A GMC PICKUP THAT I DRIVE AT NIGHT. IIHS HAS RATED THIS CARS LIGHTING AS POOR. IS THERE OR WILL THERE BE A RETROFIT TO MAKE THIS CAR SAFE??? I AM CONSIDERING TRADING FOR A DIFFERENT MODEL, THAT IS HOW SERIOUS THIS HEADLIGHT DEFICIENCY IS.

NHTSA ODI 10852704

AFTER FOUR MONTHS OF OWNERSHIP MY ENGINE STARTED KNOCKING. I TOOK IT IN, THEY SAID IT WAS A BALANCER SHAFT ASSEMBLY WITH TIMING CHAIN AND SPROCKET. THE SOUND IS STILL THERE BUT THE DEALERSHIP STARTED THE WORK IS DONE AND REFUSES TO TOUCH IT. THE NOISE IS EXTREMELY ANNOYING BUT DOES NOT AFFECT RUNNING. I AM OF COURSE WORRIED THE ENGINE MAY DIE, BUT WITH THE REFUSAL TO DO ANYTHING I DON'T WANT TO VOID THE REST OF THE WARRANTY.

NHTSA ODI 10852598

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. WHILE DRIVING 45 MPH AND MAKING A STOP, THE RADIO SHUT OFF COMPLETELY. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE WAS NOT FOUND. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 14,000.

NHTSA ODI 10846048

THE DIVERS SEAT BELT ADJUSTER RATTLES WHILE DRIVING. ONE HAS BEEN REPLACED AND THE PLASTIC PORTION OF THE ADJUSTER SHOWED SIGNIFICANT WEAR. I AM CONCERNED THAT THIS PART COULD FAIL IN A COLLISION.

NHTSA ODI 10837707

I PURCHASED THIS CAR ON 02/09/16, 1 1/2 HOURS AFTER DRIVING IT OFF THE LOT, I WAS DRIVING DOWN A MAIN ROAD AT APPROPRIATELY 57 MPH AND MY MOON ROOF GLASS EXPLODED. THERE WERE NO CARS CLOSE TO THE FRONT OF ME. THE GLASS APPEARS TO BE BOWING OUT OF THE VEHICLE, NOT INTO THE VEHICLE, AS YOU WOULD EXPECT IF A ROCK HAD HIT IT. SEE THE ATTACHED PICTURE. THERE WAS NO SOUND OF ANYTHING HITTING THE ROOF, IT SIMPLY SOUNDED LIKE A BOMB EXPLODING IN MY VEHICLE AND GLASS WENT EVERYWHERE. MY DAUGHTER WAS IN THE FRONT SEAT AND THE GLASS HIT HER FACE. I CALLED THE LOCAL CHEVY DEALER AND THEY SAID THERE WAS NOTHING THEY COULD DO THAT IT WAS LIKELY A ROCK. NOW I HAVE TO FILE A CLAIM WITH MY INSURANCE TO FIX THE GLASS, MY ROOF TOP AND TRUNK LID AS THE GLASS SCRATCHED AND ETCHED THE PAINT. SOUNDS LIKE THIS HAS HAPPENED TO QUITE A FEW PEOPLE AFTER SEARCHING SIMILAR INSTANCES WITH THIS VEHICLE. MIGHT BE SOMETHING CHEVY SHOULD LOOK INTO. THANKFULLY MY DAUGHTER AND MYSELF SUSTAINED NO INJURIES, ESPECIALLY WITH THE GLASS HITTING HER FACE. IT LEFT A SMALL RED MARK BUT DID NOT CUT HER.

NHTSA ODI 10825453

2015 CHEVY MALIBU 1LT OPERATING VEHICLE AT NORMAL SPEED LIMIT IN CITY TRAFFIC AND USED INTERIOR HEAT FOR CLIMATE CONTROL MODES BUTTONS. A SUDDEN "CLICKING' SOUND CAME FROM FAN SPEED CONTROL WHEN SWITCHING TO THE CLIMATE CONTROL MODES. SOUNDED MOSTLY FROM THE DRIVER SIDE, AND LAST FOR 2 TO 3 SECONDS. NO WARNING LIGHTS CAME ON BUT MAY HAVE BEEN STUCK IN SOME RE-SET PROCESS. NOISE SEEMED TO BE FROM DEFROST AND HEAT CONTROL MODES. DEALER REPLACED INTERIOR FAN ACTUATOR AND SYSTEM NOW FUNCTIONS AS INTENDED. I ALSO DESCRIBED THIS TO THE DEALER AS SOUNDING LIKE A FLUTTERING SOUND FROM THE FAN SPEED CONTROL. DID NOT OCCUR ON THE PASSENGER SIDE, JUST DRIVER SIDE. HAS ONLY 2300 MILES THUS FAR.

NHTSA ODI 10824672