What 268 owners told NHTSA about the 2015 Chevrolet Malibu Eco

AUTO STOP WHICH COMES STANDARD IN 2015 MALIBU'S WITH 2.5L ENGINES WILL NOT ENGAGE. IT USED TO WORK FLAWLESSLY, BUT IT WILL NOT ENGAGE. MULTIPLE FORMS THAT I HAVE READ HAVE PEOPLE STATING THEY HAVE THE SAME ISSUE.

NHTSA ODI 11242487

TL* THE CONTACT OWNED A 2015 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH IN THE RAIN, THE CONTACT REAR-ENDED ANOTHER VEHICLE THAT HAD MADE AN UNEXPECTED STOP. THE VEHICLE'S AIR BAGS DEPLOYED UPON IMPACT; AFTER THE IMPACT, THE VEHICLE ACCELERATED ON ITS OWN. THE CONTACT WAS UNABLE TO USE THE BRAKE PEDAL DUE TO THE VEHICLE'S AIR BAGS DEPLOYING. THE CONTACT THEN FORCED THE VEHICLE INTO PARK AND APPLIED THE EMERGENCY BRAKE, BUT TO NO AVAIL. THE VEHICLE EVENTUALLY COASTED TO A STOP AFTER THE CONTACT DROVE THE VEHICLE INTO A GRASS FILLED AREA. THE CONTACT SUSTAINED A BRAIN BLEED AS A RESULT OF THE COLLISION. THE OTHER DRIVER SUSTAINED BACK INJURIES; HOWEVER, NO MEDICAL ATTENTION WAS GIVEN TO EITHER PARTIES INVOLVED IN THE COLLISION. AFTER THE COLLISION, THE CONTACT WENT TO THE EMERGENCY ROOM WHERE THEY DISCOVERED SHE HAD BLEEDING ON HER BRAIN AND WAS TREATED. A POLICE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED TO THE DEALERSHIP (POP'S CHEVROLET BUICK600 US-23, PRESTONSBURG, KY 41653(606) 263-1507). THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

NHTSA ODI 11241743

THE SENSOR LIGHT FOR MY AIRBAGS STAYS ON. THE CAR HAS LESS THAN 50,000 MILES ON IT, AND THE SENSOR DOES NOT WORK.

NHTSA ODI 11241877

AIR BAG LIGHT KEPT COMING ON.

NHTSA ODI 11240747

MY 2015 CHEVY MALIBU LTZ ECO, JUST SUDDENLY LOSS POWER WHILE AT A STOP LIGHT. THE AUTO STOP HAD ENGAGED ONCE I CAME TO A COMPLETE STOP. UPON GIVING THE CAR GAS TO TAKE OFF, THE AUTO STOP HAD BEEN DISENGAGE. FOOT ON THE GAS TO GO AND THE VEHICLE JUST SAT THERE FOR A FEW SECONDS THEN IT JUST CAME ALIVE AND TOOK OFF. AT FIRST I WAS THINKING IT WAS THE TRANSMISSION ACTING UP. THEN THE COMPLETE LOSS OF POWER HAPPENED.

NHTSA ODI 11232604

REAR SEAT BELTS WILL NOT RETRACT. FRONT DRIVER SEATBELT ON OCCASION WILL NO BUCKLE

NHTSA ODI 11230920

LIGHT WARNING COMES ON STATING SAFETY AIRBAGS DEFECTED. WE NEED THIS FIXED UNDER RECALL AND HAVE BEEN WAITING FOR ABOUT 3 MONTHS.

NHTSA ODI 11229901

TAKATA RECALL THE TRANSMISSION IN THE 2015 CHEVY MALIBU JERKS AT LOW SPEEDS AND AT HIGH SPEEDS IT HOLDS THE GEAR WHEN SLOWING DOWN

NHTSA ODI 11223127

CAR WAS PARKED IN A PARKING LOT FOR OVER AN HOUR WHEN AN ELECTRICAL FIRE STARTED BY THE BATTERY AND FUSE PANEL. THERE HAVE BEEN NO MODIFICATIONS MADE TO THE CAR AT ALL. STANDARD MAINTENANCE ONLY HAS BEEN DONE INCLUDING NEW TIRES ABOUT A YEAR AGO. THERE IS NO REASON A PARKED COOL CAR SHOULD CATCH ON FIRE. THERE WERE NO OIL LEAKS AT ALL ON THE CAR.

NHTSA ODI 11222866

MY CAR WAS TAKEN IN LIKE 3 YEARS AGO FOR AIRBAG RECAL AND IT AS FIX BUT ALL OF A SUDDEN THE AIRBAG LIGHT CAME ON

NHTSA ODI 11223075

CHECK ENGINE LIGHT RANDOMLY COMES ON AND OFF. UNABLE TO GET A DIAGNOSTIC CHECK THOROUGHLY BECAUSE THE ENGINE LIGHT DOESN'T STAY ON. WAS AT AN AUTO ZONE ONE DAY WHEN IT CAME ON AGAIN AND WAS GIVEN TWO OF THE SAME CODES STATING THERE MAY BE AN O2 SENSOR ISSUE. A COUPLE WEEKS LATER WHILE DRIVING I GET A MESSAGE ON THE CAR STATING 'SERVICE POWER STEERING' THEN IT GOES OFF AGAIN. CHECK ENGINE LIGHT WENT OFF. RIGHT DRIVER BACK SEAT BELT DOESN'T CLICK IN ALL THE WAY BUT SOMETIMES IT DOES.

NHTSA ODI 11219716

TAMARA RECALL THE TRUNK RELEASE STOP WORKING AND WAS BLOWING FUSES.

NHTSA ODI 11219570

APRIL 1ST 2019 THE SERVICE AIRBAG LIGHT STARTED COMING ON ON MY DASHBOARD I WENT INTO A AUTOMOTIVE REPAIR PLACE AND THEY TOLD ME THAT THE AIR MODULE TO THE AIRBAG NEEDED TO BE REPLACED BECAUSE IT WAS DEFECTED.

NHTSA ODI 11219248

DROVE MY MALIBU TO SEE A SHOW AND PARKED IN THE GARAGE. AFTER THE SHOW, WHEN TURNED ON THE IGNITION HAD A SERVICE AIRBAG LIGHT. TOOK IT TO THE GM DEALER WHO DIAGNOSED THE PROBLEM AND SAID HAD TO REPLACE THE AIR BAG SDM ELECTRICAL MODULE WITH A TOTAL PRICE ESTIMATE OF ALMOST $1,000 CAD !!! I HAVE HAD THIS VEHICLE SINCE DECEMBER 2014 AND HAVE DRIVEN IT TO FLORIDA EVERY WINTER SINCE. IT ONLY HAS 82,500 KM ON IT. I BELIEVE THIS IS A PREMATURE FAILURE AND IS A SAFETY ISSUE. SHOULD BE THE SAME AS THE NEW CAR EMISSIONS WARRANTY WHERE EMISSION COMPONENTS ARE COVERED MUCH LONGER THAN NEW CAR WARRANTY.

NHTSA ODI 11218519

CHECK ENGINE LIGHT, TURNED OUT IT WAS SOLENOID VENT VALVE, A $36 PART THAT COST ME A TOTAL OF $600 USD TO REPLACE AFTER DIAGNOSTIC FEES AND SHOP FEES. THEY HAD TO DROP THE GAS TANK TO ACCESS IT. THIS IS A PREMATURE FAILURE FOR A FOUR YEAR OLD VEHICLE WITH ONLY 48,000 KM. IF THIS IS A REGULAR MAINTENANCE ITEM THAT REQUIRES FREQUENT REPLACEMENT, GM SHOULD HAVE PUT IT IN A MORE ACCESSIBLE LOCATION SO IT DOESN'T COST $600 TO REPLACE A $36 PART!

NHTSA ODI 11218525

AIRBAG LIGHT IS KEEP COMING ON. I HAVE POWER SEATS AND PAYED TO GET THE PANEL FIXED AND THE PANEL IS HANGING AGAIN.

NHTSA ODI 11203659

THE ABS BRAKE LIGHT COMES ON SEVERAL TIMES. MUST TURN ENGINE OFF AND RESTART TO RESET. USUALLY THE ABS LIGHT COMES ON WHEN BACKING UP. SOME TIMES WHEN DRIVING.

NHTSA ODI 11202894

THE PLASTIC TRIM ON DRIVERS SEAT WHICH HAS THE CONTROLS ON IT TO OPERATE AND HOLD THE SEAT UP ON THE SIDE CRACKED AND CONTROLS WERE NOT ACCESSIBLE AND PART WAS NO LONGER HOLDING UP THE SEAT. PURCHASED CAR MARCH 28,2015. ON OCTOBER 26,2017 I PAID FOR THE PART AND LABOR SINCE I WAS TOLD IT WAS NOT UNDER WARRANTY. IT'S NOW APRIL 9TH, 2019 AND THE PART IS PULLING AWAY FROM THE SEAT AGAIN. I WAS TOLD THE WARRANTY FOR THE LAST REPAIR EXPIRED ON OCTOBER 26, 2018. MY OPTION WAS TO PAY FOR THE PART AND REPAIR AGAIN. THE PLASTIC TRIM SHOULD BE CONSIDERED DEFECTIVE SINCE IT HOLDS THE SEAT UP AND THE BUTTONS THAT ACCESS THE SEAT CONTROLS ARE ON IT. THE PART AND LABOR CHARGES SHOULD BE COVERED BY THE MANUFACTURER FOR THIS DEFECTIVE PART.

NHTSA ODI 11195044

THE DRIVERS SEAT MOVES UNEXPECTEDLY FRONT AND BACK WITHOUT MANUAL CONTACT THEREFOR THIS CAN CAUSE MYSELF AN ACCIDENT BY MOVING THE BACK SUPPORT TO THE FRONT AND BACK THIS HAPPENED WHEN THE CAR TURNED OFF AND WHILE DRIVING

NHTSA ODI 11191465

CAR WAS PARKED IN A RESIDENTIAL PARKING LOT. A WATER LEAK BEGAN. WATER WAS ON THE FLOOR OF THE DRIVER'S SIDE AND ON THE FLOOR ON THE PASSENGER'S SIDE BEHIND THE DRIVER. I TOOK THE CAR TO AN AUTO MECHANIC AND I WERE TOLD THE LEAK WAS CAUSED BY A MANUFACTURER'S DEFECT AND THE WATER HAD BEEN SLOWLY LEAKING INTO THE CAR SINCE I FIRST HAD IT. THE WATER LEAKS IN BEHIND THE DASHBOARD AND THEN ACCUMULATES BETWEEN THE BODY FRAME AND THE CARPETING. HE SAID THE DEFECT WAS A MISSING SEAL IN THE CAR BODY FRAME. I WAS TOLD THE DEFECT CAN'T BE REPAIRED BECAUSE THE FRAME IS WELDED TOGETHER AND THE AREA TO PUT THE SEAL IN IS IMPOSSIBLE TO ACCESS. HE PUT ANOTHER TOP COAT SEAM IN THE COWL AREA, BUT STATED DUE TO THE FAULTY BODY SEAM THEY CANNOT GUARANTEE PERMANENT WATER TIGHT REPAIR. THE CAR WAS DRIED OUT FOR A WEEK IN THE AUTO SHOP. THEN THE CAR WAS RETURNED AND THE NEXT MORNING THE FLOOR ON THE DRIVER'S SIDE HAD A WATER LEAK AGAIN. THE AUTO MECHANIC SAID THAT I SHOULD NOT KEEP THIS CAR.

NHTSA ODI 11191080

TAKATA RECALL A LIGHT CAME ON THAT READ 'HAVE YOUR AIRBAG CHECKED.' I TOOK IT TO THE DEALER, RUSSELL BARNETT, WINCHESTER,TN. THEY CAME OUT WITH A PRICE FOR REPLACEMENT OF $750.00. I ASKED IF THIS WAS COVERED BY CHEVROLET. THEY ANSWERED NO. I THEN REMINDED THEM THAT I OF $10HAVE EXTENDED WARRANTY. THEY THEN SAID LET ME CHECK IT OUT. IN A FEW MINUTES, THEY CAME BACK WITH A SECOND FIGURE OF $150.00 WHICH INCLUDED THE $50.00 DEDUCTIBLE. MY QUESTION IS DO I PAY?

NHTSA ODI 11185962

MY AIRBAG SERVICE LIGHT WAS ON- I HAD A DIAGNOSTIC RAN ON MY VEHICLE. I WAS TOLD BY THE GLENDORA CHEVROLET DEALERSHIP THAT MY VEHICLE WAS TOO DANGEROUS TO DRIVE AND I NEEDED TO HAVE MY AIRBAG REPLACED FOR $1,000. I HAVE NEVER BEEN IN AN ACCIDENT AND MY AIRBAGS HAVE NEVER BEEN DEPLOYED. THIS SEEMS LIKE AN ODD SERVICE NEEDED ON A NEWER VEHICLE. THIS SHOULD BE CATEGORIZED AS A SAFETY RECALL ISSUE VERSUS A MAINTENANCE NEEDED.

NHTSA ODI 11175067

TAMARA RECALL THIS VEHICLE HAS THE AUTO STOP START SYSTEM WHERE THE ENGINE IS SUPPOSED TO ENGAGE AT A LIGHT, AND IT DOES NOT WORK. NO ONE CAN UNDERSTAND WHY IT WON'T ENGAGE AND THE DEALER WILL NOT HELP ME. THE VEHICLE WORKS AND DRIVES FINE BUT THIS SYSTEM IS FLAWED AND ALL OVER THE CHEVY FORUMS PEOPLE ARE EXPERIENCING THIS SAME PROBLEM.

NHTSA ODI 11174507

MY DEFROSTER STOPPED WORKING ON MY 2015 CHEVROLET MALIBU MAKING IT DIFFICULT TO SEE OUT OF THE WINDSHIELD WHILE DRIVING, WHEN I TURN ON FRONT WINDOW DEFROST IT BLOWS OUT OF THE FRONT VENTS AND NO AIR COMES OUT OF MY DEFROST. IT'S A HEADACHE AND I FEEL A HAZARD TO TRY TO DRIVE WITHOUT THIS, I USUALLY HAVE TO ROLL DOWN MY SIDE WINDOWS TO GET ANYWHERE WITH VISIBILITY. IT DOESN'T MATTER IF I AM PARKED, DRIVING, ETC. IT JUST DOES NOT WORK AT ALL EVER AND IT'S SCARY TO DRIVE WITH THIS ISSUE. MY VEHICLE HAS 77,000 MILES ON IT SO I FEEL THIS PROBLEM SHOULD NOT BE OCCURING.

NHTSA ODI 11174567

TL* THE CONTACT OWNS A 2015 CHEVROLET MALIBU. THE CONTACT STATED THAT THE SUN ROOF WOULD NOT PROPERLY CLOSE AND REMAINED OPENED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER (HOWARD GMC CHEVROLET, 364 W. GRAND AVENUE, ELMHURST, IL) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 86,000.

NHTSA ODI 11173870