What 194 owners told NHTSA about the 2014 Toyota RAV4 Hv

The contact owns a 2014 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11626614

The contact owns a 2014 Toyota Rav4. The contact stated while the vehicle was parked, the paint on the hood, the front driver-side door, and the rear passenger-side door was peeling. No warning light was illuminated. The VIN was included in an unknown manufacturer's customer program related to the paint issue. The vehicle was taken to an auto body shop where it was diagnosed that certain areas of the vehicle needed to be repainted. The vehicle was repaired however, the failure still occurred. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 60,000.

NHTSA ODI 11623965

The entire computer screen is stuck on the downloading picture. Then it will restart itself and do it all over again. Nothing works. No radio or anything. I’ve been looking online and seeing there is a lot of people with the same issues a but no solutions. How has Toyota not fixed this issue yet.

NHTSA ODI 11621641

The contact owns a 2014 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact advised that while she driving at approximately 45 MPH she observed three unknown warning lights on the instrument cluster. The contact stated that the vehicle steering wheel was hard to turn and she observed that white smoke was issuing from the dashboard vents. The contact stopped turned the vehicle off and waited for the smoke to clear. The contact had the vehicle towed to an independent mechanic who diagnosed the vehicle and determined that the 12V battery had shifted and that one of the terminals on the battery had become loose and touched the metal battery clamp causing a short circuit. The vehicle was repaired. The contact later drove the vehicle to a dealer but was advised that the battery clamp was not available to complete the recall. The failure was approximately 258,000. VIN tool confirms parts not available.

NHTSA ODI 11619953

The contact's daughter owns a 2014 Toyota RAV4. The contact stated that while the daughter was driving at 35 MPH, smoke was coming from under the hood and the vehicle lost automotive power. The contact stated that the failure occurred while driving downhill, however, the vehicle was coasted to the local fire department, which was on the same street. The fire department extinguished the fire. The contact stated that a fire report was filed. The contact stated that there were no injuries sustained. The vehicle was towed to the dealer where it was confirmed that the failure was due to the unrepaired recall repair. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ODI 11618763

Transmission fluid was serviced at Bill page Toyota, Falls Church, VA 22042 (102,468 miles on 11/2/2023) Transmission failed to operate at 104,771 miles. Car failed to go reverse, noise from transmission gear. Car was inspected at Toyota Ourishman, Fairfax, VA and concluded transmission problem failed.

NHTSA ODI 11618381

The contact owns a 2014 Toyota Rav4. The contact stated while driving at an undisclosed speed, the steering wheel seized, and the vehicle lost motive power. The contact stated that the instrument cluster and the radio blinked off and on. In addition, the contact noticed that some wires were burnt. The vehicle was started and taken to Auto Zone. The contact stated that the battery and the alternator were both tested and operated as designed. The vehicle was restarted, and the contact stated while driving the failure reoccurred. The vehicle was turned off and the contact attempted to restart however, the vehicle failed to start up. The vehicle was towed to the dealer where it was diagnosed and determined that battery cables were loose, and the positive battery terminal was incorrectly installed. The contact was informed that the failure was due to incorrect installation of the new battery which the previous owner had installed. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ODI 11618181

Battery shifted in engine compartment and severed battery cable

NHTSA ODI 11617644

Car on fire

NHTSA ODI 11612949

The contact owns a 2014 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical system); however, the part to do the recall repair was not yet available. The contact stated that the battery positive (+) terminal was corroded. The contact cleaned the terminal. An unknown local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ODI 11608677

Re: Manufacturer Recall Number23TB13 NHTSA Recall Number23V734 Recall StatusRecall Incomplete, remedy not yet available It has been over 6-months and manufacturer has not provided remedy for this recall. Dealer reports they have the parts but are not allowed to fix.

NHTSA ODI 11608343

The contact owns a 2014 Toyota Rav4. The contact stated while driving at various speeds, the steering wheel seized. There were no warning lights illuminated. The vehicle was taken to a local dealer, where it was diagnosed with power steering failure; however, the vehicle was not repaired. The vehicle was also taken to an independent mechanic, who diagnosed the vehicle and confirmed the failure. The contact related the failure to the NHTSA Campaign Number: 15V144000 (Steering); however, the VIN was not included. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 109,003.

NHTSA ODI 11604501

Per the current recall my vehicle can have a risk of fire. No remedy has been given since the recall information was released.

NHTSA ODI 11603455

The contact owns a 2014 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the steering wheel was difficult to maneuver while turning. There were unknown warning lights illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 126,258. VIN tool confirms parts not available.

NHTSA ODI 11602436

In reference to Toyota Motor North America - Customer Support Program ZKG. My Toyota vehicle has experienced paint peeling on the exterior metal body panels. I have applied to receive coverage from Toyota for the paint peeling as part of the ZKG Program. Toyota has denied my request for coverage and did not provide me with notice of the ZKG Program. The paint color of my vehicle is the original factory applied Blizzard Pearl (070) paint color. The vehicle experienced noticeable paint peeling around 9.5-10 years past the Date of First Use of the vehicle. I reported the paint peeling to my local Toyota dealer service center around two (2) weeks after the car was ten (10) years past the Date of First Use. Because the ZKG program coverage had expired by the time I had reported the paint peeling, the Toyota dealer service center referred me to the Toyota Brand Engagement Center. The Toyota Brand Engagement Center denied my request for coverage because the vehicle was reported shortly after the Duration of Coverage. I did not receive notice of the Customer Support Program ZKG from Toyota. I became the owner of this vehicle in the same year that the program notification was sent out. The paint peeling did not start until very close to time of coverage expiration for my vehicle. I was unaware that I would be required to report the paint peeling issue to Toyota by a certain date as I was never made aware of the Customer Support Program ZKG from Toyota.

NHTSA ODI 11599876

This car was purchased in March 2024 at Peak Motors in Hickory, NC and on [XXX] 2024, while driving the Check engine light, power steering, oil lamp, A&T temp oil, battery, tire and seatbelt light came on, the RPM went to 0 and we could no accelerate so we coasted down a hill and pull off to restart the car. After restarting it, all the lights disappeared and proceeded home and it happened 2 more times on the way home. The next day our mechanic and tested the battery and alternator, the alternator was good, but battery was weak so we got a new battery. A couple weeks later, the same thing happened and took it back in the mechanic but they could not get any codes nor could get it to reproduce what was happening so nothing could be done. They cleaned the mass air filter, but the same thing happened a few weeks later. The car has been in the shop for a total of 5 times and kept at the shop for 3 weeks. On [XXX] 2024, the car engine died again while in a drive thru and immediately took it to the mechanic 10 minutes away and they were able to get the code P1604 Startability Malfunction but the code is too generic they couldn't pinpoint specifically exactly what is the problem. Because of this being a HUGH safety issue, I contacted the dealer and they said they inspected it but could not provide proof when I asked for paperwork. I contacted Toyota in Asheville, NC where it serviced and they haven' returned my call. I contacted Mike Johnson Toyota in Hickory, NC where it was bought and they had no service records regarding this vehicle. It has passed inspection in Buncombe, NC but nobody can figure out what's going on. I am scared to drive the car because it happens at random times and it puts us at risk of being hit since we suddenly loss power but also puts others at risk as could hit us harming themselves and damaging their car. We drove the car for only a month before all of this began to happen and we just want to feel safe driving and riding in this car again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11592352

While driving, front of car ignited. Seems related to unresolved recall: Nov 01,2023 Manufacturer Recall Number23TB13 NHTSA Recall Number23V734 Recall StatusRecall Incomplete, remedy not yet available Summary Some replacement 12-volt batteries of the size specified for the subject vehicles have smaller top dimensions than others. If a small-top battery is used for replacement and the hold-down clamp is not tightened correctly, the battery could move when the vehicle is driven with forceful turns. Safety Risk The movement could cause the positive battery terminal to contact the hold-down clamp and short circuit, increasing the risk of a fire. Remedy Toyota is currently preparing the remedy. When the remedy is available, Toyota dealers will replace the battery hold down clamp, battery tray, and positive terminal cover with improved ones FREE OF CHARGE. At this time, Toyota estimates the remedy will be available in the middle of 2024 but this is subject to change. Until the remedy is available, owners who have not had the free inspection performed under Consumer Advisory 21TG01 should be encouraged to do so.

NHTSA ODI 11585470

I made my report more than 8 months ago and they did not give me an answer about the fuel pump toyota rav4 2013-2018 that all the vehicles are having a problem with a small arie escaping from that part at the top of the tank I was at the dealer and they can't do nothing because they say that this is normal and that who pays for that work and I told him that if that problem occurs, the entire vehicle has to do a recall for that problem

NHTSA ODI 11572671

2014 Toyota Rav 4 EV with 30,898 miles, the vehicle has full power but no start. towed vehicle to Toyota Dealership for dianostic it was checked with a scan tool and found code U0293, this set the code for lost communication with the EV control system. A special cable was bought to communicate with the vehicle root cause of problem is Traction Motor bad need replaced and service plug at top of battery has blown fuse need replaced. Solution is engine replacement.

NHTSA ODI 11570102

This matter is not related to a accident. This matter is related to a bad transmission on our Rava4. This started at a little over 100.000 miles. Toyota did replace transmission filter and torque converter at 102.000 miles and now we have 152.000 miles at this time, and now our 2nd gear is going out and the transmission needs to be replaced but can't found a rebuilt transmission. Due to back ordered parts. So what are we to do? The Rava4 is worthless without good transmission .Has there been any other related problems like this ? Toyota's are suppose to be good reliable cars.

NHTSA ODI 11566909

2014 Toyota RAV4 perfectly good headlight bulb stops working on low beam selection, severely limiting visibility for night-time driving. Looks like everyone on the internet is having the same problem.

NHTSA ODI 11562386

The contact owned a 2014 Toyota Rav4. The contact stated while driving up a slight grade, the vehicle stalled on the roadway. The contact stated that he saw smoke issuing from under the hood. The contact stated that he exited the vehicle and observed that flames were issuing from under the front end of the vehicle. The contact stated no warning light was illuminated. The contact stated that the fire department was called, however by the time the fire truck arrived the vehicle was fully engulfed in flames. The contact stated that the fire department extinguished the flames with water. The police department was also on scene and wrote a report. The manufacturer was not informed of the failure. The failure mileage was unknown and the VIN was not available.

NHTSA ODI 11559532

At least three time this happened while driving upon stopping at a stop sign or traffic light I was proceeding while making a turn after getting the clearance to do so. However the engine shut down and I was perplexed as to what was happening. I discovered the car had shut down and I had to restart the car. Additionally this occurred at a stop sign, while trying to make a sharp turn the car once again shut off and I was in the middle of intresection and other cars were behind me, and other coming towards me and I realized this SUV had stopped running again, putting me in direct harms way.

NHTSA ODI 11553645

My daughter was exiting the the freeway on off ramp and turning right. The car lost electrical power without any warnings on dash or notification. When she tried to turn the steering wheel she was unable to due to loss of power steering. She ended up crossing a median and was able to turn the wheel enough to pull into the suicide lane. She noticed the hood was smoking so she shut off the car and exited the vehicle. Soon the car engine area was in flames. Fire department put out the fire and police made and incident report. The car is unusable.

NHTSA ODI 11545735

The contact owned a 2014 Toyota Rav4. The contact stated while driving 25 MPH, it was noticed that there was smoke coming from under the hood of the vehicle, and the vehicle lost motive power. The contact arrived at the residence and the vehicle burst into flames causing the rear of another vehicle to melt. The fire department was able to extinguish the fire. A police report was filed. No one was injured. The vehicle was not towed or diagnosed. The dealer was not contacted. The manufacturer was not contacted. The failure mileage was 120,000.

NHTSA ODI 11543080