What 978 owners told NHTSA about the 2014 Kia Sorento Plug-in Hybrid

The contact owns a 2014 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle went into LIMP Mode and failed to accelerate above 35 MPH. There was an unknown warning light illuminated. The contact stated that the engine had seized. The vehicle was taken to the local dealer, where it was diagnosed with an internal bearing failure. The dealer informed the contact that the vehicle was previously in a crash and declined the warranty coverage. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 103,274.

NHTSA ODI 11653820

The contact owns a 2014 Kia Sorento. The contact stated while starting the vehicle, there was a ticking sound coming from the vehicle. Later, on the same day, while pulling into a friend’s driveway, the engine began making a knocking sound. The contact decided to drive to the residence nearby, and the engine started knocking again, eventually causing the engine to fail and the vehicle to lose motive power. The check engine warning light was illuminated. The vehicle was towed to the dealer who diagnosed that the rods had failed due to excessive rust, causing the rods to knock. The dealer stated that the engine needed to be replaced; however, the vehicle was not yet fully inspected or diagnosed. The contact informed the dealer that the VIN was included in NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) and asked that the recall repair be completed; however, the dealer had not confirmed completion of the recall repair. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was 147,000. Parts distribution disconnect.

NHTSA ODI 11652054

The contact owns a 2014 Kia Sorento. The contact stated while driving at an undisclosed speed, the engine made an abnormal clicking sound. No warning light was illuminated. The vehicle was taken to an independent mechanic, who discovered that there was no engine oil in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 55,145.

NHTSA ODI 11650262

The contact owns a 2014 Kia Sorento. The contact stated that while driving at various speeds, the vehicle made abnormal knocking sounds. The contact stated that the failure occurred increasingly. The contact stated that upon starting the vehicle and attempting to drive later in the evening, the engine seized. There was no warning light illuminated. The vehicle was towed to Peacock Auto, where it was diagnosed and determined that the engine had seized and needed to be replaced. The vehicle was towed back to the residence. There was no warning light illuminated. The dealer was notified of the failure and informed the contact that the VIN was not included in a related recall, and that a diagnostic test was needed. The vehicle was not repaired. The contact related to the failure to Kia Campaign Number: WTY039. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 124,000.

NHTSA ODI 11649574

All of it. Car randomly shuts off and lose power steering. No. Dealership has inspected. ALL the lights in the dash light up, screen says battery discharge warning, car shuts off and lose power steering while driving down the road.

NHTSA ODI 11648264

I purchased my 2014 kia sorrento 3.3 SX in February of 2016. I was not informed at all about any issues with the engine or that there were any recalls concerning my vehicle. I have email correspondence from the dealership where years following my purchase of any safety recall notices. I had regular oil changes and normal maintenance. In March of 2024 my engine was stalling out and it smelled like burning plastic and wasn't turning over appropriately. I took it to the kia dealership and was told that the recalls had expired and that my vehicle had no oil, the engine was going to seize and I needed a new engine. Again I wasn't told at that time of any safety recall information that could lead to engine failure and or fire. I then took it to another local mechanic and had it diagnosed. I was told that I needed a nee engine that my hand gasket had blown due to premature bearing wear and severe leaks. I brought it home and I was too afraid to drive it. Then in 2025 I received another recall notice. I contacted Kia customer care and was advised that I might ne eligible for a engine rebuild, that I should have it towed to the local dealership for diagnostics to be ran yet again. The kia adviser in the service department said she was filing a claim with kia engineers and that she needed my registration and drivers license. After a week she contacted me saying my claim was denied and that my choices were to pay $13, 000 for an engine replacement or accept a trade in of $500. Again information was withheld from me concerning this vehicles recalls. At this point I am completely dumbfounded as to what to do next. My sorrento was paid off and only had 118,000 miles on it and they refused to cover anything under the 10temr or 150,000 miles extended warranty.

NHTSA ODI 11646407

The contact owns a 2014 Kia Sorento. The contact stated that while driving at approximately 55 MPH the check engine light suddenly illuminated and the vehicle experienced a loss of automotive power and reduced speeds. Smoke and flames were also present coming from the engine compartment. The vehicle was driven to the side of the road before it stalled. The fire department was called to the scene and extinguished the flames. No injuries were reported. The vehicle was later towed to the home. Fire report information was unavailable. The cause of the failures was not determined. The manufacturer and local dealer were not yet contacted. The failure mileage was 147,000.

NHTSA ODI 11646281

Engine stopped working at a red light. I was told the timing chain shattered inside the engine. This vehicle only has 150k miles on it and has been well maintained.

NHTSA ODI 11645719

Catalytic converter . Check engine light stays on

NHTSA ODI 11643388

Dear NHTSA, I am writing to report a serious safety issue with my Kia Sorento 2014. While driving on the interstate with my family, the vehicle suddenly began to slow down without warning. We were able to move to the shoulder, but this incident put our safety at significant risk as we were on a busy highway. We initially suspected brake failure, but after having the car towed home and inspected, we discovered that the motor/engine had completely failed. This failure also impacted the electrical system, leaving the car completely immobile. It has been confirmed by a mechanic that the engine is at fault. However, local dealers and mechanics were unable to inspect it further due to a lack of necessary equipment. As of now, the component has not been inspected by the manufacturer, police, insurance representatives, or any other authority. There were no warning lamps, messages, or symptoms prior to the failure, and the vehicle showed no signs of issues leading up to the incident. We purchased this car in 2023, only to find out later that Kia had issued a recall for this issue in 2021. This recall was never disclosed by the dealership, nor was it listed on the Carfax report. Due to the recall predating our purchase, Kia has refused to provide any assistance or compensation, leaving us with an inoperable vehicle and significant financial strain. As a low-income family on a fixed budget, this situation has been extremely challenging. We kindly request your assistance in investigating this matter and helping us find a resolution. Thank you for your attention and support.

NHTSA ODI 11642874

I have a problem with the electrical, and I found that they already have a recall, but the Van Nuys dealer refused to fix it on the car.

NHTSA ODI 11642573

I have a problem with the paint on the car; it keeps falling off by itself, and I tried to contact the Kia dealer for this issue, but they said to report here to you.

NHTSA ODI 11642572

The contact owns a 2014 Kia Sorento. The contact stated while driving 30 MPH, the vehicle stalled with the check engine and the ABS warning lights illuminated. The vehicle was able to be restarted; however, the failure recurred. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 148,000.

NHTSA ODI 11642346

The contact owns a 2014 Kia Sorento. The contact stated that while his daughter was driving at approximately 40-45 MPH, there was an abnormal knocking sound coming from the engine. There were no warning lights illuminated. The driver was able to pull over safely. The vehicle was towed to an independent mechanic who determined that the engine oil was a quart low. There was no indication of an oil leak or low pressure. The vehicle was consuming an excessive amount of engine oil. The mechanic determined that the engine needed to be replaced. The vehicle was repaired. The local dealer was informed that the parts were on backorder. The vehicle was not diagnosed or repaired. The contact called another local dealer, Kia of Irvine (45 Oldfield Building B, Irvine, CA 92618); but the vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 121,000.

NHTSA ODI 11639885

Burning Oil

NHTSA ODI 11639715

The check engine light keeps going on and off and I took it to go get looked at and they said I had a faulty Cadillac converter. I looked it up and it said that they had recalls on 2014 Kia sorentos for that but when I check on the website it says I have no open recalls and I'm trying to figure out why my car is not on that list because this has been an ongoing problem and now it's so bad I'm starting to smell exhaust in the car. I'm really not sure on the date that it started I just know it's been awhile. Can you please help me.

NHTSA ODI 11639779

Paint peeling on my car and looks terrible and no help at all through the Kia. Very poor service. I take care of my car and for my paint to peel this is not right at all and they Kia can't even back up the product. Kia dealer or Kia headquarters does nothing about the issue and I have to drive their product looking like this because they don't have any support with this issue.

NHTSA ODI 11639314

Had the engine replaced before and it blew up again and the Kia dealer said the ignition wasn’t recalled after they said it was a fire hazzard

NHTSA ODI 11637196

I have a 2014 Kia Sorento 4DR LX AWD with snow white pearl exterior paint. I bought the vehicle new with 91miles on it from the dealership in Mentor Ohio. The vehicle has always been in my garage when not driving. Just before Christmas I noticed a small (dime size) piece of paint missing from my drivers side pillar then a few days later on the passenger side pillar almost half the paint was gone! I took my car to the dealership and they told me that they were going to log the complaint and took my VIN and said it was probably from a stone chip in the paint? What? A stone chip does not cause almost all of the paint to flake off???? I worked at a car dealership in the Service Department for years and this is not from a stone chip - its a paint defect. I'm not sure if this letter will do anything but just wanted my paint problem noted as I've seen many other complaints about the same issue. Thank you [XXX] , OH INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11635489

Paint delaminating in multiple areas on the vehicle Both risers, hood and roof

NHTSA ODI 11635431

The contact owns a 2014 Kia Sorento. The contact stated while driving 45 MPH, the engine started to overheat with the check engine and power steering warning lights illuminated. The temperature gauge indicated that the vehicle was running hot(H). There was white smoke coming from the engine. Due to the failure, the contact pulled over and initially had the vehicle towed to the. The vehicle was later towed to an independent mechanic where the contact was informed that the head gasket was blown and needed to be replaced. While attempting to repair the vehicle, the contact was informed that the rod bearings were also defective and that the engine needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 133,000.

NHTSA ODI 11631750

The contact owned a 2014 Kia Sorento. The contact stated that while the vehicle was parked, it had caught fire causing the entire vehicle to burst into flames, from the front end to the rear end. The fire department was called and extinguish the fire. The fire department determined the fire had started from the engine. A police report was filed. There were no injuries and no medical attention needed. The fire caused damage to both vehicles on each side of the vehicle, the parking space, and the building the vehicle was parked in front of. The vehicle was towed and deemed totaled. The dealer was not contacted. The manufacturer was made aware of the failure and opened a case regarding the failure. The failure mileage was 101,430.

NHTSA ODI 11631558

The contact owns a 2014 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The VIN was included but had not been repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI 11631577

I am having issues with delamination and paint peeling off, on my driver's side pillar. The paint is the pearl white.

NHTSA ODI 11630515

My vehicle has always been well-maintained with the dealer with regularly scheduled oil changes. On the captioned date, my vehicle failed the state emissions test. Immediately after leaving the testing facility, the check engine light came on and the engine began to rumble. The vehicle barely made it to the Kia dealership. Kia told me the entire engine needs to be rebuilt for $6,500 and that may not even solve the “timing” issues.

NHTSA ODI 11624268