What 1,671 owners told NHTSA about the 2014 Ford Explorer Police Intercept

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 40 MPH, THE VEHICLE BACKFIRED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CRANKSHAFT AND CAM SHAFT SENSORS NEEDED TO BE REPLACED. THE CONTACT CALLED SUNRISE FORD OF FONTANA (LOCATED AT 16005 VALLEY BLVD, FONTANA, CA 92335, (888) 629-1239) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

NHTSA ODI 11241129

I HAVE A 2014 FORD EXPLORER. THE HEADLIGHTS ARE SO POOR IN OPERATION THAT IT IS UNSAFE TO DRIVE THE CAR AT NIGHT. UPON GOING ON THE INTERNET, I FOUND NUMEROUS COMPLAINTS FOR THE SAME EXACT PROBLEM OF CONSUMERS NOT BEING TO SEE SAFELY WHEN THE LAMPS ARE ON IN THE EVENING. THE FORD DEALERS SAY THAT THE CAR MEETS FORD SPECS AND THE FORD CO CUSTOMER SERVICE DEPT CONFIRMS THAT THEY HAD NUMEROUS COMPLAINTS AND THAT FORD HAS NO FIX. THIS IS INDEED A SAFETY ISSUE AND A FIX AND RECALL IS ESSENTIAL. *JS

NHTSA ODI 11241496

THE AIR CONDITION CAME ON BY ITSELF AND WONT GO OFF IT'S ON FULL BLASS. I TURNED THE TRUCK OFF WAITED AND STARTED IT UP AGAIN. STILL WONT GO OFF.

NHTSA ODI 11240398

THE APIN (NAVIGATION/DISPLAY) SYSTEM ON THIS VEHICLE CONSTANTLY BLANKS OUT SO YOU LOOSE ALL SAFTEY INFORMATION. GPS CONSTANTLY GOES OFF COURSE MEANING YOUR DRIVING DOWN A ROAD AND IT HAS YOU FLOATING OFF TO THE SIDE OF THE ROAD HALF A MILE AWAY AND 1/3 MILE BEHIND OR AHEAD OF YOUR LOCATION. THIS CAUSES NUMEROUS RE-ROUTES INCLUDING THOSE THAT MIGHT NOT BE SAFE TO CONDUCT. THE HEADS UP DISPLAY SYSTEM CONSTANTLY BLANKS OUT AND RESETS LOOSING ALL SAFTEY INFORMATION, SOMETIMES IT STAYS BLANK A LONG TIME. FORD HAD EXTENDED THE WARRANTY FOR APIN SYSTEM THEY KNOW IS FAULTY TO 5 YEARS I TOOK MY VEHICLE INTO SERVICE BOTH UNDER WARRANTY I PAID DEDUCTIBLE FOR AS WELL AS IN 2018 TO HAVE IT REPAIRED; THEY APPLIED THE SAME UPDATES OVER AND OVER AND REFUSED TO REPLACE THE FAULTY APIN SYSTEM. FORD NOW REFUSES TO ASSIST AND I FEEL THIS IS MAJOR SAFTEY CONCERN, NOT ONLY DOES THE PRODUCT JUST NOT FUNCTION PROPERLY BUT I FEEL ARE MAJOR SAFTEY CONCERNS WHEN THE DISPLAYS ALL BLANK OUT AND RESET OR DO NOT COME BACK ON... THIS OCCURS WHILE DRIVING. FORD REFUSES TO FIX THE PROBLEM AND ALLOWED THE EXTENDED WARRANTY THEY OFFERED TO LAPSE SO THAT THEY COULD WASH THEIR HANDS OF IT. I FEEL THIS FAULTING SYSTEM COULD RESULT INTO A CRASH OF SOME KIND BY DISTRACTING THE DRIVER WHEN BLANKING OUT; REROUTING IMPROPERLY ONTO ROADS THAT DO NOT EXIST. AND SO ON.. THIS IS CONSTANTLY HAPPENING AND SOMETIMES IT WONT HAPPEN BUT A FEW MONTHS A PART AND OTHER TIMES IT WILL HAPPEN SEVERAL TIMES A DAY WITH IN EACH OTHER.

NHTSA ODI 11233802

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE PULLING OUT OF THE DRIVEWAY, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TOWED TO O. C. WELCH FORD LINCOLN (4920 INDEPENDENCE BLVD, HARDEEVILLE, SC 29927, (843) 288-0100). THE DEALER STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER STATED THE SAME THING AS THE DEALER AND REFERRED THE CONTACT TO NHTSA. THE CONTACT STATED THAT THE DEALER ORDERED THE PART TO REPAIR THE POWER STEERING. THE FAILURE MILEAGE WAS 93,000.

NHTSA ODI 11232742

WHEN MY CAR IDLES FOR 3-5 MINUTES, DASH BOARD STARTS DINGING AND ALL SENSORS LIGHT UP. COLD AIR TURNS INTO HOT HAIR, GAGES STOP WORKING, IF I TURN OFF THE CAR THE CAR WON'T START BACK UP UNTIL 15-20 MINUTES LATER. THIS HAPPENS MORE IN THE SUMMER TIME THEN WINTER. SO FAR THIS MONTH- JULY IT'S HAPPENED 5 TIMES.

NHTSA ODI 11232425

I WAS DRIVING ON THE HIGHWAY AND HEARD A SCRAPING SOUND SIMILAR TO THE SOUND OF ICE SCRAPING ACROSS THE WINDSHIELD BEFORE IT FLIES OFF. THE NEXT MORNING I NOTICED THAT THE TRIM AROUND THE WINDSHIELD WAS GONE. I THOUGHT IT WAS JUST MY CAR BUT I AM NOW SEEING MORE EXPLORERS WITH THE SAME PROBLEM. I CALLED A FORD DEALER AND WAS TOLD THAT THERE IS NO RECALL AND THAT I WOULD HAVE TO PAY FOR THE REPAIR.

NHTSA ODI 11232621

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 60 MPH, THE CONTACT NOTICED TOXIC FUMES COMING THROUGH THE VENTS INTO THE CABIN OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED SCARSDALE FORD (LOCATED AT 887 CENTRAL PARK AVE, SCARSDALE, NY 10583, (914) 472-9500) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 67,000.

NHTSA ODI 11232078

TAKATA RECALL MY WIFE AN I TOOK YOUR FAMILY OUT FOR THE WEEKEND AN THE CALL WAS WORKING FINE BUT SUNDAY MORNING WE WERE GOING TO HEAD TO CHURCH THE CAR STARTED BUT THE STEERING WHEEL WAS STIFF AN IT WAS EVEN HARD FOR ME TO TRY AN TURN IT .. AN WE ONLY HAVE HAD THE CAR FOR THREE MONTHS NOW AN THE DEALERSHIP SAID THE CAR WAS IN GOOD CONDITION THAT THE CAR WAS FINE BC THEY LOOKED OVER IT .SO IF I WAS DRIVING DOWN THE ROAD WOULD IT STOP WORKING AN WE HAVE NEW BORNS

NHTSA ODI 11232139

LOSS OF POWER ASSISTED STEERING WHILE DRIVING. HAS OCCURRED ON NUMEROUS OCCASIONS. VERY DIFFICULT TO CONTROL VEHICLE SAFELY TO PULL OVER TO SIDE OF ROAD AND STOP AND RESTART ENGINE TO GET POWER STEERING TO WORK AGAIN. HAVE WARNINGS POP UP ON DASH 'STEERING ASSIST FAULT SERVICE REQUIRED'. FILED REPORT WITH FORD CAS-21990659.

NHTSA ODI 11231270

I TAKE VEHICLE TO THE DEALER FOR FAULTY DRIVER SIDE DOOR SENSOR AND I STRONGLY BELIEVE IT'S DEFECTIVE ON MANUFACTURING. THEN THE DEALER NOTIFY ABOUT REAR SUSPENSION TOE LINK REPLACEMENT AFFECTING THE STEERING CONTROL. THIS RECALL ALSO AFFECT THE REAR HUBS THE DEALER CHARGE TO ME $990.00+TAX TO FIX ISSUE. THE DEALER RECOMMENDS TO CHANGE BECAUSE OF THE SAFETY ISSUES. EACH HUBS HOLD THE WHEELS.

NHTSA ODI 11231123

UNAVAILABLE CMARA , PROBLEMS WHIT BACK DOOR , ENGINE LIGHT TURNING ON

NHTSA ODI 11230600

I WAS DRIVING DOWN THE HIGHWAY WHEN I WENT TO SWITCH LANES AND NOTICED MY STEERING WAS TIGHT AND HARD TO BRING BACK TO THE CENTER WHEN TURNING. MY VEHICLE CONTINUED TO HAVE THIS ISSUE WITH STEERING BEING TIGHT AND THEN THE AIRBAG LIGHT CAME ON. I WAS WORRIED ABOUT GETTING INTO AN ACCIDENT SO I MADE AN APPOINTMENT TO HAVE THE VEHICLE SCANNED AND THEY SAID IT WAS THE ELECTRIC POWER STEERING. APPARENTLY THIS IS A COMMON PROBLEM AND ACTUALLY ONE THAT I FOUND OUT BY SEARCHING ONLINE MANY PEOPLE HAVE EXPERIENCED. THE ISSUE WAS COVERED UNDER A RECALL FOR 2011-2013 MODELS AND 2015-2017 MODEL VEHICLES, BUT NOT FOR THE 2014 MODEL.THE COST TO REPAIR IS ABOUT $2000

NHTSA ODI 11229220

I RECENTLY WAS DRIVING DOWN THE HIGHWAY AT 70MPH WHEN MY CAR'S STEERING BECAME OUT OF CONTROL. IT WAS LIKE I WAS FISHTAILING ON ICE AND THE STEERING WAS LOOSE. THANKFULLY I WAS ABLE TO BRAKE AND GET INTO A GRASSY AREA OFF THE SIDE OF THE HIGHWAY. I WAS ABLE TO GET OFF THE EXIT AND DRIVE AT A SLOWER SPEED. THANKFULLY I DID NOT CRASH BUT WAS EXTREMELY CLOSE TO CRASHING.

NHTSA ODI 11229225

ON SATURDAY, 6/29/19, I TOOK MY CAR TO BOB TOMES FORD IN MCKINNEY, TX, TO HAVE RECALL 19S17 WORK DONE AS I FEEL I HAVE LIMITED CONTROL OF MY CAR DUE TO THIS SUSPENSION TOE LINK/STEERING ISSUE. I WAS TOLD FORD SENT THE WRONG PARTS AND THAT I WOULD HAVE TO WAIT A COUPLE WEEKS FOR THE CORRECT PARTS TO COME IN. I DON'T KNOW IF THIS IS TRUE. ALL I KNOW IS, I HAVE COMPLAINED TO FORD MULTIPLE TIMES AND WAS VERY GLAD TO HEAR ABOUT THIS RECALL. NOW I HAVE TO WAIT EVEN LONGER? THIS IS THE SAME RECALL FROM 2016. WHY CAN'T FORD GET IT RIGHT? SHOULD I TRADE MY FORD IN? I JUST BOUGHT IT IN MARCH 2019. I TOLD THE GUY AT FORD, IF I CRASH MY CAR BEFORE THEY CAN FIX IT, I WILL BE TAKING FORD TO COURT. HELP

NHTSA ODI 11228722

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 40 MPH AROUND A CURVE, THE STEERING WHEEL BECAME DIFFICULT TO TURN AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWER OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND ABLE TO DRIVE, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO FIRST CHOICE FORD (LOCATED AT 1264 DEWAR DR, ROCK SPRING WY 82901, (307) 382-2519) WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC STEERING GEAR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 46,291.

NHTSA ODI 11228777

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED AND THE EPS, TRACTION CONTROL, AND VARIOUS OTHER UNKNOWN WARNING INDICATORS ILLUMINATED. THE CONTACT HAD TO STRONGLY MANEUVER THE VEHICLE IN BOTH DIRECTIONS TO PREVENT A CRASH. THE VEHICLE WAS BARELY COASTED OFF THE HIGHWAY. WHEN THE VEHICLE WAS SHUT OFF AND RESTARTED, THE VARIOUS WARNING INDICATORS STILL FLASHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS DIAGNOSED AND REPAIRED. THE VEHICLE WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBERS: 14V286000 (STEERING) AND 14E001000 (STEERING); ALTHOUGH, THE VEHICLE EXHIBITED THE SAME FAILURE. APPLE FORD SHAKOPEE (1624 WESTON CT, SHAKOPEE, MN 55379, (952) 445-2420) WAS CONTACTED AND INDICATED THAT THE VEHICLE WOULD NEED TO BE SCHEDULED FOR AN APPOINTMENT THE FOLLOWING MONDAY OR TUESDAY FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 73,000. *BF CONSUMER STATED THE RACK AND PINION STEERING ASSIST WAS REPLACED. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

NHTSA ODI 11223139

STEERING GRABS AND PULLS MY CAR WHILE DRIVING. HARD TO TURN STEERING WHEEL. NO LIGHTS OR MESSAGES APPEAR. CONTACTED DEALERSHIP DUE TO THEM FIXING THE REAR SUSPENSION TOE LINKS. THEY ADVISED IT HAS NO EFFECT ON THE STEERING OF MY SUV. I WAS DRIVING 45-50 MILES MPH ON HWY 72 FREDERICKTOWN MO TRIEING TO SLOW DOWN TO TURN LEFT.

NHTSA ODI 11222673

VEHICLE STEERING ASSIST MALFUNCTION LIGHT CAME ON AND I LOST ALL STEERING CAPABILITIES. I AM A 220 POUND MAN THAT HAD TO STRUGGLE TO GET THE VEHICLE TO THE SIDE OF THE ROAD. THE STEERING WHEEL LITERALLY LOCKED IN THE POSITION IT WAS IN. MY WIFE COMPLAINED ABOUT THIS PROBLEM EARLIER IN THE DAY. THANK GOD SHE WAS ABLE TO PULL TO THE SIDE OF THE ROAD. STEERING ASSIST MALFUNCTION LIGHT APPEARED AND JUST AS QUICK AS THIS LIGHT CAME ON, WE LOST ALL STEERING. EXTREMELY DANGEROUS CONDITION!!! I HAVE PARKED THE SUV IN THE GARAGE AND HAVE NOT USED IT SINCE. FORD ACKNOWLEDGES THIS PROBLEM IN THE 2011-2013 AND 2015-2017 VEHICLES. IT'S OBVIOUSLY AN ISSUE FROM 2011-2017. WHY WAS 2014 EXCLUDED FROM THIS RECALL?

NHTSA ODI 11222063

DRIVERS SIDE (WINDSHIELD OUTER MOULDING TRIM PILLAR) FLEW OFF WHILE DRIVING ON THE FREEWAY NEARLY HITTING CARS BEHIND ME CONTINUING TO RUBBER FLAP POUNDINGON WINDOW AND MIRROR UNTIL RUBBER FLAP ALSO FLEW OFF.

NHTSA ODI 11221056

DRIVER SIDE SEAT BELT BUCKLE WOULD NOT ENGAGE / LOCK. THIS BECAME A PROBLEM EVERY ONCE IN A WHILE AND THEN STEADILY GOT WORSE TO THE POINT THE BUCKLE WOULD NOT ENGAGE / LOCK ALL TOGETHER. FORD REPLACED UNDER EXTENDED WARRANTY (BILLED EXTENDED WARRANTY COVERAGE COMPANY FOR PART AND LABOR) - I BELIEVE THIS PART SHOULD HAVE BEEN COVERED BY FORD DIRECTLY SINCE IT HAS TO DO WITH DRIVER SAFETY. ASKED ABOUT THIS PART BEING AN ISSUE ON OTHER FORDS AND WAS TOLD IT WASN'T A KNOWN ISSUE. I'VE OWNED DOZENS OF CARS AND HAVE NEVER EXPERIENCED THIS PROBLEM.

NHTSA ODI 11220427

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE STEERING WHEEL WOULD SPORADICALLY TIGHTEN AND THE "STEERING ASSIST FAULT" AND "CHECK CHARGING SYSTEM" INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC REFERRED THE CONTACT TO BRANDON FORD (9090 E ADAMO DR, TAMPA, FL 33619, (813) 246-3673) WHERE IT WAS DIAGNOSED THAT A NEW ALTERNATOR WAS NEEDED. THE CONTACT HAD THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC FOR A SECOND OPINION. THE MECHANIC REPLACED THE ALTERNATOR. THE FAILURE RECURRED AND THE CONTACT CALLED THE DEALER WHO INFORMED HER THAT THE ALTERNATOR SHOULD HAVE BEEN REPLACED WITH ONE FROM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED AGAIN. THE CONTACT WAS CONCERNED THAT THE DEALER WAS RECOMMENDING A HIGHER REPAIR BILL. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

NHTSA ODI 11219977

ON APRIL 10, 2019 WE WERE PULLING OUT OF MY DRIVE WAY TO LEAVE MY HOUSE AND NOTICED A GRINDING SOUND COMING FROM THE FRONT END, IT WAS VERY LOUD. WE TOOK IT TO A REPUTABLE MECHANIC COMPANY LOCAL TO DO A DIAGNOSTIC THE SOUND. THIS COMPANY IS ASE-CERTIFIED. AFTER REVIEWING MY EXPLORER THEY STATED THAT THE RACK AND PINION WAS BAD AND IT NEEDED TO BE REPLACED ASAP DUE TO THIS BEING A MAJOR SAFETY ISSUE AND WE SHOULDN'T WAIT TO GET IT REPLACED. $1998.21 LATER WE RECEIVED THE CAR BACK THE NEXT DAY FIXED. I HAD CALLED FORD AND EXPLAINED TO THEM THAT THIS WAS A SAFTEY ISSUE AND WE HAD READ ON LINE THAT THE PREVIOUS YEARS HAVE BEEN RECALLED. THEY TOLD ME THAT MY YEAR DOESNT HAVE A RECALL AND STATED I COULD WRITE A LETTER AND THAT WAS ALL I COULD DO. I ALSO ASKED IF ANYONE WOULD FOLLOW UP WITH ME AND FORD COULDNT ANSWER MY QUESTIONS. WE JUST RECEIVED ANOTHER RECALL NOTICE FOR THE TOE LINK. SO THAT CAR IS GOING BACK TO THE DEALER FOR THAT WORK. THIS IS RECALL NUMBER 4 THAT I HAVE HAD TO TAKE THE CAR BACK TO THE DEALERSHIP FOR.

NHTSA ODI 11220021

TAKATAT RECALL?? I GOT IN MY CAR 1 MORNING TO GO TO WORK AND I COULDN'T GET THE MALE PART OF DRIVERS SEATBELT INTO THE FEMALE PART OF SEATBELT. MY DIVERS AIRBAG SEATBELT LIGHT HAS BEEN ON FOR 2 MONTHS. I CANNOT BUCKLE DRIVERS SEATBELT INTO THE FEMALE PART OF THE SEATBELT SO WHEN I AM BY MYSELF I BUCKLE DRIVER SEATBELT INTO PASSENGER SEATBELT. I CALLED MARSHALL FORD IN O'FALLON MISSOURI THEY TOLD MY I NEEDED TO PAY $150.00 FOR THEM TO PUT MY CAR ON THE MACHINE FOR THEM TO FIGURE OUT WHAT SENSOR IS BAD. I CANNOT AFFORD TO PAY $150.00 MUCH LESS PAY FOR THE REPAIRS. PLEASE TELL ME IF THERE IS ANOTHER FIX. MY CAR HAS NEVER BEEN IN AN ACCIDENT. HELP!

NHTSA ODI 11219726

POWER STEERING FAILURE WHILE IN MOTION ON INTERSTATE

NHTSA ODI 11219887