What 1,671 owners told NHTSA about the 2014 Ford Explorer Police Intercept

My APillar molding piece flew off the passenger side of my wind shield. I’m scared the other side will do the same thing and I don’t want anyone to get hurt but I have to use my car. I have been waiting 6 months for the parts… Also, whenever it rains my floorboards flood from water leaking through my windshield and could possibly get into my electronics as well.

NHTSA ODI 11632910

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11631415

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel seized with the traction control and check engine warning lights illuminated. The contact stated that the steering wheel became difficult to turn. The vehicle was towed to the dealer where it was diagnosed and determined that the power steering control module (PSCM) had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 131,856.

NHTSA ODI 11631282

The vehicles steering stopped working with no warning and a Steering Assist Fault alert came on the dashboard.

NHTSA ODI 11630992

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11630165

The contact owns a 2014 Ford Explorer. The contact stated while driving 10 MPH, the exterior windshield trim on the passenger's side detached and flew off the vehicle. Additionally, the contact stated that while it was raining, rainwater was leaking into the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ODI 11629261

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 65 MPH, the front passenger's side windshield exterior A-Pillar trim separated and flew off by the slipstream. An unknown local dealer was contacted and advised the contact that the part to do the recall repair was not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 170,000. VIN tool confirms parts not available.

NHTSA ODI 11627679

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the A-pillar trim on the driver's side of the windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the dealer went to the residence and diagnosed the vehicle and determined that the exterior A-pillar applique trim had failed and needed to be replaced. The vehicle was not repaired due to the parts not being available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 60,000. VIN tool confirms parts not available.

NHTSA ODI 11627488

The electric steering went out on my way home on a very curvy road. The rack and pinion apparently has failed. Please recall this part to get it fixed before someone gets hurt.

NHTSA ODI 11627096

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11626819

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11626893

Received this recall notice from Ford in February of 2024. Dealership still advises parts are not available to complete the recall. Left side pillar cover is loose.

NHTSA ODI 11626671

Making a right turn I was startled by a vehicle running a red light. Front wheel passenger side cleared the curb. Right rear tire jumped the curb jolted back to ground. I looked at tire pressure gauges and no leaks were evident. Being on a single lane road I continued driving looking for a turn in place after traveling about a quarter of a mile an engine rattle developed and there was faint smell of smoke. I traveled another block and turned into a dollar general parking lot. The entrance was on an incline and the car stopped. I had just purchased a new battery a week before and had an oil change about 3 weeks before. The car refused to start. I called triple A and had it towed to dealer. They looked at car and could not come up with a rational reason and doubted car stopped because of violent rear contact with curb at right rear wheel was cause of engine seizing. I called USAA my insurance company their investigating agent agreed. My car is serviced at this dealer and I follow all of the maintenance guidelines I have the records as well as dealer. The car has 125,000 miles and has been well maintained. I am curious if there are any other reports this has happened with 2014 Ford Explorer or any other vehicle. I find it hard to accept such a violent jolt of the running engine did not cause something to fall loose on the running engine. The dealer and appraiser found the car oil full and in pristine condition. There was no frame damage.Turning the crank towards rear they hear metal falling into oil pan. Your thoughts?

NHTSA ODI 11626686

The contact owns a 2014 Ford Explorer. The contact stated while driving at approximately 35 MPH, the air bag warning light was blinking off and on. The contact had taken the vehicle to an independent mechanic and was informed that the vehicle needed to be taken to a dealer for assistance. The contact stated that the dealer diagnosed the vehicle and determined that the second-row seat belt harnesses had an electrical issue which was preventing the air bags from functioning as needed in the rear seat harnesses and the passenger and driver's frontal air bags. The dealer referenced Technical Service Bulletin Number: 16-0001 as a possible fix to repair the vehicle. The contact was provided an estimate for the repair but declined to pay for the repair. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 50,000.

NHTSA ODI 11625989

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at approximately 60 MPH, the front passenger’s side A-pillar trim detached. In addition, several months later while driving approximately 45 MPH, the front driver’s side A-pillar trim detached. The contact was able to retrieve both A-pillar trims and temporarily repaired the vehicle with an adhesive. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 108,000. VIN tool confirms parts not available.

NHTSA ODI 11624210

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11623983

Lane keeping system malfunction. Steering assist malfunction. I have no power steering and it’s hard to control vehicle. Ford diagnosed that I need a new steering rack and sensor.

NHTSA ODI 11623742

The contact owns a 2014 Ford Explorer. The contact stated that the rubber around the front windshield had become loosened. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The dealer informed the contact that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The approximate failure mileage was 68,000. VIN tool showed no open recall.

NHTSA ODI 11623064

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11621586

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11621267

Vehicle has been under recall since February of 2024. The exterior A-pillar applique trim clip attachments were not properly engaged due to improper assembly. This trim piece fell off in highway traffic of 70 mph. Ford is still showing that the repair is not yet available.

NHTSA ODI 11621375

The contact owns a 2014 Ford Explorer. The contact stated while driving approximately 40 MPH, the vehicle lost power steering functionality, causing the steering wheel to become difficult to turn in either direction. The vehicle was towed to the local mechanic who diagnosed that the steering rack was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 60,346.

NHTSA ODI 11620671

The contact owns a 2014 Ford Explorer. The contact stated that while reversing, the rearview camera displayed an inverted image. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 160,000.

NHTSA ODI 11618550

The contact owns a 2014 Ford Explorer. The contact stated that while driving approximately 20 MPH and making a left turn, the vehicle suddenly lost power steering functionality. The traction control and the electronic stability control warning light were illuminated. The vehicle was towed to an independent mechanic, where the contact was informed that the failure might be related to the power steering control module(PSCM); however, the vehicle was not diagnosed or repaired. No further information was provided. The manufacturer was made aware of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was 170,000.

NHTSA ODI 11618053

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the trim had started to detach, causing water to leak into the cabin of the vehicle. The dealer was contacted. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

NHTSA ODI 11617871