What 1,671 owners told NHTSA about the 2014 Ford Explorer Police Intercept

The contact owns a 2014 Ford Explorer. The contact stated that while driving approximately 10-12 MPH and coming to a stop, the steering wheel seized. The contact stated that the failure almost caused a crash. The contact quickly veered to the emergency lane and turned on the hazard lights. The traction control warning light and the warning message "Steering Loss. Stop Safely" illuminated. The vehicle was being towed to the dealer and had not been diagnosed or repaired. The contact referenced NHTSA Campaign Number: 14V286000 (Steering). The manufacturer was notified of the failure and informed the contact that they could not assist because the VIN was not included. The manufacturer referred the contact to NHTSA for assistance. The failure mileage was approximately 90,000.

NHTSA ODI 11454474

The contact owns a 2014 Ford Explorer. The contact stated while pulling into a parking spot, the steering wheel became difficult to turn. The contact stated that the power steering assist warning light was illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 170,000.

NHTSA ODI 11452824

The contact owns a 2014 Ford Explorer. The contact stated that while attempting to reverse from the residence, the steering failed to turn either to the left or the right. The power steering assist warning light was illuminated. The vehicle was not taken to be diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 97,658. Vehicle has not been repaired.*JB THE CONSUMER STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL, BUT BELIEVED IT SHOULD HAVE BEEN. THE CONSUMER REFERENCED RECALL 14V28600.

NHTSA ODI 11452555

Was pulling up to gas pumps when steering failed/locked. Was able to stop vehicle to avoid collision with pumps. Steer Assist Fail warning light came on. Shut vehicle off and warning light went out and steering came back. Brought vehicle home and used other to go to work. Was told by dealer that the Steering Rack is faulted and needs replacement at 71000 miles. The 2014 Steering racks fail at between 60000-80000 miles just as the 2011-2013 Explorers do and need to be recalled before someone is killed.

NHTSA ODI 11452220

While driving I noticed the power steering had failed. The steering was difficult and jerky while making turns and while coming out of turns. With the steering inconsistent the vehicle would on occasion not come out of the turn on it's own and put myself and my family at risk of an accident. The vehicle was brought to Salem NH Ford and the problem was found to be the steering rack and lower steering u-joint, shaft assembly, and pinion. There were no warning lights on the dash. Repairs for vehicle totaled $3,346.31

NHTSA ODI 11451355

The contact owns a 2014 Ford Explorer. The contact stated that while turning the steering wheel there was an abnormal knocking and ticking sound detected. The maintenance warning light was illuminated. The contact called the local dealer and was provided a fee for diagnostic testing. The vehicle was not diagnosed or repaired. The contact stated the failure was related to NHTSA Campaign Number 21V537000 (Suspension). The manufacturer was contacted but no further assistance was provided. The approximate failure mileage was 122,000.

NHTSA ODI 11450191

Engine water pump leak the pump is internal and can potentially cause engine damage. Steering some times the power assist fails and you have to turn-off and restart the car to get the steering to work

NHTSA ODI 11448667

My steering started going out when I was merging infront of a truck. I was almost run off the road and hit by the truck at the same time but I muscled it.. it started working again for a second then went completely out saying power steering disabled pull over safely. I finally got to a place where I could pull over. Called a tow truck and my car has been sitting at the shop for months because Ford won't send the parts that were ordered. In looking up ways to get the parts I saw that there were so many other complaints of the same exact problem. I then looked up to see if there was a recall and the make and model was part of a recall but in looking up the VIN# it didn't show a recall. This issue could have killed me and from the other reports I've read it almost killed many others with the same car as well. Power Steering was inoperative. Code U3000 (control module) stored. Replace PCSM and program. PCSM is integrated into the steering rack. Integral part of the steering gear assembly. Includes lower subframe Program PCM. Is what the mechanic has put on the service order. My car was towed to the mechanic on 11/3/21. The part was ordered but Ford has yet to fill the order. The date today is 1/12/22

NHTSA ODI 11447182

Steering Gear Failure. Mileage: 119,000 - ERROR MSG: "Steering Wheel Default. Seek immediate attention". Visiting family over the holidays in a different State - December 23th. Complete Steering shutdown. There are already recalls by Ford on their 2011-2013 for this very problem. - This was a very early 2014 model Sept/Oct. of 2013. Ford dealer quoted greater than > $2500.00 to replace. No Parts availability - Amazing that other owners of 2014 Explorers have the exact same steering problem just within the past 2-3 months on this site. Please Ford !!!!! - Time to include 2014 as part of an earlier recall for SAME EXACT PROBLEM for previous 3 model years

NHTSA ODI 11445949

Steering gear failure. Ford dealer estimate $2,900 to replace the entire steering gear. A new part is not available, and there is no ETA on re-manufactured parts. The vehicle is unsafe to drive, and therefore unusable. There are recalls on 2011-2013 and 2015-2019 electronic assist steering gear systems for the same exact issue, why was 2014 was excluded, why does the vehicle require the entire steering gear after only 7 years of use, and why wont Ford take responsibility for a known failing and dangerous product. Ford CRC case # CAS34688035 has refused to take responsibility or assist.

NHTSA ODI 11444752

PCSM Power steering module. Sensor on Rack and pinion. Can inspect if needed. Steering goes out at random. Can be driving at any speed and loose all steering elements and traction control. Complete loss of steering occurs occasionally. Ford confirmed the issue and stated it was recalled in 2011-2013 models but not 2014, $2500 fix. Three lights appeared as all steering was lost on highway: Terrain management system fault, Power steering assist fault, service advanced track.

NHTSA ODI 11443298

The contact owns a 2014 Ford Explorer. The contact stated that while starting the vehicle, the “Steering Wheel Default, Seek Immediate Attention” warning message was displayed. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but informed the contact that the VIN was not under recall. The failure mileage was 168,075.

NHTSA ODI 11443140

****** DUPLICATE VOQ ****** THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE IT IS AN INADVERTENT DUPLICATE OF ODI# 11442983*DJR ***** DUPLICATE VOQ ******

NHTSA ODI 11442984

The contact owns a 2014 Ford Explorer. The contact stated that while starting the vehicle, the "Steering Wheel Default, Seek Immediate Attention" warning message was displayed. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but informed the contact that the VIN was not under recall. The failure mileage was 168,075.

NHTSA ODI 11442983

Recently started experiencing a weird noise coming from the front end near the wheel area. The noise was also physical since I could feel it through the steering wheel. I did take it to a manufacturer locally they could not duplicate the issue. I explained to them that they needed to keep it longer than a couple hours in order to duplicate the problem. I did feel like the dealer did not inspect my vehicle long enough by keeping it and driving it.

NHTSA ODI 11442669

When turning the steering wheel, you can hear a terrible squeaking noise coming from the front end of the vehicle in the center. Over time the squeaking gets worse and worse. Steering the vehicle is becoming harder to control, when letting off the gas, the whole steering wheel will stay straight but the actual wheels are quickly do a hard pull to the right. This is extremely unsafe and is likely to cause an accident. Yes the problem has been reproduced by a service center. They told me this is the same issue with the 2013 (1 year older) and there was a recall on that year, however not the 2014, even though the same part was used in the 2014 also. There are no warning lamps, or messages. They have been gradually getting worse since I purchased the vehicle.

NHTSA ODI 11440485

After having the Water Pump exchanged (on 9/8/21) and a multi-point inspection done, and finding no issues, we went on a road trip. While driving on freeways, we noticed that while in a gentle curve of the road to the left, the steering wheel would not return to the neutral position when the road straightened. As we drove home, it became worse, to where we we would have to forcefully turn the wheel to straighten back to neutral. Returned Explorer to dealership 9/21/21. They finally were able to figure out it was the Rack and Pinion that needed replaced. We got the Explorer back on 10/13/21. Please hold Ford responsible for this issue as they have not fixed the problem that was on other years and this is no different.

NHTSA ODI 11438389

The electric power steering is failing. Turning the steering wheel is becoming more difficult. I fear it will completely stop working. Earlier 2013 models have recalls for this. There has not been a recall for the 2014 model. I am bringing it to the Ford dealer 10/26/2021

NHTSA ODI 11437814

On August 14th, whilst on vacation in New Mexico, the steering of my 2014 Ford Explorer completely seized in the middle of the road, and left us helpless. Thankfully, we were on a relatively quiet side street in Taos. Just a few days earlier we were traveling up and down the steep winding roads to the top of Pikes Peak. We are thankful that this malfunction did not happen during this time, as the results could have been catastrophic. I have since read related safety recall notices for this issue, and the symptoms described in thse notices are exactly as I experienced. I am very surprised that my vehicle is not covered by any of the safety recalls. The failed rack and pinion was sent back to Ford for analysis. It is a sealed unit so the Ford mechanics at Capitol Ford in Sante Fe were unable to comment.I have attached a photo of the part. For reference with the cost of towing, repairs, car rental and flights, my outlay has been approximately $4,500. I have the necessary documentation to support this figure.

NHTSA ODI 11432591

About 2 weeks ago my steering wheel started making a noise whenever I turned the wheel both parked or moving. Since then it has progressed into a loud grinding noise. The wheel is sticking while driving on the highway and I have to force it to move at times. It does not return freely anymore on it's own to a straight forward position. After having the vehicle inspected atva local suspension shop, they told me it's dangerious and I could loose my steering entirely while driving and to have the rack and pinion replaced. I can see this is a common problem with this model and there was a similiar recall a few years prior for a similar problem. I don't think the proper improvements to the rack and pinion where ever applied in later models and there should be another recall or the prior recall should be extended. Thank you.

NHTSA ODI 11432049

The contact owns a 2014 Ford Explorer. The contact stated while driving 55 MPH, the steering wheel became difficult to turn. The contact had to turn the steering wheel with force to steer the vehicle. The contact stated that the cruise control was disabled, and the traction control warning light was illuminated when the failure occurred. The contact drove the vehicle home. The contact started the vehicle the following day and the power steering warning light illuminated on the instrument panel. The vehicle was taken to the dealer. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 143,310. Consumer stated the following morning steering locked up and was taken to the dealer. Dealer stated power steering needed to be replaced. While loading power steering broke free but makes a lot of noise. Consumer has not driven the vehicle since the failure and has noted 2014 Explorers were not included in the recalls.

NHTSA ODI 11430744

The contact owns a 2014 Ford Explorer. The contact stated that while driving at various speeds and occasionally at start-up, the vehicle would suddenly lose power steering functionality. The power steering assist fault warning light was illuminated. The contact stated that after starting the vehicle several times the power steering regained normal function. The contact stated that recently the power steering failed to reset. The dealer was contacted and stated that the rack and pinion needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the issue and referred the contact to NHTSA to file a complaint. The approximate failure mileage was 162,423.

NHTSA ODI 11430636

The contact owns a 2014 Ford Explorer. The contact stated that while operating the vehicle, the power steering failed, and the steering wheel became very difficult to turn in either direction. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 139,000.

NHTSA ODI 11427855

Power steering stopped while driving

NHTSA ODI 11427360

Steering is loose, and makes a sharp jerk to one side multiple times while driving and I am unable to keep control where the vehicle could crash.

NHTSA ODI 11427241