What 1,671 owners told NHTSA about the 2014 Ford Explorer Police Intercept

I HAVE A 2014 FORD EXPLORER XLT, RECENTLY MY PASSENGER SIDE WEATHER STRIP ALONG THE FRONT WINDSHIELD BLEW OFF WHILE DRIVING ON A HIGHWAY. MY DRIVER SIDE DID THE SAME ABOUT 3 MONTHS AGO. THE PLASTIC TRIM PIECE ALONG THE FRONT WINDSHIELD, DRIVER SIDE IS LIFTING ALSO, I HAVE TRIED TO RE-GLUE SEVERAL TIMES BUT DOES NOT SEEM TO LAST. THIS SHOULD BE FIXED BY FORD, I HAVE READ A LOT OF COMPLAINTS ABOUT THIS. THESE POSE A SAFETY ISSUE IF THE PLASTIC TRIM PIECE BLOWS OFF ON THE HIGHWAY.

NHTSA ODI 11363716

THE WINDSHIELD OUTSIDE PILLAR/TRIM MOLDING OF A 2014 FORD EXPLORER, FLEW OFF CAR WHILE DRIVING (65MPH) ON THE HIGHWAY. THIS IS THE SECOND INCIDENT WITHIN LESS THAN A YEAR. AND FROM WHAT I GATHERED FROM DEALERSHIP AND ONLINE RESEARCH, IT'S A VERY WELL KNOWN PROBLEM.

NHTSA ODI 11362448

YESTERDAY I WAS DRIVING DOWN THE FREEWAY AND THE WINDSHIELD SIDE PANEL AND RUBBER FLEW OFF WHILE I WAS DRIVING. THE PLASTIC PIECE HIT THE CAR BEHIND ME. VERY SCARY AND UNSAFE. THIS IS GOING TO COST ME OVER 500$ TO REPLACE AND THIS IS AN EXPENSIVE CAR. I ALSO MAINTAIN MY CAR WELL AND TAKE CARE OF IT. THIS IS NOT SOMETHING THAT SHOULD HAPPEN. THE WINDSHIELD REPAIR SHOP SAID THEY SEE THIS PROBLEM ON MY CAR ALL THE TIME. THIS IS UNACCEPTABLE AND DANGEROUS. FORD SHOULD HAVE TO FIX THIS PROBLEM BEFORE IT CAUSES A MAJOR WRECK AND SOMEONE DIES. *TR

NHTSA ODI 11330813

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE DRIVER'S SIDE FRONT DOOR PANEL DETACHED FROM THE DOOR FRAME. THE VEHICLE WAS TAKEN TO THE SOO MOTORS FORD (391 3 MILE RD, SAULT STE. MARIE, MI 49783, (906) 632-2278) WHO INFORMED THE CONTACT THAT THE DOOR PANEL NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED THAT THE REPAIR WAS NO LONGER COVERED UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO THE NHTSA TO FILE A COMPLAINT. THE APPROXIMATE FAILURE MILEAGE WAS 93,382.

NHTSA ODI 11330276

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THERE WAS CORROSION BUBBLES ON THE HOOD. THE VEHICLE WAS TAKEN TO GIBBONS FORD (704 MARTIN F. GIBBONS BLVD, DICKSON CITY, PA 18519, (570) 489-4747, WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO STONE CHIPS. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT COLLISION CENTER BUT NOT REPAIRED. THE MANUFACTURER WAS CONTACTED BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 36,000.

NHTSA ODI 11325408

DRIVER SIDE EXTERIOR DOOR HANDLE CAME OFF WHEN DOOR WAS OPENED WHILE STATIONARY.

NHTSA ODI 11281372

MY PANORAMIC SUNROOF/MOON ROOF SHATTERED FOR ABSOLUTELY NOT REASON RANDOMLY TONIGHT WHILE SITTING STATIONARY IN THE DRIVEWAY (NOT PARKED UNDER ANYTHING!). THANK GOODNESS I HAD MY VISOR CLOSED OR IT WOULD HAVE SHATTERED ALL OVER MY 2 CHILDREN

NHTSA ODI 11277218

WINDSHIELD MOLDING ON BOTH SIDES HAS JUST BLOWN OFF WHILE I AM DRIVING ON THE FREEWAY AND THE DRIVER SIDE PASSENGER DOOR MOLDING HAS ALSO FLOWN OFF WHILE DRIVE IN THE CANYON. I HAVE HAD ALL THREES PANELS BLOW OFF WHILE I WAS DRIVE WITH IN 3 MONTHS AND I AM SO MAD ABOUT IT BECAUSE THEY ARE SO EXPENSIVE TO REPLACE. NOT ONLY ARE THEY EXPENSIVE IF IT RAINS IT IS GOING TO RAIN STRAIGHT INTO MY CAR THIS IS A HORRIBLE HAZARDOUS PROBLEM THAT NEEDS TO BE FIXED. I AM LUCKY THAT ONE OF THOSE PANELS DIDNT HIT SOMEONE ELSES CAR AND CAUSE DAMAGE OR WORSE BECAUSE THOSE ARE BIG THICK MOLDING THAT COULD REALLY CAUSE MAJOR DAMAGE TO SOMEONE ELSE AND THEIR VEHICLE. I HAVE HAD OTHER FORD VEHICLES AND I BOUGHT THIS ONE REALLY EXCITED AND HAS BEEN NOTHING BUT DISAPPOINTING. SO LONG STORY SHORT 3 DIFFERENT PANELS/MOLDING FLEW OFF MY CAR IN THE CANYON OR FREEWAY ON 3 DIFFERENT OCCASIONS AND IT IS SO DANGEROUS.

NHTSA ODI 11241798

I WAS DRIVING ON THE HIGHWAY AND HEARD A SCRAPING SOUND SIMILAR TO THE SOUND OF ICE SCRAPING ACROSS THE WINDSHIELD BEFORE IT FLIES OFF. THE NEXT MORNING I NOTICED THAT THE TRIM AROUND THE WINDSHIELD WAS GONE. I THOUGHT IT WAS JUST MY CAR BUT I AM NOW SEEING MORE EXPLORERS WITH THE SAME PROBLEM. I CALLED A FORD DEALER AND WAS TOLD THAT THERE IS NO RECALL AND THAT I WOULD HAVE TO PAY FOR THE REPAIR.

NHTSA ODI 11232621

DRIVERS SIDE (WINDSHIELD OUTER MOULDING TRIM PILLAR) FLEW OFF WHILE DRIVING ON THE FREEWAY NEARLY HITTING CARS BEHIND ME CONTINUING TO RUBBER FLAP POUNDINGON WINDOW AND MIRROR UNTIL RUBBER FLAP ALSO FLEW OFF.

NHTSA ODI 11221056

WHILE DRIVING ON THE FREEWAY ON 2 OCCASIONS, THE A-PILAR TRIM PIECES HAVE FLOWN OFF OF BOTH THE DRIVER AND PASSENGER SIDE. THIS NEARLY CAUSED A COLLISION FOR THE VEHICLES DRIVING AROUND ME. I ALSO LEARNED THAT POSSIBLY SECONDARY TO THE TRIM PIECES FLYING OFF, THE VEHICLE IS NOW COLLECTING WATER ON BE FLOORBOARD WHICH HAS LED TO A MOLD INFESTATION IN THE VEHICLE. FORD SAID THE AFOREMENTIONED DESCRIBED ITEMS ARE NOT A MANUFACTURED OR WARRANTY REPAIR. NOW MY 5 MONTH OLD CHILD IS EXPLODED TO MOLD BECAUSE FORD CANNOT LOCATE WHERE THE VEHICLE IS LEAKING FROM.

NHTSA ODI 11181370

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE FRONT WINDSHIELD TRIM DETACHED FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 141,000.

NHTSA ODI 11155160

THE BLACK WINDSHIELD MOULDING ON THE DRIVER CAME LOOSE. THIS IS THE SECOND TIME THIS HAPPENED. I WAS ON THE HIGHWAY.

NHTSA ODI 11152046

THE PLASTIC COVERING ON THE DRIVERS SIDE WINDOW PILLAR FLEW OFF WHILE GOING THROUGH AN AUTOMATED CAR WASH. AFTER INSPECTING THE PASSENGER SIDE I NOTICED IT IS LOOSE ALSO AND WILL PROBABLY FLY OFF AT SOME POINT ALSO.

NHTSA ODI 11122363

FOR ABOUT 8 MONTHS I HAVE BEEN SUFFERING FROM DIZZINESS SPELLS THAT HAPPEN QUITE OFTEN, NAUSEA , HEADACHES, BLURRED VISION, AND ANXIETY THAT IS BROUGHT ON FROM THESE SYMPTOMS. I HAVE BEEN TO THE DOCTOR COUNTLESS TIMES ATTEMPTING TO FIGURE OUT THE PROBLEM OF THE CAUSE OF MY SICKNESS. BEFORE I FOLLOWED UP ON THE RECALL I WASN'T AWARE THAT MY CAR WAS BEING RECALLED FOR CARBON MONOXIDE CONCERNS. BUT IT ALL MAKES SENSE THE MAJORITY OF TIME I FEEL THESE SYMPTOMS IS EITHER WHEN I'M DRIVING OR HAVE FINISHED DRIVING. (NEXT DR'S VISIT I WILL REQUEST THEY DO LAB WORK FOR POTENTIAL CARBON MONOXIDE POISONING.) OF COURSE ALL THE SYMPTOMS LINGER BECAUSE OBVIOUSLY IT STAYS IN MY SYSTEM. I FEEL LIKE MY CAR IS MAKING ME REALLY SICK. I AM AFRAID TO DRIVE MY CAR THAT I HAVE HAD FOR 2 YEARS.

NHTSA ODI 11120017

I WAS DRIVING ON THE INTERSTATE AND BOTH PIECES OF THE WINDSHIELD TRIM FLEW OFF WITHIN 10 MINUTES OF ONE ANOTHER. LUCKILY ONE WAS PARTLY DETACHED AND I WAS ABLE TO KEEP IT FROM FLYING AND HITTING ANOTHER VEHICLE, BUT THE OTHER ONE FLEW OFF. LUCKILY, IT DID NOT HIT ANOTHER VEHICLE, BUT EASILY COULD HAVE HIT A VEHICLE BEHIND OR BESIDE US.

NHTSA ODI 11113576

THE A-PILLAR EXTERIOR MOLDING FELL OFF. THIS WAS THE SECOND TIME SUCH A PART FALLING OFF. THIS TIME IT WAS THE DRIVER SIDE. THE FIRST TIME WAS A YEAR AGO ON THE PASSENGER SIDE. THE A-PILLAR EXTERIOR MOLDING FELL OF ON THE FREEWAY AT HIGH SPEED. THE CAR WAS ESSENTIALLY A HIGH-SPEED ROAD HAZARD TO PUBLIC SAFETY, BECAUSE THE POINTED HARD PLASTIC MOLDING BECAME A PROJECTILE THAT CAN SERIOUSLY HURT SOME CAR OR PEOPLE BEHIND.

NHTSA ODI 11091284

I AM WRITING TO YOU IN REGARDS TO PHYSICAL ILLNESS THAT I HAVE SUFFERED AS WELL AS MY PASSENGERS FROM MY 2014 FORD EXPLORER POLICE INTERCEPTOR PACKAGE. STARTING BACK WHEN I FIRST PURCHASED THE VEHICLE AT APPROXIMATELY 59,000 MILES, I HAVE EXPERIENCED AN EXHAUST ODOR IN THE CABIN SHORTLY AFTER ACCELERATING OVER 3,000RPMS. THIS ISSUE HAS BEEN INVESTIGATED AT MY LOCAL DEALERSHIP TWICE, WITH THE TECHNICIAN CONFIRMING THE SMELL. AFTER THIS WORK WAS PERFORMED, I STILL TO THIS DAY AM SUFFERING FROM EXHAUST FUMES AND PHYSICAL ILLNESS DIRECTLY RELATED TO MY FORD EXPLORER. ALL REPAIR ORDERS FROM INVOLVED FORD DEALERSHIPS ARE IN MY POSSESSION CONFIRMING EXHAUST FUMES ARE STILL ENTERING THE CABIN. FROM THE TIME I TOOK OWNERSHIP IN OCTOBER 2016, I HAVE EXPERIENCED PHYSICAL ILLNESS WHEN DRIVING THE VEHICLE FOR MORE THAN 1 HOUR AT A TIME. I GET EXTREMELY LIGHTHEADED AND NAUSEATED, WHICH HAS CAUSED ME TO FREQUENTLY STOP THE VEHICLE AND VOMIT. MY PASSENGERS IN THE VEHICLE HAVE ALSO EXPERIENCED SIMILAR SYMPTOMS WHEN RIDING IN THE VEHICLE. WHEN THIS HAPPENS, I STOP AT A SAFE LOCATION AND REMOVE MYSELF TO FRESH AIR, AND THE SYMPTOMS SOON PASS AND I AM ABLE TO DRIVE AGAIN. RECENTLY, I HAVE TRAVELED FROM MASSACHUSETTS TO VERMONT IN MY EXPLORER. THE MOSTLY HIGHWAY DRIVING TRIP IT WAS ME AS WELL AS MY GIRLFRIEND. AFTER AROUND AN HOUR OF DRIVING AT 60MPH, MY GIRLFRIEND AND I WERE FEELING VERY DIZZY AND BECAME NAUSEATED, SO I OPTED TO STOP AND RELAX AT A REST STOP FOR FRESH AIR PRIOR TO CONTINUING MY TRIP TO VERMONT. I HAVE INSTALLED A CARBON MONOXIDE DETECTOR IN MY VEHICLE, WHICH HAS ACTIVATED MORE THAN ONE OCCASION WHILE DRIVING. AT THIS TIME I AM NEGOTIATING WITH FORD'S OFFICE OF GENERAL COUNSEL TO PERFORM A BUYBACK OF MY EXPLORER AND REPLACE IT WITH A DIFFERENT VEHICLE.

NHTSA ODI 11053333

WHILE DRIVING DOWN THE INTERSTATE AROUND 70MPH) THE TRIM ALONG THE WINDSHIELD ON THE DRIVER'S SIDE SUDDENLY SNAPPED AND FLEW OFF.

NHTSA ODI 11047098

EXHAUST FUMES IN CABIN WHEN ACCELERATING AT HIGHER SPEEDS, ESPECIALLY WHEN ENTERING INTERSTATE AND PASSING CARS AT HIGHER SPEEDS.

NHTSA ODI 11040479

THE CAR IS LITTLE UNDER THREE YEARS OLD AND THE DOOR PANEL IS COMING APART AROUND THE WINDOW. ANOTHER ISSUE IS THE SMELL OF CARBON DIOXIDE WHEN I ACCELERATE. AND ANOTHER ISSUE IS THE HOOD IS SHOWING RUST SPOT (SHOWING OXIDIZATION)

NHTSA ODI 11033100

VEHICLE HAS 40K MILES ON IT. STRANGE VIBRATION COMING FROM PASSENGER SIDE. ALL OF THE SUDDEN THE WINDOW MOLDING/TRIM FROM THE WINDSHIELD FILES OFF! CAUSING MOTOR VEHICLES BEHIND US TO SWERVE! GOT OUT AND CHECKED, SURE ENOUGH THE DRIVERS SIDE MOLDING IS LOOSE TO. THIS COULD BE A HUGE SAFETY ISSUE. HAD IT REPAIRED, GUY AT THE DEALER TOLD US IT WAS A KNOWN PROBLEM. WAS DOING APPROX 75 MPH ON I 75. IT WAS VERY SCARY

NHTSA ODI 11022474

THE WINDOW TRIM ON BOTH SIDES OF THE FRONT WINDSHIELD BECAME LOOSE AND THEN FLEW OFF OF THE VEHICLE WHILE DRIVING. THE CAR HAS 3500 MILES. WHY IS THIS NOT A RECALL? OTHERS HAVE HAD THIS SAME ISSUE I HAVE LEARNED BY READING THESE FORUMS.

NHTSA ODI 11013308

THE ELECTRONIC POWER STEERING RACK HAS FAILED ON OUR VEHICLE. THIS I HAVE SEEN IS A PROBLEM FORD HAS HAD IN THE PAST AND HAS STILL NOT REMEDIED THE PROBLEM. THE OUT OF POCKET COSTS ARE $2500.00 . THE STEERING IS UNSAFE AND IS ALLOVER THE ROAD. FURTHER TO THIS THE POWER SEAT MOTOR FAILED AND THEY WANT $2500 TO REPAIR IT . THIS I FEEL IS VERY UNFAIR AND GOUGING.

NHTSA ODI 11012753

OUR '14 EXPLORER HAS CONSISTENTLY ALLOWED EXHAUST GAS TO ENTER THE PASSENGER COMPARTMENT UPON 1/2 TO FULL THROTTLE ACCELERATION. STILL UNDER WARRANTY, THE DEALERSHIP SAID THEY WOULD FIX IT FOR ABOUT $800! THEY SAID IT WAS COMING FROM EXHAUST ENTERING THE REAR AC. AC ON OR OFF MAKES NO DIFFERENCE.

NHTSA ODI 11011261