What 1,670 owners told NHTSA about the 2014 Ford Explorer Hev

When I'm driving on the freeway. I could be on flatland and it will stall, I could be going down a hill and it stalls, I could be on a regular road, turning a corner, hitting a bump. And it stalls when I'm on the freeway, I have to get over very scary happens all the time when It happens I coast, I put it into park, i turn it off, and it restarts immediately every time. This is constantly happening. IHave a video and picture but it will not upload on this.But it says hell descending control fail

NHTSA ODI 11723535

Engine over heat warning while driving and I checked there is a coolant leakage.

NHTSA ODI 11697807

The contact owns a 2014 Ford Explorer. The contact stated that while the vehicle was stopped, the vehicle jerked, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle stalled. No warning light was illuminated. The contact was able to restart the vehicle. The contact stated that on a separate occasion, while driving at various speeds, the vehicle jerked and then the engine stalled. After several attempts, the vehicle was restarted. The check engine warning light was illuminated. The contact stated that on a separate occasion, when the contact was able to restart the vehicle, the failure recurred after driving a short distance. The contact stated that the failure persisted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 170,000.

NHTSA ODI 11695502

Engine stopped working I wanna know if there is a warranty

NHTSA ODI 11690130

Noticing a problem with the steering and wheel suspension that is affecting other Ford explorers between 2018 and 2025. Engine oil blow by. Causing oil to leak and ending up under the carriage and on the back of the vehicle. Rear camera problems.

NHTSA ODI 11661662

Vehicle has code C0063-64ABS. Also has a problem with the restraint control module and ABS module causing the front tires to lock and make the car slide. I was about to get into a car crash on Oct 24,2024 because the cars front tires locked and just slide from one side to other the steering wheel went loose and I wasn't able to control the car I took it to ford dealership where they told me that it has the code that appears at the beginning of this message

NHTSA ODI 11647641

Making a right turn I was startled by a vehicle running a red light. Front wheel passenger side cleared the curb. Right rear tire jumped the curb jolted back to ground. I looked at tire pressure gauges and no leaks were evident. Being on a single lane road I continued driving looking for a turn in place after traveling about a quarter of a mile an engine rattle developed and there was faint smell of smoke. I traveled another block and turned into a dollar general parking lot. The entrance was on an incline and the car stopped. I had just purchased a new battery a week before and had an oil change about 3 weeks before. The car refused to start. I called triple A and had it towed to dealer. They looked at car and could not come up with a rational reason and doubted car stopped because of violent rear contact with curb at right rear wheel was cause of engine seizing. I called USAA my insurance company their investigating agent agreed. My car is serviced at this dealer and I follow all of the maintenance guidelines I have the records as well as dealer. The car has 125,000 miles and has been well maintained. I am curious if there are any other reports this has happened with 2014 Ford Explorer or any other vehicle. I find it hard to accept such a violent jolt of the running engine did not cause something to fall loose on the running engine. The dealer and appraiser found the car oil full and in pristine condition. There was no frame damage.Turning the crank towards rear they hear metal falling into oil pan. Your thoughts?

NHTSA ODI 11626686

The contact owns a 2014 Ford Explorer. The contact stated that the front passenger’s side door panel had started to detach from the body of the vehicle. The vehicle was taken to a dealer where the contact was informed that there were no recalls on the VIN and the contact was provided an estimate for the repair. The vehicle was not repaired. The contact stated that while driving at highway speeds, there was an abnormal whining sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where the contact was informed that the rear wheel bearing needed to be replaced. The dealer repaired the vehicle. The contact stated that the check engine warning light later was illuminated. The vehicle was taken back to the dealer where the contact was informed that the catalytic converter needed to be replaced. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The vehicle was not repaired. The failure mileage was approximately 100,000.

NHTSA ODI 11617492

The contact owns a 2014 Ford Explorer. The contact stated that the security light was illuminated, and the battery was drained. The vehicle was taken to the local dealer, where it was diagnosed that the security panel needed to be replaced. The vehicle was repaired, but the failure recurred. While driving, the lights failed to turn on, and the horn was inoperable. The vehicle was taken back to the local dealer, where it was determined that the electrical system needed to be replaced. The vehicle was repaired. The contact stated that there was no longer a dinging sound when the doors were ajar. The interior lights were dim, and the horn was inoperable. The rubber trim was detaching. The moon roof failed to close. The vehicle was taken back to the local dealer, who determined that water had entered the vehicle through the sunroof and that the wires were wet. The dealer added plastic and glue to the sunroof. Additionally, the vehicle failed to start. There was an abnormal clicking sound while attempting to start the vehicle. The vehicle was taken back to the local dealer, where it was diagnosed that the compressor needed to be replaced because the compressor was clogged. The manufacturer was contacted, who opened a case. The failure mileage was approximately 127,000.

NHTSA ODI 11606756

VEHICLE ENGINE LIGHT CAME ON. TOOK CAR INTO MECHANIC AND FOUND OUT A CODE POINTS TO A PROBLEM WITH THE TIMING CHAIN/CAM POSITION SENSOR. PRIOR TO THE ENGINE LIGHT COMING ON CAR PREVIOUSLY HAD (2) RANSOM ISSUES THAT NOW AFTER GETTING THE DIAGNOSIS MAKES SENSE WHY THE CAR WAS AT TIMES MAKING A FLUTTER SOUND WHEN STARTING ALONG WITH THE ENGINE RANDOMLY AT TIMES ACTING LIKE TO WAS GOING TO STOP RUNNING WHILE DRIVING THE VEHICLE. I TOLD FORD AND THE MECHANIC ABOUT IT PREVIOUSLY BUT THEY BOTH SAID AS LONG AS THERE'S NO ALARMS KEEP DRIVING IT. THE VEHICLE STILL DRIVES GOOD, BUT I WAS ADVISED NOT TO DRIVE IT UNTIL REPAIRS MADE. THE REPAIR IS $4,000.00 AND PUTTING THAT KIND OF MONEY INTO A VEHICLE THAT IS CURRENTLY VALUED AT $8 TO 10K WITH 136,000 BASED OFF MY RESEARCH IS NOT PRUDENT CONSIDERING OTHER THINGS THAT WILL EVENTUALLY NEED EXPENSIVE REPAIRS. I HAVE TAKEN GOOD CARE OF THE VEHICLE ALONG WITH KEEPING UP ON ALL SERVICES. DISCUSSED WITH A COUPLE EXPERIENCED FORD MECHANICS AND THIS REPAIR IS UNFORTUNATELY VERY COMMON. I BOUGHT THE EXTENDED WARRANTY WHEN THE CAR WAS NEW FOR YOUR INFORMATION. I HOPE FORD CAN STAND BEHIND THIS MECHANICAL FAILURE THAT APPARENTLY IS A KNOW ISSUE AND ACCOMMODATE ME FOR MY LOSS OF EQUITY IN A VEHICLE THAT SHOULD NOT BE HAVING THIS KIND OF WELL KNOWN BREAKDOWN. 1. VEHICLE IS AVAILABLE FOR INSPECTION 2. SAFETY AT RISK WHEN ENGINE LOSES POWER AND ALMOST STOPS RUNNING 3. YES, YESTERDAY I WAS AT THE LOCAL FORD DEALERSHIP MET THERE TOP "HEAVY END" MECHANIC WHO WAS VERY FAMILIAR WITH THE PROBLEM ALONG WITH (2) INDEPENDENT EXPERT MECHANICS FAMILIAR WITH THE DIAGNOSIS. 4. THE MANUFACTURER YESTERDAY SAW THE VEHICLE, AFTER TALKING TO THE HEAD MECHANIC, BASED OFF THE CODE AND SYSTEMS I DECIDED IT WAS NOT PRUDENT TO THROW MONEY AWAY ON GETTING AN OFFICIAL DIAGNOSIS BASED OFF MY COMFORT LEVEL FROM THE DISCUSSIONS WITH THE MECHANICS. 5. YES, THE CHECK ENGINE LIGHT CAME ON AND I HAD THE CAR PROMPTLY INSPECTED BY A MECHANIC.

NHTSA ODI 11606159

The contact owns a 2014 Ford Explorer. The contact stated while approaching a stop light, the vehicle started to lose motive power and stalled. There was no warning light illuminated. The vehicle was able to be restarted, and the vehicle was towed to the residence. The dealer was not contacted; however, the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 105,000.

NHTSA ODI 11592084

N/A

NHTSA ODI 11587968

Water is leaking from front of engine and into oil from water pump being told it will cost 1600 to over 2000 dollars to fix

NHTSA ODI 11580947

Fumes are leaking into the cabin of the car. Possibly issues with an exhaust leak that is causing nausea and headaches when driving vehicle.

NHTSA ODI 11568934

Car was sitting idle when a fan inside the engine compartment starting being very loud. Sound went away when car started moving. Noticed coolant was empty. Filled with coolant and made a 5 mile trip. Checked again and coolant was empty again.

NHTSA ODI 11568342

My car keeps running out of coolant yet I’m leaving no puddles anywhere

NHTSA ODI 11566621

I own a 2014 Ford Explorer. When driving home on November 4th the engine coolant light came on and there was white smoke coming from under the hood and the coolant was leaking under the vehicle. I had the vehicle towed to my local mechanic who said that the water pump needs to be replaced. He does not do this type of work so I'm unsure if there is additional damage since he stopped his inspection there. I have to have it towed to another place. I'm seeing this same issue with many vehicles with the same make/model and felt it should be reported. I did contact Ford and made a complaint.

NHTSA ODI 11553784

Repeated catalytic converter failure. Issue was repaired at least twice. Converter failure caused both turbos to need replacement and has now caused engine damage. This appears to be a common issue with this engine model.

NHTSA ODI 11547912

Water pump coolant leak. I’m experiencing this problem and have seen that Fire has known about this issue and hasn’t recalled it and it’s causing engine failure and leaving consumers to fort the 2000 bill to fix since it’s internal. Does needs to recall and fix this issue and replace the pump.

NHTSA ODI 11544886

Under moderate to heavy acceleration exhaust fumes are pouring into the cabin. The harder you accelerate the more you smell. Gives me a headache every time.

NHTSA ODI 11542562

The contact owns a 2014 Ford Explorer. The contact stated while driving 30 MPH, the engine coolant temperature warning light was illuminated. The contact was able to park the vehicle at a friend's residence nearby and added coolant to the engine. The contact stated that the failure recurred. The contact took the vehicle to the local dealer, where it was diagnosed with needing the radiator and the water pump to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 132,720.

NHTSA ODI 11534095

Every time while accelerating and RPMs reach above 2500 the cab of the vehicle fills with an odor . After doing a lot of research we have come to realize it is carbon monoxide. There are several open law suits and complaints about this already. When we purchased the vehicle in May of 2021 it was taken to the Ford dealership and they told us everything in the vehicle was fine. The car is available for inspection at any point. No warning lights or anything have come on at all!

NHTSA ODI 11533086

Ever since I purchased my 2014 Ford Explorer, I noticed a foul smell inside the vehicle when accelerating. It seemed fine when driving normally, but when accelerating into traffic or whenever RPMs are increasing, it’s definitely noticeable. At first I thought it wasn’t that big of a deal, until my young step-son was in the passenger seat complaining about how he felt nauseous out of nowhere. So I decided to do a little research and found a TON of articles including the ones in these two links!: https://www.cbsnews.com/amp/news/ford-explorer-lawsuits-exhaust-leak-carbon-monoxide/ https://6abc.com/amp/ford-explorer-suv-sick-dizzy/3507986/

NHTSA ODI 11529261

While driving my 2014 Ford Explorer from South Florida to Millegville Georgia the high temp Light came on and the engine slowed on I-16. Managed to get off The Interstate at Macon Ga. Almost caused accidents in traffic. Finally got to Ford dealer said water pump failed like so many others. $2600 estimate. End of my trip, had to rent car to get home car Still in shop in Georgia waiting for repairs.

NHTSA ODI 11528976

UNKNOWN

NHTSA ODI 11527047