What 1,671 owners told NHTSA about the 2014 Ford Explorer Gas

I had the toe link recall performed in 2022. Since that time, I have replaced brakes twice, tires twice (two full sets in less than 50k miles), control arms, sway bars, and bushings. The car will not come into alignment. There is ample evidence all over the internet that the toe link recall has been a failure. There are numerous stories just like mine of secondary suspension issues and burning through tires, especially in the rear, at an alarming rate. To my knowledge Ford has done nothing to correct the issues with the toe link, once and for all. To my knowledge, Ford is not reimbursing owners for the related losses they experience because of the issue with toe links.

NHTSA ODI 11732705

There is a strong fuel order coming from passenger side after every fuel fill, affects everyone in the car while moving, especially affecting my grandchildren and my family. Backup camera rarely comes on while backing up, gives a black screen which can cause accidents especially in reverse. Rear driver side makes loud squeaky sound while driving over speed bumps slowly or bumpy roads. I purchased this vehicle used June 2025. It has an active molding recall that hasn't been fixed and I have contacted a Ford dealership last year.

NHTSA ODI 11731286

EXTERIOR A-PILLAR APPLIQUE TRIM CLIP ATTACHMENTS ARE NOT PROPERLY ENGAGED DUE TO IMPROPER ASSEMBLY OR REPAIR. REAER TOE LINK REAR TIRES TILTED INWARD due to potential fractures from corrosion or broken welds on TOE LINK.

NHTSA ODI 11723710

The contact owns a 2014 Ford Explorer. The contact stated while driving at various speeds, the vehicle was driving rough. In addition, while driving at various speeds, the vehicle vibrated abnormally; however, when the vehicle shifted to neutral(N), the vibration ceased. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that recently all four tires were damaged. The vehicle was taken to Costco and all four tires were replaced. The contact had previously received notification of NHTSA Campaign number: 21V537000 (SUSPENSION) and the vehicle was repaired. The contact related the failure to the recall. The manufacturer was made aware of the failure and informed the contact that the Extended Warranty had expired. The contact attempted to have an alignment performed but was unable to find a repair facility to perform the alignment. The manufacturer was contacted and informed the contact that the vehicle was still under warranty; however, the adjustable arm needed to be upgraded at the owner’s expense to repair the vehicle. The vehicle was not repaired. The failure mileage was approximately 90,000.

NHTSA ODI 11672273

Noticing a problem with the steering and wheel suspension that is affecting other Ford explorers between 2018 and 2025. Engine oil blow by. Causing oil to leak and ending up under the carriage and on the back of the vehicle. Rear camera problems.

NHTSA ODI 11661662

I’m still waiting for the current recall to be corrected. The suspension is worn out. Replaced rear shocks, front struts, lower control arm. This is the worse automobile I’ve ever owned. If possible, I will never buy another ford. The car’s rear back up camera has been replaced and has stopped working again.

NHTSA ODI 11638903

The contact owns a 2014 Ford Explorer. The contact stated that the front passenger’s side door panel had started to detach from the body of the vehicle. The vehicle was taken to a dealer where the contact was informed that there were no recalls on the VIN and the contact was provided an estimate for the repair. The vehicle was not repaired. The contact stated that while driving at highway speeds, there was an abnormal whining sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where the contact was informed that the rear wheel bearing needed to be replaced. The dealer repaired the vehicle. The contact stated that the check engine warning light later was illuminated. The vehicle was taken back to the dealer where the contact was informed that the catalytic converter needed to be replaced. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The vehicle was not repaired. The failure mileage was approximately 100,000.

NHTSA ODI 11617492

The contact owns a 2014 Ford Explorer. The contact stated that while driving at an undisclosed speed with his 12-year-old child in the vehicle, the steering wheel tightened up, and the vehicle drove straight and crashed into a sand barrier. The air bags deployed. The driver sustained injuries to his chest, head, and shoulder. There was no injury stated for the 12-year-old child who was also in the vehicle during the crash. Medical attention was provided to the driver. A Police report was filed but was not provided to the contact. The vehicle was towed to the Police Precinct. There were no warning lights illuminated. The contact stated that prior to the crash, the vehicle was parked and rolled back and struck another vehicle. The vehicle was repaired. The contact stated that the failure was related to NHTSA Campaign Number: 21V537000 (Suspension). The contact called an unknown local dealer, but the vehicle was not diagnosed or repaired after the crash. The contact stated that the vehicle was totaled; however, the Insurance Provider had not yet rendered a decision on the vehicle. The manufacturer was not yet contacted. The failure mileage was approximately 100,000.

NHTSA ODI 11606028

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the low tire pressure warning light illuminated. The contact also stated that when she inspected the vehicle, she became aware that the steel belts were hanging from the interior of the rear tires. The contact took the vehicle to an independent mechanic where it was diagnosed as a failure with the rear alignment. The contact was informed that the rear toe link needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was made of the failure and the contact was referred to NHSTA Hotline for assistance. The failure mileage approximately was 120,000.

NHTSA ODI 11595707

The contact owns a 2014 Ford Explorer. The contact stated that the sunroof motor had failed due to water intrusion. The vehicle was taken to an independent mechanic, where the sunroof motor was replaced. Additionally, the contact stated that after parking the vehicle in the independent mechanic parking lot on another occasion, he noticed a steal band underneath the rubber of the rear tires. The mechanic informed the contact that the suspension had failed, which was damaging the rear tires. The vehicle was being diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 97,745.

NHTSA ODI 11589043

N/A

NHTSA ODI 11587968

The contact owns a 2014 Ford Explorer. The contact stated the vehicle was registered from the Chicago plant and the vehicle resided in Northern Nevada, 30 minutes from Lake Tahoe. The contact stated the vehicle was susceptible to corrosion due to the weather in Northern Nevada. These vehicles may have rear toe links that received excessive electrocoating (e-coat) corrosion protection, which could cause the e-coat to become brittle and break away when contacted by road debris. The contact notified the dealer who referred the contact to the manufacturer. The contact referenced Ford Customer Satisfaction Program: [XXX] (Rear Toe Link Replacement) and NHTSA Campaign Number: [XXX] (Suspension) as a possible solution however, the VIN was not included in the recall. The manufacturer was notified of the issue and referred the contact to NHTSA Hotline. The contact had not experienced a failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11579799

Control arm on Ford 2014 explorer are prone to failure, causing vehicle to lose steering. Control arms rub excessively against brake components, also causing failure to both brakes, ABS, and sensors related to wheel speed. Failure is due to the manufacture. Strong action is need to prevent further road accidents if not addressed.

NHTSA ODI 11573329

See attached document from complainant

NHTSA ODI 11551805

under the program of 15N01 the 2014 Ford Explorer is not part of it and it should be as my vehicle is experiencing the same issues. The program currently ends for vehicles manufactured January 2014 and mine was manufactured in April of 2014. I would like this added so my vehicle can be repaired under the program. The make, model and body styling is the same as previous years and has the same parts.

NHTSA ODI 11544621

The contact owns a 2014 Ford Explorer. The contact stated received notification of NHTSA Campaign Numbers: 21V537000 (Suspension) and 20V675000 (Suspension). The contact stated that the vehicle was taken to the dealer for the scheduled recall repairs, and the contact was informed that the toe links could not be replaced due to the knuckles needing to be replaced prior to completing the recall repair. The contact stated that the dealer contacted the manufacturer and the manufacturer verbally agreed to complete the recall repair by replacing both parts and scheduled the service for a later date. The vehicle was taken to the dealer for the rescheduled appointment and the contact was informed by the dealer that the manufacturer declined the recall repairs as well as replacing the knuckles. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ODI 11539728

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle made abnormal sounds and was vibrating abnormally. Additionally, the tires experienced a loss of traction while turning. The vehicle was taken to an independent mechanic, who replaced the CV joints twice; however, the failure recurred. The vehicle was then taken to the dealer, where the steering rack and bushings were replaced, and an alignment was performed. The failure recurred, and the vehicle was taken back to the dealer, where it was determined that the CV joints needed to be replaced for the third time. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the VIN was not included in an unknown TSB. The failure mileage was approximately 200,000.

NHTSA ODI 11518075

The contact owns a 2014 Ford Explorer. The contact stated that after making a left turn, the vehicle jerked in the opposite direction, and then the steering wheel became difficult to turn, and she crashed into a parked vehicle. The check engine and air bag warning lights were illuminated. The contact stated that after parking the vehicle, she noticed a fluid leak underneath. The vehicle had not yet been taken to an independent mechanic or a local dealer to be diagnosed or repaired. The VIN was included in NHTSA Campaign Number: 20V675000 (Suspension). The manufacturer was made aware of the failure. The approximate failure mileage was unknown. The contact stated that the air bags never deployed at the time of the incident. Also, it is difficult to click the seatbelt clip in. The local Ford Service Team was contacted but offered no help, stating that the accident had no correlation to the recall. They stated that they would not be covering the cost of repair for that incident.

NHTSA ODI 11516053

Steering became very difficult, car would not track straight and turning was delayed. The dealer said teeth in the steering box had broken off. Also had a broken suspension strut - front right.

NHTSA ODI 11513320

The contact owns a 2014 Ford Explorer. The contact stated while inspecting the vehicle, the tech stated that the toe link needed to be replaced. The vehicle was taken to the dealer and the dealer repaired the vehicle under NHTSA Campaign Number: 21V537000 (Suspension). The vehicle was taken to the inspection center again and the tech stated that the toe link needed to be replaced once again and advised the contact to take the vehicle to the dealer for assistance. The vehicle was taken to the dealer and the dealer stated that the rear passenger’s side knuckle needed to be replaced and stated that the vehicle had exceeded the 6 marks for warranty coverage. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was 123,000.

NHTSA ODI 11512762

My Ford Explorer had a rear suspension toe link Recall, and in December I took my vehicle to the Ford dealership to get it fixed. At that time, they did a full vehicle inspection, fixed the part, and told me everything looked great. Shortly after the service, we had a snow storm, and my SUV would fishtail in Icy/snowy conditions. Every time it'd snow, it made me so scared to drive, because I'd essentially not have control over my vehicle. The issue wasn't present when the roads were clear. Within the two months since that service, my back tires have gone completely bald, down to the wires. I recently got in a car accident because my car wouldn't complete a turn and ended up t-boning a Tundra on a residential street. Luckily I was going slow so the damage to the other vehicle was minimal, and no obvious injuries have resulted from the accident. I was able to remove some of the plastic pieces around the fender, in order to still drive it, so I took it to the Ford dealership that originally serviced my car for an inspection. Now that the dealership has inspected my vehicle, they're claiming that it's not on their liability and that they're not responsible for any of the damage. Now the alignment is off on both the front and back, and the strut is bent (whether that's from the accident or not, we don't know). The Manager admitted that when servicing my vehicle they were only allowed to perform a rear alignment, but a front alignment was never suggested or offered to me. When aligning a vehicle (especially in the winter) the whole vehicle should be aligned, not just half. They of course claim zero liability or responsibility, even though I was having issues with it fishtailing shortly after it being serviced at their shop, for a part on the suspension, which affects alignment.

NHTSA ODI 11510009

The contact owns a 2014 Ford Explorer. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 19V435000 (Suspension). The technician then became aware that the front alignment needed to be adjusted due that the rear alignment adjustment. The vehicle was not repaired. The manufacturer was contacted but declined to perform the alignment. The approximate failure mileage was 100,000.

NHTSA ODI 11501236

The contact owns a 2014 Ford Explorer. The contact stated that while her daughter was driving approximately 15 MPH, the steering wheel became difficult to turn. The driver was able to steer the vehicle safely to a nearby parking lot. The contact was unaware if any warning lights were illuminated. The vehicle was towed to the local dealer and was diagnosed with the steering gear assembly failure. The vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 16V245000 (Suspension). The approximate failure mileage was 105,000.

NHTSA ODI 11473375

The rear suspension on this vehicle stinks! I've done 2 recalls for the toe links. Now I've had to replace the rear wheel bearings. They were both bad! Niw that's done, i've a really bad(dangerous) swaying problem! The darn thing won't hardly stay on the road! I had to go to the VA for a dr appt last week in Huntington WV. On the way home i hit a downpour. I was lucky to get pulled over! The thing hydro-planed and bucked all over the road. I was only going about 40-45mph! The toe and camber are way out on the driver side rear, and the passenger side isn't much better... Those aren't the only problems. There's quite a list with this piece of junk! From the cat converters to the rear door locks, there's always been issues. I'm the second driver. I'm on disability and drive nowhere. Especially doing/driving cazy/ abusive. My dad was the other driver until he passed in 2018, and he was just an old preacher. He never hit 75mph in the thing, though he put alot of highway miles on it. I've never been above like 78 - 80mph in it... We both were/are very proactive as far as maintenence... There ought to be a lemon law...

NHTSA ODI 11467256

The contact owns a 2014 Ford Explorer. The contact stated that while driving over bumps in the roadway at various speeds, a jolt could be felt from the rear end of the vehicle. The contact then received a recall notice for NHTSA Campaign Number: 21V537000 (Suspension) which she linked to the failure. The contact took the vehicle to a dealer for the repair; however, upon return of the vehicle, the contact was informed that she needed to replace a knuckle assembly on the toe link that was not covered under a recall. The contact was assured that the vehicle was safe to drive and she was referred to the manufacturer for assistance. The contact then stated that while driving 65 MPH, she drove over a bump in the roadway and the entire rear end of the vehicle slid into the opposite lane of traffic and almost caused an accident. The contact then read her service report which stated that the recall was not serviced since the assembly knuckle was not replaced. The manufacturer was notified of the failure and offered no assistance. The contact was then transferred to the NHTSA to file a complaint. The vehicle was not repaired. The failure mileage was 108,000.

NHTSA ODI 11460486