Apr 14, 2025Transmission & drivetrainFuel system1 injury
My 2014 Chevy Cruze has been having some major safety issues as of late. The powertrain has been one of the major components in this system that has failed. The engine has overheated 3 times in the last 3 months causing many safety concerns to others on the road as well as myself due to having to randomly pull over on the side of the road on the busy highway. The car has jolted many times due to losing power and causing my neck to have a severe pinched nerve. These issues are related mainly to the fluid cooling/management systems and related hoses. It is available for inspection upon request. The problem has been confirmed by independent service center. The engine light repeatedly goes on and off causing many issues to the car daily.
NHTSA ODI 11654439
May 7, 2018EngineFuel system1 injury
EXHAUST FUMES ENTERING AIR VENTS. TAKEN IN TO DEALER SEVERAL TIMES AND THEY CANNOT FIX THE PROBLEM. MY DAUGHTER HAS BEEN SICK AND WE KEEP EXPLAINING TO THE THAT FUMES HAVE CAUSED HER TO HAVE PNEUMONIA, SINUS ISSUES, DRY EYES, SORE THROAT, MIGRAINE HEADACHES, SLEEPY DRIVING AND HOURS AFTER DRIVING, CONFUSION, ANXIETY, NAUSEA. THE DEALERS MECHANIC SOLUTION IS NOT TO USE AC OR HEAT AND KEEP WINDOWS OPEN. MY HUSBAND DROVE IT 20 MINUTES IN TRAFFIC AND GOT SICK WHEN HE REACH THE DEALER FOR 3RD REPAIR REQUEST IN 2 MONTHS. ENGINEER FROM GM IS LOOKING AT CAR MAY 2018. MY DAUGHTERS HEALTH IS CONTINUING TO IMPROVE NOT DRIVING THE CRUZE. NOT ONE PERSON SHOULD BE SICK OR DIE FROM A CAR THAT HAS A DEFECT THAT CANT BE RESOLVED.
NHTSA ODI 11092224
Sep 15, 2017Body & structureBrakesFuel systemFire
THE CAR WAS TAKEN IN TO BE ROUTINELY SERVICED AND IT WAS NOTICED THAT THERE WAS AN OIL LEAK. THE DEALERSHIP ONLY PROVIDE A TEMPORARY FIX. TRYING TO GET AN APT AS A FOLLOWUP WAS POINTLESS, BECAUSE THE DEALERSHIP INDICATED THAT THEY WERE BUSY. WELL, THE CAR CAUGHT FIRE AND THE SERV ICE DEPT. REFUSED TO ACKNOWLEDGE THAT THERE WAS A PROBLEM AND THAT THEY WERE TOO BUSY THE CAR WAS BEING DRIVEN ON A HIGHWAY, THERE WAS A POPPING SOUND, AND THEN THE CAR CAUGHT FIRE.
NHTSA ODI 11023694
Nov 12, 2016AirbagsSeatsFuel systemCrash
OCTOBER 12 2016 MY CHEVY CRUZE WAS HIT BY A PETERBILT 375 DUMP TRUCK IN TWO PLACE THE DRIVER SIDE REAR WHEEL AND DRIVER AND PASSEGER DOOR SPEED WAS JUST OVER 20 MILE PER HOUR INCREASING BECAUSE THE MACK TRUCK BULLDOZE ME UP THE ROAD MY AIRBAGS DID NOT DEPLOY AND MY SEAT BELT DID NOT TIGHTEN UP. I COMPLAINED IN 2015 AUGUST ABOUT THE FUEL INJECTION NOT ALLOWING THE CAR TO ACCELERATE WHEN I SUPPRESS THE GAS PEDAL TO THE FLOOR MY CAR JUST DID NOT MOVE FOR ABOUT 5 SECONDS THEN SURGED VIOLENTLY. WENTWORTH CHEVROLET AND GM CUSTOMER CARE CENTER CONDUCTED A PRODUCT SAFETY CHECK ON MY ANTI LOCKING/AIRBAGS/ AND FUEL INJECTION RELEASING THE CAR 15 DAYS LATER STATING THE VEHICLE HAD NOT PROBLEM THEN 10/12/2016 HAPPENED. I BELIEVE GM AND WENTWORTH ALLOWED A COMPROMISED AND BROKEN VEHICLE BACK OUT ON THE ROAD ENDANGERING MY LIFE ACTING WITH RECKLESS NEGLIGENCE AND COMPLETE LACK OF OWNERSHIP AND RESPONSIBILITY.
NHTSA ODI 10925611
Jan 1, 2016EngineFuel systemFire
FUEL SYSTEM FAILURE RESULTING IN CATASTROPHIC ENGINE FIRE. I PURCHASED THIS VEHICLE BRAND NEW IN APRIL 2014. AFTER COMPLAINING ABOUT ENGINE POWER LOSS THREE MONTHS PRIOR, I STARTED SMELLING A FUEL ODOR THE WEEK BEFORE THANKSGIVING, I IMMEDIATELY NOTIFIED THE CHEVROLET DEALER ABOUT THE ODOR, THE DEALER DID INFORM ME THAT A TSB WAS ON GM DEALER WORLD IN REGARDS TO THE FUEL RAILS POSSIBLY COMING LOOSE CAUSING A FUEL ODOR / HESITATION. AFTER CAREFUL EXAMINATION OF THE VEHICLE THERE WAS NO VISIBLE FUEL LIQUID PRESENT ON THE ENGINE OR GROUND BELOW THE VEHICLE. THE VEHICLE SAT PARKED IN THE DRIVEWAY FOR MAJORITY OF THE DAY, UPON STARTING THE VEHICLE TO TRANSPORT TO THE DEALER THREE MINUTES AFTER THE VEHICLE BURST INTO FLAMES IN THE ENGINE COMPARTMENT, USING A GARDEN HOSE WHILE CALLING 911 THE VEHICLE BECAME FULLY INVOLVED IN THE ENGINE BAY SPREADING INTO THE PASSENGER COMPARTMENT. ONCE WATER CONTACTED THE ENGINE BAY THE FIRE FURTHER SPREAD INDICATING THE FIRE WAS CHEMICALLY BASED. THE LOCAL FIRE DEPARTMENT EXTINGUISHED THE VEHICLE USING A FOAM WATER MIXTURE. THE VEHICLE WAS DECLARED A TOTAL LOSS BY INSURANCE, I CONTACTED GM CUSTOMER SUPPORT ONLY TO BE STONEWALLED BY THE AGENT. I HAD OVER 10000 DOLLARS IN PAYMENTS INVESTED IN THIS VEHICLE. GM SHOULD HAVE STEPPED UP TO THE PLATE NOT THE INSURANCE. NOT A SURPRISE AFTER THE IGNITION SWITCH DISCRETIONS AND DEATHS. GOOGLE CHEVY CRUZE ENGINE FIRES THIS HAS HAPPENED SEVERAL TIMES BEFORE!!!!!!!!!!
NHTSA ODI 10817297