What 459 owners told NHTSA about the 2013 Tesla Model S 75d

The Tesla Large Drive Motor, has a known design flaw that Tesla will not repair… it has a coolant leak the affects and kills the motor… they have down a redesign for the performance motor called a coolant delete but not for the LDU… and they will charge over $6500 to replace the motor. I’m on my 6th LDU (motor) and now out warranty. There are thousands of cases of this failure .. it should be absorbed recall and free replacement … they know it’s a problem, please force a design change oand recall

NHTSA ODI 11583224

slowing down pulling into a parking spot and there was a sudden unintended acceleration causing the vehicle to jump over the bumper onto the other side of the parking lot causing property damage to the front passenger side and a vehicle to the right parking spot.

NHTSA ODI 11567902

Power steering has failed and the car is dangerous to drive unless you have Arnold Schwarteneggers strength. Tesla wants to charge an exorbitant amount to repair their failure (just as they charged me for fixing THEIR recall with the EMMC unit. They keep passing the buck on the consumer which I can not afford to fix their problems in this financial climate.

NHTSA ODI 11552752

Driving at normal speeds and conditions my rear drivers control arm snapped off and wheel almost fell off , if driving at higher speed could have been deadly

NHTSA ODI 11549906

I am writing to express my serious concerns regarding two critical component failures in my 2013 Tesla Model S within the past 12 months, both of which occurred shortly after the manufacturer's warranty had expired. These issues have not only been financially burdensome but also raise questions about the reliability and longevity of Tesla vehicles. Motor Replacement: In Sept 2022, I was compelled to replace the motor in my Tesla Model S at a cost of $6,304.89. This occurred despite my vehicle maintaining a clean record and having only around 70k miles on it at the time. The timing of this failure, immediately after the expiration of the manufacturer's warranty, is concerning and suggests a potential design or manufacturing flaw. Battery Replacement: Most recently, I have been informed that the battery in my Tesla Model S requires replacement at an estimated cost of $15,545.97. Like the motor failure, this comes as a substantial financial burden, and again, it has happened just after the warranty period has ended. I find these consecutive, high-cost component failures within a short timeframe to be unacceptable and have led me to question the overall reliability of Tesla vehicles. As a responsible and safety-conscious consumer, I believe it is vital to report these issues to the NHTSA to ensure the safety and protection of all Tesla owners and the general public. I respectfully request that the NHTSA investigates these repeated component failures in Tesla vehicles, particularly the motor and battery, and assesses whether there may be any systemic issues that warrant further action or recalls. It is crucial for the NHTSA to uphold and enforce safety standards in the automotive industry to prevent similar situations from occurring in the future. I have attached relevant documents and receipts as evidence of the mentioned repairs for your reference. - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11548100

About 6 mo. ago, a sticky substance started leaking under the center touch screen. I went to the dealer, and was told that the screen was leaking due to high temperatures inside the car while parked. They refused to do anything about it. I went online to a Tesla forum, and learned that this is a common problem with the Model S touch screen. Ultimately, the screen will "bubble" and the go completely blank. Without this screen I cannot access navigation, climate, or entertainment features. I believe this to be a major safety issue.

NHTSA ODI 11545039

The passenger side door opens when put in park.

NHTSA ODI 11544188

On August 23, 2023 I was driving my 2013 Tesla Model S on the Van Wyck Expressway when suddenly the steering wheel became very stiff making the car hard to steer. I experience a loss of electronic power in steering the car. I called Tesla Road Service they dispatched a tow truck one of their tow provider and I was charged $475.00 dollars. It was towed to: Tesla Service Center @ 160 Van Brunt Street Brooklyn, NY 11231. I mentioned to Tesla Service Center per information I reviewed online this is a recall SB-22-00-014 per the year of my vehicle 2013 Tesla Model S. Tesla Service Center charged me $500.84 cents for a diagnosis they said the Electric Power Steering Gear Rack & Pinion is the issue and refused to acknowledge the recall per the model of my 2013 Model S Tesla. They quote me an amount of $4, 500.00 dollars before tax to fix the issue. When I declined the repairs per this expensive price I was informed by Tesla Service Center @ 160 Van Brunt Street to come and pickup the car. I arrived on Friday, August 25, 2023 to pickup the car with a tow truck the service department could not locate my keys. It took them 3 hours to find my key and then they put the car on service mode not allowing the car to go on park or drive only staying on neutral. They claimed that happened because the car reset itself. When I insist by a manager for them to fix that problem since the car did not come in with that issue only a stiff steering problem they refused. After several discussion with different staff and managers they had one of their mechanic to fix the issue and the car was able to go on Drive & Park again so I can have it towed to my location which took 3 tow trucks since Tesla wasn't cooperative in the beginning. I had the car towed to my location with the stiff steering the failed Electric Power Steering Gear Rack & Pinion Tesla refused to repair the problem per the Recall safety issue on this car. They want to charge me $4,500.00 plus tax out of pocket.

NHTSA ODI 11540947

The central display computer goes blank while driving or when the car heats up. Suddenly the car does not respond to any touch screen. AC cannot be managed, rear camera is not available and the car is undrivable. The screen comes back when the car cools down completely. This happens everytime the car heats up -whether it is parked outside for couple of hours or inside the garage on a hot day or when I am driving for over an hour. This incident has occurred multiple times and I have to take it in to be repaired

NHTSA ODI 11539534

Car when parked over time fails to move when engaged citing parking brake fault. I don't even use parking brake. Car is completely jammed. I looked up online and found a recall notice for the same issue where calipers were at fault.

NHTSA ODI 11539489

Lower rear driver side control arm broke. A pop was heard at the stop sign only yards away (40 approximately) from my destination. Vehicle was placed into reverse to back into a driveway. The vehicle got stuck in the middle of the road and required a tow to move it.

NHTSA ODI 11532948

The contact owns a 2013 Tesla Model S. The contact stated that while attempting to start the vehicle, the message “unable to drive, voltage supply” and “vehicle may not restart” was displayed. The vehicle failed to start. The vehicle was towed to the local service center who diagnosed that the drive unit was faulty and needed to be replaced, due to water ingress coming from the rear of the vehicle. The vehicle was not yet repaired. In addition, while operating the vehicle, a warning alert was displayed regarding the battery system and that the battery would no longer recharge. The vehicle was towed to the dealer who diagnosed that the HV battery pack had failed due to corrosion caused by condensation from the HVAC system. The HV battery was replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 95,000.

NHTSA ODI 11532730

When unlocking the doors, the passenger side front and rear doors pop open.

NHTSA ODI 11532769

In November 2020, I had my Tesla MCU replaced under the NHTSA recall (Exhibit1). Attached is the invoice of the repair (Exhibit 2). On July 3, 2023, my MCU malfunctioned again. The dashboard is frozen showing the car is at 72 MPH in drive in a parking lot (exhibit 3). This is a safety issue since I cannot tell how fast I am driving when I am going with the flow of traffic. I nearly hit a person since I could not tell what gear I was in and ended up going in reverse rather than drive. I contacted Tesla requesting repair under the recall. Their response was that my car is old and they would not cover it even though it drives fine. I drove home in the slow lane since I could not tell my speed. They sent me an estimate of $1914.13 to replace the Nvidia Tegra MCU with an Intel Tegra MCU (exhibit 4). Since the car drives fine and the battery is good, I want to continue using my car but this is a safety issue. It seems that when Tesla pushes out updates on older cars, this crashes the MCU. It seems that they are trying to force owners of older cars to buy new ones. What are my options of solving this safety issue?

NHTSA ODI 11530285

First the passenger door handle broke and Tesla fixed it, now the driver door handle broke. Seems like a safety issue and these things are just designed to break.

NHTSA ODI 11530168

Center LCD SCREEN bubbling and leaking fluid from panel into car.

NHTSA ODI 11527818

The driver's side rear door handle stuck open and you can't get door open. This is the 3rd driver's side rear handle for this vehicle. Tesla would not cover the repair.

NHTSA ODI 11526460

My main center computer touch screen has been leaking a sticky toxic glue for over 5 years. This toxic sticky glue continues to leak all over the interior of my vehicle which regularly needs to be cleaned. This saftey issue has been reported to Tesla several times and Tesla refuses to take responsibility for this saftey issue. The sticky toxic glue leaks severly worse when exposed to higher temperatures and definitely is related to heat/thermal heat exposure. Tesla did not utilize an automotive grade computer screen on earlier production vehicles and has since changed the type of computer screens utilized in their current production vehicles. This is an ongoing problems with thousands of earlier production vehicles. Tesla is aware of this problem and refuses take responsibility to issue a recall which affects thousands of customers who are experiencing this same saftey issue. Tesla WILL NOT help or do anything to resolve this problem saying my vehicle is out of warranty. I had to take the interior of my vehicle apart to constantly clean this leaking toxic sticky glue. This glue has been leaking on other interior electrical components which is a serious saftey issue!

NHTSA ODI 11526128

the uncured conductive adhessive between the display and the glass. The supplier did not use a proper UV light technique (they used expired bulbs" to cure the adhesive into a solid form and over time, the liquid is now coming out of the bottom of the screen and making a mess.

NHTSA ODI 11522671

Screen in front of the driver froze. Speedometer did not change, odometer did not change, map and directions did not change, gearshift indicator did not change, clock was frozen.

NHTSA ODI 11522147

Explained to Tesla service center immediately upon purchasing vehicle while it was still under warranty that the vehicle range was unacceptable using TESLA's warranty guideline for requirements for a battery replacement while under warranty. TELSA refused to changed the battery even though I took the vehicle to TESLA several times while the Battery was still under warranty. A month after the warranty expired the motor died, it had been showing signs wear but TESLA failed to property inform me of the issue and charged me over $6000 for the repair due to my lack of knowledge on what the symptoms are for a failing motor. Shortly after the warning for "Charging - Maximum battery charge level reduced" has come on and TESLA is trying to charge me about $21,000 for a replacement battery.

NHTSA ODI 11511655

My Tesla 2013 model S has the exact same problems as ones in your recall notice NHTSA Campaign # 21V035 yet My VIN # does not show up in your list of recalled cars. I took my car into Tesla dealer on Dec 14 2022 and they fixed it and charged me $103.35 for the repair. I asked how long a warranty I would have and they replied "to the end of parking lot". I have had car in to Tesla twice since then as problem has gotten worse and each time they fiddled with it and it came back working for a short time each time I went in. On Feb 14, 2023 I went in again as I could drive the car but screen dark. Made an appointment to have it fixed and was told cost will be $2385.00 including a new radio as old one won't work with new screen. This is robbery as problem is the same as with the recalled vehicles. This is a safety issue and I thought manufactures were responsible for safety defects. In addition Tesla refuses to give me back the old parts unless I pay them $750.00. I asked what they did with old parts and they would not tell me. Again this is wrong.

NHTSA ODI 11507836

The contact owns a 2013 Tesla Model S. The contact stated that while driving at an undisclosed speed, the center display screen malfunctioned, causing the rearview camera to intermittently fail. Additionally, the failure caused a delay while switching gears to drive(D) and to park(P). The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and determined through the Tesla App that the VCM daughterboard needed to be replaced with one containing an enhanced eMMC controller. The contact related the failure to NHTSA Campaign Number: 21V035000 (Back Over Prevention, Visibility, Exterior Lighting) however, the VIN was not included in the recall. The failure mileage was approximately 95,500.

NHTSA ODI 11505178

I am complaining about Tesla’s dishonest and underhanded repair center and battery. In October 2021, I was told I was receiving a new battery. When I picked up my car, I noticed it was not getting the maximum charge. Through investigation, we found a refurbished battery was given. Less than 3 months later, the refurbished battery failed. Michael Hilgado (Tesla manager) explained it was a faulty battery and that I would receive a replacement at no charge and with a new warranty because the one they placed in October was faulty. The battery was replaced. Please find below the timeline of all additional repairs and breakdowns. The Tesla App locks you out and changes prices, times, etc. without owners having access to information for verification. When paying for services, there is no review or education regarding the vehicle, warranty, etc. December 2022, ten months after the refurbished battery was replaced, the battery failed again and Tesla wants to charge another $15,000 for repairs. Please find below the timelines:

NHTSA ODI 11501685

At random the Steering assist reduce, traction control disabled, stability, control, disable, regenerative breaking reduced. Wipers are affected during these error messages. The car is trying to get me killed!! On different days, all those errors are gone and the car drives normal. Suspect this is a software defect and can be very dangerous. Seems like something got reset after the car is turned off. All software are up to date on the car and on the phone app. Once no more errors from the car, it would drive normal until it randomly disable traction control, stability control and wipers becomes very slow, get stuck at times.

NHTSA ODI 11500922