What 153 owners told NHTSA about the 2013 Kia Rio

I drove to a local store while my friend went shopping I remained in the vehicle and let it idle I proceeded to drive away to head home and the car started having idle and throttle malfunction to where there was no gas peddle response and eventually car died I barely got to a parking lot nearby restarted car and same symptoms occurred I was able to give it enough throttle to creep down the road i Had to keep restarting motor to get it to move at to which it finally wouldn’t move at all, prior it was leaking oil severely out the bottom what looked like near the oil filter, it now starts and dies immediately with no gas peddle response won’t even rev up to a idle

NHTSA ODI 11460340

Engine is knocking because of carbon build up caused by KIA installing faulty engines . Most all other models have been recalled already .

NHTSA ODI 11454490

I was driving the car and heard something explode/pop. I was on the right lane and was able to pull over. Smoke was coming out of the car and oil was dripping from the bottom. The motor seems to have combusted and cracked. A mixture of oil and water continue to drip from the bottom of the vehicle.

NHTSA ODI 11443018

We purchased a very low miles (42K) Kia from the dealer as a 2nd owner. In less than 6 months the car has serious safety issues. The vehicle shuts off and stalls while idling at stop lights, stop signs or slow traffic with no warning. All other powered components like radio, lights etc remain on and functioning. The car is hard to start after the vehicle shuts off and has stalled and takes multiple tries to turn over. When accelerating the vehicle will randomly not respond at all to the gas pedal, will not increase speed, RPM will not move and the car will not respond. When the car does accelerate, it will sputter and rpm will increase dramatically. This is very dangerous to those driving and those on the road. If the vehicle does not respond to acceleration the risk to the driver and occupants is serious. There could be an accident from oncoming traffic both rear and from behind. There is great life threatening risk. Local mechanic stated the car throws no codes when diagnosed, and there is no check engine light on. Kia knows their vehicles have this issue and has recalled many other models in the same years. There are multiple identical NHTSA.GOV complaints noting identical vehicle problems. The problem is not able to be found with diagnostic. The KIA RIO should be recalled and repaired immediately. The car was sold with serious safety issues. There was a class action even that did not proceed that alleges the gamma engines cause sudden stalling, excessive oil consumption, engine failures and fires in the vehicles.

NHTSA ODI 11432051

CAR HARDLY EVER INDICATED LOW OIL. HAD TO ADD OIL CONSTANTLY BETWEEN OIL CHANGES. NO PROBLEMS UNTIL THE CAR GOT OVER 100K MILES. CHECK ENGINE LIGHT CAME ON WE CHECKED THE OIL IT WAS 2 QUARTS LOW. ADDED OIL ENGINE STARTED KNOCKING. MECHANIC SAID WE HAD TOO MUCH OIL. GOT AN ENGINE FLUSH AND ANOTHER OIL CHANGE ENGINE WAS STILL KNOCKING AND OIL WAS VERY DIRTY. MECHANIC INDICATED THIS IS A COMMON PROBLEM WITH MOST KIAS WITH THE GDI ENGINES. 2 WEEKS AFTER OIL CHANGE THE CAR STARTED SMOKING AND WAS ALMOST COMPLETELY OUT OF OIL. TOOK IT TO ANOTHER MECHANIC WHO SAID THE ENGINE SHOULD BE RECALLED AND HE DIDNT UNDERSTAND WHY IT WASNT. HE SAID MY ENGINE WAS DOING WHAT ALL THE OTHER ENGINES HAVE DONE ON THE OTHER MODELS RECALLED. I CALLED THE LOCAL KIA DEALERSHIP WHO TOLD ME THAT I HAVE HAD THE CAR SINCE 2014 AND IT WAS JUST OLD. THEY WONT BE RECALLING. I TOOK GOOD CARE OF THIS CAR HARDLY EVER WENT TOO FAR PAST AN OIL CHANGE THIS SHOULDN'T HAVE HAPPENED AND I HAD TO GET A NEW CAR. THIS SHOULD BE RECALLED LIKE ALL THE OTHER KIAS IT'S UNFAIR THEY SELL CARS THAT BREAK ONCE YOU GO PAST 100K MILES.

NHTSA ODI 11413418

SELF DESTROYING. CAR CYLINDER CAN GET IMPACTED TO THE CEILING. KNOCK SENSOR NOT WORKING CORRECTLY IT IS FUNCTIONING PROPERLY BUT NOT WORKING CORRECTLY, CAUSING AN ENGINE TO DETERIORATE AT A RAPID RATE NON-INTENDED USE, HAS SAME ENGINE AS OTHER KEY IS IN HYUNDAIS IN THIS ONE IS NOT ON THE RECALL AND IS HAVING THE SAME ISSUE SAME ISSUES AS THE RECALLS. KNOCK SENSOR CATASTROPHIC FAILURE. FOR THE DATE OF THE START OF THE ISSUE IT WAS WELL BEFORE THEN DON'T REMEMBER THE EXACT DATE. CAR WILL NOT DRIVE SMELLS LIKE THE ENGINES GOING TO CATCH ON FIRE

NHTSA ODI 11363182

OIL CONSUMPTION WITH NO OBVIOUS TAIL PIPE SMOKE. NOT LEAKING OIL. PERHAPS A QUART OF OIL ADDED TO ENGINE EVERY 750 MILES. THIS ISSUE STARTED AROUND 115,000 MILES. NO LOW OIL PRESSURE INDICATER LIGHT ACTIVATED. I HAD TO REPLACE CATALYTIC CONVERTER DO TO OIL DEPOSITS.

NHTSA ODI 11348563

THE CAR HAS BEEN USING ALOT OF OIL LAST 12 MONTHS , OIL IS CONSTANTLY LOW EVERYTIME IT HAS BEEN CHECKED , SERVICED , MY DAUGHTER HAS HAD TO ADD OIL TO THE VEHICLE AND CHECKED FREQUENTLY , THE ENGINE LOCKED UP ON HER ON A MAJOR INTERSTATE COMING HOME FROM A TRIP . 2 HOLES IN THE MOTOR NOW, ESTIMATE OF MOTOR REPLACEMENT FROM KIA 4,000 PLUS

NHTSA ODI 11343200

WHILE RUNNING THE ENGINE BURNS THROUGH OIL VERY QUICKLY. ENGINE DOES NOT WARN THAT OIL IS LOW BUT BEGINS TO RUN 'ROUGHLY' WHEN OIL IS NEEDED. I ADD OIL EVERY COUPLE OF WEEKS IN BETWEEN ACTUAL OIL CHANGES. I ONLY DISCOVERED THIS PROBLEM WHEN I TOOK THE CAR IN FOR MAINTENANCE AND MY MECHANIC TOLD ME THAT THERE WAS ZERO OIL IN IT AND HE WAS SURPRISED THAT THE ENGINE WAS EVEN RUNNING AT ALL.

NHTSA ODI 11256382

AS I WAS DRIVING TO LAUNDRYMAT MY ENGINE STARTS MAKING NOISE AND THEN THE CHECK ENGINE CAME ON, ALL THE OIL HAD BURNED OUT OF CAR, THE CAR STALLED AND I WAS STRANDED. THERE WASNT ANY OIL OR ENGINE WARNING SIGNS AT ALL B4 THIS HAPPENED, IM HEARTBROKEN AND STILL HAVE 2 YEARS TO PAY, THIS ENGINE IS FAULTY! MY AUNTY WHO IS A POLICE OFFICER OWNS A 2014 KIA AND SAME HAPPENED TO HERS! PLEASE TAKE ACTION AGAIST KIA TO CORRECT THIS MODEL ALSO, THE 201E KIA RIO

NHTSA ODI 11241856

SITTING AT A RED LIGHT IN CITY TRAFFIC, PRESSED THE GAS TO GO WHEN GREEN LIGHT OCCURRED AND CAR STALLED. LIGHTS, POWER WINDOWS, RADIO ALL STILL WORKED, BUT THE ENGINE WAS DEAD. LET CAR SIT FOR 30 MINUTES, IT STARTED UP COMPLETELY FINE. CAR STALLED AGAIN AT RED LIGHT WHILE AT IDLE IN CITY TRAFFIC. LET CAR SIT FOR A FEW MOMENTS, STARTED IT UP AND DROVE HOME WITHOUT INCIDENT. NO CHECK ENGINE LIGHT, NO BATTERY LIGHT, NO LOW OIL LIGHT. TOOK CAR TO NEIGHBORHOOD MECHANIC, WAS TOLD NOTHING WAS WRONG. BATTERY AND ALTERNATOR WERE IN GREAT WORKING ORDER, GROUND CONNECTIONS WERE FINE. THEY TOOK CAR ON 20 MILE RIDE WITH NO STALLING. TOOK CAR TO DEALERSHIP, THEY HAVE NO IDEA WHAT IS WRONG EITHER. TOLD ME TO COME BACK WHEN I HAVE A CHECK ENGINE LIGHT, OTHER THAN THAT, THEY CAN NOT HELP ME. CAR CONTINUES TO STALL WHILE IDLE WITH NO CHECK ENGINE LIGHT.

NHTSA ODI 11193122

AFTER ONLY 70000 MILES I WAS TOLD THE ENGINE HAS SLUDGE BUILD UP AND NEEDS TO BE REPLACED AND IS UNSAFE TO DRIVE. THE CAR WAS ALWAYS MAINTAINED AT THE DEALERSHIP AND THE OIL WAS CHANGED ON A REGULAR, TIMELY BASIS THROUGH THE DEALER. THE DEALER RECORDS WERE SENT TO KIA WHO WOULD NOT GAURANTEE TO COVER THE REPLACEMENT OF THE ENGINE, THEY MAY OR MAY NOT COVER IT. IF ITS NOT COVERED I AM ON THE HOOK. I WAS TOLD BY DEALER THAT THE OIL HAD METAL SHAVINGS IN THE OIL, THIS WAS ALSO SENT TO KIA BY THE DEALER. I WAS TOLD KIA NEEDED A PICTURE THAT ONLY COULD BE OBTAINED BY TEARING DOWN THE ENGINE AND THAT ONCE THIS HAPPENED THE ENGINE COULDN'T BE PUT BACK TOGETHER. AT THIS POINT I WAS COMMITTED TO A NEW ENGINE, EITHER KIA WOULD PAY OR I WOULD. AT THIS TIME I HAVE NOT DONE ANYTHING. I KNOW KIA HAS THIS ISSUE WITH OTHER KIA MODELS. THE VEHICLE WAS TAKEN IN IMMEDATELY WHEN A CHECK ENGINE LIGHT CAME ON,

NHTSA ODI 11183269

CAR BURNS THROUGH OIL. NO LEAKS, JUST BURNS OIL. WHEN OIL IS EMPTY, NO CHECK OIL LIGHT COMES ON. MUST ADD OIL CONSTANTLY. MY MECHANIC SAID I HAD 'NO OIL' IN MY ENGINE DURING MY LAST CHECK. HE FILLED IT UP AND THEN I DECIDED TO CHECK IT MYSELF A COUPLE OF MONTHS LATER AND THE SAME THING IS HAPPENING.

NHTSA ODI 11173063

RATTLES UPON ACCELERATION, BURNING EXCESSIVE OIL. NO OIL LEAKS. INDICATOR LIGHT DOES NO COME ON UNTIL THE OIL IS ALMOST COMPLETELY GONE AND RATTLING UPON ACCELERATION IS THE WARNING!!!

NHTSA ODI 11151826

ON 06/12/2018, MY 2013 KIA RIO HAD A FIRE IN THE ENGINE COMPARTMENT THAT TOTALED THE VEHICLE. THE FIRE WAS NOT THE RESULT OF AN ACCIDENT OR RECENT MAINTENANCE. THE CAR SIMPLY BURST INTO FLAMES IN THE ENGINE COMPARTMENT WHILE DRIVING.

NHTSA ODI 11113386

UPON RESEARCH I WAS ABLE TO FIND OUT THAT THE KIA RIO HAS THE SAME ENGINE USED IN THE KIA OPTIMA WHICH HAS BEEN RECALLED. JUST RECENTLY METAL SHAVINGS WERE FOUND MY KIA RIO WHY ARE NOT ALL CARS WITH THE SAME ENGINE BEING RECALLED?

NHTSA ODI 11102630

I WAS DRIVING WITH MY DOG TO A VET APPOINTMENT. I HEARD A NOISE THAT SOUNDED LIKE I HIT A POT WHOLE BUT I LOOKED AND THERE WAS NO WHOLE AND THE CAR WAS STILL DRIVING LIKE NORMAL SO I CONTINUED ON MY WAY. THERE WAS A DETOUR FOR ROAD CONSTRUCTION I ENDED UP HAVING TO PULL OVER BECAUSE I DID NOT KNOW WHERE I WAS. THE CAR DIED SEEMED TO BE BECAUSE OF THE BATTERY LOSS POWER SO I LET THE CAR REST AND WALKED MY DOG .THEN GOT BACK IN MY CAR IT STARTED BACK UP AND TURNED AROUND ON THE HIGHWAY. THEN MINUTES AFTER GOING MY CAR LOST POWER AND THE SPEED REDUCED TO 40 MILES PER HOUR WHEN I HAD BEEN DRIVING 65 MPH. ALL THE WARNING LIGHTS CAME ON AND IT MADE A NOISE FROM UNDER THE CARRIAGE /BODY OF THE CAR.THIS ALL HAPPEN AT THE SAME TIME. I WAS ABLE TO COAST INTO A GAS STATION/ CONVENIENCE STORE. I LIVE IN ALABAMA AND IT WAS LIKE 90 DEGREES THAT DAY. I TRIED TO RESTART THE CAR WHEN SOMEONE TRIED TO HELP ME AND IT THREW METAL FROM UNDER THE BODY AT US. LATER FOUND OUT IT THREW A ROD .I AM UNDER 100,000 MILES AND WAY UNDER 10 YEARS ON THE WARRANTY AND HAVE BEEN INFORMED BY A MECHANIC THAT IT THREW A ROD AND THERE IS NO WAY TO TELL WHAT CAUSED IT.THE ROD WENT THREW THE OIL PAN. I WAS LUCKY THERE WAS NO TRAFFIC AT THE TIME THIS ALL HAPPENED. KIA TRIED TO TELL ME IT HAD TO BE A RECALL TO BE COVERED UNTIL I WENT TO THERE OFFICE AND CONFRONTED THE WOMAN WHOM HAD SAID THAT TO ME. WHEN I TOLD HER I DID NOT HAVE ALL MY PAPER WORK /RECORDS ON THE MAINTENANCE SHE SAID THEY WOULD HAVE TO CHARGE ME TO LOOK AT IT TO DETERMINED WHAT CAUSED THE ENGINE TO THROW A ROD. I THEN TALKED TO A FRIEND OF A FRIEND THAT WORKS AT KIA FOR HELP AND I AM STILL WAITING FOR HIS REPLY IF THEY WILL HELP ME OR NOT.MY CAR IS 2013 KIA RIO .MY HUSBAND HAD GONE TO CULLMAN AL. WHICH IS ABOUT 3 HOURS FROM US THE WEEKEND BEFORE THIS HAPPENED AND HAD CHECKED THE OIL AND ADDED WHAT WAS NEEDED THEN .

NHTSA ODI 11099943

TL* THE CONTACT OWNS A 2013 KIA RIO. EVER SINCE THE VEHICLE WAS PURCHASED, THE SERVICE ENGINE INDICATOR ILLUMINATED AND THE VEHICLE FAILED TO ACCELERATE SUDDENLY DUE TO AN INTERNAL ENGINE FAILURE. THE DEALER (BOB BELL KIA OF BALTIMORE, 7900 EASTERN AVE #1, BALTIMORE, MD 21224, (410) 288-2500) INITIALLY DIAGNOSED THAT THERE WAS A WRENCH UNDER THE HOOD, BUT HAD BEEN THE ONLY REPAIR FACILITY SERVICING A VEHICLE, THE SECOND TIME, THE THROTTLE BODY WAS REPLACED. DURING THE THIRD REPAIR, THE ENGINE ASSEMBLY WAS REPLACED, BUT THE VEHICLE FAILED TO ACCELERATE OVER 20 MPH. ALSO, THE SERVICE ENGINE INDICATOR REMAINED ILLUMINATED WITHIN LESS THAN 30 DAYS OF THE THIRD REPAIR FROM THE DEALER WITH NO REMEDY. THE VEHICLE WAS TAKEN TO AN INSPECTION STATION WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO A SENSOR RELATED TO THE THROTTLE. THE MANUFACTURER ISSUED 15 TSBS ON THE ENGINE, BUT THERE WAS NO RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 6.

NHTSA ODI 11076238

I WAS DRIVING HOME WORK ON THE FREEWAY AND HAD ONLY BEEN ON THE ROAD FOR 15 MINUTES. IT WAS RUSH HOUR TRAFFIC AND HAD MY WINDOW DOWN WHEN I NOTICED AND ELECTRICAL BURNING SMELL. I THOUGHT IT MIGHT BE FROM FROM SOMETHING OUTSIDE AND KEPT DRIVING. THE SMELL GOT STRONGER AND STRONGER. AFTER JUST A COUPLE MINUTES OF FURTHER DRIVING SMOKE STARTED POURING IN FROM MY DEFROST VENTS. I GOT THE VEHICLE TO THE SIDE OF THE ROAD AND JUST AS I GOT OUT FLAMES WERE COMING FROM UNDER THE HOOD OF THE CAR AND IT WAS TOTALLY ENGULFED IN SECONDS. THE CAUSE OF YET UNKNOWN AND UNDER INVESTIGATION FROM MY INSURANCE COMPANY. THE VEHICLE HAS NEVER NEEDED ANY WORK DONE TO IT AND JUST PASSED THE MARYLAND STATE INSPECTION FOR REGISTRATION 6 WEEKS PRIOR TO THIS HAPPENING.

NHTSA ODI 11040984

I WAS DRIVING ON THE HIGHWAY AT 70MPH WITH ONE OTHER PERSON IN THE VEHICLE, WHEN THERE WAS A COMBINATION OF WHIRRING, CLICKING, AND BANGING SOUNDS FROM THE ENGINE. AS WE PULLED OFF ON THE EXIT IT SOUNDED AS IF PARTS WERE FALLING OUT FROM UNDER THE CAR, BUT WHEN WE LOOKED IN THE REAR VIEW MIRROR THERE WAS NO DEBRIS ON THE ROAD. WHEN WE PULLED INTO THE REST AREA AND PARKED THE CAR TO CHECK IT OUT AND BEGIN THE PROCESS OF GETTING A TOW TRUCK BEFORE THE CAR HAD US STRANDED AND BROKE DOWN, SMOKE BEGAN OMITTING FROM THE HOOD AND IT GOT THICKER AND FLAMES BEGAN COMING OUT FROM UNDER THE HOOD MAINLY ON THE LEFT SIDE OF THE CAR UNTIL IT HAD SPREAD TO BOTH SIDES AND BEGAN TRAVELING INTO THE CABIN OF THE CAR. CAR WAS IN GOOD SHAPE, WITH ONLY A NEED FOR AN OIL CHANGE WHEN THE PROBLEM AND FIRE BEGAN. FIRE CREWS ARRIVED AND PUT OUT THE FIRE. ENGINE LIGHT DID TURN ON AND AND START BLINKING AS WE GOT ON THE EXIT RAMP. CAR WAS TURNED OFF AT THE TIME THE SMOKE AND FIRE BEGAN. MOST OF THE DAMAGE SUSTAINED WAS ON THE DRIVES SIDE OF THE CABIN AND ALL OF THE FRONT OF THE CAR AND ENGINE AREA. WHILE WE UNDERSTAND THIS COULD BE SOMETHING UNRELATED TO A MANUFACTURER DEFAULT, WE WANT TO BE SURE THAT WE TAKE THE CORRECT STEPS SINCE A CAR THAT WAS ONLY 3 YEARS OLD DID BURST INTO FLAMES.

NHTSA ODI 10991038

JUST BOUGHT A 2013 RIO WITH 28,000 MILES ON IT ON 9/2/16. THE CAR SAT IN OUR DRIVEWAY ALL LAST WEEK BECAUSE WE WERE ON VACATION, SO WE MAYBE PUT 100 MILES ON IT AND DROVE IT 4 TIMES. DROVE 20 MINUTES ROUND TRIP TO THE POST OFFICE YESTERDAY, PARKED IN DRIVEWAY AND WENT BACK INTO HOUSE TO WORK. WIFE CAME HOME FROM WORK ABOUT 10 MINUTES LATER AND CAME RUNNING IN THE HOUSE SAYING THE NEW CAR IS ON FIRE. CALLED 911 AND BEFORE FIRE DEPARTMENT WAS ABLE TO GET THERE, THE FLAMES WERE AS HIGH AS OUR SECOND FLOOR WINDOWS. CAR WAS PARKED ABOUT 10-15 FEET AWAY FROM HOUSE, BUT THE HEAT DAMAGED PART OF OUR HOUSE AS WELL. I HAVE CONTACTED INSURANCE, BUT I REALLY FEEL THIS IS A KIA ISSUE / PROBLEM, AND WE REALLY SHOULD NOT HAVE TO USE INSURANCE TO REPLACE THE CAR. THIS CAR IS STILL UNDER MANUFACTURE WARRANTY, AND THEY NEED TO BE HELD ACCOUNTABLE. THEN LAST NIGHT AFTER THE TOW COMPANY CAME, WE STARTED RESEARCHING THIS AND HAVE FOUND MANY, MANY 2012-2014 KIA'S DOING THIS. I LOGGED A COMPLAINT ON YOUR KIA'S WEBSITE, BUT HAVE NOT GOT A RESPONSE BACK YET, AND YES, I FEEL I SHOULD GET A RESPONSE OVER THE WEEKEND. OUR CAR BURST INTO FLAMES, DAMAGED PART OF OUR HOUSE FROM THE HEAT, AND IT COULD OF BEEN MUCH WORSE, ESPECIALLY IF I PARKED THE CAR IN THE GARAGE YESTERDAY. WOULD REALLY LIKE TO HEAR FROM KIA, OR OTHER OWNERS THAT HAVE HAD THIS PROBLEM. IT SEEMS THAT WITH ALL OF THE GOOGLE HITS ABOUT KIA'S CATCHING FIRE, THERE SHOULD HAVE BEEN A RECALL ON ANY OF THE MODELS THAT HAVE HAD THIS PROBLEM, AND GET THEM EITHER FIXED, OR OFF OF THE ROAD, AT KIA'S EXPENSE.

NHTSA ODI 10907339

WHENEVER CAR IS RUNNING WOULD HERE A KNOCKING OR RATTLING SOUND,HAD TOO REPLACE PARKING LIGHT BULBS THREE TIMES IN FIRST YEAR THEY BURNT OUT AND ON THREE OTHER OCCASIONS THE CHECK ENGINE LIGHT WOULD KICK ON AND WHEN I WOULD GET CAR TO SERVICE CENTER CHECK ENGINE LIGHT WOULD GO BACK OUT AND THEY WOULD WANT TO CHARGE ME TO RUN A DIAGNOSTIC IF NOTHING SHOWED AFTER THEY RAN IT ALSO SAID MY WARRANTY WOULDN'T COVER FAULTY IGNITION AND DOOR LOCK FIRST MY DOOR LOCKS STARTED GETTING JAMMED AND I ASSUMED THAT MAYBE SOMEONE HAD TRIED TO BREAK INTO CAR BUT THEN MY CAR WAS IN REPAIR SHOP ON A UNRELATED ISSUE MY REPAIR GUY CALLS AND TELLS ME MY IGNITION AND KEY ARE STUCK BETWEEN ACC AND START AND WOULDN'T COME OUT OR TURN THE REST OF THE WAY ON OR OFF ALSO HAVE HAD TO PAY FOR AIR FILTER REPLACEMENT ON CAR AT SIX MONTHS OLD AND THE LABOR BECAUSE IT WASN'T PART OF EXTENDED SERVICE PLAN THE KEY THEN HAS BEEN LITTLE TRICKY HAVING TO PUT IN AT A ANGLE KINDA AND NOW ITS STUCK AGAIN IN BETWEEN ACC AND START AGAIN SO REPAIR GUY DID SOME SEARCHING AND FOUND THAT SOMETIMES IF YOU DISCONNECT THE NEG BAT CABLE IT WILL RELEASE THE IGNITION AND THAT IT COULD HAVE SOMETHING TO DO WITH THE GEAR SHIFT NOT IN GAUGING INTO PARK ALL THE WAY EVEN THOUGH THE SHIFTER SAYS IT IS AND THE SHIFTER WONT GO UP ANYMORE THERE SEEMS TO BE ONE THING AFTER ANOTHER WITH THIS CAR OH AND I ALSO BURNED MYSELF LEANING AGAINST FRONT QUARTER PANEL BUT THE HOOD ITS SELF WAS COOL TO THE TOUCH. *TR

NHTSA ODI 10704355

TL* THE CONTACT OWNS A 2013 KIA RIO. WHILE DRIVING AT APPROXIMATELY 40 MPH AND SLOWING DOWN AT A STOP LIGHT, THE CONTACT OBSERVED SMOKE COMING FROM THE HOOD OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND LIFTED THE HOOD AND OBSERVED FLAMES. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE YARD. THE MANUFACTURER WAS MADE AWARE THE FAILURE. THE FAILURE MILEAGE 9,175. UPDATED 09/01/2015*LJ UPDATED 10/14/2015*JS

NHTSA ODI 10701992

TL* THE CONTACT OWNED A 2013 KIA RIO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THERE WAS SMOKE COMING FROM THE HOOD. THE CONTACT UNLATCHED THE HOOD AND DISCOVERED THAT THE ENTIRE ENGINE COMPARTMENT WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE CAUSE OF THE FIRE WAS NOT DETERMINED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000.

NHTSA ODI 10694206

KIA RIO5 LX 2013 STARTED TO MAKE RATTLING / PINGING NOISE IN THE ENGINE AT 70000 MILES. I TOOK IT TO THE DEALERSHIP WAS TOLD THEY CAN'T HEAR IT. THE NOISE STARTED TO GET LOUDER AT 89000 MILES BROUGHT IT BACK TO DEALERSHIP AND THE TECHNICIAN SAID IT'S BECAUSE OF EXCESSIVE CARBON. THEN WAS TOLD TO DO DECARB, REPLACE SERPENTINE BELT, FUEL TANK FILTER & SPARK PLUGS AND THE PINGING WOULD GO AWAY. THE PINGING WAS STILL THERE BUT NOT AS BAD AROUND 94000 MILES BROUGHT IT BACK FOR PINGING HAD THE TECHNICIAN RIDE WITH ME AND HE AGREED IT WAS PINGING ALL THE TIME NOW. THEY DID ANOTHER DECARB SYSTEM ON IT AND TOLD ME THAT ITS NORMAL THE CAR IS GOING TO PING AND I SHOULD RUN 91 OCTANE EVERY 4TH TANK OF GAS. AT 96000 MILES CHECK ENGINE LIGHT COMES ON AND IT'S KNOCK SENSOR CODE THEY HAD TO CALL NORTH AMERICA KIA & KOREA OF KIA LOOKING FOR ANSWER TO SEE WHAT THE PROBLEM IS WITH MY CAR. MY KIA WAS AT DCH KIA OF TEMECULA FOR 7 DAYS AND THEY STILL COULDN'T GIVE ANSWER WHY OR WHAT WAS WRONG WITH MY CAR. THEY JUST SAID IT WAS ONE OF THOSE ISSUE THAT EVERYONE WAS SCRATCHING THERE HEADS AT. THEY USED A TOP ENGINE CLEANER AND THE KNOCK SENSOR CODE HAS BEEN STABLE FOR NOW BUT THE PINGING IS STILL THERE. THEY JUST KEEP TELLING ME I DRIVE TO MUCH & TO USE CHEVRON TECHRON FUEL ADDITIVE PLUS EVERY 4TH TANK USE 91 OCTANE. I CALL KIA CONSUMER AFFAIRS AND WAS TOLD MY CASE IS GETTING PASSED ON TO ONE OF THERE ANALYZE. FINALLY THE ANALYZE CALLED ME I ASKED HIM IF HE HAD MY PAPER WORK HE SAID NO HE DIDN'T NEED IT HE TALKED TO THE TECHNICIAN AT KIA OF TEMECULA AND WANTED TO HEAR MY SIDE. I EXPLAINED TO HIM MY ISSUES AND THE ANALYZE NICK SAID SO IS THE CHECK ENGINE LIGHT ON? REPLIED NO HE SAID SO IT'S FIXED THEN I EXPLAINED TO HIM NO SINCE KIA OF TEMECULA COULDN'T GIVE ME ANSWER WHY OR WHAT IS CAUSING THE ISSUES OF MY KIA RIO. NICK SAID HE WOULD CALL ME BACK, IT'S BEEN 2 WEEKS NO PHONE CALL BACK TO ME. *TR

NHTSA ODI 10628307