What 1,774 owners told NHTSA about the 2013 Ford Fusion Energi

2013 Ford Fusion 1.6 car system started to read low coolant level while driving parked. Checked level it was filled just fine. Cut car back on same thing then over temp. Code came up as well, turned car off checked under the hood fluids all over the front end. My car was fixed in 2019 for recall 17s09 for engine coolant problems that caused this before as well as 5 other recalls

NHTSA ODI 11434944

The contact owns a 2013 Ford Fusion. The contact stated since purchasing the vehicle, while driving, the vehicle failed to exceed 40 MPH. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed the vehicle but did not inform the contact of the diagnostic result. The contact stated that the vehicle was repaired however, upon starting the vehicle, the accelerator pedal was depressed but the vehicle failed to respond. The vehicle was taken to the mechanic who diagnosed that the transmission had failed. The contact stated that the vehicle was repaired however, the failure persisted. The vehicle was taken back to the mechanic and the valve body, the computer system, and the transmission were replaced. The contact stated that the failure had been reoccurring and the check engine light was illuminated. The manufacturer was not made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 99,000.

NHTSA ODI 11430342

The contact owned a 2013 Ford Fusion. The contact stated while he was parked on the side of the road, he noticed dark smoke coming from underneath the hood of the vehicle. The contact stated as he turned off the vehicle, the vehicle caught on fire. There were no warning lights illuminated. There were no injuries sustained. The contact was able to extinguish the fire with the assistance of the emergency units. A police report was filed. The vehicle was towed to a tow lot, where it was deemed a total loss. The dealer was made aware of the failure and advised the contact that they could not assist. The manufacturer was made aware of the failure and informed the contact that they could not assist due to the severity of the fire. The manufacturer stated that the failure was not related to NHTSA Campaign Number: 12V551000 (Engine and Engine Cooling). The approximate failure mileage was 140,000.

NHTSA ODI 11428643

Defective Ford engine and engine cooling recalls have been issued for select models (i.e., recalls 12S41; 17S09;) for cars with 1.6 liter engines due to issues associated with low coolant levels in which a recall was issued in 2017 requiring Ford to install new coolant level sensors and the associated hardware and software in order to prevent engine overheating and catastrophic failure. While the recall was not issued for the 2013 Ford Fusion Energi Titanium Hybrid 2.0 liter engines, the problems identified with the 1.6 liter engines also characterize many of the 2.0 liter engines, including the one that I drive. My Ford has had 18 recalls, and during 2020 the engine light came on 4 different times between February and October of 2020 in which I brought the vehicle to Serramonte Ford service center to determine the reason. Ford did routine inspections and recall work in each visit, but it was not until the final time that the engine light came on that the tech looked inside the engine to discover leaking oil that Ford's service staff informed me I would require a new engine. Ford suggests replacing the defective engine with a rebuilt engine rather than breaking down and diagnosing the cause of the oil in the engine block, according to Ford due to the relatively cheaper cost to me (Ford did not make the diagnosis until after the car was out of warranty) of installing a rebuilt engine rather than tearing down the existing engine to diagnose and repair. I suspect that the 2.0 liter engine has the exact same issues as the 1.6 and should have been included in the 2017 recall, when I could have had the coolant level sensor installed while the car remained under the manufacturer's warranty. The car is at risk of a catastrophic fire now if I drive it off of the service center's lot, where it has been since November 2020. 12S41 and 17S09 recalls should be offered to the 2.0 liter engine models as well, before more people die.

NHTSA ODI 11426507

The contact owns a 2013 Ford Fusion. The contact stated while driving at various speeds, the vehicle stalled. The contact also stated that the power steering failed not allowing the contact to steer the vehicle. The contact stated that the coolant warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed with the engine needing to be replaced. The vehicle was not repaired. The contact was relating the failure to NHTSA campaign number: 17V209000 (Engine and Engine Cooling). The manufacturer had been informed of the failure and informed the contact that the Vin was not under recall. The failure mileage was approximately 100,000.

NHTSA ODI 11425495

The contact owned a 2013 Ford Fusion. The contact stated while driving at 25 mph, there was an abnormal smoke odor inside of the vehicle. The contact stated that the vehicle caught on fire. The fire department was called out and extinguished the fire. A police and fire report were filed. No medical attention was sought. The vehicle was towed to a police towing facility. The dealer was made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was 125,000.

NHTSA ODI 11420610

16 year old driver left home and 4 miles into trip noted that the hot engine indicator had come one. She stopped immediately at the next road and opened the hood to see what the problem was and immediately noted smoke and flames under the hood. Car then proceeded to erupt into flames and burned resulting in a total loss.

NHTSA ODI 11419300

MY 2013 FORD FUSION CONTINUOUSLY HARD SHIFTS AND JERKS WHILE DRIVING. SPARK PLUGS HAVE BEEN CHANGED ALSO TRANSMISSION FLUID CHECKS HAVE BEEN DONE AND IT CONTINUES TO HAPPEN. MY MILEAGE IS ONLY 80,900. THIS HAS CONTINUED NOW FOR ALMOST A YEAR AND A HALF.

NHTSA ODI 11408257

ENGINE FAILURE DUE TO COOLANT LEAKING INTO ENGINE OIL AFTER RECALL PERFORMED, [RECALL # 17V209000] HAD THE CAR IN FOR MANY SERVICE PROBLEMS RELATED TO MISFIRE ON CYLINDER ONE. HAD INJECTORS CLEANED, REPLACED SPARK PLUGS, REPLACED THE COIL PACK, HAD THE COOLANT SYSTEM FLUSHED AND PRESSURIZED FOR LEAKS, ONLY 42000 MILES,

NHTSA ODI 11400317

LOOSING COOLANT, WHITE SMOKE FROM EXHAUST, ENGINE OVERHEATING MESSAGE

NHTSA ODI 11399584

LEAVING GAS STATION. CAR JUST STOPS DRIVING WHILE IN THE DRIVING GEAR. SO I PULLED OVER SLOWLY TO THE SIDE OF THE ROAD AND I HAD A WARNING TO 'SEE MANUAL' 'HILL ASSISTANT NOT AVAILABLE' 'STOP SAFELY NOW' AND IT WAS SHOWING TRACTION CONTROL ON. IT WILL NOT DRIVE. AND RUNS WEIRD NOW.

NHTSA ODI 11398839

PURCHASED A 2013 FORD FUSION IN 2020 AND KEPT THE CAR FOR ABOUT 4 MONTHS. DURING THE 4TH MONTH OF OWNING THE CAR I NOTICED THAT I WOULD FILL UP THE COOLANT RESERVOIR AND A COUPLE DAYS LATER I WOULD HAVE TO FILL IT UP AGAIN. I CHECKED UNDER THE CAR FOR LEAKS AND THERE WEREN'T ANY LEAKS THAT I COULD FIND. I CHECKED FORUMS FOR ANY OTHER PEOPLE HAVING THE SAME PROBLEM AND I FOUND OUT THAT THERE IS AN INTERNAL ENGINE COOLANT LEAK FOR FORD FUSIONS WITH THE 1.6L ECOBOOST MODELS. THAT'S THE EXACT MODEL I HAVE. I CALLED FORD GAVE THEM MY VIN NUMBER AND THEY TOLD ME THERE WEREN'T ANY RECALLS FOR MY VEHICLE AT THE TIME. SO I HAD A MECHANIC CHECK OUT MY COOLANT LINES AND THEY TOLD ME THAT THERE WAS A HUGE LEAK IN MY COOLANT SYSTEM, ALTHOUGH THEY COULDN'T TELL ME WHERE. I HAD THE VEHICLE PRESSURE TESTED AND THE LEAK WAS INTERNAL. DROVE THE CAR BACK HOME THAT DAY AND ONCE I REACHED MY HOUSE SMOKE STARTED TO COME INSIDE THE CABIN. I IMMEDIATELY PARKED THE VEHICLE AND POPPED THE HOOD AND NOTICED THERE WAS A FIRE UNDER MY HOOD. CALLED THE FIRE DEPARTMENT THEY ARRIVED AFTER ABOUT 3 MINUTES AND BY THAT TIME THE VEHICLE WAS DONE FOR. I COULD'VE LOST MY LIFE THAT DAY. I'M HAPPY THAT I DIDN'T. FORD PREVIOUSLY RECALLED CERTAIN 2013 AND 2014 FORD VEHICLES EQUIPPED WITH THE 1.6L ENGINE FOR A SIMILAR ISSUE UNDER RECALL CAMPAIGNS 12V551 AND 17V209. UNFORTUNATELY I'M NOW OUT OF $12,000 AND I NO LONGER HAVE A VEHICLE BECAUSE OF THIS MECHANICAL FAILURE.

NHTSA ODI 11398764

AS SOON AS I STARTED IT THE POWER STEERING ASSIST FAULT LIGHT CAME ON. THEN THE COOLANT OVERHEATING WARNING CAME ON AND DE RATED THE VEHICLE. THEN I SHUT IT OFF. WAS IN MY DRIVEWAY

NHTSA ODI 11394745

WHILE DRIVING, COOLANT WARNING LIGHT CAME ON AND ABOUT 5 MIN LATER CAR DIED. I OPENED HOOD AND THERE WAS STILL COOLANT IN CAR. TOOK TO DEALER. QUOTED $10,000 FOR NEW ENGINE. I WAS NEVER NOTIFIED OF A RECALL RE COOLANT LEAKING INTO ENGINE AND IN SUBSEQUENT VISITS DEALER NEVER ADDRESSED THE RECALL AND NEVER FIXED PROBLEM.

NHTSA ODI 11390667

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE STARTED TO JERK AND WHITE SMOKE WOULD COME OUT FROM THE REAR. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THERE WAS ODOR OF COOLANT BURNING. THE VEHICLE WAS TAKEN TO JIM TIDWELL FORD, 2205 BARRETT LAKES BLVD, KENNESAW, GA 30144, AND WAS DIAGNOSED THAT COOLANT LEAKING INTO THE ENGINE. THE TECHNICIAN RECOMMENDED THE CONTACT WAS TO REPLACE THE ENGINE LONG BLOCK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,916.

NHTSA ODI 11388825

ON MONDAY 1-4-21 THE ENGINE COOLANT OVER TEMPERATURE LIGHT CAME ON, THE RESERVOIR WAS JUST BELOW MINIMUM SO COOLANT WAS ADDED 2 DAYS LATER THE CAR STARTS SPITTERING AND SPUTTERING AND WILL ONLY GO 5 MPH TO GET IT BACK UP 3 STREETS TO HOME. NO ENGINE LIGHTS HAD COME ON IN THE 2 DAYS SINCE FILLING. I HAD THE CAR TOWED TO A REPAIR SHOP. I LOOKED UP RECALLS ON THIS CAR AND CALLED FORD CUSTOMER SERVICE JUST TO FIND OUT THAT TRI-COUNTY FORD HAD SERVICED THIS CAR FOR THIS RECALL (17S09) ON NOV. 2017 AND FEB 2018. THE ISSUE IS STILL THERE APPARENTLY BUT BECAUSE OF THE 12MNTH/12000 MILE WARRANTY I NOW HAVE TO PAY OUT OF POCKET FOR THIS REPAIR FOR THE 3RD TIME. SO WHEN IS FORD GOING TO ACTUALLY FIX THE PROBLEM? I WAS TOLD TO KEEP MY RECEIPTS JUST IN CASE ANOTHER RECALL HAPPENS BUT IN THE MEAN TIME I AM LEFT WITH A 3RD REPAIR BILL AND A RENTAL CAR BILL. I WOULD APPRECIATE YOUR FEEDBACK.

NHTSA ODI 11387472

CONTINUED PROBLEMS WITH ENGINE COOLANT. A COUPLE OF YEARS AGO I HAD A COUPLE OF RECALLS FOR THE ENGINE COOLANT SENSOR FAULTING AND LEAVING MY FAMILY. STRANDED IN SUBZERO TEMPERATURES. THE CAR WAS SERVICED FOR THESE AND NOW IS LEAKING COOLANT I TO THE ENGINE THROUGH A FAULTY HEAD GASKET ISSUE FILLING MY OIL WITH COOLANT AND MAKING THE CAR OVERHEAT. THE CAR HAS 106,000 MILES ON IT AND IS SERVICED REGULARLY.

NHTSA ODI 11387523

THERE WAS A RECALL ON MY MODEL IN 2018 WHICH THEY SAY WAS FIXED. BUT IT IS CAUSING UN GOING ISSUES. NOW THE (CTV)? MODULE NEEDS REPLACING. BOTTOM LINE, CYLINDER HEAD SENSOR KEEPS SHOOTING A CODE THAT THE COOLANT IS TO LOW, WHILE IT IS NOT. YOU START THE CAR AND THE NEEDLE SHOOTS TO HOT. WARNING SIGNAL GOES OF AND ENGINE STARTS TO SHAKE PLUS FANS KICK ON. ENGINE LIGHT PLUS OVERHEATING COMES ON. LEAKS HAVE BEEN FIXED BUT THE MODULE WAS A RECALL AND THEY VERBALLY NO LONGER GRANT IT FREELY FIXED, BECAUSE OF TIME OVERLAPS.

NHTSA ODI 11384823

2013 FORD FUSION WITH 90K MILES, MULTIPLE RECALLS FOR COOLANT SYSTEM, DEALER NOW SAYING ENGINE MUST BE REPLACED. WARRANTY SERVICE ON 12/06/18 FOR NEW COOLANT SENSOR, AND HAD BYPASS T-ASSEMBLY REPLACED ($312 CHARGE). OVERHEATING WITH COOLANT LEAKAGE AND OIL LEAKAGE, RETURN TO DEALER ON 7/23/19. ASSESSMENT IS THE ENGINE NEEDED REPLACEMENT, OVERHEATING CAUSED CRACKED CYLINDER AND COOLANT IS LEAKING INTO THE ENGINE.

NHTSA ODI 11384268

I PURCHASED THE CAR 4 MONTHS AGO AND DISCOVERED SHORTLY AFTER IT WAS LEAKING COOLANT FROM A HOSE IN THE HEATING SYSTEM. THIS EXTERNAL COOLANT LEAK WAS A 500$ REPAIR. EARLIER THIS WEEK, MY CHECK ENGINE LIGHT CAME ON FOR THE FIRST TIME WHEN I WAS IN TRAFFIC ON MY WAY HOME FROM WORK. I WAS DRIVING ABOUT 20 MPH AND HEARD A DULL THUD (I WAS TOLD LATER THIS WAS PROBABLY MY ENGINE POPPING). I IMMEDIATELY TOOK THE CAR TO A SHOP TO HAVE THE CODE READ (P0302). I SCHEDULED AN APPOINTMENT AT MY LOCAL FORD DEALERSHIP AT 7 AM THE NEXT MORNING (14 HOURS AFTER THE LIGHT CAME ON). THEY DIAGNOSED THE CAR AND CALLED ME TO TELL ME THERE WAS AN INTERNAL COOLANT LEAK IN THE ENGINE AND THE ONLY WAY TO FIX THE CAR WAS A TOTAL ENGINE REPLACEMENT. THEY QUOTED ME AT 8500$ (MORE THAN THE AMOUNT I PURCHASED THE CAR FOR) AND TOLD ME MULTIPLE TIMES THERE WAS NOTHING ELSE I COULD DO TO FIX IT. I FOUND OUT AFTER MY FAMILY CHECKED OUT THE CAR THAT THE LEAK HAD CAUSED A CRACKED HEAD GASKET AND THE SPARK PLUGS IN THE CYLINDER WERE CONTAMINATED FROM THE COOLANT. THE FORD ECOBOOST 1.6L ENGINE HAS AN OPEN RECALL FOR CAUSING ENGINE FIRES BECAUSE OF AN INTERNAL COOLANT LEAK, BUT THEY REFUSED TO ACKNOWLEDGE THAT THE DESIGN FLAW IN THE ENGINE THAT CAUSE COOLANT LEAKS LED TO THE IRREPARABLE DAMAGE TO MY ENGINE. THEY TOLD ME I COULD DRIVE THE CAR OFF THE LOT SINCE I WAS NOT COMPLETING THE REPAIR THERE, BUT I COULDN'T MAKE IT OUT OF THE PARKING LOT AND HAD TO HAVE THE CAR TOWED TO MY HOUSE. THE CAR WAS SHAKING AND THE CHECK ENGINE LIGHT WAS FLASHING, WHICH IT HAD NOT BEEN WHEN I BROUGHT THE CAR IN. THE ENGINE IS NOT SAFE AND EVEN IF I WERE TO FIX IT THE DESIGN FLAW WOULD LIKELY CAUSE THE PROBLEM TO REOCCUR. FORD NEEDS TO ACKNOWLEDGE THE ENGINE IS UNSAFE AND PAY TO REPLACE IT WITH A NEWER ENGINE THAT DOES NOT HAVE THE SAME FLAWS.

NHTSA ODI 11383978

TL* THE CONTACT OWNED A 2013 FORD FUSION. THE CONTACT STATED WHILE APPROACHING A STOP SIGN, WHEN SHE SAW NOTICED SMOKE EXITING THE FRONT HOOD. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT WAS ABLE TO EXIT THE VEHICLE WITH HER SON AND STATED SAW FIRE UNDER THE HOOD AND STARTING TO MOVE TO THE REAR OF THE VEHICLE. THE CONTACT AND HER SON DID NOT SUSTAIN ANY INJURIES OR SEEK MEDICAL ATTENTION. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE AND FIRE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE FIRE DEPARTMENT DEEMED THE VEHICLE WAS LOSS. THE VEHICLE WAS TOWED TO JUNKYARD. THE CONTACT CALLED LOCAL DEALER CROSSROADS FORD LINCOLN OF LUMBERTON ( 5045 DAWN DR, LUMBERTON, NC 28358;(910) 738-6281) AND WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED AS OF YET. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 17V209000 (ENGINE AND ENGINE COOLING) AND WAS INFORMED BY THE MANUFACTURE HER VIN WAS INCLUDED TO RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 165,000. *DT*JB*DT*LN

NHTSA ODI 11378452

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS WHITE SMOKE COMING FROM THE ENGINE COMPARTMENT AND ENTERING INSIDE OF THE VEHICLE WITHOUT WARNING. AN INDEPENDENT MECHANIC WAS CALLED TO THE RESIDENCE, AND INFORMED HER THAT THE FAILURE WAS THE RESULT OF A CRACKED CYLINDER HEAD WHICH CAUSED AN OIL LEAK. MCCOY & MILLS FORD (700 W COMMONWEALTH AVE, FULLERTON, CA 92832, (855) 710-0183) WAS CONTACTED BY PHONE AND INFORMED OF THE FAILURE. THE CONTACT WAS PROVIDED INFORMATION ON NHTSA CAMPAIGN NUMBER: 17V209000 (ENGINE AND ENGINE COOLING) WHICH WAS LINKED TO THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER AND THE CONTACT WAS INFORMED THAT THE RECALL REPAIR WAS PREVIOUSLY PERFORMED. THE CONTACT WAS PROVIDED AN ESTIMATE FOR THE REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

NHTSA ODI 11378353

ENGINE STARTED OVERHEATING WHEN I WAS ON MY WAY TO WORK. I CHECKED THE COOLANT AND IT WAS LOW. I REPLACED THE COOLANT TO PROPER LEVEL. LATER THAT DAY, AFTER DRIVING DOWN A BUSY CITY STREET, WHITE SMOKE STARTED TO COME FROM UNDER THE HOOD. I PULLED INTO A PARKING LOT AND SAW FLAMES COMING FROM BEHIND THE ENGINE. I CALLED FORD AND THEY GOT ME IN THE FOLLOWING WEEK. AFTER A MONTH OF BACK AND FORTH WITH WARRANTY COMPANY, FORD CALLED ME TO SAY THE WARRANTY COMPANY DECLINED THE REPAIR BECAUSE THEY DON'T COVER DAMAGE DUE TO OVERHEATING. MY CAR HAS OVERHEATED OCCASIONALLY EVEN AFTER GETTING THE RECALL 17V209000 'FIXED.' FORD SAID THE REPAIR IS $9K. I'M FRUSTRATED BECAUSE THIS HAS HAPPENED TO SEVERAL OTHER PEOPLE WHO HAVE HAD THE SAME PROBLEM AS ME AND IT'S NOT BEING ADDRESSED!

NHTSA ODI 11377581

I WAS DRIVING TO WORK AND I HEARD A LOUD SOUND FOLLOW BY OIL PRESSURE LOST I PULL OVER AT A GAS STATION AND NOTICE THAT ALL MY OIL WAS PORING OUT OUT MY VEHICLE .I THAN CAR FOR A TOW TRUCK TO HAVE MY VEHICLE TOWED ..WHY DIS MY VEHICLE DO THAT.I DID NOT MAKE IT TO WORK ...I HAD TO CALL OFF WAS NOT HAPPY ABOUT IT.THIS SITUATION COST ME MY JOB DUE TO CAR FAILURE..IT HAPPENED ON CITY STREET LEADING TO HIGH WAY.

NHTSA ODI 11376501

CAR CONTINUES TO LOSE COOLANT AND OVERHEAT. IT HAS BEEN IN AND OUT OF THE SHOP FOR 6 MONTHS WITH NO LUCK ON A SOLUTION. TWO DIFFERENT SHOPS HAVE SAID THE RADIATOR AND THERMOSTAT IS FINE. WE THOUGHT WE HAD IT FIXED THIS LAST TIME IN THE SHOP, THE SEAL IN THE RESERVOIR TANK HAD AN AIR BUBBLE IN IT, BUT 6 DAYS INTO HAVING IT HOME THE COOLANT LEVEL LIGHT CAME IN ONCE AGAIN. I AM AT A LOST AND OUT OF FUNDS TO CONTINUE TO PUT IT IN THE SHOP. THE ISSUE ALWAYS HAPPENS WHEN IN MOTION, WILL GET AN OVERHEATING WARNING AND TEMPERATURE WILL GO FROM NORMAL TO OVERHEATED WITHIN SEXONDS AND CAR WILL GO INTO LIMP MODE

NHTSA ODI 11375708