What 1,774 owners told NHTSA about the 2013 Ford Fusion Energi

I HAVE A RECALL ON MY CAR TO REPLACE THE TRANSMITION CABLE. I HAD THIS SAME PROBLEM BACK IN 2016. I KNEW BACK THEN THAT THIS WAS A BIG ISSUE AND THAT IT WAS A DEFECTIVE RECALL ISSUE AND I PAID $571.25 TO FIX A TRANMISSION SHIFTER CABLE. I STILL HAVE THE RECEIPT AND ALL THE NOTES THAT THE DEALERSHIP WROTE AND IT MATCHES THIS RECALL. I FILED ACOMPLAINT WITH NHTSA AND NO ACTION TAKEN BACK THEN AND I FEEL SINCE THIS IS A RECALL THAT I SHOULD HAVE NEVER PAID OUT OF POCKET FOR THIS RECALL AND I FEEL I SHOULD GET A REFUND FROM FORD. I ALMOST DIED WHEN I LOST CONTROL OF MY GEAR SHIFT AND I HAD MY CHILDREN IN THE CAR WHEN I LOST CONTROL OF MY 2013 FORD FUSION ON 9/16/16. I COULD NOT GET MY CAR GEAR TO SHIFT AT ALL AND IT WAS MOVING BY ITSELF. IF IT WASNT FOR THE EMERGENCY BRAKE ME AND MY TWO CHILDREN WOULD HAVE CRASHED AND GOT INJURED OR IMJURY SOMEONE ELSE. I HAVE ALL MY PAPERWORK AND WOULD LIKE TO SPEAK WITH SOMEONE FROM I KNEW BACK THEN THAT THIS WAS A MANUFACTURER/DEFECTIVE IN 2016, AND RECEIVED A LETTER DATED AUG 2018 THAT THERE IS A RECALL THAT I PAID FULL PRICE TO REPAIR AND FILED A COMPLAINT WITH NHTSA ABOUT IT, BUT NO ACTION WAS TAKEN BACK THEN. I WOULD LIKE TO FULE A COMPLAINT.

NHTSA ODI 11124048

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE THE VEHICLE WAS PARKED ON AN INCLINE, IT INADVERTENTLY STARTED TO ROLL AWAY. THE CONTACT HAD TO FORCEFULLY DEPRESS THE BRAKE PEDAL, BUT IT FAILED TO STOP THE VEHICLE. THE EMERGENCY BRAKE HAD TO BE ENGAGED IN ORDER TO STOP THE VEHICLE. THE CONTACT STATED THAT MULTIPLE UNKNOWN WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO FRANKLIN PARK LINCOLN, INC. (5272 MONROE ST, TOLEDO, OH 43623, (419) 882-7171) WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 65,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 11115523

POORLY DESIGNED SEAL AROUND BACK-UP CAMERA HOUSING ALLOWS MOISTURE INTO HOUSING, SENDS FAULTY SIGNAL TO ENGINE WHEN VEHICLE IS STARTED AND SHIFTED TO REVERSE ULTIMATELY SHUTTING DOWN THE ENGINE. THIS DOES NOT HAPPEN 100% OF TIME, BUT IT IS CONCERNING. USUALLY OCCURS DURING/AFTER RAIN, SNOW, OR HIGH HUMIDITY DAYS. THIS DESIGN FLAW ALSO DISABLES THE BRAKES, EMERGENCY BRAKE, AND POWER STEERING. VEHICLE DOES NOT TURN ON RIGHT AWAY AND STARTER CONTINUOUSLY CLICKS UNTIL VEHICLE COMPUTER RESPONDS TO START, KEY FAUB IS THE ONLY WAY I HAVE BEEN ABLE TO START THE VEHICLE AFTER THIS EVENT OCCURS. SOMETIMES THE COMPUTER GETS SO JAMMED UP THAT I MUST COMPLETELY DISCONNECT THE BATTERY AND HARD RESTART THE COMPUTER. WHEN THE ISSUE OCCURS THE VEHICLE CANNOT BE STOPPED AND WILL CONTINUOUSLY MOVE BACKWARDS UNTIL IT STOPS ON ITS OWN, IT HITS SOMETHING, OR THE VEHICLE CAN BE STARTED AGAIN. THIS DID HAPPEN TO ME WHILE I WAS PARKED ON A SLIGHT INCLINE AND MY CAR STOPPED AFTER IT ROLLED IN TO A PARKED CAR, LUCKILY NO DAMAGE OCCURED. AS SOMEONE WHO USED TO BE AN AIRBAG DESIGN ENGINEER I DEFINITELY BELIEVE THIS TO BE A SAFETY ISSUE. A MECHANIC AT THE FORD DEALERSHIP I BOUGHT THE VEHICLE FROM INFORMED ME THAT THIS ISSUE IS KNOWN TO FORD(HE FOUND THE INFORMATION ON HOW TO DIAGNOSE, REPAIR, AND WHAT PARTS TO BUY IN THE REPAIR DATABASE) AND I CALLED FORD TO CONFIRM THAT THEY DO KNOW THIS ISSUE. FORD INFORMED ME THAT THEY DO KNOW OF THE ISSUE, BUT IT IS NOT A SAFETY CONCERN. THIS ISSUE COSTS OVER $800 TO FIX AT A DEALERSHIP. MY EXTENDED WARRENTY WON'T COVER THE COST OF THE REPAIR BECAUSE IT IS CONSIDERED "WATER DAMAGE"

NHTSA ODI 11113535

ON NUMEROUS OCCASIONS, I HAVE EXPERIENCED A MOMENTARY LOSS OF CONTROL OF MY CAR WHEN BRAKING. THE CAR ACCELERATES MOMENTARILY AFTER THE BRAKES ENGAGE AND I HAVE TAKEN MY FOOT OFF OF THE ACCELERATOR. THIS PROBLEM OCCURS WHEN DECELERATING AROUND A CURVE , DRIVING DOWNHILL, OR WHEN DECELERATING OVER A BUMP OR OTHER AREA OF RAISED PAVEMENT LIKE MY DRIVEWAY. THESE INSTANCES HAVE OCCURRED ON CITY STREETS, AT SPEEDS UNDER 40 MPH. WHEN IT OCCURS IT FEELS AS IF THE CAR IS ACCELERATING. I WOULD ALSO DESCRIBE THE FEELING AS A SURGE, EVEN THOUGH THE CAR IS BRAKING, AND SHOULD BE SLOWING. I HAVE ALSO DESCRIBED THIS AS A FEELING THAT THE BRAKES SLIP OR STOP WORKING MOMENTARILY AND THEN RE-ENGAGE. THE EXPERIENCE IS FRIGHTENING, AND I AM CONCERNED THAT THE CAR COULD SURGE FORWARD WHILE I AM BRAKING AND RESULT IN A COLLISION OR INJURIES. THE CAR CURRENTLY HAS 26,000 MILES AND I HAVE TAKEN THE CAR IN FOR SERVICE REGULARLY. THESE SURGES RECENTLY HAVE SEEMED LONGER IN DURATION MORE RECENTLY. I HAVE NOTED THIS CONCERN TO MY FORD DEALER AND ASKED THEM TO CHECK THE BRAKES FOR PROBLEMS. THE DEALERSHIP HAS TOLD ME THAT THEY COULD NOT REPLICATE THE SURGE OR SKIDDING SENSATION. THIS IS NOT A SAFE CONDITION.

NHTSA ODI 11096454

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT THE WARNING INDICATOR ILLUMINATED FOR THE COOLANT TEMPERATURE, WHICH WAS INCREASING. THE VEHICLE FAILED TO ACCELERATE ABOVE 5 MPH. THE CONTACT STATED THAT THE ENGINE WAS TURNED OFF AND RESTARTED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO THE DEALER (HOLLINGSWORTH RICHARDS FORD, 778 FLORIDA BLVD, BATON ROUGE, LA 70806, (225) 927-5555) WHERE IT WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 17V209000 (ENGINE AND ENGINE COOLING). THE CONTACT WAS UNSURE IF THE REMEDY CAUSED THE FAILURES BECAUSE THE VEHICLE HAD NO FAILURES PRIOR TO THE RECALL REMEDY. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS INCLUDED IN EXTENDED WARRANTY CAMPAIGN NUMBER: 14N02 (ABS VEHICLE SPEED SIGNAL RELATED COMMUNICATION LOSS THAT DISABLES OBDII SYSTEM MONITORS). THE CONTACT STATED THAT THE VEHICLE HAD BEEN AT THE DEALER FOR OVER A WEEK WITHOUT DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ODI 11091256

WHILE BRAKING USING LIGHT TO MEDIUM PRESSURE (AND, THUS, WHILE THE CAR IS USING REGENERATIVE BRAKING), IF I HIT A POTHOLE OR BUMP JUST RIGHT, THE CAR WILL SURGE FORWARD AS IF THE ACCELERATOR WAS PUSHED. (AND, OF COURSE IT WASN'T.) THE PROBLEM IS RELATIVELY INTERMITTENT, BUT THAT DOESN'T MEAN IT IS NONEXISTENT. QUITE THE OPPOSITE; IT CAN BE RECREATED AS LONG AS THE CONDITIONS ARE CORRECT (AS DESCRIBED ABOVE). EVEN WHEN YOU RECREATE THE EXACT CONDITIONS, IT IS STILL INTERMITTENT (BUT, AGAIN, THAT DOESN'T MEAN NONEXISTENT). FORD HAS LOOKED AT THE PROBLEM REPEATEDLY AND DEEMED IT "UNABLE TO RECREATE." THIS IS A FALSEHOOD; THE PROBLEM WAS RECREATED ONCE WITH A DEALER DRIVING THE CAR. ALSO, FORD GAVE ME A DATA RECORDER UNIT AND, USING THAT, I WAS ABLE TO RECREATE THE PROBLEM WHILE THE RECORDER RAN. WHEN THEY RETRIEVED THE DATA, FORD CLAIMED THE CAR "PERFORMED AS EXPECTED." FORD REFUSED TO EXPLAIN WHETHER THAT MEANT THE CAR DID NOT SURGE OR WHETHER IT APPEARED TO SURGE, BUT THE SURGE APPEARED TO BE CALLED FOR. FORD REFUSED TO RELEASE THE RAW "FLIGHT RECORDER" DATA TO ME. FORD REFUSES TO FURTHER ADDRESS THIS PROBLEM. OUT-OF-CONTROL SURGING IS A DANGEROUS AND SERIOUS PROBLEM AND THIS PROBLEM REMAINS UNRESOLVED. I HAVE DOCUMENT EVERY STEP OF THE WAY AS I HAVE ATTEMPTED TO RESOLVE THIS. I ATTACH BELOW A LETTER I WROTE A YEAR AGO THAT BOTH DETAILS WHAT I HAD BEEN THROUGH AND THE PROBLEM ITSELF. I WOULD BE HAPPY TO PROVIDE MUCH MORE. THE DATE I PUT BELOW IS ONLY AN APPROXIMATION. I'M NOT SURE EXACTLY WHEN IT STARTED, BUT IT HAS BEEN GOING ON FOR YEARS.

NHTSA ODI 11081380

REAR BRAKES NEED REPLACEMENT AT ONLY 22,500 MILES. ALTHOUGH HAVING BEEN THE SUBJECT OF AN OWNER COMPLAINT DURING THE WARRANTY PERIOD, THE DEALER REFUSES TO TAKE ANY POSITIVE ACTION AND STATES THEY ARE A CONSUMABLE ITEM.

NHTSA ODI 11066983

PREMATURE AND SUDDEN REAR BREAK FAILURE OF BOTH PASSENGER AND DRIVER SIDE: SINCE PURCHASE CAR SHOWED MODERATE VIBRATION UPON HEAVY BREAKING BUT APPEARED TO FUNCTION NORMALLY PRIOR TO TOTAL REAR BRAKE FAILURE. A SUDDEN SCREECHING NOISE SHOWED UP COMPING FROM THE REAR OF THE VEHICLE ALONG WITH A NOTICEABLE LOSS OF BREAKING POWER. UPON IMMEDIATE VISUAL INSPECTION THE REAR BREAK PADS WERE COMPLETELY WORN WITH ONLY 18,983 MILES SINCE PURCHASED IN 2014. THE WORN PADS SHOWED TO CAUSE IMMEDIATE AND SIGNIFICANT DAMAGE TO THE BREAK DISCS. PREMATURE WEAR AND DAMAGE TO THE DISCS WERE NOT COVERED BY THE VEHICLE'S WARRANTY AS THE VEHICLE EXCEEDED IT FOR 4 MONTHS OR ANY CURRENT RECALL.

NHTSA ODI 11047792

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE CONTACT WAS INFORMED THAT THE REAR BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE CONTACT WAS CONCERNED THAT THE REAR BRAKE PADS NEEDED TO BE REPLACED AFTER ONLY 22,000 MILES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

NHTSA ODI 10980400

MY 2013 FORD FUSION HAS21,000 MILES ON IT AND THE FORD PEOPLE TELL ME IT NEEDS REAR BRAKES I HAVE A2009 SAME MODEL THAT I HAD BRAKES REPLACED AT 60,000 WHEN I ASK THE FORD PEOPLE WHY I GET NO ANSWER . I THINK THEY HAVE A SAFETY PROBLEM WITH THE BRAKE PADS .CAN YOU HELP ME.?

NHTSA ODI 10979380

TODAY MY BRAKE PEDAL WENT DOWN TO THE FLOOR . WHEN I STARTED MY VEHICLE . THE ABS LIGHT CAME ON. NO HILL SIDE START.. SERVICE ADVANCE TRACTION. I HAVE REPLACED ALL . BRAKE PADS, SHOCKS ,AND HAD ROTOR WORKED ON. ABS HAS GOTTEN WORST. I TOOK MY CAR TO THE NEAREST FORD SHOP. I ASKED THEM TO CHECK IT OUT AND REPLACE MY ABS SENSOR.

NHTSA ODI 10968681

MY ABS KEEP COMING ON IT GIVES THREE WARNING. CHECK ADVANCE TRACTION, NO HILL SIDE START. IT CLEAR ONCE LIGHT GO OFF. THE BRAKE THUMP. THEIR IS A SPRING NOISE THE STEERING BECOME BIND UP. THIS HAPPEN AFTER THE CAR MOVES ANY DISTANCE WHEN IT IS DECIDE TO.

NHTSA ODI 10967639

I HAVE HAD MY FORD FUSION FOR 6 MONTHS. OVER THE LAST 2 MONTHS I HAVE HAD ISSUES WITH BRAKING. THE BRAKES FAIL FOR A SPLIT SECOND JUST BEFORE COMING TO A COMPLETE STOP TO ADD TO THAT IT SOMETIMES DECIDES TO SURGE AND LURCHES FORWARD JUST BEFORE IT STOPS. IT HAS BEEN IN AND OUT OF THE FORD DEALER FOR REPAIR, THE FIRST FEW TIMES I WAS TOLD NOTHING WAS WRONG. THE LAST TIME, THEY DECIDE TO REPLACE THE THROTTLE BOTTLE AND A MODULE. FOR A FEW DAYS THE CAR SEEMED TO BE DOING BETTER UNTIL TODAY WHEN PULLING INTO MY DRIVEWAY. AS I WAS STOPPING TO PARK, THE CAR LURCHED FORWARD INTO A PILE OF WOOD. IF THIS HAD BEEN AT AN INTERSECTION OR SOMEONE CROSSING IN FRONT OF ME THIS COULD HAVE BEEN FATAL. I AM NOW SCARED TO DRIVE THE CAR AT ALL! LET ALONE LET MY TEEN DRIVE BEHIND THE WHEEL. I AM OUT OF OPTIONS! I CANNOT REFINANCE ANOTHER CAR.

NHTSA ODI 10957385

WEAR OR CORROSION ON THE FRONT SPEED SENSOR HARDNESS LED TO THE DISABLING OF ALL TRACTION/STABILITY CONTROL, REAR PARK ASSIST, ABS AND AIRBAG OPERATION.

NHTSA ODI 10956042

WIFE WAS DRIVING THE CAR TO WORK APPROACHING A STOP SIGN TO A VERY BUSY HIGHWAY. SHE WENT TO APPLY THE BRAKE WHEN SHE DISCOVERED THAT THE BRAKES HAD COMPLETELY FAILED, STEERING CONTROL HAD BEEN LOST AND THE PARKING BRAKE HAD BEEN DISABLED AS WELL. BASICALLY ALL MEANS OF BRINGING THE VEHICLE TO A CONTROLLED STOP HAD FAILED AT THE SAME TIME. BEING UNABLE TO BRING THE CAR TO A STOP IT CARRIED HER OUT IN THE HIGHWAY WERE LUCKILY THE LARGE TRUCK COMING DOWN THE ROAD WAS PAYING ATTENTION AND MANAGED TO SWERVE AROUND HER. SHE WAS ABLE TO GET THE CAR TO COME TO AN EVENTUAL STOP AT WHICH TIME SHE CALL ME AND I CAME TO LOOK AT IT. I WAS ABLE TO CONFIRM THAT THE CAR HAD NO BRAKES, POWER STEERING WAS LOST AND THAT THE PARKING BREAK WAS IN FAILURE AS WELL. WE HAD THE CAR TOWED TO BILLY HOWELL FORD WHERE THEY INITIALLY TOLD US THAT THEY SUSPECTED THAT THE WIRING HARNESS HAD GONE TO GROUND BUT FOUND OUT LATER THAT THE ABS MODULE FAILED WHICH HAS CONTROLS INTO THE STEERING AND PARKING BRAKE SYSTEM WHICH IS WHY THOSE FAILED AS WELL. I OPENED A CASE WITH FORD GIVEN THE NEAR CATASTROPHIC NATURE OF THE FAILURE AND ASKED THEM WHAT ARE OPTIONS WERE TO TRADE THE CAR IN BECAUSE I DIDN'T WANT ANYONE IN MY FAMILY GOING BACK INTO THE VEHICLE. I WAS TOLD BY FORD THAT THE CAR DOESN'T QUALIFY FOR BUY BACK SINCE IT IS A 2013 AND THAT I DID NOT QUALIFY FOR ANY PROGRAMS. EXPLAINED TO FORD THAT I WAS NOT LOOKING FOR A BUY BACK BUT JUST FOR THEM TO WORK WITH THE DEALER TO ALLOW ME TO TRADE IT IN FOR WHAT I OWE WHICH IS NOT FAR FROM THE TRADE IN VALUE. THE DEALER TOLD ME THAT THERE IS NOT AN ACTIVE RECALL ON THE FAILURE WE EXPERIENCED SO WE WOULD HAVE TO PAY APPROXIMATELY $2,000 TO HAVE IT REPAIRED AS WELL.

NHTSA ODI 10906801

INITIAL FAILURE OF PARKING BREAK SWITCH WARNING LIGHT (AND SWITCH ITSELF) FOLLOW BY WIRE HARNESS FAILURE UNDER DASH DUE TO WIRES RUBBING AGAINST EXPOSED STEEL DASH FRAME CAUSING UNKNOWN ADDITIONAL ISSUES, INCLUDING ACTIVATION OF DASHBOARD CHECK ENGINE LIGHT. FAILURES HAPPENED OVER TIME AS WIRING BECAME FRAYED AND FINALLY CAUSED A SERIES OF SHORT CIRCUITS. THE WIRING HARNESS FAILURE WAS REPORTED TO FORD CUSTOMER SERVICE - CASE NUMBER CAS-10375276-L2-W7-J7. NO ACTION WAS TAKEN OTHER THAN A FOLLOW-UP EMAIL FROM THE DEALER'S SERVICE MANAGER SUGGESTING I HOLD ON TO THE PAPERWORK IN THE EVENT OF A RECALL. NOTE THAT THE MECHANIC INFORMED THE SERVICE DEPARTMENT THAT "I'VE SEEN THIS BEFORE". THE CAR HAS ABOUT 62,200 MILES ON IT AND IS ONLY 3 YEARS OLD. GIVEN THE COMPUTERIZED NATURE OF THIS CAR, A COMPUTER WIRE HARNESS FAILURE IS CLEARLY A SAFETY HAZARD WORTH INVESTIGATION. MY GUESS IS THAT THERE ARE SEVERAL POSSIBLE SIMPLE FIXES, INCLUDING RE-ROUTING THE WIRE HARNESS, LINING THE STEEL FRAME WITH A RUBBER COATING AND SIMILAR APPROPRIATE STEPS THAT COULD BE TAKEN.

NHTSA ODI 10898427

REAR BRAKE PADS AND ROTORS NEED REPLACED AT ONLY 37,000 MILES.

NHTSA ODI 10785317

THE REGENERATIVE BRAKING WILL CUT OUT UNDER SPECIFIC CIRCUMSTANCES AND THE CAR WILL FEEL LIKE IT IS LURCHING FORWARD INSTEAD OF SLOWING DOWN. THE SITUATION IS: BRAKING USING ONLY REGEN BRAKES, NO FRICTION BRAKES; STEADY PEDAL PRESSURE; GOING 15-20 MPH; TURNING THE STEERING WHEEL AT LEAST 90 DEGREES LEFT OR RIGHT; DRIVING ON SMOOTH PAVEMENT. DATA I HAVE LOGGED FROM THE SOBDMC INDICATES THAT THE TRACTION MOTOR BRIEFLY REDUCES ITS NEGATIVE TORQUE WHICH CAUSES THE CAR TO SURGE FORWARD. IN ONE INSTANCE THAT I LOGGED THE NEGATIVE TORQUE SHOWS AROUND 48 FT-LBS AND THEN SUDDENLY DROPS TO ABOUT 8 FT-LBS. THE TRACTION MOTOR THEN GRADUALLY INCREASES TORQUE BACK TO THE APPROPRIATE LEVEL. IN ANOTHER INSTANCE THE NEGATIVE TORQUE SUDDENLY WENT FROM ABOUT 28 FT-LBS TO 8 FT-LBS. THE DROP IN TORQUE OCCURS IN 1/10 OF ONE SECOND PER MY LOGGED DATA. IT TAKES ABOUT 2.5-3.0 SECONDS FOR THE TRACTION MOTOR TO RETURN TO THE APPROPRIATE LEVEL OF NEGATIVE TORQUE TO STOP THE VEHICLE. THIS BEHAVIOR BEGAN OCCURRING RIGHT AFTER OUR VEHICLE WAS SERVICED BY A LOCAL FORD DEALERSHIP. THE WORK DONE BY THE FORD DEALERSHIP INCLUDED REPLACING THE 12V BATTERY & 3 RECALLS: 14S21, 15E03 & 15S14. I BELIEVE THAT THIS SERVICE IS RESPONSIBLE FOR THESE PROBLEMS, AS THIS ISSUE WAS NOT PRESENT BEFORE OUR CAR WENT TO THE DEALERSHIP.

NHTSA ODI 10758745

THE BRAKES ON MY 2013 FORD FUSION TITANIUM HAD BEEN IMPROPERLY "PULSING" FOR SOME TIME. BROUGHT CAR TO MY MECHANIC TO CHECK BRAKES ~7/31/15. HE FOUND THAT REAR CALIPERS, PADS AND ROTORS WERE ESSENTIALLY TOTALLY WORN WHILE FRONT BRAKES WERE FINE AND SHOWED MINIMAL WEAR. HAD TO HAVE REAR CALIPERS, PADS AND ROTORS COMPLETELY REPLACED. MECHANIC SAID THIS SORT OF BRAKE WEAR IS NOT NORMAL FOR A VEHICLE WITH ~26,000 MILES ON IT. IN FACT, IN HIS EXPERIENCE THE FRONT BRAKES USUALLY GO BEFORE THE REAR BRAKES...UPDATED 11/02/15 *BF UPDATED 01/08/2016*JS *CN

NHTSA ODI 10746600

THIS IS A CASE OF MULTIPLE INCIDENTS, FIRST INCIDENT WITH SIGNIFICANT ISSUE WAS ON 12/11/2014. AS I WAS PULLING OUT OF MY DRIVEWAY AND REVERSING ACROSS TWO LANES OF TRAFFIC, MY CAR TURNED OFF AND SAID "PRESS BRAKE TO START" (I HAVE THE PUSH-START-IGNITION). THE CAR TURNED OFF AS I WAS REVERING ACROSS THE STREET, I HAD TO PUT THE CAR IN PARK IN ORDER TO RESTART THE CAR. I RESTARTED THE CAR AND DROVE IT TO THE DEALERSHIP, WHICH THEY HAVE NEVER HEARD OF THIS ISSUE AND SAID THEY COULD NOT GET ME IN FOR AN APPOINTMENT UNTIL 12/15. ON 12/14/2014, AS I WAS DRIVING DOWN THE ROAD AT ~25MPH, MY CAR STARTED TO ACT LIKE IT WAS GOING TO QUIT, BEFORE I COULD PULL OFF TO THE SIDE OF THE ROAD, THE CAR TURNED OFF AND SAID "PRESS BRAKE TO START" I WAS ABLE TO GET THE CAR TO THE SIDE OF THE ROAD, AS I DID I PUT THE CAR IN PARK AND TRIED TO RESTART THE CAR AND IT JUST KEPT ROLLING OVER AND I HAD TO PUSH THE START BUTTON TO GET IT TO STOP, AS I DID, THE BRAKES AND STEERING WHEEL LOCKED AND I HAD TO HAVE THE CAR TOWED TO THE DEALERSHIP. THE DEALERSHIP HAD THE CAR FOR 3 DAYS, COULD NOT FIND AN ISSUE. I FILED A COMPLAINT WITH FORD AND THEY HAVE CLOSED MY CASE SAYING THERE IS NOT AN ISSUE. IT IS NOW AT A 2ND DEALERSHIP WHERE THEY CAN NOT FIND AN ISSUE. I HAVE BEEN TOLD BY FORD TO CONTINUE DRIVING MY CAR UNTIL THE ISSUE HAPPENS AGAIN, WHICH IS A MAJOR CONCERN FOR MY PERSONAL AND OTHERS SAFETY AS I AM DRIVING DOWN THE ROAD. WHEN THE CAR QUITS, I HAVE HARDLY ANY CONTROL OVER THE VEHICLE AND LUCKILY I HAVE BEEN GOING AT SLOW PACE, BUT I DO NOT FEEL SAFE DRIVING THIS CAR AND FEEL LIKE FORD HAS GIVEN UP ON ME. THIS CAR HAS BEEN NOTHING BUT PROBLEMS SINCE I'VE HAD IT WITH 9 RECALLS AND NOW THIS ISSUE, I AM CONCERNED THAT I AM NOT THE ONLY PERSON HAVING THIS ISSUE AND WOULD LIKE TO HAVE THE PROBLEM ADDRESSED BEFORE SOMEONE IS IN A SERIOUS ACCIDENT. *JS UPDATED 2/11/16 *JS

NHTSA ODI 10668968

I WAS INVOLVED IN A MOTOR VEHICLE ACCIDENT, IN WHICH I WAS FIRST HIT BY ANOTHER CAR AND THEN COLLIDED WITH A LAMP POST. THE INITIAL BLOW RENDERED MY VEHICLE WITHOUT BRAKE POWER AND THE AIRBAGS DID NOT DEPLOY. I WAS WEARING A SEATBELT. MY CAR HEADED TOWARD THE STREET LAMP. I TRIED TO PRESS MY BRAKE, BUT IT WOULD NOT WORK. I TURNED MY STEERING WHEEL TO THE LEFT TO AVOID A HEAD-ON WITH THE LIGHT POST. UNFORTUNATELY, I HIT THE POST AND IT BROKE (LATER A POLICEMAN PUSHED IT OVER AND IT FELL TO THE GROUND). THE CAR FINALLY STOPPED AT ABOUT 200 FEET AWAY FROM THE SITE OF THE ACCIDENT, AS I DROVE IT ONTO THE MEDIAN STRIP. MY CAR WAS DAMAGED ON THE LEFT AND RIGHT FRONT LOWER AREA AND THE RIGHT TIRE WAS PUSHED WAY BACK. THE SWAY BAR AND KNUCKLE BROKE, AMONG OTHER THINGS. THE RIGHT FRONT DOOR WAS UNABLE TO OPEN. AFTER ALL THESE REPAIRS WERE DONE, THEY COULDN'T START THE CAR BECAUSE THE CRANKSHAFT SENSOR ALSO HAD TO BE REPLACED. IN TOTAL, THESE REPAIRS TOOK MORE THAN TWO MONTHS TO COMPLETE. I SPOKE TO THE REGIONAL MANAGER OF FORD MOTOR COMPANY TO SEE IF THEY WANTED TO INVESTIGATE THIS PARTICULAR CAR, AS IT OPERATED POORLY DURING THE ACCIDENT. THEY WERE NOT INTERESTED, AND SAID TO ALLOW GEICO TO HANDLE THINGS AND HAVE GEICO CALL THEM IF THEY FOUND ANYTHING AMISS. MY BACK WAS INJURED AND I CANNOT SAFELY LIFT MORE THAN 5 LBS AT A TIME. MY NEUROSURGEON ADVISED THAT I HAVE SURGERY SOON, OTHERWISE I RISK BECOMING PARALYZED FROM THE WAIST DOWN. I HAVE A THUMB INJURY AND THE ACCIDENT ALSO RE-ACTIVATED AN OLD CONCUSSION. MY NOSE MUST HAVE HIT THE STEERING WHEEL, AS IT WAS SORE FOR A WEEK. I CAN WALK AROUND AND FUNCTION RIGHT NOW, I JUST CAN'T LIFT ANYTHING. MY CAR IS READY IN THE SHOP, BUT I AM AFRAID TO DRIVE IT, AND I HAVE FIVE YEARS OF PAYMENTS LEFT ON IT. I NEVER WOULD HAVE HIT THE LAMP POST IF MY BRAKES HAD WORKED, AND MY AIRBAGS DID NOT DEPLOY FOR EITHER IMPACT. *TR

NHTSA ODI 10619452

I OWN A 2013 FORD FUSION, I HAVE HAD A VERY SERIOUS MECHANICAL MALFUNCTION OVER THE PAST 3 WEEKS. THE VEHICLE WILL COMPLETELY SHUT DOWN WHILE OPERATING THE VEHICLE CAUSING THE STEERING WHEEL TO LOCK, BRAKES NOT TO WORK, EMERGENCY BRAKE NOT WORK AND FINALLY THE AIR BAGS DO NOT DEPLOY. I HAVE TAKEN THE VEHICLE BACK TO THE DEALERSHIP WHERE I PURCHASED IT FROM ON 2 OCCASIONS. THE FIRST TIME WAS MARCH 28TH AND AFTER HAVING THE CAR FOR 7 HOURS I WAS TOLD THAT THEY DIDN?T HAVE TIME TO LOOK AT IT AND THAT I SHOULD BRING IT BACK NEXT WEEK. I ASKED THEM WHAT I WAS SUPPOSED TO DO IF IT HAPPENED AGAIN AND I WAS TOLD ?KEEP TRYING TO RESTART THE CAR? AND BRING IT BACK NEXT WEEK. THE WEEK OF THE 31ST THRU THE 4TH I HAD TWO MORE OCCASIONS WHERE THE CAR SHUT DOWN. I TOOK THE CAR IN ON APRIL 4TH AND WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. I ASKED FOR A RENTAL OR A LOANER CAR AND WAS TOLD THAT THEY DIDN?T HAVE ANY. I DIDN?T DRIVE THE CAR THAT WEEKEND BECAUSE I DIDN?T FEEL SAFE PUTTING MY FAMILY IN IT. ON APRIL 7TH I WAS DRIVING HOME FROM WORK WHEN THE CAR SHUT DOWN AND AS A RESULT I WENT THROUGH A 6 FOOT TALL STONE WALL THAT WAS REINFORCED BY REBAR. I WAS LUCKILY NOT INJURED, I HIT THE WALL BETWEEN 20-25 MPH AND HAD NO AIRBAG DEPLOYMENT. I HAVE TALKED TO THE DEALERSHIP WHERE I PURCHASED THE CAR AND WAS TOLD THAT THIS IS SOMETHING THAT FORD MOTOR COMPANY TAKES CARE OFF. I HAVE CONTACTED FORD AND SPOKE WITH DIVANA IN THE LEGAL DEPARTMENT AND WAS TOLD THAT THIS IS A PRODUCT LIABILITY WITH THE CAR. THIS WAS ON APRIL 8TH . ON APRIL 11TH I WAS CONTACTED BY FORD AND TOLD THAT THERE IS NOTHING THAT THEY CAN DO AND THAT I SHOULD CALL THEM BACK IF IT HAPPENS AGAIN. I POSED THE QUESTION IF I WERE DRIVING AT 75 MPH A HIT A 18 WHEELER WHAT WAS I SUPPOSED TO DO. I GUESS THEY WOULDN?T HAVE TO WORRY ABOUT A COMPLAINT. *JS

NHTSA ODI 10579691

THE MOON ROOF WINDOW OPENED WITH OUT ANY BUTTON BEING PRESSED. STORM RAIN WAS STARTING. THERE WAS A LOT OF AUTO TRAFFIC. I WAS DRIVING , MY WIFE WAS SITTING NEXT TO ME AND THERE WAS A CAR COMING OUT OF A PARKING LOT TO THE LEFT OF ME AND PERPENDICULAR TO MY CAR :WHAT HAPPENED NEXT SIMULTANEOUSLY WAS: A. AUTO WENT INTO "COLLISION AVOIDANCE MODE"; WINDSHIELD SEVERAL RED LED WARNING LIGHTS BEGAN BLINKING, AND ALERT NOISE FROM AUTO STARTED , AND STEERING WHEEL SHUTTERED. THE LATER TWO ACTIONS ARE NOT TERRIBLY CLEAR TO ME B MY WIFE STARTED TO SHOUT FOR ME TO WATCHOUT. C I STARTED TO PRESS ON BRAKES. THUS AVOIDING A COLLISION BETWEEN MY CAR AND CAR TO BE MOVING ACROSS MY PATH I WAS TOLD THAT THE CAR DOES NOT STOP IN ANY TYPE OF COLLISION MODE. IT JUST SLOWS DOWN. I DID NOT KNOW WHETHER THIS AVOIDANCE MODE WAS PRESENT (AT THE SLOW SPEED I WAS GOING IN. I DID KNOW THAT WHEN THE CAR WAS IN CRUISE CONTROL AND THIS MODE WAS ACTIVATED AND THAT AVOIDANCE REACTIONS WERE ACTIVATED. . I AM VERY CONCERNED THAT THIS MAY HAPPEN AGAIN. WITH SERIOUS CONSEQUENCES OCCURRING. *TR

NHTSA ODI 10520192