What 2,224 owners told NHTSA about the 2013 Ford Explorer Police Intercept

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 40 MPH, the steering wheel became firm, requiring extra effort while steering the vehicle. The contact stated that the stability control warning light was illuminated. The contact stated that the warning light turned off an hour before the vehicle lost power steering functionality. The contact pulled over and turned off and restarted the vehicle however, the power steering functionality had not returned. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the electronic power steering assist had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 14V286000 (Steering). The failure mileage was approximately 156,000.

NHTSA ODI 11525724

While turning, the power steering assist stopped functioning, leaving me veering into oncoming traffic as I could not complete my turn without the power steering assist.

NHTSA ODI 11525411

Vehicle began exhibiting intermittent, momentary ABS activation (right front) which would cause vehicle to randomly and severely pull to the right and momentarily flash the traction control warning lamp. This problem began early in 2022 and was first taken to Ford dealership in May 2022. Multiple visits to dealer resulted in inability to diagnose due to lack of recorded codes although they were able to reproduce. Dealer hypothesized a bad electronic steering rack. Subsequent visits to non-Ford repair shops yielded no solution despite replacing ABS Control Module, Electronic Steering rack, yaw sensor, and front struts. Repair shop was able to reproduce. Recently took vehicle to Ford dealer who reproduced and performed pinpoint tests identifying the yaw sensor in the Restraint Control Module (RCM) as most likely cause, but replacement failed to solve. Dealer then removed the front bumper assembly and cleaned and calibrated the cruise control module. Dealer finally identified the problem as a failed Steering Wheel Rotation Sensor and replaced/repaired on May 25, 2023 (over a year after first exhibiting). This part (Ford BB5Z-3F818-A) covers 25 fitments ranging from 2011-2016 and is on national back-order. Speaking with dealers across the US while searching for the part, we found many dealers have been awaiting this part to fix similar problems for a year or more and there were only 7 dealers nationwide with this part in inventory. Based on these facts, it would appear this is likely a "known" issue for Ford, however there has never been a TSB or recall issued to resolve or prevent this from occurring. On multiple occasions, the intermittent ABS activation nearly pulled the vehicle into another lane of traffic and/or into other vehicles' path. I believe this part failure poses a significant safety risk and should, at a minimum, be disclosed to Ford/Lincoln/Mercury dealers via a TSB or through a recall.

NHTSA ODI 11524515

The contact owns a 2013 Ford Explorer. The contact stated that while driving at various speeds, the power steering assist fault message was displayed. Over time, excessive effort was required to steer the vehicle because the steering wheel was firm. The contact called the dealer and was referred to the manufacturer. The contact was informed that the VIN was not included in NHTSA Campaign Number: 14V286000 (Steering). The vehicle was not repaired. The failure mileage was approximately 216,000.

NHTSA ODI 11522027

The contact owns a 2013 Ford Explorer. The contact stated that on several occasions when the vehicle was started, an unknown warning light illuminated, and the vehicle lost power steering functionality. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 126,000.

NHTSA ODI 11521167

The contact owns a 2013 Ford Explorer. The contact stated while making a left turn, the steering wheel seized. The contact stated that the service power steering now warning light was illuminated. The contact depressed the brake pedal, and the steering wheel was able to turn properly. The vehicle was not diagnosed or repaired. A dealer was not contacted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V286000 (Steering) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 243,000.

NHTSA ODI 11520892

The contact owns a 2013 Ford Explorer. The contact stated that while driving at various speeds, the power steering assist warning light illuminated, and the steering wheel became firm. The dealer was notified of the failure, and the contact was informed that the VIN was not under recall. Upon investigation, the contact discovered NHTSA Campaign Number: 14V286000 (Steering) which she linked to the failure. The manufacturer was also notified of the failure and the contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 98,000.

NHTSA ODI 11521021

I was driving and the steering wheel got really hard to turn. It continues too do this periodically. I know there was a recall for this on vehicles built before mine.

NHTSA ODI 11519672

The contact owns a 2013 Ford Explorer The contact stated that why driving approximately 75 mph when suddenly the power assist failed. The contact had pulled over and restarted the vehicle however the power assist failed to correct. The power assist warning light had illuminated. The contact took the vehicle to the dealer who stated that the power assist module failed and needed to be replaced. The vehicle was repaired by a certified mechanic who was not associated with the dealer to which the vehicle was brought. The failure persisted causing the vehicle to be an additional 2 times. The contact stated the owner before them had the same power assist module replaced once before as well. The manufacturer was made aware of the failure and informed them that they had missed the warranty/recall deadline then referred them to NHTSA. The approximate failure mileage was 85,000.

NHTSA ODI 11516290

There is a recall for 2011-2013 Ford Explorers re: Electric power steering malfunction but my VIN# is not included. My 2013 Explorer is experiencing this problem. Can you help? Vehicle was not driven much after incident. Thank you!

NHTSA ODI 11515725

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 40 MPH and exiting the highway, while making a left turn, the steering wheel failed to respond. The contact stated that while switching to the center lane, the vehicle kept drifting to the left. The contact stated no warning light was illuminated. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that the rack and pinion steering arms needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was 204,049.

NHTSA ODI 11515176

My suspension was damaged and my car froze and stalled during winter storm and caused my car to go to several shops and I spent lots money on repairs

NHTSA ODI 11514735

Power steering assist fault

NHTSA ODI 11514137

The contact owns a 2013 Ford Explorer. The contact stated that while making a turn from a complete stop, the vehicle gradually lost power steering functionality. There was no warning light illuminated. The contact was able to continue driving by using physical strength to steer the vehicle. The contact stated that the failure occurred increasingly while making turns and decreased while driving on straight. The contact related the failure to NHTSA Campaign Number: 14V286000 (Steering); however, the VIN was not included. The dealer was notified of the failure and an appointment was scheduled for a diagnostic test. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 168,000.

NHTSA ODI 11513001

My power steering assist fault came on while driving my steering wheel became very hard to turn which caused me to almost crash I had swerve and stop me and my 3 year old were almost killed my truck electrical system is malfunctioning on its on and ford will not look into it I’ve read up on all the recalls ford has had for the power steering assist fault and it’s scary that it happened to me while driving I’m extremely terrified to drive after having that happen to us

NHTSA ODI 11513051

The contact owns a 2013 Ford Explorer. The contact stated while driving 40 MPH with her three-year-old in the vehicle, the power steering assist fault warning light illuminated and the steering wheel became difficult to turn, causing the vehicle to strike a street pole sign. The contact stated that she was unable to turn the steering wheel. The contact stated that the air bags did not deploy. The driver sustained neck injuries but did not receive medical attention. A Police report was not filed. The contact was concerned for her safety and had the vehicle towed to an independent mechanic and was diagnosed with an electrical power steering assist failure. The contact was informed that the electrical power steering assist needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was informed that the part required to fix the vehicle was no longer in production. The contact referenced NHTSA Campaign Number: 14V286000 (Steering) however, the VIN was not included. The failure mileage was 200,060.

NHTSA ODI 11513075

Power steering assist fault I was driving when it came on and almost wrecked with my 3 year old in the car with me

NHTSA ODI 11512309

The contact owns a 2013 Ford Explorer. The contact stated when he started the vehicle and shifted into drive(D), the vehicle lost power steering functionality. The contact turned the vehicle off and, on several times, but the power steering functionality failed to return. The contact drove the vehicle back to the residence without power steering at approximately 30 MPH. The contact stated that the power steering assist warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the steering rack assembly needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to NHTSA Campaign Number: 14V286000 (Steering). The manufacturer had not been informed of the failure. The failure mileage was approximately 130,000.

NHTSA ODI 11510972

The SUV will swerve into other lane when it switches gears. Replaced both struts. Odor in the cab. Coolant will not stay and after spending $1000 for repairs, it still cannot be fixed. Cracked head gasket.

NHTSA ODI 11510468

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 60 MPH, there was an abnormal sound coming from both front wheels. The contact stated that it sounded like the tires rubbing on the wheel wells. The contact stated that the check power steering warning light was illuminated. The contact pulled off the highway into a parking lot and stopped the vehicle and saw the "Service Power Steering Now" light was illuminated. The contact turned off and restarted the vehicle however, the failure persisted. The contact stated that the steering wheel failed to turn to the right or the left. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had been informed of the failure. The contact had been advised by Ford Customer Service that there was a recall, NHTSA Campaign Number: 14V286000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 138,000.

NHTSA ODI 11507379

The contact owns a 2013 Ford Explorer. The contact stated while his wife was driving at an unknown speed, the steering wheel became difficult to turn intermittently. The contact stated no warning light was illuminated. The contact stated that the radio, entertainment systems, and navigation systems were inoperable during the failure. The contact took the vehicle to an independent mechanic for the repairs due to the vehicle being vandalized and experienced the failure. The independent mechanic was informed of the rack and pinion and electric power steering. The vehicle was not repaired. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14V286000 (Steering) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was unknown.

NHTSA ODI 11507412

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist with the power steering assist fault message displayed. The contact restarted the vehicle to correct the failure. The vehicle was taken to an independent mechanic, who diagnosed that the failure was related to NHTSA Campaign Number: 14V286000 (Steering) however, the VIN was not included in the recall. The dealer was made aware of the failure but confirmed that there was no recall associated with the VIN. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 173,000.

NHTSA ODI 11506976

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to an independent mechanic and the mechanic related the failure to NHTSA Campaign Number: 14V286000 (Steering). The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 190,000.

NHTSA ODI 11506368

The individual has a 2013 Ford Explorer with two active recalls for rear toe link fracture and reached out to Alton Blakely dealership in Somerset, Kentucky, to have it repaired. However, the dealership refused to repair the vehicle and directed the individual to find another dealership. The reason given was that in the past, they have conducted the repair and left the vehicle in worse shape than before, with the vehicle unable to be appropriately aligned, leading to uneven wear on the tires. The individual is looking to draft a complaint to the National Highway Traffic Safety Administration (NHTSA) about the dealership's refusal to repair the vehicle, despite it being a recall repair.

NHTSA ODI 11506064

The contact owns a 2013 Ford Explorer. The contact stated while driving at approximately 3 MPH, and leaving his driveway, the power steering failed to operate as needed. The contact stopped and turned off and then restarted the vehicle. The vehicle resumed power steering functionality. The contact stated that the "power steering assist" warning light was illuminated. The contact stated that the power steering assist failure was intermittent. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer had been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 14V286000 (Steering). The failure mileage was approximately 150,000.

NHTSA ODI 11505792