What 121 owners told NHTSA about the 2012 Volvo S60 T5

The steering wheel trim peeled and created a razor sharp surface at the bottom which sliced through my finger and caused pain and bleeding. It is difficult to avoid touching the sharp part of the steering wheel especially at highway speeds. This startled me while driving and distracted me while I attempted to stop the bleeding. Volvo has agreed to replace the trim but will charge for labor if I choose to go into a dealer.

NHTSA ODI 11483292

A METAL SILVER PIECE ON STEERING HAS A SHARP EDGE THAT RESULTED IN A CUT ON FINGER WHILE DRIVING. THE VEHICLE WAS IN MOTION AND TURNING.

NHTSA ODI 11057659

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THERE WAS A LOSS OF STEERING CONTROL AND THE REAR END SPUN UNCONTROLLABLY. THE DYNAMIC TRACTION CONTROL FAILED TO ACTIVATE AND THE VEHICLE CRASHED INTO THE CURBSIDE, CAUSING DAMAGE TO THE FRONT DRIVER AND PASSENGER'S SIDE WHEEL RIMS. IN ADDITION, THE REAR DRIVER'S SIDE RIM AND FRONT BUMPER WAS DAMAGED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. A TROUBLE CODE WAS DETECTED FOR THE SRS MODULE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 18,991.

NHTSA ODI 10543130

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT THE ALUMINUM ON THE STEERING WHEEL BECAME DETACHED. THE CONTACT SUSTAINED LACERATIONS TO THE HANDS AS A RESULT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 21,700.

NHTSA ODI 10534272

THE STEERING WHEEL BEZEL DELAMINATES ON THE BOTTOM OF THE STEERING WHEEL AND BECOMES VERY SHARP CAUSING CUTS ON HANDS. DEALER REPLACED THE BEZEL AND WE HAVE THE SAME PROBLEM AGAIN. IT APPEARS TO BE A DEFECT IN THE DESIGN OR MANUFACTURE OF THE BEZEL. THERE SHOULD BE NO SHARP CUTTING EDGES ON THE STEERING WHEEL! *TR

NHTSA ODI 10503380