What 121 owners told NHTSA about the 2012 Volvo S60 Recharge

VEHICLE HAD A NO START, NO CRANK CONDITION WHILE PARKED. WAS TOWED TO DEALERSHIP. DEALER DETERMINED NO START, NO CRANK CONDITION WAS CAUSED BY OUTDATED SOFTWARE. I DO NOT THINK VOLVO SHOULD DESIGN A CAR TO NOT START IF SOFTWARE IS OUTDATED. HAD I NEEDED TO USE THE CAR TO DRIVE TO HOSPITAL OR SOME OTHER EMERGENCY THIS WOULD HAVE BEEN AN ISSUE.

NHTSA ODI 11093399

CAR DID NOT INDICATE LOW OIL PRESSURE AT ANY TIME. ENGINE SEIZED AND STALLED ON FREEWAY CREATING DRIVING HAZZARD. CAR WAS IN MOTION AT APPROX. 65 MPL, STARTED SHAKING AS IF A TIRE HAD BLOWN. CAR STARTED TO SMELL LIKE BUNED OIL, STALLED AND WOULD NOT RESTART. THE ONLY ALERT THAT CAME ON WAS THE LOW BATTERY ICON AFTER THE MOTOR SEIZED.

NHTSA ODI 11089975

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT THE ENGINE SEIZED WITHOUT WARNING WHILE DRIVING 45 MPH. THE VEHICLE WAS TOWED TO MCGRATH VOLVO CARS BARRINGTON (300 MN HOUGH ST, BARRINGTON, IL) WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED DUE TO THE OIL BEING FOUR QUARTS LOW. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 13V592000 (ENGINE AND ENGINE COOLING) AS A POSSIBLE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

NHTSA ODI 11088658

VOLVO HAS AN INTERNAL SERVICE RECALL FOR THEIR ENGINE OIL SENSORS. THE INFORMATION CAN BE FOUND HERE: THEY HAVE STATED THAT THEY FIXED THE SENSOR IN MY VEHICLE; HOWEVER, I STILL EXPERIENCED THE EXACT PROBLEM DESCRIBED IN THE SERVICE RECALL. MY CAR SHOWED 0 ENGINE OIL LIGHT READINGS, BUT MY ENGINE SEIZED UP IN THE MIDDLE OF THE INTERSTATE. HAD OTHER VEHICLES BEEN AROUND, I WOULD HAVE SURELY BEEN IN AN ACCIDENT.

NHTSA ODI 11075638

AT AROUND 51,000 MILES, THE OIL PRESSURE LIGHT BLINKED. WE CHECKED THE OIL AND FOUND THAT WE HAD TO ADD 5 QUARTS ON 11/5/2017. VOLVO ADDED ANOTHER QUART ON 12/26/2017. WE ARE CONCERNED ABOUT THE OIL USAGE AND SAFETY, AND ARE KEEPING IN CONTACT WITH OUR VOLVO DEALER TO SEE IF THIS CONTINUES.

NHTSA ODI 11063666

A METAL SILVER PIECE ON STEERING HAS A SHARP EDGE THAT RESULTED IN A CUT ON FINGER WHILE DRIVING. THE VEHICLE WAS IN MOTION AND TURNING.

NHTSA ODI 11057659

TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT THE DEALER (JIM FISHER VOLVO, 2108 W BURNSIDE ST, PORTLAND, OR 97210, (503) 295-5571) INDICATED THAT THE ENGINE ASSEMBLY NEEDED TO BE REPLACED DUE TO A PREMATURE INTERNAL FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

NHTSA ODI 11001412

THE CAR WAS CONSUMING OIL AT A SHOCKING RATE - 12 QUARTS OVER THE COURSE OF 2 MONTHS AND THE OIL LIGHT DID NOT ILLUMINATE, EVEN WHEN THE ENGINE WAS COMPLETELY OUT OF OIL! I OPENED A CASE WITH VOLVO USA AT THE TIME AND WAS TOLD TO BRING THE CAR TO A DEALER. THE DEALER COULD NOT FIND A LEAK AND DID NOT RESOLVE THE PROBLEM. I RETURNED TO THE DEALER AGAIN FOR THE SAME ISSUE AND IT WAS STILL NOT RESOLVED. A FEW WEEKS AFTER MY MOST RECENT VISIT TO THE DEALER, THE CAR MADE A LOUD NOISE WHILE IN TRAFFIC GOING ABOUT 30 MPH. THE CAR WAS DEAD IN THE MIDDLE OF ATLANTA TRAFFIC. IT TURNS OUT THE ENGINE "THREW A ROD" AND THE ENTIRE ENGINE WOULD NEED TO BE REPLACED ($11K)! THIS CAR HAS 78K MILES ON IT. I AGAIN REACHED OUT TO VOLVO USA AND WAS TOLD THAT ALL GOODWILL REPAIRS WERE AT THE DISCRETION OF THE DEALER AND THE DEALER DID NOT FEEL ANY ASSISTANCE WAS IN ORDER IN THIS CASE. AT THIS TIME I HAVE A VERY GOOD LOOKING AND EXPENSIVE BOAT ANCHOR IN MY DRIVEWAY. AFTER READING MANY SIMILAR COMPLAINTS ON THIS SITE, I HAVE ONCE AGAIN REACHED OUT TO VOLVO USA FOR ASSISTANCE. THERE IS OBVIOUSLY A PROBLEM WITH THE 2012 S60 T5 ENGINE.

NHTSA ODI 10992073

ENGINE FAILED AFTER 84,000 MILES. ENGINE WAS CARED FOR WELL; VEHICLE RECEIVED SERVICE AT RECOMMENDED SERVICE INTERVALS. THE VEHICLE IS OPERATED UNDER NORMAL CONDITIONS THAT RESULT IN AVERAGE WEAR AND TEAR.

NHTSA ODI 10968256

<40K MILES 2ND OWNER BOUGHT CERTIFIED FROM DEALER 2015..2012 VOLVO S60..ENGINE LIGHT KEEPS COMING ON. TOOK TO DEALER IN DAVIE FLORIDA SAYS ENGINE COOLING SYSTEM PROBLEM..FAN OR AS SUCH..IM SEEING X6 RECALLS ON SIMILAR YEAR MAKE AND MODEL.MY VEHICLE VIN NOT SHOWING ON RECALL ROSTER..DEALER WANTS 1200.00 TO REPAIR..WHY WOULD I HAVE TO PAY IF ON RECALL ROSTER .BUT MY VIN NUMBER NOT REGISTERED FOR SAME ISSUE?

NHTSA ODI 10954571

MY VEHICLE WAS PARKED IN A GROCERY STORE LOT. I ENTERED THE VEHICLE TO BACK IT OUT OF ITS PARKING SPOT. IT WAS NEXT TO A FULL SIZED VAN WHICH HAD CARPET CLEANING EQUIPMENT MOUNTED INSIDE. I STARTED THE CAR AND PLACED IT IN REVERSE AS IT BEGAN TO ACCELERATE ON ITS OWN. I TRIED TO SLOW THE VEHICLE WITH THE BRAKE WHICH FAILED. I COLLIDED WITH A BLOCK WALL IN THE REAR OF THE CAR AND ATTEMPTED TO GET IT OUT OF GEAR, WITH THE SOLID JARRING FROM THE REAR THE CAR WENT INTO DRIVE AND CONTINUED TO ACCELERATE TO FULL SPEED, WHILE I WAS ATTEMPTING TO BRAKE. THE VOLVO HIT THE VAN WHICH IT HAD BEEN PARKED NEXT TO IN THE REAR LEFT BUMPER AND DROVE IT APPROXIMATELY 20 FEET THROUGH A PLANTER AND INTO A PARKING SPOT ON THE OTHER SIDE OF THE PLANTER. THIS CAR (VOLVO) IS EQUIPPED WITH A COLLISION WARNING SYSTEM THAT WAS SUPPOSED TO HAVE AUTO BRAKED AND DID NOT. ADDITIONALLY THE AIR BAGS DID NOT DEPLOY. I TOOK THE CAR TO VOLVO AND HAD THEM ATTEMPT TO PULL CODES FROM THE VEHICLES INFORMATION SYSTEM. THEY REPORTED THAT NO CODES WERE PRESENT AND ATTEMPTED TO EXPLAIN AWAY THE INCIDENT AS DRIVER ERROR. THE CAR WAS TOTALED IN THE PROCESS. I AM CERTAIN THAT THERE WAS NO DRIVER ERROR AND THAT WHAT HAPPENED WAS A SUDDEN UNEXPLAINED ACCELERATION. OTHER SOMEWHAT SIMILAR INCIDENTS ARE REPORTED ON THE INTERNET. THE CAR HAS BEEN RETAINED IN MY POSSESSION UNTIL MAR 9TH 2017. IN THE EVENT IT SHOULD BE EVALUATED I HAVE IT AVAILABLE.

NHTSA ODI 10949233

VEHICLE BURNED THROUGH ALL OIL CAUSING ENGINE FAILURE WITH NO WARNING FROM VEHICLE ELECTRONICS (CHECK ENGINE LIGHT CAME ON AS ENGINE BEGAN TO FAIL; WAS ABLE TO TRAVEL TO CLOSEST MECHANIC). VEHICLE DEALERSHIP SAID THIS IS A KNOWN ISSUE THAT HAS HAD PREVIOUS RECALL (FOR OIL PRESSURE WARNING) FOR OTHER OF THE SAME MODEL YEAR BUT NOT THIS PARTICULAR VEHICLE.

NHTSA ODI 10949277

ON APRIL 12, 2016 I TOOK MY VOLVO S-60 LEASED BRAND NEW FROM VOLVO AND THE PURCHASED AT THE END OF THE LEASE AS A CERTIFIED PRE-OWNED CAR IN FOR AN OIL CHANGE AND A CHECK OIL LIGHT. VOLVO HAD A RECALL ON OIL PRESSURE CENSORS (THIS HAD CAUSED OTHER CAR ENGINES TO SEIZE SOMETHING THAT THE NTSB HAS REPORTED ON). THE VOLVO AUTHORIZED DEALER, HERB GORDON, CLAIMED TO HAVE MADE THIS REPAIR. HOWEVER ON JUNE 21, 2016, THE ENGINE SEIZED IN THE MIDDLE OF A BUSY ROAD. THE VOLVO AUTHORIZED DEALER DETERMINED IT NEEDED A NEW ENGINE, AT THE TIME, I ASKED ABOUT SIMPLY APPLYING THE COST TO REPLACE THE ENGINE (ABOUT $12,000) TO GETTING ME INTO A NEW CAR. VOLVO REFUSED AND WENT AHEAD WITH AN ENGINE REPLACEMENT (THEY HAD MY CAR FROM JUNE 21, 2016 TO AUGUST 1, 2016. THE CAR BROKE DOWN AGAIN ON AUGUST 15, 2016 WHILE MY FAMILY AND I WERE ON THE ROAD FOR A VACATION. WHEN WE RETURNED FROM VACATION THE CAR WAS GIVEN BACK TO US BUT THE PROBLEM NOW IS THAT THE CAR'S VALUE HAS SIGNIFICANTLY DIMINISHED BECAUSE OF THE ENGINE REPLACEMENT, THE BLUEBOOK VALUE OF THE CAR IS ON AVERAGE $13,789 BUT THE HIGHEST WE CAN GET FOR IT IS $8,000 BECAUSE OF THE DAMAGE DONE TO IT BY VOLVO. WE HAVE TRIED TO GET VOLVO TO WORK WITH US BY MAKING UP THAT DIFFERENCE AS A TRADE IN ON A CAR THEY HAVE IN STOCK. WE HAVE BEEN MET WITH NOTHING BUT HOSTILITY AND ABUSE. IN FACT EARLIER TODAY WE WERE TOLD BY A CUSTOMER SERVICE REPRESENTATIVE AT VOLVO TO SHUT UP AND THEN HE HUNG UP ON US,

NHTSA ODI 10943927

REAR DRIVER SIDE DOOR FLEW OPEN WHILE DAUGHTER WAS IN THE BACK SEAT. SHE FELL OUT THE CAR. PERSON WAS DRIVING THE VEHICLE AND THE DOOR JUST FLEW OPEN. PLEASE GET TO THE BOTTOM OF THIS IMMEDIATELY.

NHTSA ODI 10929744

TL* THE CONTACT OWNS A 2012 VOLVO S60. WHILE DRIVING 5 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STARTER NEEDED TO BE REPLACED. THE STARTER WAS REPLACED, BUT THE FAILURE RECURRED WHILE STILL AT THE DEALER. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V592000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 49,740.

NHTSA ODI 10924834

TL* THE CONTACT OWNS A 2012 VOLVO S60. WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE; HOWEVER, THE FAILURE RECURRED. THE DEALER DIAGNOSED THAT THE ENGINE CONTROL MODULE SOFTWARE NEEDED TO BE UPDATED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V303000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

NHTSA ODI 10909675

MY 2012 S60 HAS LESS THAN 63K MILES AND IT IS BURNING OIL. I'VE NOT SEEN ANY LEAKS OR EXHAUST SMOKE, SO I ASSUMED ALL WAS WELL. DEALER SHIP ADVISED IT'S NORMAL FOR A VOLVO TO LOSS 1-2 QUARTS OF OIL BETWEEN OIL CHANGES. RECENTLY THE ENGINE FAILED WITH NO WARNING, AND WARRANTY IS OUT. CAN'T BELIEVE A 2012 VEH. WOULD HAVE SUCH ENGINE PROBLEMS AND VOLVO CUSTOMER SERVICE DOES NOT ACKNOWLEDGE THE PROBLEM.

NHTSA ODI 10908835

THE CAR IS USING OIL LIKE CRAZY. GOING THRU 3-4 QUARTS EVERY 2000 MILES. STARTED AT 40541 WHEN SERVICED, THEY NOTED IT WAS A QUART LOW. I AM NOW AT 79000. & THE PROBLEM HAS JUST GOTTEN WORSE. I SPOKE TO DEALER ABOUT THIS & THEY ACTED AS IF THEY HAD NO IDEA WHAT IT COULD BE OR WHY. THEY AGREED TO DO OIL CONSUMPTION TEST (THEY SAID WAS THE NEXT STEP IN PROTOCOL) WHEN I TOLD THEM THAT I HAD READ THAT THIS WAS A MAJOR PROBLEM & I HAD COPY OF THE SERVICE BULLETIN THAT HAD BEEN ISSUED. THEY EVEN TOLD ME MINE WAS NOT INCLUDED, THAT THE T6 MODELS WERE THE ONES WITH THE ISSUE. THAT IS NOT TRUE. TOOK IT BACK AGAIN AFTER 2000 MILES & I WAS BARELY SHOWING ANY OIL ON THE DIPSTICK BUT THEY TOLD ME TO BRING IT IN & NOT TO ADD OIL. I DIDN'T WANT TO DRIVE IT THIS LOW. I GET IT OVER TO THE DEALER WHICH IS 40 MIN AWAY. THEY CHECKED IT & GAVE ME A LOANER BUT MADE ME PAY $150. I ASKED WHAT THIS WAS OF SINCE THEY SAID THE LOANER WOULD BE PROVIDED FOR FREE & THEY SAID IT WAS "TAX". IT HAS BEEN 7 DAYS & I HAVEN'T HEARD ANYTHING. THEY HAVEN'T TOUCHED MY CAR. THEY CALLED AFTER 5 DAYS & SAID THAT THEY WERE WAITING TO HEAR FROM THEIR REP. I DON'T KNOW IF I SHOULD CALL VOLVO NORTH AMERICA MYSELF, OR GIVE THE DEALER MORE TIME. I DON'T HAVE MUCH FAITH IN THEM AT THIS POINT. I FEEL THEY ACT SECRETIVE & WON'T BE HONEST ABOUT PROBLEMS. I HOPE THEY PROVE ME WRONG & RESTORE MY FAITH IN VOLVO. I WAS SO EXCITED TO BUY A VOLVO & WAS LOOKING FORWARD TO HAVING THIS CAR FOR A LONG TIME. I WAS EVEN CONSIDERING GETTING A VOLVO SUV. THIS IS A PROBLEM THAT MANY ARE HAVING. IT SEEMS TO BE THE PISTON & RINGS. SOME HAVE HAD TO HAVE NEW ENGINES BC THE PISTON & RINGS DIDN'T HELP.

NHTSA ODI 10893572

WHEN AT A FULL STOP, WITH FOOT ON THE BRAKE, ON A HILL AND IN GEAR (DRIVE) THE CAR ROLLS BACKWARDS WHEN REMOVING MY FOOT FROM THE BREAK PEDAL. THE TRANSMISSION DOES NOT ENGAGE UNLESS THE GAS PEDAL IS DEPRESSED. THE VOLVO OF SAN DIEGO "TECHNICIAN" CHECKED A 2013 VEHICLE WITH THE SAME TRANSMISSION AND FOUND THE SAME PROBLEM. UNFORTUNATELY, HE USED THIS TEST TO PROVE THAT THIS WAS NORMAL BEHAVIOR FOR THIS VEHICLE, AND THUS, THE TRANSMISSION WAS IN FINE CONDITION. .I DON'T SEE HOW A CAR ROLLING BACKWARDS WHILE IN A FORWARD GEAR COULD EVER BE CONSIDERED NORMAL BEHAVIOR. IT IS AT BEST, A DEFECT, AT WORST, A SAFETY ISSUE. VOLVO OF SAN DIEGO REFUSES TO FIX THE PROBLEM. IT SHOULD BE NOTED THAT THIS CAR HAS ONLY 46,000 MILES, AND IS STILL UNDER FULL WARRANTY. THERE ARE OTHER ISSUES WITH THIS TRANSMISSION, BUT THEY ARE DIFFICULT TO DESCRIBE IN THIS FORMAT, BUT THE PROBLEMS WERE VERIFIED BY THE VOLVO OF SAN DIEGO PERSON WHO WENT ON THE TEST DRIVE WITH ME, ON JUNE 15TH, 2016. THIS IS AN ONGOING ISSUE WHICH I HAVE BEEN DESCRIBING TO VOLVO OF SAN DIEGO SINCE DECEMBER 2015. TO DATE, THEY HAVE REFUSED TO EVEN ACKNOWLEDGE THAT THERE IS A PROBLEM.

NHTSA ODI 10885219

WHEN THE CAR IS OUTDOORS, IN TEMPERATURES APPROACHING 100 F, THE REAR (BACKUP) CAMERA FLICKERS OR FAILS ALTOGETHER.

NHTSA ODI 10881411

MY 2012 VOLVO S60 IS USING ONE QUART OF OIL FOR EVERY 900-1000 MILES. THIS IS TOO MUCH. I WAS TOLD THAT IT WAS THE PISTON RINGS THAT ARE BAD.

NHTSA ODI 10865156

2012 VOLVO S60. VEHICLE IS AT 64,114 MILES. ABOUT A WEEK AGO, MY CHECK ENGINE LIGHT CAME ON AND I NOTICED A HIGH PITCHED WHISTLE COMING FROM THE ENGINE WHEN DRIVING. I TOOK THE CAR TO THE MECHANIC AND HE STATED THAT A RUBBER DIAPHRAGM IN THE OIL TRAP HAD RUPTURED CAUSING THE VEHICLE TO GO ON FULL VACUUM AND IN-TAKE TOO MUCH AIR AND OIL. IN FACT, IT WAS TAKING IN SO MUCH OIL THAT THE OIL WAS NEARLY DEPLETED. HE STATED THAT HE HAS SEEN SIMILAR ISSUES WITH VOLVOS IN THE PAST. APPROXIMATELY 6 MONTHS AGO, I TOOK THE VEHICLE INTO THE DEALER FOR AN OIL SERVICE. AT THAT TIME, HE STATED THAT THE ENGINE'S OIL WAS ALMOST DEPLETED. I'M NOW BEGINNING TO SUSPECT THAT THE BROKEN DIAPHRAGM IS RELATED TO THAT ISSUE AS WELL. I'VE SEEN OTHER COMPLAINTS REGARDING DEPLETED OIL (AND THE LACK OF A DRIVER NOTIFICATION DUE TO A MALFUNCTIONING OIL SENSOR). THIS COULD POTENTIALLY BE THE ROOT CAUSE OF THE OIL DEPLETION IN THESE OTHER CASES AS WELL.

NHTSA ODI 10863613

HAVING ELECTRICAL PROBLEMS AND SOFTWARE PROBLEMS. IN THE MIDDLE OF DRIVING ALL ELECTRONICS WILL GO OFF. ALSO, CAR WONT ALWAYS SHUT DOWN OR START PROPERLY. LOOKED OVER MANY FORUMS AND FOUND THE EXACT COMPLAINTS. THERE HAVE BEEN OTHER RECALLS FOR ELECTRICAL AND SOFTWARE FOR THE S60, BUT APPARENTLY THEY DONT APPLY TO MY VIN, EVEN THOUGH I AM HAVING THE EXACT SAME ISSUE.

NHTSA ODI 10850541

1) POWER STEERING FLUID LEAKING CONSTANTLY SINCE PURCHASING CAR AT 52K MILES; DIAGNOSED AS RACK AND PINION FAILURE 2) ENGINE LIGHT CAME ON AND ENGINE MADE WHISTLING NOISE AT 60K MILES WHILE DRIVING; DIAGNOSED AS PCV FAILURE

NHTSA ODI 10817350

I WAS DRIVING DOWN THE INTERSTATE, SUDDENLY I HEARD A LOUD BOOM. I COULD HEAR SOMETHING SLIDING DOWN MY ROOF AND OFF THE BACK OF THE CAR. I DIDN'T KNOW WHAT WAS GOING ON, THEN I HEARD A WIND NOISE ABOVE. I REALIZED THAT MY SUNROOF WAS BROKEN AND GLASS WAS CASCADING DOWN AND FLYING OFF OF MY CAR. IT JUST SPONTANEOUSLY EXPLODED. I PULLED OVER TO LOOK AT THE SUNROOF AND TO SEE IF THERE WAS A ROCK THAT HIT IT OR SOMETHING ELSE. THERE WAS NOTHING THERE EXCEPT FOR A SHATTERED SUNROOF WITH A HUGE HOLE. THE GLASS WAS POINTING UPWARD AS IF IT HAD EXPLODED FROM THE INSIDE.

NHTSA ODI 10809037