What 266 owners told NHTSA about the 2012 Toyota RAV4 Hv

Over the last 4 years I have had 2 prior occurrence where I've lost power turning or stopping, causing the engine to stall. Both times the vehicle was taken to our mechanic and he replaced the connectors to the battery. On January 18th, 2024, while turning off of a rural highway onto the street we live on I again lost power and the engine stalled and smelled a faint electrical smell. I called my mechanic and he said he could get it in on January 22nd. We checked all connections to the battery, made sure the battery terminals were clean. The morning of January 22nd, while on my way to the mechanic the vehicle in front of me stopped quickly. I started to stop a little quicker than normal, causing the front of the vehicle to tip down. I immediately lost power and the engine died, causing me to rear end the vehicle in front of me. The collisions was at slow speed, but it also caused disproportionate damage to my vehicle. Over the weekend of January 20th, we became aware if a recall for 2013 to 2018 Rav4s regarding the tops of newer batteries being smaller and causing problems with the battery shifting causing loss of power and potential fires. We strongly believe this recall needs to be extended to the 2012s.

NHTSA ODI 11587409

My rav4 caught fire by its self not running in the battery compartment and burned completely to the metal

NHTSA ODI 11438012

DRIVER SIDE REAR QUARTER PANEL STARTED ON FIRE. THIS OCCURRED AFTER AN APPROXIMATELY 4 MILE DRIVE. I BELIEVE THE FIRE STARTED ON THE DRIVE. I PARKED THE VEHICLE IN A PARKING LOT WITH ONLY ONE OTHER VEHICLE. WHEN I WAS WALKING INTO THE STORE I SMELLED BURNING PLASTIC BUT DID NOT RELATE IT TO MY CAR BURNING. I WAS IN THE STORE ABOUT 5 MINUTES. WHEN I WALKED OUT I SAW THE FIRE. THERE WAS NO OUTSIDE INFLUENCE TO THE FIRE AND NOTHING INSIDE THE VEHICLE VEHICLE. THE ONLY THING IN THAT AREA OF THE VEHICLE IS WIRING.

NHTSA ODI 10958384

ON OCTOBER 17 SHORTLY BEFORE 2 PM PST IN CLEAR WEATHER, I WAS PULLING INTO A PARKING SPOT ON PRIVATE PROPERTY AT ABOUT 2 TO 3 MPH. I TURNED THE VEHICLE INTO THE SPOT AND APPLIED THE BRAKES BUT THE CAR SURGED OVER THE CURB, HIT A TREE, WENT OVER AN EMBANKMENT AND CRASHED ONTO A PARKED CAR. (THE AIRBAG DID NOT DEPLOY, BUT THERE WERE NO INJURIES.) THE IGNITION WOULD NOT TURN OFF AFTER REPEATED ATTEMPTS. FINALLY I DEPRESSED THE IGNITION BUTTON FOR ABOUT 10 SECONDS AND IT TURNED OFF. JUST 5 DAYS EARLIER, THE CAR HAD UNDERGONE A SAFETY RECALL REPAIR TO THE ELECTRONIC CIRCUITRY. TOYOTA HAD ISSUED A SAFETY RECALL DUE TO A SOFTWARE DEFECT WHICH AFFECTED "COMPONENTS IN THE ELECTRIC VEHICLE TRACTION MOTOR ASSEMBLY." WE INFORMED TOYOTA THIS APPEARED TO BE AN UNINTENDED ACCELERATION INCIDENT. THEY PROMISED TO ASSIGN AN ENGINEER TO THOROUGHLY INSPECT THE VEHICLE AND DOWNLOAD INFORMATION FROM THE EVENT DATA RECORDER (EDR). THE ENGINEER INSPECTED THE CAR AND PREPARED A 22 PAGE REPORT. HOWEVER HE WAS UNABLE TO DOWNLOAD THE EDR INFORMATION DUE TO A DATA COMMUNICATION ERROR. TOYOTA CLAIMED IT WAS DUE TO A LOW BATTERY. THE ENGINEER CONFIRMED TO ME THAT IT WAS A DATA COMMUNICATION ERROR AND THAT THE VEHICLE WAS HALF CHARGED WHEN HE DROVE IT. TOYOTA REFUSED TO SHARE THE ENGINEER'S REPORT. THEY STATED IN SIX SHORT SENTENCES THAT THE ACCELERATION AND BRAKE PEDALS BOTH WORKED. THEY DID NOT ADDRESS THE RECALL, THE INCIDENT WITH THE IGNITION SWITCH, OR THE DATA COMMUNICATION ERROR, ALL OF WHICH SIGNAL POSSIBLE PROBLEMS WITH THE ELECTRIC CIRCUITRY/SOFTWARE. WHEN WE WROTE THEM A DETAILED LETTER WITH ALL THE ATTACHMENTS TO DOCUMENT THE RECALL, THEY SIMPLY RESPONDED THAT THE ACCELERATION PEDAL AND BRAKE PEDAL WORKED.

NHTSA ODI 10811744

ON THURSDAY 18 DECEMBER, MY WIFE AND I LEFT SPRINGFIELD, MISSOURI TO DALLAS, TEXAS TO VISIT OUR FAMILY FOR THE CHRISTMAS HOLIDAY. WE WERE DRIVING OUR RECENTLY PURCHASED 2012 RAV4 WITH APPROXIMATELY 33,000 MILES WHICH WE PURCHASED IN LATE SEPTEMBER 2014. WE STOPPED SEVERAL TIMES DURING OUR TRIP TO REFUEL AND ALLOW MY WIFE, WHO IS 6 MONTH PREGNANT, A CHANCE TO STRETCH HER LEGS. FOR MUCH OF THE TRIP, I USED CRUISE CONTROL WHEN POSSIBLE AT VARYING SPEEDS FROM 65 MPH (IN MISSOURI) TO 75 MPH (IN PARTS OF OKLAHOMA). AT APPROXIMATELY 4:30 PM, WHILE DRIVING THROUGH TUSHKA, OKLAHOMA WE APPROACHED A STOPLIGHT WHERE THE SPEED LIMIT DROPPED FROM 65 TO 45 MPH. THE LIGHT WAS RED, A SEMI WAS STOPPED AT THE LIGHT, AND I ATTEMPTED TO APPLY THE CAR'S BRAKES. AS I DID SO, THE CAR FELT AS IF IT WAS FIGHTING MY ATTEMPTS TO STOP IT. I HAD TO KEEP BOTH HANDS ON THE WHEEL, AND I DO NOT KNOW IF THE CRUISE CONTROL DISENGAGED. AS I APPROACHED THE SEMI, I PRESSED HARDER ON THE BRAKES IN ORDER TO STOP MY VEHICLE. FINALLY WITH LESS THAN A CAR LENGTH, MY CAR CAME TO A FULL STOP. WITH MY FOOT STILL PRESSED FIRMLY ON THE BRAKES, BOTH MY WIFE AND I HEARD THE CAR BEGIN TO MAKE A HIGH-PITCHED NOISE. I IMMEDIATELY PUT THE CAR INTO 'PARK,' AT WHICH POINT THE ENGINE BEGAN TO REV AND I SAW THAT THE RPM GAUGE ON THE CAR ROSE TO 7-8,000 RPM. AT THIS POINT, I TURNED THE CAR OFF AT THE IGNITION SWITCH. MY INTENT WAS TO RE-START THE CAR AND SAFELY PULL OVER AFTER WE PROCEEDED THROUGH THE INTERSECTION. HOWEVER, AT THIS POINT THE LIGHT TURNED GREEN AND, AS I RESTARTED THE CAR, WE WERE HIT FROM BEHIND BY ANOTHER VEHICLE. ON FRIDAY, THE 19TH, I TOOK MY VEHICLE TO TOYOTA OF LEWISVILLE (TX) WHERE THEY PROVED UNABLE TO DIAGNOSE THE PROBLEM. I WAS CONTACTED BY A REPRESENTATIVE ON 12/29/2014 WHO INFORMED ME THAT NOTHING WOULD BE DONE UNLESS THE EVENT "REPLICATED" OR SOMEONE HAD BEEN INJURED. *JS

NHTSA ODI 10669207

THE CAR WAS PARKED IN THE DRIVEWAY WITH THE DOORS LOCKED AND THE WINDOWS ROLLED UP. SOMETIME BETWEEN 10PM AND 5:30AM THERE WAS A FIRE THAT CREATED ENOUGH HEAT TO MELT THE COATING ON THE FRONT WINDSHIELD AND BLOW OUT THE FRONT WINDSHIELD, MELT THE CENTER OF THE DASH AND THE AREA BETWEEN THE VISORS WHERE THE CONTROLS FOR THE SUNROOF AND INTERIOR LIGHTS WERE. IT ALSO CAUSED A SHORT IN THE WIRING THAT RESULTED IN TURNING ON THE HEADLIGHTS EVEN THOUGH THE SWITCH WAS OFF. WE HAD TO DISCONNECT THE CAR BATTERY TO TURN OFF THE LIGHTS. TOYOTA DID AN INVESTIGATION AND DECIDED THAT THE AURORA BE ANY BABY ON THE DASH SPONTANEOUSLY COMBUSTED IN THE MIDDLE OF THE NIGHT CAUSING THE FIRE AND DAMAGE. SINCE THERE HAVE BEEN REPORTS OF OTHER TOYOTAS HAVING PROBLEMS WITH ELECTRICAL I THOUGHT YOU WOULD WANT TO KNOW ABOUT THIS CASE. *JS

NHTSA ODI 10462327