What 684 owners told NHTSA about the 2012 Toyota Prius C

All the lights on my dash lit up. I took it immediately to Toyota of Dallas . I tried numerous times connecting with Dimatrius service manager. No call back. An inspection was done on the vehicle. He stated it would be a $5000 job and I was out of warranty. Their is too many people having this issue if you search many 2012-2014 people are having this issue in a addition to to a google search search for a letter at Capistrano Toyota.

NHTSA ODI 11502018

The contact owns a 2012 Toyota Prius V. The contact stated while driving 30 MPH, the vehicle stalled inadvertently. Several unknown warning lights were illuminated. Additionally, the brake pedal was depressed but failed to respond. The contact veered to the side of the road and intentionally struck the curb to stop the vehicle. The vehicle failed to restart. The contact stated that the vehicle later restarted and was driven to the dealer. The dealer diagnosed that the ABS actuator had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because an unknown Toyota Courtesy Program issued for the failure had expired. The failure mileage was approximately 160,000.

NHTSA ODI 11501111

The contact owns a 2012 Toyota Prius. The contact stated while driving approximately 40 MPH, the brakes became inoperable. The ABS and traction control warning lights were illuminated. The vehicle was taken to an unknown local dealer where it was diagnosed that the brake booster and brake pump assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 335,000.

NHTSA ODI 11500818

Toyota Program ZJB, internal malfunctions of the brake booster assemblies. A known failure of the brake booster than Toyota did extend the warranty on for 10 years BUT would not honor the warranty unless specific diagnostic codes appeared on the vehicle. My issue is that all of the symptoms of the failure occurred on my vehicle (pump constantly running, varying hydraulic pressure resulting in pulsing brake stops, soft brake pedal) but the warranty would not be honored because the diagnostic did not manifest itself. Had technicians tell me that it definitely was this booster failure, but Toyota would not pay for it unless the diagnostic came up. I am now left with a vehicle that has a failed brake system and no monetary support from Toyota. Quoted $2500 to $3000 to repair. Not safe to drive in my opinion with a known failure that I am having trouble getting funding to repair. Contacted Toyota customer support and they reiterated that they would not pay for the repair without the diagnostic occurring and now their extended warranty expired August 31, 2021. Inspection available upon request Safety issue as braking is inconsistent and not predictable Problem was identified by Toyota dealer service department No diagnostic alarms - which is the only symptom not present

NHTSA ODI 11500901

I am having issues with my Toyota I was never contacted NHTSA CAMPAIGN ID: 18V684000. My car has failed numerous times.

NHTSA ODI 11500728

Headlamp Lens Issue Vehicle Manufacturers Must Correct ISSUE 1. The increase in pedestrian-vehicular accidents and fatalities is, at times, related to the driver not seeing the person in time to stop. Not seeing a person in time may be related to poor street lighting or a decrease in front visibility caused by fogged headlamp lenses. Current nighttime traffic has a variety of vehicles operating with varying front light visibility. 2. For certain vehicles, the lens alone is replaceable. With other vehicle models, the entire front lamp must be replaced. The exorbitant cost of replacing the front lamp is causing some people to opt to drive with densely fogged front headlight lenses risking pedestrian safety. 3. Some car dealership offer a "defogging" cleaning service for greater visibility but does not guarantee to restore the car's front illumination to minimum required safety standards. Recommendation Require vehicle manufacturers to make front headlights with detachable lenses, or make the lenses fog proof. A replaceable lens is cost effective for all income individuals. Making lens replacement affordable may decrease the number of pedestrian-vehicular accidents and fatalities. Discussion The headlight lens of my car became increasingly fogged, overtime, decreasing night visibility ahead. The Toyota dealership offered a $300 cleaning service for both lenses or replacing the headlamp at about $300 each; $600. I opted for the cleaning. When completed, the headlight lens of my vehicle looking much less fogged. When I asked, the dealership told me that their cleaning service does not guarantee compliance with minimum front safety illumination for night driving. I was told that my car does not come with removable lenses. To ensure minimum safety front night visibility, I purchase new headlamps total costing about $300 each; I spent $900 because the $300 cleaning service was completed and not deductible. I contacted Toyota management and went up the chain of command

NHTSA ODI 11499725

The Brake Booster or Actuator is failing, without any indication or warning lights on the dash alarming us to the problem. The car has been making weird sounds, but after being inspected, this, according to the Authorized Toyota Dealer, on December 22, 2022, is a life-threatening and very dangerous malfunction to myself and others around me when driving. This is the first hybrid car we have owned, and we thought the noises we had been hearing for a couple years was normal, because there were no warning lights coming on to tell us otherwise. The dealer did not want us to drive the car any further due to the danger of the problem. We asked the dealer to repair the problem without charge, but that request was denied by the Toyota Brand Engagement Center (Case 221222000587). The dealer is currently repairing the malfunction at a cost of approximately $2650 plus tax). We are highly disappointed with Toyota not repairing this known problem under a dealer recall.

NHTSA ODI 11499480

The contact owns a 2012 Toyota Prius. The contact stated that while driving at an undisclosed speed, the brake warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the brake master cylinder and brake booster needed to be replaced; however, the dealer informed the contact that the repair was not covered under warranty. The vehicle was not repaired. The contact stated that the failure recurred while driving and the vehicle hesitated while the brake pedal was depressed. The contact slammed on the brake pedal and the vehicle came to a complete stop. The vehicle was towed to the residence. The manufacturer was not made aware of the failure. The failure mileage was 185,519.

NHTSA ODI 11499030

The brakes on my 2012 Toyota Prius failed suddenly with little warning after starting the car, and when I began driving off in a busy Walmart parking. I was startled when I felt that the brakes did not seem to work, nearly causing me to collide with the car in front of me. I had to quickly depress the brake pedal to bring the car to a stop. The normal braking power was greatly reduced when I depressed the brake pedal, and I had to use more force to bring the vehicle to a stop. Only when I looked down did I see that some of the dashboard lights relating to the brake system stayed lit and not turn off like they normally do. These lights appear to be brake warning, ABS warning, and anti-skidding lights. The brake problem has been inspected and confirmed by both an independent service center as well as the Toyota dealer. The failed brake component was diagnosed as an abnormal leak in the accumulator, and the brake booster with master cylinder assembly requiring replacement, with the code #c1391. After having done some research, it appears that this exact brake problem seems to be afflicting many such generation Toyota Prius vehicles, and the manufacturer Toyota was aware of this problem existing in such vehicles.

NHTSA ODI 11498182

The contact owns a 2012 Toyota Prius V. The contact stated while driving approximately 40 MPH, the brake pedal was depressed with excessive force; however, the brakes failed to respond as needed. The contact stated that five unknown warning lights were illuminated. The contact then stated that the failure was reoccurring while driving at various speeds. The vehicle was taken to the dealer where an outside technician diagnosed the failure as five unknown fault codes related to the brakes. The contact stated that the brake booster and actuator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 211,000.

NHTSA ODI 11498122

The car has been diagnosed by a Toyota dealership as having an internal leak in the Brake Booster and Accumulator, both are part of the brake system. Repair estimate of $3800 00 dlls. Currently i have 3 check lights on, Brake, ABS and Traction control. All controlled by the same module

NHTSA ODI 11497459

Purchased 2012 Prius used. Replaced low beams and high beam headlights shortly after. Passenger side low beam is no longer working (bulb was replaced 3 months ago). Upon googling causes saw 2010-2011 Prius had a recall for recurrent headlight issues, the wiring harness was replaced in them. It seem the 2012 is having the same issue in the 8 pages of complaints on exterior lightning that I saw. Toyota should extend the fix to include 2012 Prius.

NHTSA ODI 11496959

My prius got ABS, Brake, Traction light on when I was on traffic in the highway. Car lost brake power. Regenerative brake does not. It takes longer to stop the car. TOYOTA NEEDS TO FIX THIS. THE ABS MODULE IS GONNA FAIL AT SOME POINT. Dealership asks $5000 to fix. C1391

NHTSA ODI 11495844

At 106K miles and after 10 years and 8 months in service (new vehicle bought in March 2012) Brake booster internal leak, code c1391. Brake light, ABS light and VSC light stay on. Can not drive it as the brake booster internal leak is making the brakes spongy and slow in response. Talked to Toyota and they said it is out of warranty and the deal is estimating $2000 plus for the repair. Miles on my cars 106K are way less than 150,000 allowed by Program Service bulletin ZJB (attached) but Toyota is denying repair coverage as the vehicle life is eight months more than 10 year limit since first use. Did not drive it much within the last two years because of working from home due to covid 19. Had it been driven more frequently the brake system failure would have happened way earlier as the internal leak (possible fatigue failure causing leak) should be more related to driven miles and brake system cycling of pressurizing and depressurizing than just being parked on the drive way. Would request if NHTSA could extend the duration of ZJB bulletin considering the fact that many drivers did not drive that much in the last two years due to working from home and this internal leakage failure can be related to fatigue loading of the hydraulic components and the number of fatigue cycle are directly proportional to the driven miles and not the life of the vehicle. Thanks

NHTSA ODI 11495063

The brake system (accumulator/booster) has failed and reduced stopping ability. Error code is C1391

NHTSA ODI 11493646

The contact owns a 2012 Toyota Prius. The contact stated that while driving approximately 50 MPH, the ABS, brakes, and traction control warning lights illuminated. The brakes became inoperable, but the driver was able to regain control of the vehicle and pulled over. The vehicle was taken to the local dealer where it was diagnosed there was a hydro pump motor fault and hydro motor pump relay fault with codes C1252 and C1253 and the hydro boost brake pump kit and brake assembly needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred him to the NHTSA hotline. The approximate failure mileage was 97,000.

NHTSA ODI 11491960

I have a 2012 Toyota Prius that the Toyota dealership has confirmed that I have a failed ABS actuator and is displaying the correct repair codes for the service bulletin but they refusing to cover any of the costs to replace the ABS actuator and boost pump. Since the failure of the ABS actuator I have had 2 close calls where I needed to stop fast and my tires locked up, I lost control of the car and spun out but luckily I did not hit anything. The brake, ABS, and 2 other warning lights have come on and off intermittently on the dashboard of my 2012 Toyota Prius. I summited a good faith request to the repair my Toyota Prius ABS actuator at Toyota of Anaheim on 10/28/2022 and due to it being 20 days past the 10 year limit and slightly over the 150,000 mile limit at 158,000 they say that I'm 100% responsible for the repair costs of $3,231.78. This proven design flaw is not my fault, it did not occur under normal wear and tear and the brake ABS actuator and boost pump should last much longer than it did. Now I'm faced with paying a huge bill for the repair or pick up my Prius from the dealership and drive it home with a defective ABS actuator. This is another example that Toyota is placing profit ahead of safety.

NHTSA ODI 11491970

During a hard braking, felt brake pedal softer and less responsive braking. Now ABS Icon, Brake Icon, and Traction Icon is on. Confirmed Code P1391 in ABS system.

NHTSA ODI 11491723

I was driving on the expressway and experienced a sudden loss of power. The internal combustion engine suddenly stopped and did not deliver any power to the wheels. I immediately received a message on the system that said 'Check Hybrid System Stop Vehicle in a Safe Place'. The electric motor still continued to provide some power with the available battery charge. I was able to make it to the shoulder of the road but it was challenging to get to the shoulder with no power or warning and high speed traffic. My wife and I were in the vehicle. The vehicle had no engine or error codes until the failure on the expressway. The vehicle has the code P0A1A and P0A94. This is consistent with the error codes in the NHTSA 19V491000 recall and Toyota Safety Recalls E0E and F0R.

NHTSA ODI 11490716

The contact owns a 2012 Toyota Prius V. The contact stated while driving at an undisclosed speed and making a stop, there was a rattling sound coming from the brakes while depressing the brake pedal. The vehicle was taken to the dealer for diagnostic testing. The contact was informed that the brake booster needed to be replaced. The vehicle was not repaired because there were no fault codes retrieved. The manufacturer was contacted and stated that the vehicle was out of warranty. The failure mileage was 100,000.

NHTSA ODI 11489860

My breakes failed when driving. I almost got in accident. Code C1391. Brake Actuaror Failure. car has 200,000 miles. Toyota is denying to repair the car. It is well known problem with that but still not fixing.

NHTSA ODI 11489347

The brake booster pump has started to run every 30 seconds while the car is operating. When pressing on the brakes, there is an unusual sound and has begun to feel different. There are no warning lights yet, but after consulting with the local Toyota dealership they informed me of the ZJB Customer Assistance Program which addresses this issue. Unfortunately the offer to repair has expired and the dealership has declined coverage. I contacted Corporate Toyota and they are declining to cover the repair. I don't have the $3500 to replace this brake booster pump at this time. This is a safety concern and I don't understand how this is not a RECALL due to the potential safety concern. PLEASE HOLD TOYOTA ACCOUNTABLE TO THIS SAFETY PROBLEM.

NHTSA ODI 11489170

2012 Toyota Prius V, 125k. Sudden loss of braking power accompanied with BRAKE, BRAKE SYSTEM, SLIP INDICATOR, and PCS warning lights. Scan shows codes B2060 (ABS malfunction) and C1931 (Abnormal leak of brake ACC pressure). Brake fluid significantly lower. No signs of external leak. Can hear the brake booster pump running almost constantly. All signs indicate this is the issue identified in Customer Support Program 20TE07. This is a significant safety issue that may lead to loss of braking and serious injury / death. It should be a recall.

NHTSA ODI 11488896

Small internal brake fluid leak inside the break booster assembly with master cilinder. Code c1391

NHTSA ODI 11488186

While on the freeway, I was braking due to traffic and the car started shaking and the ABS light, "BRAKE" light and traction light all came on and remained on. The brake system did not operate properly, which nearly caused a collision.

NHTSA ODI 11486237