What 290 owners told NHTSA about the 2012 Subaru Outback

On October 27, 2021 while driving the car a number of vehicle light began flashing. We checked every thing we could and proceeded to drive it home, approximately 47 miles. First thing on 10/28/2021 it was examined by a Subaru dealer service department and they found no issues other than they replaced the serpentine belt and a few light bulbs. The car was driven again on 1o/29/21 and 11/1/21 with no incident. On the way home from work on 11/3/21 the same vehicle lights began flashing. We checked everything we could and found nothing wrong. We began travelling home and about 25 miles into the trip we heard what sounded like metal clanking. Shortly thereafter we began to lose power and the engine started smoking. The engine compartment was on fire by the time we were on the side of the road so we exited the car. In around 10-15 seconds the car was fully engulfed by flames and burned to the metal.

NHTSA ODI 11439746

WAS DRIVING ON HIGHWAY WHEN LIGHTS ON DASH STARTED FLASHING ON & OFF, CRUISE, BRAKE, CHECK ENGINE, THE TEMPERATURE LIGHT WAS FLASHING BLUE & RED. I PULLED OVER TO MAKE SURE EMERGENCY BRAKE WAS OFF. TURNED CAR OFF AND ON AND CHECKED GAS CAP WAS TIGHT AS I HAD GOOGLED WHY IT MIGHT BE FLASHING. I CONTINUED FOR ANOTHER MILE AND ENGINE STARTED MAKING CLICKING NOISE WHEN I PRESSED GAS. I PULLED OVER AND STOPPED, CAR LIGHTS WERE STILL FLASHING AND IT BEGAN TO SMOKE UNDER HOOD. SMOKE STARTED COMING THROUGH AIR CONDITIONING VENTS AND WE GOT OUT IMMEDIATELY AND ENGINE CAUGHT FIRE.

NHTSA ODI 11303050

COOLANT LIGHT THEN CHECK ENGINE LIGHT ON. AFTER DRIVING 2 1/2 HOURS COOLANT APPEARED TO BE LEAKING SO FILLED COOLANT TO TOP WITH WATER.. 12 MINUTES LATER, WHILE DRIVING, LIGHTS BACK ON/ENGINE REV/ENGINE DIES/ SMOKE. LIFTED HOOD/MANY FLAMES FROM CENTER /SLAMMED HOOD SHUT AND RAN FAR AWAY. SEVERAL SMALL EXPLOSIONS AS CAR BURNED. VOLUNTARY FIRE DEPT. FINALLY ARRIVED BUT CAR ALMOST TOTALLY GONE. ONLY BACK TIRES LEFT USABLE. *JS

NHTSA ODI 10608750