What 282 owners told NHTSA about the 2012 Ram 2500 Mega Cab

FRAME BROKE IN 3 SPOTS, ALONG WITH A FRAME AND WHEEL BEARINGS, GEAR CONTROL BOX, ALIGNMENT, THE TRUCK BODY MOVES WHEN TURNING NOT THE WHEELS. THE TIRE STABILIZER HASN'T TURNED OFF IN OVER A YEAR AFTER POURING THOUSANDS OF DOLLARS IN REPAIRS.. TRUCK IS UNDRINKABLE AND NOT EVEN 10 YEARS OLD. *TR

NHTSA ODI 11329345

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED TO THE SIDE OF THE ROAD. THE VEHICLE WAS RESTARTED. ADDITIONALLY, THE CONTACT STATED THAT WHILE DRIVING IF THE KEY FOB WAS TOUCHED, THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TEST. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

NHTSA ODI 11320941

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 3 MPH, THE VEHICLE STEERING WHEEL TURNED ON ITS OWN AND THE ABILITY TO STEER CEASED. NO WARNING INDICATORS WERE ILLUMINATED. THE CONTACT LOOKED UNDER THE VEHICLE AND NOTICED THE STEERING ROD WAS DETACHED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, THEY DETERMINED THAT THE STEERING ROD HAD TO BE REPLACED. THE VEHICLE WAS TOWED TO COLORADO SPRINGS DODGE LOCATED AT (7455 AUSTIN BLUFFS PKWY, COLORADO SPRINGS, CO 80923), WHERE IT WAS CONFIRMED THAT THE STEERING ROD DETACHED AND NEEDED TO BE REPLACED. THE REPAIR WAS STILL PENDING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

NHTSA ODI 11317703

WHILE PARKING MY RAM 2500, MY CENTER DRAG LINK JOINT AT THE CRIMPED PORTION WHERE THE TIE ROD LINKS IN CAM APART. THIS COMPLETELY DISABLED THE STEERING OF THE DRIVERS SIDE WHEEL. THIS IN NOT A WEAR JOINT OR A, NORMALLY REPLACED JOINT ON THE STEERING COMPONENTS. THIS LINK ON THE RIGHT SIDE (FACING THE VEHICLE) GOES TO A TIE ROD END, AND ON THE LEFT SIDE IT GOES TO AN ADJUSTABLE LINK, FOR ADJUSTING WHEEL ALIGNMENT, AND THEN ONTO THE LEFT (AGAIN FROM THE FRONT OF THE VEHICLE) TIE ROD. THIS HAPPENED IN A PARKING LOT, WHEN I WAS POSITIONING THE VEHICLE IN A PARKING SPOT AND TURNED MY WHEEL TO CORRECT MY LOCATION. THE JOINT BEING DESCRIBED SEPARATED. DISABLING ANY STEERING ABILITY.

NHTSA ODI 11317731

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED WHILE DRIVING AT AN UNKNOWN SPEED THE TRACK BAR BUSHING FELL APART AND CAUSED EXCESSIVE SHAKING WITHOUT WARNING. THE CONTACT HAD TO PULL THE VEHICLE TO THE SIDE OF THE ROAD FOR SEVERAL MINUTES. THE CONTACT DROVE THE VEHICLE TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TEST OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 135,000.

NHTSA ODI 11310198

ON NOV 23 2019, WHILE I WAS DRIVING MY TRUCK IT SUDDENLY DIED. I PULLED OVER AND STARTED IT AGAIN. THIS HAPPENED 2 MORE TIMES THAT DAY ONCE ON THE HIGHWAY. SINCE THEN IT HAS WORKED INTERMITTENTLY WITH THE ISSUE HAPPENING WHILE IN MOTION AND ALSO WHILE STATIONARY. I DID SOME RESEARCH AND FOUND OUT THAT I'M NOT ALONE WITH THIS ISSUE. I HAVE READ SEVERAL FORUMS WITH A LOT OF OWNERS COMPLAINING ABOUT THE IGNITION MODULE, WIN. CLEARLY THIS ISN'T A COUPLE ISOLATED INCIDENTS AND NEEDS TO BE ADDRESSED BY RAM. I WOULD FIND IT HARD TO BELIEVE THAT A TOTAL LOSS OF POWER DUE TO A FAULTY WIN THAT HAS BEEN RECOGNIZED AS AN ISSUE AND MODIFIED IN NEWER VEHICLES WOULDN'T BE A SAFETY RECALL. FROM WHAT I GATHER THIS PARTICULAR WIN IS ABLE TO GET DIRTY ON THE CIRCUIT BOARD THUS CAUSING A FAILURE IN THE CONNECTION AND RAM KNEW ABOUT THE PROBLEM.

NHTSA ODI 11288065

MY IGNITION SWITCH FAILED YESTERDAY (7/10/2019) WHILE DRIVING,I WAS DOING 50 MPH IN A MODERATE CURVE WHEN IT FAILED LEAVING ME WITH NO POWER STEERING OR ANTI-LOCK BRAKES I SLAMMED THE BRAKES ON WHICH PUT ME INTO A 180 DEGREE SPIN WINDING UP IN THE OTHER LANE FACING WHERE I CAME FROM WHEN THE SWITCH FAILED IT WAS LIKE SOMEONE SHUT THE TRUCK OFF!!!!

NHTSA ODI 11230954

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING 70 MPH, THE CONTACT SMELLED SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT WAS ABLE TO DRIVE HOME AND PARK THE VEHICLE. THE CONTACT OPENED THE HOOD AND NOTICED SMOKE COMING FROM THE ALTERNATOR. THE CONTACT ALSO NOTICED THAT THE BATTERY CABLES WERE OVERHEATED. THE CONTACT DISCONNECTED THE BATTERY CABLE WIRES, WHICH CAUSED THE SMOKE TO STOP. THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 16V739000 (ELECTRICAL SYSTEM). THE CONTACT CALLED ALLEN SAMUELS CHRYSLER DODGE JEEP RAM WACO (LOCATED AT 201 W LOOP 340, WACO, TX 76712, (254) 848-6200) AND NOTIFIED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 200,000.

NHTSA ODI 11230566

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED THAT THE REAR AXLES SEIZED AND THE REAR TIRES SLID WHILE OPERATING THE VEHICLE. THE VEHICLE SLID OFF THE ROAD DUE TO THE FAILURE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE CONTACT WAS A MECHANIC AND DIAGNOSED THAT THE VEHICLE NEEDED A FILL PLUG AND NEW GEAR OIL. THE VEHICLE WAS NOT REPAIRED BECAUSE THE CONTACT DID NOT HAVE THE PROPER FILL COVER FOR THE FILL PLUG. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS UNKNOWN.

NHTSA ODI 11193335

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND WAS ABLE TO DRIVE NORMALLY. THE FAILURE RECURRED NUMEROUS TIMES. THE CONTACT CALLED UNIVERSITY CHRYSLER DODGE JEEP RAM OF FLORENCE (LOCATED AT 2354 FLORENCE BLVD, FLORENCE, AL 35630, (256) 766-7324) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

NHTSA ODI 11187493

FRONT END HAS POPPING NOISE IN IT. DEALER TOLD ME I WOULD HAVE TO HAVE STEERING LINKAGE REPLACE SOON. I SEE THERE WAS A RECALL ON MY YEAR/MODEL TRUCK BUT I NEVER RECEIVED A RECALL FOR THIS PROBLEM. SHOULD I NOT BE DRIVING IT MUCH BECAUSE OF THIS RECALL? THIS HAS BEEN ONGOING FOR SEVERAL YEARS, THEY JUST MENTIONED IT IN THE LAST TIME I GOT IT SERVICED AND ANOTHER RECALL TAKEN CARE OF. HAS DONE THIS SINCE I PURCHASED TRUCK NEW IN FEBRUARY OF 2012.

NHTSA ODI 11185749

I WAS DRIVING ON A CITY STREET DOING 40MPH WHEN I HIT A SMALL BUMP IN THE ROAD AND MY TRUCK JUST TURNED OFF SAYING ON THE MESSAGE CENTER SCREEN KEY IN IGNITION. THIS HAS HAPPENED TO ME 3 TIMES NOW SINCE I HAVE OWNED THE TRUCK. I HAVE SPOKE TO MY LOCAL DEALER ABOUT THE ISSUE AND HAVE DONE EXTENSIVE RESEARCH ON THE WEB, AND HAVE FOUND OUT THAT RAM KNOWS ABOUT THE ISSUE AT HAND AND HAS MADE A 2ND GENERATION WIN MODULE AND COST OF THE PART IS ROUGHLY $500 PLUS NEW KEY FOB AND PROGRAMING. BUT FOR SOME UNKNOWN REASON THIS IS NOT A ROAD SAFETY ISSUE THAT HAS BEEN MADE A RECALL. I AM IN MOTION WHILE DRIVING AND MY TRUCK STOPS RUNNING AND I'M IN THE MIDDLE OF A TURN DOING 60MPH AND WELL THERE GOES POWER STEERING AND BREAKS DEATH WILL HAPPEN AT SOME POINT. VERY DISTURBED MOPAR FAN.

NHTSA ODI 11185744

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING 60 MPH, THE IGNITION SWITCH WOULD INDEPENDENTLY TURN OFF ONCE THE VEHICLE STRUCK A BUMP OR A POTHOLE. THE CONTACT WOULD HAVE TO RESTART THE VEHICLE IN ORDER FOR IT TO RESUME NORMAL OPERATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO TEAM ONE CHRYSLER DODGE JEEP RAM OF GADSDEN (1149 1ST AVE, GADSDEN, AL 35901, (256) 543-9583) WHERE IT WAS DIAGNOSED THAT THE IGNITION MODULE SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 170,000. THE VIN WAS UNKNOWN.

NHTSA ODI 11185908

THE KEY IGNITION SWITCH CRANK UP AND THEN DIES ABOUT 5 TIME THE S RUN GOOD LIKE YOU THINK GO TO PULL OUT ON THE ROAD AND THE TRUCK DIES BECAUSE OF THE KEY SWITCH ALMOST DIED BECAUSE OF IT LUCKY THE TRUCK DRIVER SAW ME SITTING IN THE ROAD

NHTSA ODI 11184196

AIRBAG LIGHT ON; AIRBAG INOP. RECALL THAT HAVE BEEN IDENTIFIED TO BE EFFECT THE 2013 MODELS ALSO EFFECT THE 2012 MODELS.

NHTSA ODI 11183630

WIN MODULE SHUT MY TRUCK OFF WHILE DRIVING DOWN THE HIGHWAY 4 TIMES IN 2 DAYS. THIS IS DANGEROUS WHEN MY 4 CHILDREN ARE IN THE VEHICLE.

NHTSA ODI 11182681

I OWN A 2012 RAM 2500 6 SPEED MANUAL TRANSMISSION WITH 130 THOUSAND MILES ON IT FIRST. I WAS DRIVING DOWN ON AN INTERSTATE IN DAN ANTONIO GOING AROUND 70 MPH WHEN I HEAR AND FEEL A BAD VIBRATION. I START TO SLOW DOWN WHEN I HEAR A LOUD BANG AND FEEL SOMETHING HIT THE FLOORBOARD. IT HIT SO HARD THE PENS I HAD NEXT TO THE SHIFTER FLEW TO THE BACKSEAT. I IMMEDIATELY LOSE MY CLUTCH (SLAVE CYLINDER WAS SMASHED) AND I LIMP IT TO THE SIDE OF THE ROAD. I MAKE IT TO THE SHOULDER PUT MY FLASHERS AND TURN THE TRUCK OFF. I GET OUT AND MY FRONT DRIVE SHAFT IS COMPLETELY GONE AND SO IS HALF OF MY TRANSFER CASE ALONG WITH THE SLAVE CYLINDER TO WORK MY CLUTCH. MY FUEL AND BRAKE LINES ARE INTACT BUT ARE PULLED DOWN BELOW THE FRAME. I INFORM MY INSURANCE IMMEDIATELY, AND THEY COME OUT TO INSPECT IT, AND SAY IT WAS MECHANICAL. SINCE I DIDN'T HAVE MECHANICAL COVERAGE ON MY FULL COVERAGE THERE IS NOTHING THEY WILL DO. I HAVE MY MECHANIC LOOK AT IT AND SAY THE VIBRATION CAUSED MY BOLTS THAT HOLD THE FRONT DRIVE SHAFT TO THE FRONT DIFFERENTIAL SHEARED OFF AND THE SHAFT GOT LODGED INTO THE GROUND CAUSING IT TO BREAK THE TRANSFER CASE IN HALF. FROM WHAT I'VE BEEN TOLD THIS IS MORE OF AN ISSUE THAN RAM WANTS TO LEAD ON. TRANSFER CASES ARE HARD TO GET AHOLD OF SAME AS THE DRIVE SHAFT. SO FAR I HAVE GOTTEN THE SLAVE CYLINDER MASTER CYLINDER REPLACED FOR 150 DOLLARS. I'VE BEEN QUOTED UPWARDS TO 2000 DOLLARS FOR A REMANUFACTURED TRANSFER CASE. SINCE THEY DON'T COME WITH THE MOTOR THAT IS ANOTHER 300 DOLLARS. THEN THE FRONT DRIVE SHAFT COST AROUND 700 TO 750 DOLLARS. TO PAY MY MECHANIC FOR THE WORK HE IS GOING TO DO IT FOR 500 DOLLARS. A TOTAL OF 3650 WITH ANOTHER 150 TO TOW IT BACK FROM THE SHOP SINCE MY INSURANCE REFUSED TO DO THAT FOR ME. A TOTAL OF 3800 DOLLARS BECAUSE THE CV JOINT WENT OUT WITHOUT ANY WARNINGS SIGNS.

NHTSA ODI 11176663

FACTORY INSTALLED TRAILER BREAKS DO NOT WORK, I TOW A 10,000# TRAILER THAT I CANT TOW WITHOUT TRAILER BREAKS. CALLED DODGE @1-866-726-4636, THAY KNOW OF THE PROBLEM BUT CANT FIX IT. THIS WILL EVENTULY LEAD TO AN ACCIDENT.I WAS ON THE C.A. 101 NORTH AND HAD NO TRAILER BREAKS THIS IS DANGEROUS

NHTSA ODI 11173406

R03 (REPLACES L25) WIRELESS IGNITION NODE (WIN) MODULE WIN MODULE FAILURE. WHEN DRIVING THE VEHICLE IN MOTION, THE ENGINE AND POWER SHUTS OFF TO THE VEHICLE, CAUSING LOSS OF POWER STEERING AND BRAKING POWER. THIS HAPPENED TO ME WHILE DRIVING ON THE FREEWAY. THIS HAS BEEN RECALLED DUE TO THE SAME SITUATION ON MULTIPLE OTHER DODGE/CHRYSLER VEHICLES THAT HAVE THE SAME WIN MODULE PART/PART# AS MY 2012 RAM. 'THE WIRELESS IGNITION NODE (WIN) MODULE ON THESE VEHICLES MAY HAVE UNINTENTIONAL MOVEMENT OF THE FREQUENCY OPERATED BUTTON IGNITION KEY, OR FOBIK, FROM THE 'ON' TO THE 'ACCESSORY' POSITION WHILE DRIVING. THIS COULD CAUSE UNINTENDED ENGINE SHUT OFF AND INCREASE THE RISK OF A CRASH.' HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2016/RCMN-16V240-9929.PDF

NHTSA ODI 11172632

WIN MODULE. THE WIN MODULE IN MY TRUCK IS FAILING. THIS CAUSES INTERMITTENT NO START AND ALSO THE ENGINE WILL SUDDENLY STOP RUNNING WHILE IN MOTION. THIS USUALLY HAPPENS WITH A BUMP IN THE ROAD AND HAS HAPPENED WHILE PULLING OUT OF A DRIVEWAY INTO TRAFFIC. THERE ARE MANY COMPLAINTS ON THE WEB FOR THIS ISSUE.

NHTSA ODI 11163933

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED NORMALLY. THE CONTACT STATED THAT THE FAILURE OCCURRED ON A DAILY BASIS FOR APPROXIMATELY ONE MONTH. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 37,000. *DT*JB

NHTSA ODI 11162025

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING APPROXIMATELY 25 MPH, A RATTLING NOISE WAS HEARD FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED AND REPLACED THE WATER PUMP. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE MILEAGE WAS 67,197.

NHTSA ODI 11161420

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING 50 MPH, THE VEHICLE STALLED AND FAILED TO RESTART. THE CONTACT HAD TO MOVE THE KEY SLOWLY IN ORDER FOR THE VEHICLE TO START. THE VEHICLE WAS TAKEN TO GRIEGER'S MOTOR SALES CHRYSLER DODGE JEEP RAM (1756 W US HWY 30, VALPARAISO, IN 46385, 219-462-4117) WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000. THE VIN WAS UNKNOWN. *DT *JB

NHTSA ODI 11151563

IGNITION SWITCH-WHILE DRIVING DOWN THE ROAD WITH MY WIFE AND SMALL CHILDREN, MY TRUCK SHUT OFF ON ITS OWN. I TRIED TO RESTART THE ENGINE AND IT STARTED, BUT SHUT BACK OFF. I NOTICED THAT THE IGNITION SWITCH WAS FEELING LOOSE. THIS HAS HAPPENED 5 OR 6 TIMES IN THE LAST TWO DAYS. I GOT ONLINE AND FOUND OUT THAT I AM NOT THE ONLY ONE THAT HAS HAD THIS PROBLEM. WHAT HAPPENS IF I AM DRIVING DOWN THE ROAD AND MY TRUCK SHUTS OFF ON ITS OWN AND I AM IN AN INTERSECTION? I HAVE BEEN A FIREFIGHTER FOR 10 YEARS NOW, I DON'T WANT TO SEE ANY MORE UNNECESSARY MVA'S HAPPEN DUE TO FAULTY PARTS. THIS PROBLEM NEEDS TO BE CORRECTED ASAP!!!

NHTSA ODI 11139618

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING 65 MPH, THE CONTACT DETECTED A BURNING ODOR COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO COVERT CHRYSLER DODGE JEEP RAM (8107 RESEARCH BLVD, AUSTIN, TX 78758, (512) 730-3300) WHERE THE CONTACT WAS INFORMED THAT THE RELAY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.

NHTSA ODI 11132137