What 392 owners told NHTSA about the 2012 Kia Sportage Phev Phev

I was driving eastbound in my 2012 Kia Sportage on I-82 just past Benton City MP97 at about 11AM on Monday June 22, 2026, when my engine knocked twice, the red check engine light came on, and I lost power. I pulled over off the road next to a concrete barrier that was beside a rock roadcut. My flashers would not operate, I put it into park, turned off the ignition and immediately noticed the smell of burning oil or rubber. I had 2 half gallon containers of water on my front seat, so I popped the switch, lifted the hood, used the prop rod to hold the hood up as I started dowsing the flames that were popping up on the passenger side of my engine compartment near the firewall. After using both half gallons, I ran to the rear of the vehicle, opened the hatchback, and grabbed a gallon spray bottle of water and brought that back around to the front of the vehicle. By this point the prop rod holding the hood was bending and the flames were popping back up, I pumped the sprayer and directed a stream of water with my left hand and used my right to hold up the hood as the prop rod was not working. After the fire was completely out, I returned to the rear of the vehicle, donned my reflective vest, put a portable flasher on my vehicle, and at this point a Benton County fireman in a pickup arrived - he was called by a motorist that saw me pulling over with smoke trailing my vehicle. The fireman was followed by a large firetruck and crew. They propped up the hood with a bar and inspected the motor to verify the fire was completely extinguished. They took my information and left. A Washington State Patrol arrived, assessed the scene and offered assistance, but I already had called my wife so he left me to wait for her. He told me I had 24 hours to get the car off the interstate. I had the car towed to my driveway by A&E towing at about 2:30PM. I just realized this morning that I ought to report it to you. I haven't tried to start it, but I'm sure it won't.

NHTSA ODI 11746708

My vehicle had just recently been parked and turned off after only having driven 10 miles. Upon returning to my car less than 5 minutes later, a plume of white smoke and a small flame could be seen below the hood of the car. Within minutes the entire engine was engulfed in flames. By the time the Fire Department arrived, the blaze had already reached the rear of the vehicle. Everything was completely lost.

NHTSA ODI 11469891

WAS DRIVING AND THE AIRBAG INFLATED, THE BRAKES LOCKED UP. THEN STARTED SMELLING GAS AND SMOKE

NHTSA ODI 11374214

THIS INFORMATION IS FROM MECHANIC: ENGINE BEGAN TO SMOKE, VEHICLE DROVE INTO PARKING LOT, PUT IN PARK, OPENED HOOD, GREY/GREEN SMOKE NOTICED, ENGINE WOULD NOT RESTART. MECHANIC STATED THAT THE ENGINE SEIZED UP - WOULD NOT RESTART - HAD TO BE TOWED TO MECHANIC.

NHTSA ODI 11318104

TL* THE CONTACT OWNED A 2012 KIA SPORTAGE. WHILE THE CONTACT'S VEHICLE WAS PARKED, A WITNESS OBSERVED SMOKE AND FLAMES UNDER THE HOOD. THE FIRE AND POLICE DEPARTMENTS ARRIVED AND BOTH DEPARTMENTS FILED REPORTS. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED AND REMAINED IN THE PARKING LOT. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

NHTSA ODI 11267230