What 2,604 owners told NHTSA about the 2012 Ford Fusion Hev

ON 10/5/2013, I HAD TO CALL ROADSIDE RESCUE TO JUMP START CAR. I TOOK VEHICLE TO ADVANCE AUTO ON 10/6/2013 TO TEST BATTERY. THE PRINTOUT RESULTS FOUND, INDICATOR LIGHT WAS YELLOW, COLD CRANKING AMPS 500 ON BATTERY, TEMPERATURE WAS TO HIGH AT 124DEGREES. ON 10/7/2013, CALL ROADSIDE RESCUE TO JUMPSTART VEHICLE. I LET THE VEHICLE IDLE FOR A BIT, HOPING TO RECHARGE THE BATTERY BACK TO FULL FUNCTION. ON 10/8/2013 CALLED ROADSIDE RESCUE TO JUMPSTART VEHICLE FOR THE 3RD TIME AND THEN DROVE TO FORD DEALERSHIP. WITH GREAT HESITATION, FORD REPLACED THE BATTERY. I HAD TO TELL THE TECHNICIAN TO LOOK AT THE BATTERY'S YELLOW LIGHT. *TR

NHTSA ODI 10648259

WITHOUT ANY ISSUES IN THE 6 MONTHS I'VE OWNED THE CAR, THE ENGINE SHUT DOWN. THE BATTERY APPEARED FULL. GAS TANK IS FULL. AFTER ONLY DRIVING FOR 1/4 MILE, THE STOP SAFELY NOW WARNING LIGHT CAME ON AND CAR SHUT DOWN. LUCKILY WE WERE RIGHT NEXT TO A CONVENIENCE STORE AND WERE ABLE TO GET AWAY FROM TRAFFIC. IF WE WERE ON A 2 LANE ROAD, WE WOULD OF BEEN STUCK IN THE MIDDLE OF TRAFFIC. WE WERE ABLE TO RESTART AND MOVE 10 FT AT A TIME. STILL WAITING FOR DIAGNOSIS. *TR

NHTSA ODI 10644182

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT MENTIONED THE INSTRUMENT PANEL WARNING LIGHTS ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000. UPDATED 12/18/14*CN THE CONSUMER STATED WHEN SHE PRESSED THE ACCELERATED PEDAL, THE VEHICLE SLIGHTLY ACCELERATED, AND THE VEHICLE WOULD ALSO JERK FORWARD. AT TIMES, THE VEHICLE WOULD CUT OFF WHILE DRIVING. UPDATED 01/07/15 *JB

NHTSA ODI 10641924

WHILE DRIVING, THE CAR BEGAN TO SHAKE AND JERK LIKE THE ENGINE WANTED TO DIE. THEN I LOST ENGINE POWER. THE CAR STILL HAD POWER AND WAS ON, BUT THERE WAS NO THROTTLE WHEN I PUSHED THE GAS. THE ENGINE LIGHT AND A LITTLE WRENCH CAME ON. I PUT IT IN PARK, TURNED IT OFF, RESTARTED IT, AND IT STILL HAD NO ENGINE THROTTLE TO IT. BUT THE CAR HAD A SMALL AMOUNT OF POWER, LIKE I WAS COASTING ALONG, SO THAT I COULD GET THROUGH THE STOP LIGHT AND MAKE IT TO THE SIDE OF THE ROAD. EVERY TIME I TRIED THE GAS PEDAL THOUGH, THERE WAS NO RESPONSE; IT WENT TO THE FLOOR. I WAS AT THE LIGHT BY MY NEIGHBORHOOD, RIGHT BY THE TRAIN TRACKS. THANK GOD I HAD ENOUGH POWER TO GET THROUGH THAT! *TR

NHTSA ODI 10638114

WHILE DRIVING, THE GAS PEDAL BECAME UNRESPONSIVE AND THE ORANGE WRENCH SYMBOL CAME ON. I PULLED OVER AND SHUT THE CAR OFF. I ATTEMPTED TO RESTART THE CAR. THE CAR RESTARTED AND I WAS ABLE TO CONTINUE DRIVING AS NORMAL. THIS PROBLEM HAS OCCURRED APPROX 4 TIMES. EACH TIME WITH THE SAME PRESENTATION AND EACH TIME I WAS ABLE TO RESTART THE CAR. *TR

NHTSA ODI 10632684

I WAS DRIVING ON INTERSTATE 70 AT APPROXIMATELY 65 MPH WHEN I SUDDENLY LOST ALL ENGINE POWER. I WAS ALMOST HIT BY A SEMI TRAVELING BEHIND ME BECAUSE MY VEHICLE HAD ABSOLUTELY ZERO ACCELERATION. THE "WRENCH" LIGHT ON MY CAR CAME ON AT THE SAME TIME THIS HAPPENED. THE SEMI BEHIND ME SWERVED TO MISS ME AND I WAS ABLE TO GET MY CAR OFF TO THE SIDE OF THE ROAD. LIGHTS, CLIMATE CONTROL (A/C), RADIO, ETC. WORKED FINE. ENGINE STILL RAN BUT WOULD NOT MOVE FORWARD. I TURNED THE CAR OFF TO CALL FOR ASSISTANCE. UPON SEEING IF THE CAR WOULD RE-START, IT DID AND NO "WRENCH" LIGHT APPEARED. I WAS ABLE TO THEN GET THE CAR TO MY LOCAL FORD DEALERSHIP, BUT BEING A HOLIDAY THEY WERE CLOSED. I COULD HAVE BEEN KILLED WHEN THIS HAPPENED ON THE INTERSTATE WITH THE SEMI BEHIND ME!! SOUNDS LIKE SOME KIND OF FUEL INJECTOR OR THROTTLE PROBLEM. MY VEHICLE IS NOT EVEN 3 YEARS OLD AND I BOUGHT IT BRAND NEW IN DEC. 2011. *TR

NHTSA ODI 10629947

ENGINE LIGHT APPEARED ON DASH. FOLLOWED INSTRUCTIONAL MANUAL DIRECTIONS AND ENGINE LIGHT DISPLAY STAYED INTERMITTENT. AS OF JULY 24TH ENGINE LIGHT DISPLAY REMAINS ON AND EVERY TIME I STOP TO PUT ANY AMOUNT OF FUEL IN IT, IT STRUGGLES TO START AND TAKES AT LEAST 3 ATTEMPTS BEFORE IT WILL START. HOWEVER, IF I LEAVE IT RUNNING WHEN ADDING FUEL I HAVE NO PROBLEM, WHICH IS NOT RECOMMENDED. HAD AUTO ZONE RUN DIAGNOSTICS CHECK AND THEY GAVE ME THE CODE BUT THE FORD DEALERSHIP (KELLY FORD, MELBOURNE FL) WOULD NOT EVEN ATTEMPT TO LOOK UP THE CODE AS THEY SAID I HAVE TO COME IN AND PAY $100.00 DIAGNOSTIC FEE AND $160.00 HOURLY TO HAVE FIXED. I AM MORE WORRIED ABOUT DOWN THE ROAD ISSUES AS SEEN ON THIS WEB SITE. BOUGHT THE CAR USED IN DECEMBER OF 2012 WITH ONLY 11,000 MILES ON IT. *TR

NHTSA ODI 10629600

I WAS DRIVING DOWN THE HIGHWAY WHEN SUDDENLY MY VEHICLE LOST POWER. I ATTEMPTED TO PRESS THE ACCELERATOR BUT THE CAR JUST JERKED VIOLENTLY. I WAS FORCED TO STOP IN THE MIDDLE OF THE HIGHWAY BECAUSE I WAS UNABLE TO ACCELERATE TO THE SIDE OF THE HIGHWAY. I WAS ALMOST REAR-ENDED 3 TIMES DO TO THE SPEED OF TRAFFIC AND MY CAR SUDDENLY LOSING POWER. WHEN THE VEHICLE LOST POWER, A "WRENCH" SYMBOL APPEARED ON THE DASH. I PLACED THE VEHICLE IN PARK AND SAT FOR A FEW SECONDS AND ATTEMPTED TO START THE VEHICLE. ONCE STARTED I PULLED OVER TO THE SIDE OF THE HIGHWAY. THE CAR WAS RUNNING FINE SO I DECIDED TO DRIVE ON THE HIGHWAY AGAIN. AFTER ABOUT 1/2 A MILE, THE CAR STOPPED SUDDENLY AGAIN, THIS TIME I WAS ABLE TO COAST ONTO THE MEDIAN BECAUSE I WAS DRIVING IN THE SLOW LANE. THIS CONTINUED FOR SEVERAL MILES UNTIL I FINALLY PULLED OVER AND CALLED A TOW TRUCK. *TR

NHTSA ODI 10626876

WHILE DRIVING MY NEW FORD FUSION, ONLY 5 MONTHS SINCE PURCHASE, THE VEHICLE LOST POWER AND STALLED. WHEN I TOOK IT TO THE DEALER THEY COULD FIND NOTHING WRONG AND SAID WHAT'S THE ISSUE IT STARTED DIDN'T IT? THE SAME THING HAPPENED AGAIN IN MAY AND JULY OF 2014. IT IS A KNOWN ISSUE WITH FORD AND A CUSTOMER SATISFACTION WAS ISSUED TO REPLACE THE THROTTLE BODY, BUT THE DEALERSHIP WON'T DO SO BECAUSE NO CODE SHOWS UP WHEN I'VE TAKEN THE CAR IN AFTER EACH EPISODE. THIS IS A SAFELY ISSUE AND A KNOWN ISSUE. WHY NHTSA ALLOWED THEM TO GET AWAY WITH NOT DOING A RECALL IS BEYOND ME. IT IS UNSAFE DRIVING A VEHICLE THAT SUDDENLY LOSES POWER. IT SHOULD NOT MATTER THAT A CODE DOESN'T SHOW UP. WHAT HAPPENED BEFORE COMPUTERS? IT'S A KNOWN ISSUE AND IS HAPPENING SO IT SHOULD GET REPLACED. THANKFULLY I WASN'T DRIVING OVER 35 WHEN THIS OCCURRED, BUT WHAT ABOUT THE NEXT TIME IF I'M ON A HIGHWAY GOING 60? WHAT WILL IT TAKE - PEOPLE TO GET SERIOUSLY INJURED TO GET A TRUE RECALL? *TR

NHTSA ODI 10618456

WHILE DRIVING ON A MAJOR HIGHWAY AT A SET RATE OF SPEED THE CAR ACTED AS IF IT WAS TRYING TO SHIFT GEARS AND BUCKED, RPM'S WENT UP AND THEN BACK TO NORMAL. IT WENT TO THE DEALER AND THROTTLE BODY WAS REPLACED, A WEEK OR SO AFTERWARDS THE CAR STARTED TO DO THE SAME THING, BUT THIS TIME ALSO IN REVERSE. I TOOK IT BACK TO THE DEALER WHERE THEY STATED THAT NOTHING WAS WRONG BUT THEY ONLY PUT 4 MILES OF A TEST DRIVE ON THE CAR. LAST WEEK THE FUSION LEFT ME ON A MAJOR HIGHWAY JUST SHUTTING DOWN WITH NO WARNING AND I HAPPENED TO HAVE MY 2 YEAR OLD. I LEFT IT SIT ABOUT 30 MINUTES AND TURNED OVER THE IGNITION AND IT STARTED LIKE NORMAL. I WAS JUST THANKFUL TO GET HOME WITHOUT AND ACCIDENT. IT'S NOT SAFE... THE CAR LOOKS GREAT BUT ITS LIKE YOU TAKE YOUR LIFE INTO YOUR OWN HANDS DRIVING IT. *TR

NHTSA ODI 10618199

FELT LIKE A SURGE THEN ENGINE STALLED. HAD TO PULL OVER TURN THE CAR OFF THEN RESTART. *TR

NHTSA ODI 10605451

VEHICLE LURCHED THEN LOST POWER AND CHECK ENGINE LIGHT CAME ON. VEHICLE WOULD NOT ACCELERATE AFTER LOSING POWER. SINCE THE REPAIRS, THE VEHICLE WILL OCCASIONALLY LURCH WHEN THE CAR IS IN GEAR AND THE BRAKES ARE APPLIED. *TR

NHTSA ODI 10592762

STARTING OUT, THROTTLE HAD NO RESPONSE ON TAKE OFF, NOW TAKING A RIGHT HAND TURN THROTTLE HAS NO RESPONSE THEN JUMPS FORWARD, VERY DIFFICULT PULLING OUT ONTO A HIGHWAY. I'VE TAKEN IT TO TWO DIFFERENT FORD DEALERS AND THEY REFUSE TO DO ANYTHING TILL THE CHECK ENGINE LITE COMES ON, MEANWHILE I'M DRIVING A DANGEROUS CAR... *TR

NHTSA ODI 10573993

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT SHE RECEIVED A LETTER NOTIFYING HER OF A CUSTOMER SATISFACTION PROGRAM RELATED TO NHTSA ACTION NUMBER: PE13003 (ENGINE) . THE CONTACT MENTIONED THAT SHE WAS VERY CONCERNED FOR HER SAFETY AND THAT THERE SHOULD HAVE BEEN A RECALL ISSUED FOR THE DEFECT. THE DEALER WAS CONTACTED, WHO REFUSED TO ASSIST HER UNLESS THE VEHICLE WAS EXHIBITING THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CURRENT MILEAGE WAS 18,300.

NHTSA ODI 10569342

WAS AT A STOP SIGN WHEN I ACCERLERATED THE ENGINE STOPED. I VEERED TO THE RIGHT AND THE CAR RESTARTED. I TOOK IT TO THE LOCAL FORD DEALERSHIP. THEY SAID THEY COULD FIND NOTHING WRONG THE CAR. IT HAS HAPPENED A TOTAL OF THREE TIMES WITH THE SAME RESULT, THEY SAY NOTHING WRONG WITH THE CAR. I CALLED FORD THEY INITATED A BUY BACK BUT THE CAR DID NOT PASS CALIFORNIA LEMON LAW MUSTER SO MY CASE WAS CLOSED. *TR

NHTSA ODI 10566084

SEPTEMBER 24, 2013-I WAS DRIVING HOME AND THE CAR BEGAN TO SHUT DOWN. THE WRENCH CAME UP AND IT LOSE ALL POWER. I WAS ABLE TO COAST INTO THE MEDIAN AS IT WAS 5;00 TRAFFIC. I TURNED COMPLETELY OFF AND RESTARTED AGAIN. DECEMBER 5, 2013.. THE SAME THING HAPPENED AS I WAS ON A SIDE STREET. I TURNED OFF AND RESTARTED. 2/24/2014 I WAS GOING TO WORK AND IT CUT OFF ON VERY BUSY 6 LANE HIGHWAY. IT WAS VERY SCARY AS NO ONE WAS BEHIND ME. I TURNED OFF AND THEN RESTARTED THE CAR. I WAS SO RELIEVED THAT NO ONE WAS ON THIS BUSY ROAD WHICH IS ALWAYS TRAFFIC GOING VERY FAST. I HAVE A SERVICE ALL INTO FORD FOR FRIDAY 2/28/2014. *TR

NHTSA ODI 10565630

I HAVE HAD SEVERAL ISSUES LEADING UP TO THIS AND THE DEALER WOULD SAY NOTHING IS WRONG. CAR JUMPS FORWARD WHEN IDLING, CAR LOOSES POWER WHEN ACCELERATING ON HIGHWAY. LASTLY WAS COMPLETE LOSS OF POWER AND NEARLY HIT BY BUS WITH KIDS IN CAR. THEY REPLACED THROTTLE BODY, A/C MOTOR ETC....TWO WEEKS GONE BYE AND IT IS STARTING AGAIN. I NEED TO GIVE THIS CAR TO MY DAUGHTER TO DRIVE BUT IT IS NOT SAFE. *TR

NHTSA ODI 10555792

I NOTICED A "JUMPY RIDE' DURING TRIP TO ALBUQUERQUE AND BACK....FIRST ROAD TRIP SINCE BUYING CAR IN APRIL,'13. IT WAS SORT OF A SHIFTING OF A GEAR WHEN THERE SHOULD HAVE BEEN NOTHING LIKE THAT AT THAT SPEED. STARTED NOTICING AROUND TOWN AT 35 THE SAME JUMPY FEELING...JUST SEEMED LIKE TOO MUCH SHIFTING. THE RIDE IS VERY "ROUGH" ...NEVER HAD A CAR LIKE THIS...LOVED MY '09 FUSION, BUT THIS ONE STINKS. AFRAID IT'S WEARING OUT THE TRANNY AND COULD BE DANGEROUS. 3 DEALERS HAVE JUST BLOWN ME OFF ALONG WITH THE CORPORATE PERSON I TALKED TO...A "[XXX]" FOR MY REGION FOR FORD. I AM WORRIED AND CAN GET NOTHING DONE! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI 10551709

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT THE VEHICLE INTERMITTENTLY STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE REPLICATED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 5,000. ..UPDATED 12-30-13 *BF UPDATED 1/14/2014 *JS

NHTSA ODI 10550371

ON 10/9/2013 I WAS STOPPED AT A LIGHT AND THEN WHEN I PROCEEDED TO GO ON A GREEN LIGHT, MY CAR STALLED WITHOUT ANY WARNING OR LIGHTS ON MY DASH WHILE IN TRAFFIC. THERE WAS A CAR BEHIND ME THAT ALMOST REAR ENDED ME. WENT TO RESTART THE VEHICLE AND IT DID NOT START RIGHT AWAY. I HAD TO PUT THE CAR IN PARK WITH HAZARDS ON, IN THE MIDDLE OF TRAFFIC, AND TRIED TO START THE CAR TWO MORE TIMES BEFORE THE CAR STARTED AGAIN. THE CAR HAS BEEN GIVING ME ISSUES WITH HESITATION AND VIBRATION FOR THE PAST 4 MONTHS. I HAVE TAKEN IT TO FORD AND THEY HAVE CHECKED MY CAR 2 TIMES AND NEVER WAS ABLE TO SOLVE THE PROBLEM. BEFORE I TOOK IT TO FORD THE CAR HAS STALLED ON 6/19/2013 PRIOR TO TAKING THE CAR TO THE LOCAL FORD SHOP. THEY SAID IT WAS THE PROGRAMMING AND THEY INSTALLED THE UPDATE FOR THE COMPUTER, BUT IT NEVER SOLVED THE PROBLEM. THE LAST TIME IT STALLED ON ME, MY HUSBAND, WHO IS AN ACURA TECHNICIAN, PULLED THE P2111 CODE OUT USING A POCKET CODE READER OUT OF FREEZE FRAME DATA. THERE WAS NO CODES STORED IN PCM 6 HRS AFTER THE INCIDENT. 2 DAYS LATER CHECKED FOR FREEZE FRAME DATA AGAIN AND THERE WAS NO FREEZE FRAME DATA. *TR

NHTSA ODI 10548179

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED WHILE DRIVING 60 MPH THE VEHICLE LOST POWER, THE WRENCH LIGHT ILLUMINATED WHEN THE FAILURE OCCURRED. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO THE EMERGENCY LANE, RESTART IT AND RESUME NORMAL FUNCTION. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 35,000. ...UPDATED 12/03/13 *BF THE CONSUMER STATED THE VEHICLE SHUT DOWN 3 TIMES DISPLAYING THE WRENCH WARNING. UPDATED 12/6/2013 *JS

NHTSA ODI 10547592

WAS DRIVING ON INTERSTATE IN HEAVY TRAFFIC. CAR IMMEDIATELY-WITHOUT WARNING- LOST POWER TO ACCELERATE. WENT TO A LIMP DRIVING MODE. WARNING LIGHT (WRENCH) CAME ON. WAS VERY DANGEROUS SITUATION. HAD TO MANEUVER TO SIDE OF ROAD. ALMOST WAS HIT FROM BEHIND. CAR SHOOK AND STUTTERED. TURNED OFF IGNITION AND WAITED A COUPLE MINUTES. STARTED CAR, ALL WARNING LIGHTS CLEARED. WAS ABLE TO MAKE IT HOME WITHOUT ANY OTHER IN INCIDENT. FEW DAYS LATER SAME MALFUNCTION HAPPENED AGAIN. CAR LOST ACCELERATION AND HAD TO LIMP TO SAFE PLACE IN HEAVY TRAFFIC. TURNED OFF CAR AND RESTARTED. TOOK CAR TO FORD DEALERSHIP AND WAS TOLD CAR IS OUT OF WARRANTY AND DIAGNOSIS WAS THROTTLE BODY. A COMMON PROBLEM BUT NOT A RECALL. WOW. *TR

NHTSA ODI 10547524

DRIVING AT HIGHWAY SPEED, ENGINE STALLS WHILE ATTEMPTING TO MERGE. ORANGE WRENCH LIGHT APPEARS NEAR FUEL GAUGE. ROUGH IDLING BELOW 1000 RPM. TURN CAR OFF AND WAIT ONE MINUTE. RESTART CAR AND DRIVE WITHOUT INCIDENT. *TR

NHTSA ODI 10544540

TL* THE CONTACT OWNS A 2012 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS MERGED OFF THE ROADWAY WHERE THE ENGINE WAS RESTARTED. THE VEHICLE WAS NOT TAKEN FOR REPAIRS OR DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 44,000.

NHTSA ODI 10542265

MY SON GOT INTO THE CAR, GOING TO THE STORE, HE SAID SOMETHING WRONG WITH THE CAR. I SAID WHAT, HE SAID WHEN I CRANKED IT UP, SOUND LIKE I HEARD IT CLICKING. HE CHECK THE OIL, IT WAS A HALF OF A HALF QUART LOW. HE LEFT IN 2 SECONDS HE CALLED BACK, SAID SOMETHING IS WRONG, SO HIS DADDY WENT WHERE HE WAS, IT WAS STILL RUNNING, BUT LOST SPEED, IT WOULD ONLY GO 2 OR 3 MILES PER HOUR. AFTER GETTING IT BACK HOME, IT SAT A LITTLE WHILE AND IT WAS GOOD TO GO. LABOR DAY I WAS ON INTERSTATE 85 IT DONE THE SAME THING TO ME, BUT I HAD TO CALL A WRECKER I WAS TO FAR AWAY FROM HOME. NOW EVERYONE WANT ME TO PAY FOR THE TESTING OF THE CAR TO DETERMAN WHAT THE PROBLEM IS. FORD NEED`S TO DO SOMETHING ABOUT THIS TOO MANY COMPLAINTS I HAVE READ THEM. !!!! DON`T WAIT UNTIL DEATH OCCURS!!!!. *JB

NHTSA ODI 10541805