What 3,788 owners told NHTSA about the 2012 Ford Focus

The contact owns a 2012 Ford Focus. The contact stated that the vehicle overheated while driving approximately 30-35 MPH and stalled in the middle of the road. The check engine warning light was illuminated. The contact stated that the vehicle only restarted after cooling down for 15-30 minutes. The contact veered to the side of the road. The contact continued driving; however, the vehicle would not exceed 35 MPH. The contact stated that the failure occurred several times, and on some occasions, the vehicle was pushed to the side of the road with the assistance a Police Officer. The vehicle was taken to the dealer, where it was diagnosed that the dual clutch, slave cylinder, motor mount, purge valve and other unknown parts had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 140,000.

NHTSA ODI 11529758

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the transmission downshifted to second gear. Additionally, the transmission failed to shift to reverse(R) as needed. The contact removed and replaced the TCM, and the vehicle operated as needed for an hour; however, the failure recurred. The vehicle was taken to the dealer, who informed the contact that the vehicle had a faulty clutch actuator. Additionally, the dealer informed the contact that because the codes that illuminated were not the same as those in Customer Satisfaction Program: 14M02 (Transmission Control Module) the vehicle could not be repaired under the warranty. The contact related the failure to the Customer Satisfaction Program. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure was mileage was unknown.

NHTSA ODI 11529789

The contact owns a 2012 Ford Focus. The contact stated that she received notification of the NHTSA Campaign Number: 13V523000 (Power Train). The vehicle was taken to the dealer for the recall repair. The contact was then informed that the recall was completed and retained the vehicle however, the contact stated that while driving approximately 10 minutes away from the dealer at an undisclosed speed, she heard an abnormal sound while on an incline. The contact then stated that she allowed the vehicle to drift back into the street while shifted into drive(D). The contact stated that she depressed the brake pedal and shifted into reverse(R) and the “Pull Over - Transmission Overheated” message was displayed. The vehicle was taken back to the dealer where it was diagnosed that the TCM (Transmission Control Module) failed and needed to be replaced. The vehicle was not repaired. The vehicle was currently at the dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 122,511.

NHTSA ODI 11529186

I'm wondering since there are so many complaints, even I am one of then, why isn't anything getting done. I'm paying out of pocket. Ford don't want to fix my car, 2012 ford focus sel. It's b.s. it's costing me alot of money. And I don't get reimbursed for nothing. I'm highly mad. I should sue ford company for not doing [XXX]. Thanks INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11528640

Driving down the road and all of a sudden the transmission starts jumping out of gear and back in gear, then light comes on stating transmission is overheating. Shut car off to cool transmission and car will not start back, after around an hour car cranks back up, but continues to jumping in and out of gear and light stating transmission is overheating stop for 5 minutes and relays clicking under the hood around the motor/ transmission.

NHTSA ODI 11528512

It wont go in reverse and comes out of gear transmission?

NHTSA ODI 11527634

The contact owns a 2012 Ford Focus. The contact stated while stopped at an intersection, a message illuminated to “Stop Driving Immediately” was displayed. The contact stated that the vehicle stalled. The contact had the vehicle towed to an independent mechanic who diagnosed the vehicle and determined that the Transmission Control Module had failed and needed to be replaced. The vehicle had been repaired. The contact stated that it was difficult to shift into drive(D) or park(P). Additionally, the vehicle was hesitating while shifting into gear. The contact researched online and related the failure to Customer Satisfaction Program: 14M02 Transmission Control Module (Power Train). The manufacturer had been informed of the failure. The failure mileage was approximately 99,400.

NHTSA ODI 11526797

The problem is with the transmission and dual clutch and electrical. My car shakes when still, doesn't want to go when I put on the gas, doesn't want to change gears. The electrical keeps going on and off and the fan goes on and stays on after I shut car off and get out and stays on. I took it to schicker ford on south kingshighway to get programmed and I got my car back it was worse.

NHTSA ODI 11526713

The component is unknown and below is description. The car is stalling while accelerating and rushing forward when it does accelerate. At stop lights and when the car stops in traffic the vehicle is stalling. When the gas pedal is pushed to accelerate the stalling can cause a vehicle behind me to crash. After stalling, the acceleration causes the car to rush forward and it could cause my vehicle to run into someone in front of me. The vehicle was inspected at a dealership however I strongly believe their recommendations were not correct and that there is an easy fix for the issue above. They also claimed that it had nothing to do with the recall and did not provide information on the assessment about the recall. This particular recall does cause stalling so it is baffling to see that the dealership did not provide a written assessment on the report like they did for the door handles. I paid $150 for an assessment and around $200 for tow to bring the vehicle home after the assessment. The check engine light did come on and I took the vehicle to the dealership due to how unsafe the car was driving. I feared driving the vehicle and had it towed to the dealership for this poor assessment. I have not driven this vehicle in a year due to the unsafe driving conditions. I would like for the recall to be fixed and determine if that is causing the issue or not.

NHTSA ODI 11526362

The contact owns a 2012 Ford Focus. The contact stated while driving 35 MPH and shifting gear, the transmission delayed while shifting to the next gear with the "Transmission Failure" message displayed. The contact stopped on the side of the road and shut off and restarted the vehicle, and the vehicle started operating normally. The vehicle was taken to the dealer and the contact was informed that the transmission control module (TCM) needed to be replaced. The contact was informed that the vehicle was not included in NHTSA Campaign Number: 13V523000 (Power Train). The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The contact was referred to NHTSA Hotline. The failure mileage was 77,000.

NHTSA ODI 11525592

The truck opens by itself while I’m driving.

NHTSA ODI 11525355

[Two incidents involving the same ABS control module. Early January 2023 and Late May 2023] ABS control module failed while going downhill (valve stuck open). Resulted in the brake pedal going to the floor. Had to stop by downshifting and the using hand brake. Whenever brake pedal is pressed after this, it goes a random distance to the floor with no pressure before applying some brake. Ford quoted me a 1 year lead time on replacing the part (and mentioned this is part of a pending recall. This recall will come out after they redesign a new module). They refused my request for a rental/loaner vehicle until it is fixed. I brought it to an independent garage to get the unit replaced. After that, my brake pedal worked as expected for a few months. Last week, the pedal went to the floor again. I brought it to a Ford dealership, and they confirmed that the new module already experienced the same failure as the original one. It is currently at the dealership, who will not have a part to repair my car again until August. I was refused a loaner vehicle by both the dealership and corporate Ford over this PENDING SAFETY RECALL, where they are unable to fix my car. I was told by they dealership that they won't stop me from driving my car in the mean time if I feel safe doing so. It is not safe, so I am leaving the car at the dealership. I do not have a date for when a new revision module will be made, along with official recall. Ford is refusing to reimburse me for my initial repair until they get around to officially announcing the recall. I also found out from them that they reprogrammed the ABS control module back in March 2013 while they reprogrammed a different module (I only new about the TCM reprogram). This means they knew the ABS module had issues 10 years ago, a month after I bought the car. They did nothing for 10 years despite the Fusions having the exact same issue. This is a blatant disregard for the safety of their customers' safety.

NHTSA ODI 11525260

See incident 11525260 for details, as it describes both incidences where the ABS Control module failed. I am logging a second complaint so that the second module failure is recorded. Short version: The ABS control module failed again, leaving me with no brakes. The valve gets stuck open inside the module, making the brake pedal unpredictable and sometimes with no stopping power. Ford is unable to fix my car in a timely manner, and is refusing to provide a vehicle to drive until they fix it 2-3 months from now.

NHTSA ODI 11525263

The contact owns a 2012 Ford Focus. The contact stated the front passenger’s side door latch opened independently while the vehicle was parked in a parking lot. The contact called the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V331000 (Latches/Locks/Linkages); however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 115,000.

NHTSA ODI 11524384

Causing vehicle to shutter or jerk making the driver lose control for a minute or two when driving. Happens only, when accelerating at from a stop or turn.

NHTSA ODI 11522776

I was driving about 45mph when the car tried to downshift then upshift and it stalled in the middle of the road. The transmission light came on right as it stalled along with the traction control light. Which the traction control light it made me swerve into oncoming traffic almost causing an accident. So I got it to the opposite side of the road and went to put it in park and it lunged forward while crooked at the same time almost hitting a passing car. Over a year ago I had called a dealership about the TCM because every great while the car would shudder but nothing severe and was told the 10 yr 150000 mile recal didn't fit my car even though it was still within the 10 yr part but had 180000 on it. I ended up having the car towed to my mechanic since once I restarted it after a half hour wait before it would turn over tellingmy.no key was detected I turned the car around and went about a quarter of a mile down the road and it stalled on me and wouldn't go into park and I rolled down a hill towards kids getting dropped off by the bus after school let out. I ended up being able to turn it without power steering working into an abandoned house driveway. About 100 feet from a kid. Ford wants 400 to even diagnose it if I can get it towed there. The car should have been fixed under warranty last year but ford always finds a way out of fixing their vehicles. I have a 2012 ford focus se.

NHTSA ODI 11521813

After completing door latch recall there is still an alert the the hatchback is open. And doesn't shut off. The dealer states that I have to pay for replacement since the recall shows complete. Except the instructions did not show anything in regards to this component , in regards to the fuel system, the dealer said I would have to pay for test to determine if the PCM would fix the engine ight after I took in for recall.

NHTSA ODI 11520873

The automatic dual clutch is shaking my steering wheel and whole car.

NHTSA ODI 11520771

Shuddering and vibration while driving. Engine light turn on.

NHTSA ODI 11519779

On April 29, 2023 our 2012 Ford Focus SE with a 5 speed manual transmission indicated a dashboard warning stating the power steering assist was inoperable. Steering was still able to be done manually, but with much greater input required, especially at low speeds. Being a manual transmission, this is especially problematic as steering regularly has to be performed one handed. Fortunately this incident did not occur while driving, but reviewing many other similar complaints on the NHSTA website, as well as seaching '2012 Ford Focus steering issues' online, it is evident that this loss of assist CAN and HAS occurred to others when the vehicle was in motion. This poses a serious safety risk to not only the driver, but others on the road as well. This is an issue known to Ford Motor Company as they issued a recall (15S18) for similar problems on other Ford vehicles, but not the Focus. I am requesting the NHTSA investigate this situation and take action to compel Ford to fix the Focus as well under a recall to prevent similar situations from causing potential injury or death. I encourage one of your investigators to try driving one of these vehicles without the power assist to see just how dangerous it is, especially in low speed maneuvers. This car is primarily used by my son for his commuting to and from college. He is the one that first saw the warning. I am very thankful this did not happen while he was in motion. I will be contacting my dealer on Monday May 1, 2023 to start the diagnosis/repair process.

NHTSA ODI 11519644

PCM failed dealership didn't replace the recall but cleared it

NHTSA ODI 11519659

transmission control model in the car needs a new one

NHTSA ODI 11519457

The contact owns a 2012 Ford Focus. The contact stated that while driving approximately 15 MPH, the accelerator pedal was depressed, and the vehicle started jerking. Additionally, the vehicle failed to accelerate as intended. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI 11518754

While stopped and preparing to turn left at yield light, my check engine light suddenly came on followed by several alerts and dings. Not understanding what was occurring in that exact moment, I had an opportunity to safely make the left turn, and intended to address the issue once off the main road. Within moments of releasing the brake my car began violently revving and jolted forward into the intersection, in response I quickly threw on my hazard lights while trying to maintain control of the situation. Following this moment, my car suddenly had zero acceleration or vehicle control- just loud revving and bells and whistles. This left me briefly stranded in the middle of the intersection with oncoming traffic approaching quickly. I threw the car into park, and then back into drive- it never stopped revving, but it finally gave me enough control to lurch the vehicle out of intersection and barely into the entrance of a subdivision. It was utterly terrifying, and as result caused me to have a massive panic attack. Mind you, This car is barely over 100k in miles, and I just purchased it last summer from a used car dealership- so I took to the internet to search the issue while waiting for AAA to arrive. To my unknowing amazement, this car was slated with 2 major safety recalls- one being related to the transmission. I do not understand how this vehicle was allowed to be sold to me with such issues, or without disclosure about the possible recalls. With that aside, I was utterly distraught when my research concluded that Ford KNEW about these issues before they hit the market- they’re also allowed to keep them on the road with sorry assed “band-aid” repairs for the faulty equipment- still knowing full and well that this issue is Guaranteed to happen again! So now, I knowingly have to continue payments on a death trap- that I currently cannot drive. I am losing income I couldn’t afford to lose, and I’m terrified of my car. This is not ok…I’m not ok.

NHTSA ODI 11518509

The contact owns a 2012 Ford Focus. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 13V523000 (Power Train) however, the failure recurred. The contact stated that while driving at an undisclosed speed, the vehicle was shuddering with the check engine warning light illuminated. The dealer and Gordie Boucher Ford of Thiensville (121 N Main St, Thiensville, WI 53092) were made aware of the failure but informed the contact that the vehicle was not covered under warranty, and she was responsible to pay out of pocket for the diagnostic test and repair. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 93,490.

NHTSA ODI 11517591