What 3,788 owners told NHTSA about the 2012 Ford Focus

For almost 5 years everytime I fill my gas tank the fumes leak from my car. About 2 days ago the tank started leaking gas from a huge crack in the tank. I told the Ford service center about this issue and they said that my individual car wasn't under the recall (for this exact issue) so they can only look at it and see what they can do. I know of a few other Focus models (a little newer than my 2012) who have also experienced this issue as well whose cars was not under the recall. Just in the 10 minute and less than 15 mile drive from my house to the service center I saw my fuel gauge go from 275 miles to 223, not to mention about 4 days ago I went to fuel up and when I got home my tank was at 330 miles and I haven't left my house since I fueled up (except going to the service center). I called the Ford Customer Center and ws told to fill out this form and to see about a recall approval for my car for this issue.

NHTSA ODI 11588577

The contact owns a 2012 Ford Focus. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact stated that when the vehicle was started and the gear shifter was in reverse, the vehicle would not reverse(R). In addition, the check engine warning light had been illuminated before and remained illuminated after the transmission replacement in June 2023. The contact stated that the transmission had been replaced by the previous owner also. The vehicle was towed to the dealer where it was diagnosed with a failed transmission clutch and actuator and the transmission clutch and actuator needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 200,000.

NHTSA ODI 11587712

The trunk lid is rusting/deteriorating along the rim that meets the back bumper. I just dropped it off my red Ford Focus to Scott's Auto Fixit in Webster, NY for repair. I couldn't afford the new truck lid that the dealership service department offered at the Ford Dealership in Webster. The trunk lid was inspected by my auto insurance representative in 2019 (I have photos from 2019 and today {2024}). The lid is deteriorating with pieces of the lid falling into the trunk. I'm concerned of the possible risk of the trunk deteriorating to the point that other safety components would be affected - light, latch, lock (security). I've also notice that several Ford Focus automobiles are experiencing the same issue; the trunk lids are visibly rusting/deteriorating. The rust has discolored the paint on the rear bumper; that also needs to be addressed. frustrated!

NHTSA ODI 11587539

The contact owns a 2012 Ford Focus. The contact stated while driving approximately 35 MPH, the vehicle was unable to properly shift gear. Additionally, the transmission began to lose motive power. The message that the transmission was overheating was displayed. The vehicle was able to restart after 30 minutes. The vehicle was taken to a dealer where it was diagnosed as a failure with the transmission control module and needed to be replaced. The vehicle was repaired but the dealer stated that the shift module also needed to be replaced. The manufacturer was notified of the failure and a case was opened. The failure mileage was 112,000.

NHTSA ODI 11583604

My 2012 Ford SE stalls out between First, second and third gear whenever I am accelerating to 40mph. The Transmission error continues to pop up after driving for a long period of time. Whenever driving 50 mph to 70 mph as soon as I release the gas pedal, the car goes into neutral stall out & whenever I press down on the gas pedal nothing happens and I have to pull over & Turn the car off and turn it back on to reset the transmission computer. If I don’t do that and I press the gas pedal again, the car would jerk and I have to pull over immediately and the car off. I cannot press full on the gas pedal because the car would not accelerate at full speed. Whenever I put gas in the car, it won’t start right away. It would jerk and choke just to start up. It takes me a couple attempts to start the car after putting gas in order for it to start and go. Whenever I’m finished driving and turn the car off, it makes it clicking noise in the engine area for about 2 to 5 minutes and it won’t stop and it only happens when you open the front doors or when the car is completely turned the car off. Whenever I put a full tank of gas or a half tank , the car would not dry properly install out on the highway or street I can’t drive at normal speed because I don’t know when the car is gonna stall out before it hits 1,2 or 3rd gear, which makes it very dangerous to drive on the highway.

NHTSA ODI 11581162

The contact owns a 2012 Ford Focus. The contact stated while driving from a complete stop, the vehicle shuddered and hesitated to respond upon depressing the accelerator pedal. There was no warning light illuminated. The contact stated that the failure had been recurring while driving. The vehicle was taken to the dealer, where it was diagnosed that the transmission clutch was slipping. The dealer determined that the clutch and the levers needed to be replaced, as per Ford TSB Number: 16-0109. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 47,000.

NHTSA ODI 11580124

The contact owns a 2012 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle stalled and ran out of fuel on several occasions. The check engine warning light was illuminated. The vehicle was taken to the local mechanic who performed a diagnostic test and informed the contact to return the vehicle to the dealer to be repaired under NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The contact took the vehicle to the dealer and was informed that the purge valve and fuel pump needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure. The failure mileage was approximately 169,000.

NHTSA ODI 11579503

Focus, which was purchased in California in 2017, clutch has gone which caused to stall and jerk in traffic, now has to be replaced at my expense! $4300. This was a massive hazard and defect!

NHTSA ODI 11579034

The contact's daughter owns a 2012 Ford Fusion. The contact stated that while driving at high rates of speed, the "Pull Over Transmission Clutch Hot" message was displayed on the instrument panel. The vehicle was taken to a dealer where the vehicle was diagnosed with a defective transmission and the contact was given an estimate for the repair. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for further assistance. The vehicle was not repaired. The failure mileage was unknown.

NHTSA ODI 11578876

While driving car trying to stall in middle of traffic.

NHTSA ODI 11578004

Se acelera y desacelera repentinamente Quiero acelerar para llegar a la mismas velocidad del trafico y no lo hace y eso hase que ponga en peligro la vidad mia y de mi familia por que otro carro puede chocarme. Cuando sucedio eso se activo el CHECK, lo apago por completo y los parabrisas se activan repentinamente , todo esto es muy raro y no es bueno para mi

NHTSA ODI 11576328

My son was driving vehicle to work when the power steering assist failure light came on and the steering became difficult. He was in traffic and this could have very easily caused and accident as the car is now very hard to steer. Have not had it looked at yet because from what I have seen the cost to repair is well over $2000 and I don't have that kind of money laying around.

NHTSA ODI 11575955

Intermittent loss of brake pressure. ABS would activate and leave the brake pedal feeling soft and having low brake pressure. This problem would randomly fix itself and then randomly happen again while braking normally or after the ABS would engage. Sometime the problem would last for weeks until suddenly the brake pedal would be firm and have strong brake pressure.

NHTSA ODI 11575148

The contact owns a 2012 Ford Focus. The contact stated that upon the start of the vehicle, the "Engine Malfunction, Service Now" message was displayed on the instrument panel. In addition, the "Parking Aide Malfunction Service Required" message was displayed on the instrument panel when the vehicle was shifted into reverse(R). The vehicle also stalled upon the depression of the accelerator pedal after coming to a complete stop with the check engine warning light flashing on the instrument panel. The contact took the vehicle to an independent mechanic and replaced the battery, starter, and spark plugs; however, the failure persisted. The vehicle was taken back to the independent mechanic and the contact was informed that the transmission control module (TCM) was defective. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 100,000.

NHTSA ODI 11574949

The door ajar light illuminates on the dash even though the door is shut, the door ajar shows it is the driver side back door. With that warning I'm unable to lock the doors while inside the vehicle and the doors do not lock when putting the vehicle in drive from park or unlock when putting the vehicle in park from drive. I'm also unable to use the door handle lock and unlock sensor on the outside of the driver door.

NHTSA ODI 11573504

While driving on interstate ,my car suddenly started hesitating and failed to pick up speed. The engine light came on. I pulled over, but did not turn car off fearing it would not restart, to look at owners manual. The problem continued as I drove home. I have driven it once for a short distance since and there was no change. This could cause an accident since it happened unexpectedly while driving at high speed. Brake light fault warning light is illuminated although light appears to be working. This could cause rear end collision if not operating. Luggage compartment opens while driving which causes visibility issue and chance of items stored there to blow out and cause accident. I can not tell if this issue is included in recall addressing locks and latches. Driver side window no longer operates, preventing escape if needed

NHTSA ODI 11573168

The contact owns a 2012 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle started to shudder, prompting the contact to pull to the shoulder of the roadway. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the clutch, requiring a replacement clutch. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 89,000.

NHTSA ODI 11571856

I have reported before my vehicle is and has been cyber attacked. This time around my horn has been disable. They turn on the radio, they turn on the light lights of the vehicle, they turn on the radio, they turn on the ac/heat control. If I take it in again, they are going to tell me nothing is wrong. This is very dangerous for me as a driver. I cannot drive a vehicle without a horn. I NEVER heard from you guys on the last report I made. Not sure how this one is going to help. This Ford vehicle is dangerous! If you can please assist, I would appreciate it. Thank you!

NHTSA ODI 11571363

The transmission is experiencing intermitnet slipping and hesitation. When attempting to take off at a stop light on an inclined road the car rolled backwards before transmission engaged & I was able to proceed. No warning lights or messages are present.

NHTSA ODI 11571545

Shuttering, shift slipping, wont move

NHTSA ODI 11571309

The contact owns a 2012 Ford Focus. The contact stated that while driving at various speeds, the transmission experienced a loss of motive power, causing the vehicle to decelerate and the vehicle failed to properly accelerate. During the failure the message "Transmission Malfunction, Service Now" was displayed. The cause of the failure was not yet determined, and the vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was approximately 70,000.

NHTSA ODI 11571031

My power steering went out so my rack and pinion needed replaced and my car is only at 85,000 miles. This is a manufacturer error on ford's part and would like it to be looked into.

NHTSA ODI 11569320

While driving vehicle power steering went completely out and warning message displayed. Control of car was difficult due to know power steering. No prior problems with steering before. have not had problem diagnosed as mechanics are all booked weeks out.

NHTSA ODI 11569127

The transmission module, and Transmission. While on freeway with my family car shut off while driving. Yes , Yes , No there were no warning signs until after the jerking and shaking started after 39 days then the engine light came on. After that a that the sign said transmission over heating pull over and let car cool down. what was most scary is that it shut off while driving.

NHTSA ODI 11567854

The contact owns a 2012 Ford Focus. The contact stated that once the fuel level was less than a quarter tank full, the vehicle would begin to hesitate upon the depression of the accelerator pedal. There was no warning light illuminated. Upon investigation, the contact discovered and linked the failure to NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The dealer was notified of the failure and the contact was informed that the vehicle was not included in the recall. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 49,000.

NHTSA ODI 11566078