What 3,789 owners told NHTSA about the 2012 Ford Focus Bev

STARTED MY CAR THIS MORNING AND IMMEDIATELY MY "STEERING REQUIRES ASSIST" ALERT CAME ON AND I FOUND I HAD NO POWER STEERING. MY CAR SHOWED NO SIGNS OF ANY ISSUE WHEN I PARKED IT LAST NIGHT 12/14/16 AROUND 7PM BUT WHEN I WENT TO LEAVE FOR WORK AT 12/15/16 AT 5:30AM THE ALERT CAME ON. I HAD MY CAR TOWED TO THE DEALER AND DEALER HAS INFORMED ME THAT 1) A CAR WITH LESS THAN 70K NEEDS THE ENTIRE STEERING COLUMN REPLACED TO THE TUNE OF $2000 AND 2) THAT THIS FAILURE IS SO COMMONPLACE THEY STOCK THE STEERING ASSEMBLY FOR THIS REPAIR. I'M JUST THANKFUL I WASN'T COMMUTING ON THE INTERSTATE WHEN THIS OCCURRED WHEREAS MANY OTHERS WERE NOT.

NHTSA ODI 10935566

STARTED CAR AND STEERING WHEEL FROZE - POWER STEERING COMPLETELY INCAPACITATED. ERROR NOTIFICATION DISPLAYED "STEERING ASSIST FAULT." I TURNED THE CAR OFF AND WHEN I RESTARTED IT WAS GONE. THIS ALSO HAPPENED A YEAR AGO AND NOW AGAIN INTERMITTENTLY. THIS IS A SAFETY HAZARD THAT HAS BEEN REPORTED BY MANY OTHERS. FORD NEEDS TO RECALL THESE MODELS BEFORE A SERIOUS EVENT HAPPENS.

NHTSA ODI 10934011

AT 49000 MILES GOT " SERVICE POWER STEERING NOW " LIGHT AND STEERING WAS LOCKED UP AT START OF CAR. HAS HAPPENED 4 TIMES IN 8 DAYS AT START UP OF CAR. RESTARTING FIXES STEERING BUT AFRAID PROBLEM WILL ESCALATE AND CAUSE ACCIDENT OR WORSE...PLEASE INVESTIGATE BEFORE SOMEONE IS HURT OR KILLED FROM LOSS OF CONTROL OF STEERING.

NHTSA ODI 10933665

I WAS TURNING INTO MY APT COMPLEX POWE STERLING WENT OUT LIGHT SAID MALFUNCTIONS POWE STEERING. I WAS TRYING TO CONTROL HIT A POLE. SEAT BELT TIGHTEN AROUND MY NECK. I HAD JUST HAD A PROCEDURE DID TWO WEEKS PRYOR INJECTION IN MY NECK WENT TO DOCTOR HE TOLD ME I WAS SO INFORMED HE COULD NOT TELL GAVE ME FIVE DIFFERENT MESS I GO C HIM ON 8TH DEC SHOULD BEEN BACK SOONER I HAVE NO CAR IN SHOP NO MONEY GET IT OUT.

NHTSA ODI 10933741

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 01/31/17*LJ

NHTSA ODI 10930198

DRIVING AT NIGHT ON COUNTY ROAD APPROX 25-30 MPH DRY PAVEMENT WENT TO TURN THE WHEEL OF THE CAR TO FOLLOW THE ROAD AND THERE WAS NO RESPONSE FROM THE STEERING WHEEL OR THE BRAKES. CAR WENT OFF THE ROAD HEADED FOR A TREE. WENT INTO DITCH BEFORE STEERING BECAME AVAILABLE AGAIN. IN INVESTIGATING THIS ISSUE ON MY OWN PRIOR TO TAKING TO DEALER. I HAVE FOUND THIS TO BE AN ISSUE AND EVEN A NOTED INVESTIGATION LISTED OR AWARENESS OF THE HIGHWAY SAFETY ADMINISTRATION. I CAN TELL YOU THERE WAS ABSOLUTELY ZERO CONTROL OF THIS CAR AT THAT TIME. THESE CARS ARE VERY DANGEROUS ON MANY LEVELS AS THEY HAVE MULTIPLE DEFECTIVE PARTS. JUST CALL JIM O'NEAL IN SELLERSBURG INDIANA AS THEY HAVE ALL THE RECORDS OF SHOWING THEY HAVE ALMOST REBUILT MY ENTIRE CAR SINCE I BOUGHT NEW IN 2012. UPON BEING EVALUATED AND DRIVEN, WITH THIS OCCURRING TO THE TECHNICIAN AS WELL AT JIM O'NEAL FORD, IT WAS FOUND THAT THE ENTIRE STEERING COMPONENT HAD FAILED AND NEEDED TO BE REPLACED. FORD IS AWARE OF THIS CONCERN AS THERE HAVE BEEN 2 BULLETINS SENT TO THEIR DEALERSHIP SERVICE DEPARTMENTS. DOCUMENTED IN RESEARCH IF YOU LOOK AND ALSO TOLD TO ME VERBALLY BY [XXX] THE SERVICE MANAGER AT JIM O'NEAL FORD. AT NO TIME IN THE MANY VISITS TO THE REPAIR SHOP AT FORD HAS ANYONE MENTIONED THE FACT THAT THIS COULD POSSIBLY OCCUR OR HAS THERE BEEN ANY PREVENTIVE CHECKS OF THE SYSTEM. I REALLY WOULD LIKE THIS INVESTIGATED AS I DO SEE I AM NOT THE ONLY ONE THAT HAS HAD THIS ISSUE AND WAS JUST LUCKY ENOUGH TO HAVE NOT HAD A SERIOUS ACCIDENT WITH MY CHILDREN IN THE CAR DURING THIS LATEST FAILURE IN THIS CAR. FORD SHOULD BE HELD ACCOUNTABLE FOR PRODUCING AND NOT UPHOLDING THEIR END OF THIS CAR AS PEOPLE ARE BEING SERIOUSLY INJURED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI 10930226

ON FRIDAY, 12/2/16, WHEN PULLING OUT OF ON-STREET PARKING SPACE, WARNING "STEERING ASSIST FAULT SERVICE REQUIRED" CAME ON, AND I COMPLETELY LOST STEERING CONTROL. TURNED OFF CAR, THEN TURNED ON AGAIN, WITH SAME WARNING. CALLED FORD DEALER, WAS TOLD THEY COULDN'T DO ANYTHING TILL MONDAY. HAD TO CALL TOW. AFTER 20 MINUTES, I TRIED CAR AGAIN, AND EVERYTHING WAS FINE. I AM AFRAID TO DRIVE, ESPECIALLY IF MY STEERING GOES OUT AGAIN.

NHTSA ODI 10929925

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE DRIVING 2 MPH, THE POWER STEERING SEIZED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO BE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000.

NHTSA ODI 10929946

NO POWER STEERING AT ALL AFTER STARTING MY CAR. POWER STEERING FAULT ASSIST LIGHT ON DASH WAS ON. VEHICLE WAS PARKED IN MY DRIVEWAY. THE STEERING FAULT ASSIST LIGHT HAD COME ON SEVERAL TIMES A COUPLE OF WEEKS BEFORE WHEN STARTING THE CAR AND I HAD NO POWER STEERING BUT WHEN I TURNED OFF THE IGNITION AND THEN BACK ON SEVERAL TIMES THE POWER STEERING WOULD WORK AND THE STEERING FAULT ASSIST LIGHT WOULD GO OFF. HAD TO HAVE VEHICLE TOWED TO DEALER FOR REPAIR.

NHTSA ODI 10928835

I STARTED GETTING THIS ON SCREEN ERROR "STEERING ASSIST MALFUNCTION" A COUPLE OF MONTHS AGO, BUT IT WOULD DISAPPEAR AFTER A FEW MINUTES. TODAY WHEN I WENT TO START THE CAR THE MESSAGE APPEARED ONLY THIS TIME IT STAYED. I TURNED THE CAR OFF AND BACK ON AND STILL HAD THE ISSUE. I HAD TO DRIVE MY CHILDREN TO SCHOOL WITH NO POWER STEERING. I'M FILING THE COMPLAINT BECAUSE AFTER SEARCHING THE ENTIRE DAY IT TURNS OUT THIS IS A PRETTY COMMON ISSUE WITH THE 2012 FORD FOCUS. SOME DEALERS LIE AND SAY THEY HAVE "NEVER SEEN IT BEFORE." THEY CHARGE ON AVERAGE $1700 TO REPAIR IT. THEY RECALLED SEVERAL OTHER FORD MODELS FROM 2012, BUT NOT THIS ONE. THEY SHOULD HAVE. HAD I ALREADY BEEN DRIVING WITH MY CHILDREN WHEN THIS WENT OUT I WOULD HAVE WRECKED. HAD I NOT DRIVEN AN OLDER CAR THAT DOESN'T HAVE POWER STEERING I PROBABLY WOULDN'T HAVE KNOWN WHAT TO DO OR HOW TO REACT. THIS IS A DANGEROUS ISSUE AND FORD NEEDS TO TAKE RESPONSIBILITY FOR THE PROBLEM. *TR

NHTSA ODI 10928879

POWER STEERING COMPLETELY WENT OUT. ERROR NOTIFICATION ON DASH SAYS "STEERING ASSIST FAULT." THIS WAS AN INTERMITTENT PROBLEM FOR THE LAST COUPLE MONTHS THAT WAS FIXED MY TURNING THE CAR OFF AND RESTARTING IT. BUT IT HAS COMPLETELY GONE OFF AND IT WILL NOT RESET WITH TURNING THE CAR OFF AND ON. REPLACED 80AMP MEGAFUSE THAT OTHERS ONLINE SAID MAY BE THE ISSUE, THIS DID NOT CORRECT THE PROBLEM. MY ONLY OTHER IDEA IS THAT IT IS THE POWER STEERING RACK THAT EVERYONE ELSE ONLINE HAS NEEDED REPLACED.

NHTSA ODI 10928541

RANDOMLY, WHEN STARTING THE CAR, I RECEIVE A STEERING ASSIST FAULT ERROR CAUSING THE STEERING WHEEL TO FREEZE. THE ONLY REMEDY IS TO TURN THE CAR OFF, WAIT A FEW MINUTES, AND RESTART. THE ERROR SHOULD GO AWAY AND THE STEERING WHEEL CAN EASILY MOVE.

NHTSA ODI 10928572

POWER STEERING ASSIST FAULT WHEN DRIVING. NO POWER STEERING AT ALL. DIFFICULT TO DRIVE THE CAR.

NHTSA ODI 10927472

ON A WET PAVEMENT IN THE RAIN WHILE ATTEMPTING TO MAKE A RIGHT TURN INTO A SHOPPING CENTER THE POWER STEERING LOCKED UP AND WOULD NOT TURN OR RESPOND. THE VEHICLE CONTINUED INTO AN ISLAND CURB BREAKING OFF THE FRONT LEFT TIRE CAUSING OVER $4,300.00 IN DAMAGE. THE PROBLEM WITH THE POWER STEERING LOCKING UP DURING WET WEATHER WAS CONFIRMED BY THE REPAIR SHOP. FORD MOTOR COMPANY (CUSTOMER SERVICE) WAS CONTACTED BUT WOULD NOT SEND A REPRESENTATIVE TO LOOK AT THE VEHICLE. THIS ISSUE IS ONGOING AS EVERYONE WHO DRIVES THE VEHICLE HAS EXPERIENCED THE STEERING LOCKING UP DURING WET CONDITIONS. THE VEHICLE ALSO HAS A SHUDDERING ISSUE WHERE THE VEHILCLE BUCKS WHEN MOVING FORWARD.

NHTSA ODI 10925757

POWER STEERING ASSIST FAILED WHILE PULLING OUT OF DRIVEWAY. FORD IS AWARE OF THIS ISSUE AND HAS FAILED TO ISSUE A RECALL ON THIS MODEL, BUT HAS ON OTHER MODELS WITH SAME ISSUE. THERE ARE MANY OTHER COMPLAINTS OF THIS PROBLEM YOU CAN FIND ONLINE, EVEN NEWS ARTICLES ABOUT THIS HAPPENING WITH THIS MODEL. EVEN THE SERVICE TECHNICIANS AT THE FORD DEALER KNEW OF THE PROBLEM.

NHTSA ODI 10925584

WHEN THE CAR IS TURNED ON AND STATIONARY, IT WILL DISPLAY "STEERING ASSIST FAULT," AND THE POWER STEERING WILL NOT TURN ON, GREATLY REDUCING THE CAPACITY TO STEER. UPON TURNING THE CAR OFF AND BACK ON, THE POWER STEERING RE-ENGAGES. IT HAS BEEN DOING THIS FOR ABOUT ONE YEAR NOW.

NHTSA ODI 10925473

CAR HAD BEEN PARKED OVERNIGHT. WENT TO START UP AND THE "FAULTY STEERING ASSIST" WARNING LIGHT CAME ON. I CALLED THE DEALER AND THEY SAID TO CHECK THE BATTERY. TOOK IT TO A MECHANIC AND HE HAD TO REPLACE THE ELECTRONIC STEERING GEAR AND RACK AND PINION. TOTAL COST $2500.

NHTSA ODI 10925503

A FEW DAYS BEFORE INCIDENT THE CAR DEVELOPED A RUBBING NOISE IN THE STEERING COLUMN AND MY FIANCE STATED THAT THE CAR WAS DIFFICULT TO STEER. THINKING IT WAS A POWER STEERING ISSUE - A SERVICE APPOINTMENT WAS SCHEDULED AND I DROVE THE CAR TO THE DEALER AFTER HOURS. THE DISTANCE IS APPROXIMATELY 13 MILES. AFTER ABOUT 10 MILES THE DASH DISPLAY INDICATED A YELLOW DISPLAY STATING "SERVICE STEERING SYSTEM SOON". I CONTINUED TO DEALERSHIP AND ARRIVED JUST BEFORE 7:00 PM. WHEN I TURNED THE CAR INTO A PARKING SPACE NEAR SERVICE THE STEERING COLUMN LOCKED AND BECAME IMMOVABLE AND CAR DISPLAY STATED A RED WARNING BOX " TOTAL STEERING FAILURE - STOP SAFELY" THIS IS THE CONDITION THE SERVICE MANAGER FOUND THE NEXT MORNING. THE CAUSE IS A TOTAL FAILURE OF THE ELECTRONIC STEERING CONTROL MODULE. THE COST TO REPLACE THIS PART IS $2000 AFTER WHICH TIME THE DEALER CAN DIAGNOSE "ANY OF THE OTHER THREE COMMON CAUSES OF STEERING LOSS."

NHTSA ODI 10925788

MAKING A RIGHT HAND TURN IN SILVER LAKE, CA WHEN THE POWER STEERING ASSIST FAILURE LIGHT CAME ON. THE STEERING WHEEL SEEMED TO FREEZE. I WAS ABLE TO PULL OVER BUT WAS DEFINITELY SHAKEN AS I ALMOST HIT SEVERAL CARS. I KNOW THAT IF MY YOUNGER SISTER WAS DRIVING SHE WOULD NOT HAVE KNOWN WHAT TO DO. I TURNED THE CAR OFF AND RESTARTED AND WAS ABLE TO GET HOME. AFTER RESEARCH AND REALIZING THIS IS A COMMON PROBLEM WITH THE 2012 FOCUS NOT SURE WHAT TO DO AND DO NOT HAVE THE ESTIMATED $2,000 TO REPAIR.

NHTSA ODI 10924698

I WOULD LIKE TO REPORT MY STEERING MALFUNCTION ON MY FOCUS HAS GONE OUT...I HAVE SEEN MANY COMPLAINTS ON THE EXACT SAME MODEL AND YEAR ON THIS AND IT'S A PROBLEM THAT NEEDS TO BE RECALLED. MY RECENT EXPERIENCE WITH THIS PROBLEM OCCURRED WHILE I WAS ON THE FREEWAY WITH MY CHILDREN AND IT WAS VERY SCARY THE STEERING WHEEL LOCKED UP AND WAS SO HARD TO STEER IT. THIS IS AN URGENT MATTER THAT NEED TO BE RECALLED.

NHTSA ODI 10924788

AUBURN, ME - WHILE REVERSING OUT OF MY DRIVEWAY THE "AUTO STEERING ASSIST FAILURE" MESSAGE APPEARED AND I LOST POWER STEERING IN THE VEHICLE, STEERING WHEEL WAS ALMOST IMPOSSIBLE TO TURN. LEFT CAR FOR THE EVENING AND STARTED THE CAR AGAIN IN THE MORNING. WARNING MESSAGE DID NOT APPEAR AND POWER STEERING SEEMED TO HAVE RETURNED. I HAD THE CAR TOWED TO THE LOCAL FORD DEALERSHIP. MECHANICS WERE UNABLE TO FIND AN ISSUE OR REPRODUCE IT AFTER HAVING THE VEHICLE FOR THREE DAYS. SITED THAT THEY HAD NOT HEARD OF OR SEEN ANY ISSUES WITH POWER STEERING FAILURES WITH OTHER FORD FOCUS VEHICLES. THE VEHICLE HAS 130K (APRX) MILES. *TR

NHTSA ODI 10924193

THE VEHICLE WAS IN MOTION WHEN A SUDDEN LOSS IN POWER STEERING OCCURRED. A "STEERING ASSIST FAILURE" MESSAGE APPEARED ON THE DISPLAY. THE VEHICLE HAD PREVIOUSLY BEEN CHECKED AT A FACTORY DEALERSHIP FOR THIS ISSUE WHICH APPEARED INTERMITTENTLY AND NO APPARENT PROBLEM WAS FOUND. THE EPAS SYSTEM IS NOW DISABLED FULL TIME AND THE VEHICLE HAS ONLY 26K MILES. IT IS MY UNDERSTANDING THAT FORD IS AWARE OF FAULTY COMPONENTS/ENGINEERING REGARDING THIS PROBLEM BUT REFUSES TO RECALL. A SUDDEN LOSS OF POWER STEERING COULD RESULT IN CATASTROPHIC CONSEQUENCES AND LOSS OF LIFE. COSTLY REPAIRS WOULD NOT SOLVE THE INHERENT PROBLEMS WITH THIS SYSTEM AS IT WOULD BE PRONE TO FAIL AGAIN. PLEASE TAKE ACTION

NHTSA ODI 10924140

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE IDLING AT A STOP SIGN, THE POWER STEERING FAILED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 99,050.

NHTSA ODI 10923883

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE DRIVING 35 MPH, THE POWER STEERING FAILED TO OPERATE AS INTENDED. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, THE STEERING ASSIST SERVICE FAULT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,000.

NHTSA ODI 10920603

ELECTRONIC POWER STEERING SUDDENLY FAILED WHILE TURNING INTO A PARKING AREA. THE WHEEL BECAME SO STIFF THAT IT WAS NEARLY IMPOSSIBLE TO TURN IT. THIS EVENT OCCURRED IN A PARKING LOT AT LOW SPEEDS BUT SOME REPORTS SHOW THAT THIS HAS HAPPENED TO OTHER 2012 FOCUS CARS WHILE DRIVING AT HIGHWAY SPEEDS. *TR

NHTSA ODI 10919389