What 821 owners told NHTSA about the 2012 Ford Explorer Police Intercept

WHILE DRIVING ON A 2-LANE HIGHWAY ABOUT 50 MHP, MY 2012 FORD EXPLORER SUDDENLY LOST ALL SPEED AND THE GAS PEDAL HAD NO EFFECT. AFTER DRIFTING OVER TO THE SHOULDER OUT OF HARMS WAY, THE POWER REMAINED ON AND THE DASHBOARD SAID "CHECK MANUAL" WITH A WRENCH LIT UP. WHAT HAPPENED WAS THAT IT JUST LOST ALL SPEED AND THE GAS PEDAL HAD NO EFFECT UNTIL I TURNED OFF THE POWER AND RE-STARTED. THIS WAS THE FIRST INCIDENT. THIS HAPPENED TWICE MORE IN THE FOLLOWING MONTH FOR A TOTAL OF THREE TIMES WHEN THE EXACT SAME THING HAPPENED, JUST LOST ALL SPEED. FINALLY FORD SERVICE WAS ABLE TO DIAGNOSE IT AND SAID IT WAS THE THROTTLE BODY. AFTER DOING RESEARCH, IT APPEARS THAT OTHER FORD MODELS HAVE THE SAME THROTTLE BODY PROBLEM, LOSS OF SPEED. THIS SHOULD HAVE BEEN A RECALL BUT SOMEONE DROPPED THE BALL, MAKING IT A PART OF THE CUSTOMER SATISFACTION PROGRAM (CSP 13N03) INSTEAD. THIS IS OBVIOUSLY A VERY DANGEROUS SITUATION. FORD SERVICE HAS BEEN EXTREMELY DIFFICULT WORK WITH AS THEY WILL NOT HONOR CSP 13N03 FOR MY EXPLORER.

NHTSA ODI 10750232

I WAS ON A RESIDENTIAL STREET DRIVING 35 MILES AN HOUR WHEN THE CAR SUDDENLY WENT LESS THAN 5 MILES AN HOUR IMMEDIATELY. I DROVE IT OFF TO A SAFE SPOT AND PARKED IT. LUCKILY NO ONE WAS BEHIND MED AND I WAS NOT ON AN INTERSTATE OR HIGHWAY. NO WARNING. IT WOULD NOT GO OVER 5 MILES AN HOUR, EVEN WITH THE ACCELERATOR PUSH ALL THE WAY TO THE FLOOR. I TOOK IT BACK TO THE DEALER, WHERE IT WAS EVALUATED AND I WAS TOLD IT NEEDED AN "UPDATE". NOW, I RECEIVED A LETTER IN THE MAIL FROM FORD AND WAS TOLD THERE IS A RECALL ON THIS CAR'S POWER STEERING UNIT. I AM AFRAID OF NOW DRIVING THE CAR TILL THE ELECTRICAL /COMPUTER SYSTEM IS FULLY TESTED. HOW DO I GET AN ANSWER?

NHTSA ODI 10748883

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V171000 (STRUCTURE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 09/21/15*LJ *CN

NHTSA ODI 10746681

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V171000 (STRUCTURE) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI 10746425

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 75 MPH, A WRENCH WARNING INDICATOR ILLUMINATED. THE VEHICLE LOST POWER AND DECELERATED TO 2 MPH. THE CONTACT MENTIONED THAT A ROARING NOISE EMITTED FROM THE ENGINE BUT WAS ABLE TO MERGE THE VEHICLE TO THE SIDE OF THE ROAD. SHORTLY AFTER, THE VEHICLE RESTARTED AND RESUMED NORMAL OPERATION. DAYS LATER, THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN WAS UNABLE TO REPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 46,000.

NHTSA ODI 10744974

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE DEALER STATED THAT THE FAILURE WAS REFERENCED IN SERVICE BULLETIN NUMBER: 10044523. THE FAILURE ALSO PRODUCED AN AIR TENSIONER CODE, WHICH COULD PREVENT THE AIR BAG TENSIONER FROM TIGHTENING OR THE AIR BAGS FROM DEPLOYING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.

NHTSA ODI 10745057

WE OUR PURCHASED THIS VEHICLE FROM A LOCAL FORD DEALER. OVERALL WE LOVED THE VEHICLE UNTIL WE REALIZED THIS SUV WAS NOT 4 WHEEL OR ALL WHEEL IT WAS JUST A REGULAR VEHICLE. IT HAS 20" INCH WHEELS AND WE CANNOT FIND ALL SEASON TIRES TO FIT THIS VEHICLE. IT WAS THE SCARIEST WINTER OF OUR LIVES!! WE TAKE SMALL CHILDREN TO AND FROM SCHOOL(MENNONITE) AND ALSO HAVE TWO MENTALLY CHALLENGED FOLKS WHO LIVE WITH US AND HAVE TO TRANSPORT THEM TO DR'S APPT FROM TIME TO TIME. WHY ON EARTH WOULD A VEHICLE LIKE THIS BE ORDERED TO BE SOLD IN THIS REGION EQUIPPED WITH THE TIRES IT HAD ON IT. ITS EXTREMELY DANGEROUS IN WINTER CONDITIONS. WE'RE IN OUR LATE 60'S. AND HAD TO LITERALLY PUSH THIS VEHICLE OUT OF OUR DRIVEWAY IN NOTHING BUT A DUSTING OF SNOW!!! ANY TIRE DEALER WE TRIED TO GET TIRES FROM WERE IN TOTAL DISBELIEF THAT ITS AN SUV TYPE VEHICLE WITH NO EXTRA DRIVE CAPABILITIES AND THEY CANNOT FIND TIRES FOR THE 20" RIMS.

NHTSA ODI 10744368

POWER CUT OFF. (GOLDEN WRENCH OF I DONT KNOW WHAT'S WRONG CAME ON) ON 4 LANE HAD TO PULL OVER TO SHOULDER OF ROAD. CUT OFF ENGINE, RESTART, NO LIGHT DROVE TO FORD SHOP MONDAY AND LEFT CAR. SHOP TO CHECK OUT AND GET BACK WITH ME. FRIDAY HAD TO CALL AND SEE IF ANY NEWS OF WHATS WRONG. TOLD AFTER 3 HR RUNAROUND, NEEDS BATTERY AND THROTTLE BODY $ 900.00 +- OUT OF WARRANTY CONSUMER SATISFACTION PROGRAM 13N03

NHTSA ODI 10743324

WHILE DRIVING MY FOR 2012 FORD EXPLORER ECOBOOST 2.0L, ACCELERATING AT APPROX 55MPH UP A HILL, I LOST POWER ON SEVERAL OCCASIONS STARTING ON JULY 11TH. I HAD TO PULL OVER AND DRIVE 10MPH WITH HAZARDS ON. THANKFULLY WAS ABLE TO PULL OVER AND NOT ON THE FREEWAY. MY EXPLORER HAS BEEN AT THE FORD DEALERSHIP NOW FOR THREE DAYS AND THEY STILL DO NOT KNOW WHAT IS WRONG WITH IT, AND NOT ABLE TO FIX IT. I'M ALREADY GOING TO HAVE TO PAY 600 IN LABOR SO FAR AND OVER A 100 FOR A RENTAL AND OF COURSE IT'S NOT UNDER WARRANTY. I BELEIVE THIS IS A HUGE SAFETY ISSUE, SINCE YOU LOOSE ALL POWER. YOU COULD END UP IN A TERRIBLE ACCIDENT IF THIS HAPPENS ON THE FREEWAY.

NHTSA ODI 10734325

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHEN IT RAINED, WATER ENTERED THE VEHICLE FROM THE THIRD ROW PASSENGER SIDE SEAT BELT. THE CONTACT STATED THAT THE INTERIOR WALLS AND THE FLOOR OF THE VEHICLE BECAME WET. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. MA 09/25 UPDATED 11/27/2017*CN

NHTSA ODI 10734380

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND THE SERVICE POWER STEERING WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE STEERING SEIZED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING GEAR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V286000 (STEERING). THE FAILURE MILEAGE WAS 42,000.

NHTSA ODI 10731687

HAD TO HAVE REAR BOTH REAR CALIPERS, ROTORS, AND BRAKE PADS REPLACED BECAUSE CALIPERS WERE HANGING UP CAUSING THE BRAKES TO DRAG. I ALSO NOTICED SMOKE, COULD FEEL HEAT, AND SMELL HOT METAL COMING FROM RIGHT REAR WHEEL ON OR AROUND 6/14/15. I ALSO NOTICED THE SAME ON 6/26/15. DEALERSHIP WHERE I HAD VEHICLE REPAIRED SAID THAT THE LEFT REAR BRAKES PADS WERE WORN OUT, THE RIGHT REAR PADS WERE 2MM FROM BEING WORN OUT. ALSO BOTH ROTORS WERE WARPED AND DISCOLORED. VEHICLE HAS ADVANCETRAC SYSTEM AS STANDARD EQUIPMENT, BECAUSE OF HEAT AND DRAGGING BRAKES, THE SERVICE ADVANCETRAC LIGHT WOULD COME ON WHEN THE ABOVE SITUATION OCCURED. COST OF REPLACEMENT CALIPERS FROM FORD WAS COVERED UNDER THE EXTENDED WARRANTY PURCHASED AT TIME OF VEHICLE PURCHASE. THE ROTORS, PADS, AND INSTALLATION COSTS TOTALED $412.93.

NHTSA ODI 10731626

POWER STEERING FAILED ON INTERSTATE. DRIVER DROVE TO A SAFE PLACE. I MET THEM AND DROVE THE CAR TO A PLACE UNTIL IT COULD BE DRIVEN TO A DEALERSHIP. WHEN I TRIED TO DRIVE IT TO THE DEALERSHIP, VEHICLE WOULD NOT STEER AT ALL. I CALLED A TOW TRUCK. DEALERSHIP TOLD ME THE STEERING GEAR NEEDED REPLACED. THEY SAID IT WASN'T COVERED UNDER THE RECALL. I CALLED FORD CUSTOMER SERVICE AND THEY SAID THE RECALL HAD BEEN PERFORMED AND WAS CLOSED, THEREFORE THE STEERING GEAR WAS NOT COVERED. WHEN THEY PERFORMED THE SOFTWARE UPGRADE FOR THE STEERING I HAD NOT HAD A PROBLEM WITH THE STEERING. I BELIEVE FORD AGREED TO THE RECALL AND PROVIDED THE SOFTWARE UPGRADE TO AVOID FIXING THE REAL PROBLEM, THE STEERING GEAR. IF THE STEERING HAD COMPLETELY LOCKED UP ON MY WIFE, SHE COULD HAVE BEEN INVOLVED IN A VIOLENT ACCIDENT AT 70 MPH. I THINK THE INVESTIGATION SHOULD BE REOPENED ON THE STEERING FAILURE, DUE TO THE FACT PEOPLE COULD BE INJURED OR KILLED IN AN ACCIDENT AND BECAUSE I BELIEVE FORD CHOSE TO MAKE THE LEAST COSTLY REPAIR TO AVOID CORRECTING THE PROBLEM. I AM NOT THE ONLY PERSON THAT HAS HAD THIS PROBLEM. I HAVE SEEN MULTIPLE POSTS WHERE FORD DID THE SAME THING TO OTHER OWNERS WITH THIS PROBLEM. IT IS OBVIOUS THE COST DIFFERENCE BETWEEN A SOFTWARE "FIX" AND THE STEERING GEAR REPLACEMENT AT A COST OF OVER $1,500.00 WOULD BE THE DESIRED FIX FOR FORD. THE SAFETY FIX WOULD BE REPLACEMENT OF THE STEERING GEAR. I BELIEVE YOU SHOULD INVESTIGATE ANY ACCIDENTS THAT MAY HAVE OCCURRED DUE TO THIS DEFECT AND MAY NOT HAVE BEEN INVESTIGATED DUE TO EXTENSIVE FRONT END DAMAGE. I COULD NOT STEER THE VEHICLE AT ALL, WHEN I WANTED TO DRIVE IT TO THE DEALER. THIS WAS WITNESSED BY RELATIVES AND THE TOW TRUCK DRIVER. I DON'T THINK FORD SHOULD BE ABLE TO OFFER A "SOFTWARE FIX" TO A PROBLEM THAT IS NOT FIXED BY THE SOFTWARE UPGRADE. THANK YOU FOR ALL YOU DO. *TR

NHTSA ODI 10731380

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE WINDOW GUARD ON THE FRONT PASSENGER WINDSHIELD DETACHED. THE VEHICLE WAS TAKEN DEALER WHERE IT WAS DIAGNOSED THAT THE WINDOW GUARD PART NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED ON THE THIRD OCCASION BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 49,000. UPDATED 09/03/15*LJ THE CONSUMER STATED THE MANUFACTURER WAS NOTIFIED TWICE AND NO ASSISTANCE WAS OFFERED. THE FAILURE HAS OCCURRED ON BOTH THE PASSENGER'S SIDE AND DRIVER'S SIDE OF THE VEHICLE. UPDATED 12/16/2015 *JS

NHTSA ODI 10730879

ON 6/23/2015 MY WIFE BROUGHT HER 2012 FORD EXPLORER TO ME STATING IT WAS VERY HARD TO STEER. BY THE TIME I LEFT WORK AT 6PM, THE HIXSON FORD DEALERSHIP WAS CLOSED. THE NEXT MORNING, WHILE ON THE WAY TO THE FORD DEALERSHIP AND WHILE GOING AROUND A LONG CURVE ON HWY 546, THE STEERING WHEEL TOTALLY LOCKED UP CAUSING ME TO BE WITHIN INCHES OF HITTING AN ON-COMING CAR IN THE CURVE. JERKING THE WHEEL IN THE OPPOSITE DIRECTION THAT I WAS TURNING IN THE CURVE AND THEN BACK UNLOCKED IT AND ENABLED ME TO GET BACK IN MY LANE. FORD STATES THAT THEY HAD ALREADY "REPROGRAMMED THE PSCM POWER STEERING CONTROL MODULE" LAST JULY SO THEREFORE THE "RECALL" FOR THIS ISSUE (#14S06) HAS ALREADY BEEN CLEARED FOR THIS PARTICULAR VEHICLE. WHETHER FORD ALREADY REPROGRAMMED THE PSCM OR NOT, THE ISSUE WHICH THE RECALL WAS ISSUED "POWER STEERING MAY LOCK UP" HAS HAPPENED. MY POSITION IS THAT "REPROGRAMMING" OR UPDATING THE SOFTWARE IS NOT GOING TO FIX A FAULTY SENSOR WHICH IS A PART OF THE STEERING GEAR SO THE "ALTERNATIVE" RECALL FIX SHOULD HAVE BEEN COMPLETED IN THE FIRST PLACE WHICH IS "REPLACING THE STEERING GEAR". HIXSON WANTS $1,795 TO REPLACE THE ELECTRONIC STEERING GEAR. THE FAULTY SENSOR CANNOT BE REPLACED BECAUSE IT'S APPARENTLY BUILT INTO THE STEERING GEAR. THIS RECALL ISSUE SHOULD BE PAID FOR BY FORD WHO HAS ALREADY ADMITTED TO A FAULTY SENSOR. IM NOW ON MY 6TH DAY OF A RENTAL CAR.

NHTSA ODI 10731049

STEERING MAKING CLUNKING NOISE WHEN YOU TURN STEERING LEFT TO RIGHT MOST OF THE TIME TO THE RIGHT

NHTSA ODI 10730858

WHEN TURNING STEERING WHEEL LEFT TO RIGHT IT MAKES CLUNKING SOUND SOUND COMES FROM UNDER CAR MOST OF THE TIME TO THE RIGHT

NHTSA ODI 10730859

DRIVING TO WORK AT THE NORMAL SPEED LIMIT 6:30 AM IN LIGHT TRAFFIC. AMBIENT TEMPERATURE WAS 65 DEGREES IN DRY CONDITIONS. SUDDENLY FELT LIKE THE TRANSMISSION HAD BEEN PLACED IN NEUTRAL. ENGINE CONTINUED TO RUN BUT NO POWER TO THE TRANSMISSION. WAS ABLE TO LET THE CAR COAST UNTIL I COULD TURN ON TO A SIDE STREET AND STOP. AN ERROR CONDITION DISPLAYED "AWD OFF" AND THEN A WRENCH ICON APPEARED. I PLACED THE TRANSMISSION IN PARK AND TURNED OFF THE ENGINE. RESTARTED THE ENGINE AND THE CAR RESUMED NORMAL DRIVING CONDITIONS. TOOK THE CAR THE NEXT DAY TO THE FORD DEALERSHIP. WAS TOLD THAT NO ERROR CODE WAS CAPTURED SO THEY COULD NOT DO ANYTHING. I ASKED HOW IT WAS THAT THE COMPUTER COULD DISPLAY THE "AWD OFF" MESSAGE AND THE WRENCH ICON WITHOUT A CODE BEING STORED. NO RESPONSE. WAS TOLD TO LEAVE CAR RUNNING NEXT TIME, CALL A TOW TRUCK AND THEN THEY COULD GET THE CODE. OF COURSE, I AM NOT ALWAYS CLOSE TO THE DEALERSHIP, IT COULD HAPPEN AFTER THEY CLOSED OR ON A WEEKEND. NOTED THAT IN MARCH 2014 FORD SETTLED A COMPLAINT ON "THROTTLE BODY" PROBLEMS IN ESCAPE, FUSION, ETC, THAT HAD A SIMILAR DESCRIPTION. EXPLORER WAS NOT INCLUDED IN THAT SETTLEMENT. *TR

NHTSA ODI 10730371

I FIRST ENCOUNTERED THE PROBLEM ON MONDAY JUNE 08, 2015 AS I WAS DRIVING TO WORK AT THE TRAFFIC LIGHT ALL OF A SUDDEN THE STEERING WAS REALLY HARD TO STEER AS I WAS TRYING TO MAKE A LEFT TURN I HAD TO USE ALL OF MIGHT TO MAKE THE TURN VERY SCARY. I WAS ABLE TO DRIVE MY CAR HOME AFTER WORK THAT NIGHT, EVERYTHING OKAY TILL WEDNESDAY, JUNE 10, 2015 @ 7-8AM, DRIVING TO DROP MY KIDS OFF TO SCHOOL AND WORK, AS I WAS A MAKING A LEFT TURN IT HAPPENED AGAIN, BUT WORST IT WAS BUSIER DAY, 2 ERROR MESSAGE CAME ON ABOUT STEERING ASSIST AND TRAC ADVANCE MESSAGE, AND 2 LIGHTS CAME ON DASHBOARD WITH A CAR AND 2 WAVY LINES (ROAD) 2ND PICTURE WAS THE SAME WITH THE WORD OFF. I HAD TO USE ALL MY MIGHT AND DRIVE SLOW TO TURN INTO THE SCHOOL TURNED THE CAR OFF AND ON HOPING LIGHTS WILL GO OFF, STILL THE SAME CALL MY BOSS LET HER MY CAR ISSUES AND THAT IM RUNNING LATE. I CALLED FORD SERVICE DEPT, I WAS TOLD TO THE BRING CAR IN IMMEDIATELY NOT SAFE TO DRIVE BUT IT WILL COST ME TO TOW CAR. I DROVE CAR IN THAT NIGHT MYSELF, THURSDAY PICK UP RENTAL, FRIDAY -06/12/15, I RECEIVED A CALL FROM FORD SAYING PART WILL COST ME 1500.00- 2000.00, NOT INCLUDING LABOR. OUTRAGEOUS ITS A ELECTRICAL PROBLEM FORD SHOULD FIX IT FREE, BUT NO PER REP, LET HIM KNOW WHAT I WANT TO DO ON MONDAY RENTAL WILL BE ON MY OWN AFTER THAT. WOW, FIRST MY RENTAL I HAVE TO PAY FOR UPGRADE IT WAS NOT SAME SIZE AS MY VEHICLE, FAMILY OF 6(INCLUDING MY BLIND, DISABLED WHEELCHAIR FATHER) WHO WE CARE FOR, FORD STILL WONT COVER FOR A CAR SAME SIZE AS MY CAR. I WAS TOLD I NEED TO TAKE CARE OF THE DIFFERENCE FOR RENTAL UPGRADE IF I WANT A BIGGER CAR. SO, IVE DECIDED I DONT HAVE THAT KIND OF MONEY SO I WILL PICK MY CAR UP ON MONDAY, JUNE 15, 2015 AND HOPE AND PRAY THAT I WONT GET INTO AN ACCIDENT BECAUSE FORD WILL NOT WORK ME. MY OPTION IS TO TRADE MY CAR IN FOR ANOTHER CAR AND SPEND MORE MONEY. VERY DISAPPOINTED IN FORD!!!!!

NHTSA ODI 10725173

ON MY WAY TO WORK THE SERVICE POWER STEERING LIGHT CAME ON IN MY 2012 FORD EXPLORER. WHEN I GOT WORK I CALLED THE FORD DEALER THEY SAID BRING THE VEHICLE IN THE STEERING COULD GO OUT. LATER THE SAME DAY I TOOK IT TO THE DEALER AND THE STEERING WENT OUT IN THE 2.5 MILE TRIP TO GET TO THERE. I WAS GOING VERY SLOW AND MANAGED TO MAINTAIN CONTROL OF THE CAR, IT WAS DIFFICULT AND SCARY, NO HYDRAULICS ANY MORE THESE SYSTEMS ARE ALL ELECTRONIC. THE DEALER HAS HAD THE VEHICLE FOR A WEEK AND HAS NOT BEEN ABLE TO RECREATE OR DIAGNOSIS WHAT'S WRONG AND THEREFORE HOW TO FIX IT. FORD HAS BEEN ABSOLUTELY NO HELP WILL NOT RETURN PHONE CALLS, NOTHING. SO TODAY THEY STOP THE CAR RENTAL COVERAGE AND SHOVE AN UNDIAGNOSED SAFELY ISSUE BACK ON ME. I REALLY DO NOT WANT TO DRIVE THIS VEHICLE NOT KNOWING IF THE STEERING MIGHT GO OUT AT ANY TIME. I FOUND ON THE INTERNET THERE HAVE BEEN STEERING RECALLS ON THIS VEHICLE MAKE, MODEL AND YEAR, BUT APPARENTLY ONLY THOSE ASSEMBLED IN CHICAGO. FORD HAS NOT ISSUED A RECALL ON THIS VEHICLE.

NHTSA ODI 10722941

I AM UNABLE TO ENTER THE DATE OF 5/29/2015 WHICH WAS THE DATE THIS OCCURRED. THE CAR WAS DRIVING GOOD AND I STOPPED TO SHOP. I CAME BACK TO THE CAR, CRANKED THE CAR AND IMMEDIATELY RECEIVED THE MESSAGE OF POWER ASSIST FAILURE. I TRIED TO BACK UP AND REALIZED THAT I HAD NO POWER STEERING. I WAS ABLE TO GET TO A PARKING SPOT AND CHECKED THE SERVICE MANUAL. I FOLLOWED THE INSTRUCTIONS AND HOPED THAT THE POWER STEERING WOULD RESET AS WAS TOLD IN THE OWNER'S MANUAL. I WAS ABLE TO DRIVE SLOWLY AND GET HOME. TODAY I TOOK MY CAR TO HIXSON FORD, MONROE, LA AND HAD IT CHECKED. AT THIS POINT I WAS RECEIVING AN ADDITIONAL ERROR MESSAGES RELATED TO TRACTION. ALSO, MY SIGNAL LIGHTS WOULD NOT WORK. I HAD READ LAST NIGHT THAT THERE WERE SOME RECALLS ON THIS PROBLEM RELATED TO FORD EXPLORERS. THE TECHNICIAN CHECKED MY CAR AND TOLD ME WE WOULD HAVE TO REPLACE THE STEERING SHAFT/GEARS FOR $1,794.00. I HAD TO LEAVE MY CAR AT THE DEALERSHIP BECAUSE IT IS NOT DRIVEABLE. I WOULD LIKE FOR YOU TO CHECK AND SEE IF THIS IS AN ON-GOING PROBLEM FOR CARS WITH VIN NUMBERS NOT INCLUDED IN THE RECALL. I WAS TOLD THE RECALL WAS BASED ON WHERE THE CAR WAS MANUFACTURED. IT APPEARS TO ME THAT FORD HAS CONSISTENTLY HAD A PROBLEM WITH THE POWER ASSIST FAILURE ON 2012 FORD EXPLORERS.

NHTSA ODI 10722436

I WENT TO CRANK MY CAR AND WHEN I DID I IMMEDIATELY RECEIVED A POWER STEER FAIL ASSIST NOTICE. MY CAR HAD NO POWER STEERING. I WAS ABLE TO SLOWLY DRIVE TO A PARKING SPACE AND REVIEW MY OWNER'S MANUAL. I LET THE CAR SET FOR 10 SECONDS AND THEN CRANKED AGAIN IN HOPES THAT IT WOULD RESET. IT DIDN'T. I WAS ABLE TO DRIVE HOME AND PARK THE CAR. THIS MORNING I TOOK THE CAR TO HIXSON FORD IN MONROE, LA. BY THAT TIME I HAD RECEIVED A TRACTION ERROR ON THE DASHBOARD AND ALSO WAS UNABLE TO USE MY SIGNAL LIGHT. I WAS TOLD ALL OF THIS WAS IN RELATION TO THE POWER STEERING AND THE NEED TO REPLACE THE STEERING COLUMN FOR A PRICE OF $1794.00. IT APPEARS THAT FORD IS VERY AWARE OF THE PROBLEMS OF THE POWER STEERING FAILURE. WHY HASN'T THERE BEEN A LARGER RECALL? MY CAR IS NOT ONE OF THE 2012 MODELS THAT WAS RECALLED. JUST OUT OF WARRANTY AND THEN THIS. I THINK FURTHER INVESTIGATION IS NEEDED IN THE PROBLEMS WITH THE POWER STEER FAILURE.

NHTSA ODI 10722439

STARTED CAR AND POWER STEERING ASSIST FAILURE WARNING CAME ON. YOU COULD NOT STEER AT ALL. HAD TO TURN CAR OFF AND ON A COUPLE TIMES TO GET COMPUTER TO RESET. CARS 3 YRS OLD JUST OUT OF WARRANTY AND FORD WON'T COVER IT EVEN THOUGH STEERING COULD LOCK UP AS YOUR DRIVING.

NHTSA ODI 10721807

I PARKED THE VEHICLE TO GO INTO A STORE. WHEN I RETURNED AND STARTED THE VEHICLE. I HAD THE POWER ASSIST FAULT AND SERVICE TRACK MANAGEMENT ERRORS SHOW ON THE PANEL. I HAD TO DRIVE THE CAR HOME WITHOUT POWER STEERING. I TOOK THE CAR IN FOR SERVICE YESTERDAY AND WAS TOLD THAT IT NEEDED A STEERING GEAR. I WAS UNDER THE IMPRESSION THAT THIS WOULD BE PART OF THE POWER STEERING RECALL ISSUED LAST YEAR, HOWEVER THAT IS NOT THE CASE. I WAS TOLD BY THE SERVICE TECH THAT HE TRIED TO CONTACT FORD TO SEE IF THEY WOULD WORK WITH ME ON THIS AND THEY STATED THERE WAS NOTHING THEY COULD DO. SO I BROUGHT THE CAR HOME WITHOUT REPAIR OR NEW PARTS ORDERED DUE TO THE COSTLINESS OF THIS ISSUE. IT APPEARS THAT I AM NOT THE ONLY ONE HAVING THIS POTENTIALLY DANGEROUS ISSUE WITH THEIR VEHICLE. AT THIS POINT, I AM QUITE DISAPPOINTED WITH FORD!!

NHTSA ODI 10720981

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE FUEL PUMP FAILED. THE DEALER STATED THAT THE FUEL PUMP WAS ON NATIONAL BACK ORDER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000.

NHTSA ODI 10716231