What 904 owners told NHTSA about the 2012 Chevrolet Malibu Hybrid

The brake caplier screw came out why driving the vehicle and broke the brake line and the vehicle lost control try to use the emergency brake and it didn't work vehicle crash

NHTSA ODI 11703616

I bought the car a year ago from a used car lot. Replaced the cam shaft positioning sensor as per diagnostic reading for check engine light. Since then, svc air bag light has stayed on. Traction control light stays on and is disengaged. When braking ESC warning goes on and off and sliding occurs. The low beam headlights go on and off intermittently and no way of knowing when it will happen. When turning cruise control on or off, the car will accelerate on its own and will increase speed until brake is applied. Regardless of whether cruise control was turned on or off. I have had it looked at at my local Mr.Tire and they cannot figure out what is happening.

NHTSA ODI 11442865

I have a 2012 Chevy Malibu i bought it in 2014. I have had the Esc light come on in 2016 but no problem with it untill now of this year in 2022. Not knowing the problem i have already put ALOT into it. I took it to a machanic they told me it was the rack and pinion. So got that done . Apparently it wasn't it took it to another machanic they told me it was struts got that done too n still nothing so i looked it up online got CV joint, inner ,tie rod, wheel alignment. All those done n still nothing fix it. I didn't know what else to do until i made more scratch on my vehicle and i found that it could be a recall .

NHTSA ODI 11429076

GM Tech Bulletins say there is a Ghost Problem with Elect. Stability Controller. GM mentions there is no recall or known cure for this. .Components/contacts were cleaned at service shop but " Serv. ESC-ESC OFF" keeps appearing in "driver display" when hitting bumps -turning car.. i will mail service sheets. This option was available on 08-09-10 models of Malibu but Std. on my 2012 car. It is worthless when there is thick snow.. I will send , by mail, serv. records on this unsolvable problem... It continues to happen ,at slow speed - not just one time...I believe YOU can read the G.M.-TSBs, as it was shown to me.... Consumer stated it showed a bad steering column multi switch & Yaw sensor unit , part still available.. Unit fires off bad code when barely moving and turning to right... Unit gets damp and works for a while. Turns out: Plastic Yaw coil in steering column broke up against the shaft, and the multi reed switch is probably bad, in there. The consumer stated after a new multi switch was installed, the bracket of the plastic broke again.

NHTSA ODI 11424228

THE CENTER BRAKE LIGHT DOESN'T WORK. I PUT IN A NEW LED LIGHT ASSEMBLY IN AND IT STILL DOESN'T WORK.

NHTSA ODI 11415495

I BROUGHT MY VEHICLE INTO A CHEVROLET CENTER NEAR ME TO HAVE A 'MANUFACTURERS WARRANTY FIX' DONE TO MY VEHICLE ON 04/17/2021, AS THE POWER STEERING HAD FAILED AND I WAS ABLE TO GET THIS FIXED FOR FREE. WHEN I TURNED MY VEHICLE ON AND NOTICED THE POWER STEERING NOTIFICATION ON MY DASH, I TRIED TO BACK MY CAR OUT OF WHERE I WAS PARKED AND MOVE MY WHEEL, BUT COULD NOT MOVE THE WHEEL. WHEN THE PART WAS REPLACED, I WAS TOLD THAT THERE WERE STILL SENSORS ON MY DASH INDICATING THAT I NEEDED THE ESC AND STABILITY TRACTION CONTROL SERVICED FOR MY CAR. ACCORDING TO THE CHEVROLET DEALERSHIP, THIS HAD 'NOTHING TO DO WITH THE SPECIAL POLICY FIX' AND NOT SOMETHING THEY WOULD BE FIXING FOR ME. AFTER CHECKING THE NHTSA.GOV FOR ANY RECALLS ON MY 2012 CHEVY MALIBU, I FOUND ONE FROM MAY 2014 THAT DESCRIBED EXACTLY THE PROBLEM I WAS HAVING WITH MY VEHICLE: LOSS OF VEHICLE STABILITY TRACTION CONTROL, CRUISE CONTROL AND RANDOM ILLUMINATION OF BRAKE LIGHTS. I CONTACTED CHEVY ONCE AGAIN ABOUT THIS RECALL, TO WHICH THEY SAID THERE 'WAS NO RECALL FOR THE VEHICLE, AND IF THERE WAS IT WAS ALREADY FIXED'. NOT ONLY WAS THIS COMPLETELY UNPROFESSIONAL AND LACKING CONCERN OF SAFETY FOR MY CHILD AND I, I DO NOT KNOW WHERE TO TURN TO FOR THIS TO BE REMEDIED. ATTACHED IS THE TICKET FOR THE INITIAL FIX I HAD DONE.

NHTSA ODI 11414319

THE CAR HAD GM SERVICE BULLETIN 13036 (RECALL CAMPAIGN 14V252) PERFORMED ON SEPTEMBER 19, 2014 AND THE CAR IS EXPERIENCING THE EXACT SAME CONDITIONS AS DESCRIBED IN THE SERVICE BULLETIN[1] SO THE "FIX" DIDN'T RESOLVE WHAT IS NOW AN ON GOING SAFETY ISSUE. IT SHOULD BE NOTED IN THE RECALL "WHY" SECTION TO OWNERS THE USE OF "...OVER TIME...". THEREFORE, THE ISSUE IS KNOWN TO BE TIME DEPENDENT AND THE FIX DOESN'T APPEAR TO FULLY RESOLVE THE ISSUE INTO THE FUTURE. 1: WE ARE CURRENTLY SEEING THE FOLLOWING CONDITIONS: - SERVICE BRAKE LAMPS MAY NOT ILLUMINATE WHEN THE SERVICE BRAKES ARE BEING APPLIED. - IF CRUISE CONTROL IS ENGAGED, ADDITIONAL SERVICE BRAKE PEDAL TRAVEL MAY BE REQUIRED TO DISENGAGE IT. - TRACTION CONTROL, ELECTRONIC STABILITY CONTROL, AND PANIC BRAKING ASSIST FEATURES, IF EQUIPPED, MAY BE DISABLED. - SERVICE ESC AND/OR TRACTION CONTROL TELL-TALES MAY ILLUMINATE WITH THIS CONDITION.

NHTSA ODI 11406752

SINCE BUYING THIS VEHICLE, I'VE HAD TROUBLE WITH THE BRAKES, AIRBAG SENSORS, ELECTRICAL PROBLEMS, SEATBELT ISSUES AND ALSO THE AIRBAG LIGHT, HAD A MECHANIC REPLACE THE AIRBAG SENSORS IN THE REAR, BUT THE LIGHT STILL COMES ON. THE BRAKES ARE NOW SHUTTERING WORSE WHEN I APPLY THE BRAKES AND IT FEELS LIKE THE WHEELS ARE GOING TO FALL APART. *TR

NHTSA ODI 11329120

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING 70 MPH, THE VEHICLE EXPERIENCED ACCELERATION FAILURE AND STALLED. IN ADDITION, THE GEAR HAD A DIFFICULT TIME SHIFTING FROM PARK INTO REVERSE OR DRIVE WHEN ATTEMPTING TO MOVE OUT OF A PARKED POSITION. THE VEHICLE WAS TAKEN TO BERGSTROM CHEVROLET OF MADISON (1345 APPLEGATE RD, MADISON, WI 53713, (608) 271-2212) WHERE IT WAS DIAGNOSED THAT THE BODY CONTROL MODULE AND AN ELECTRIC BRAKE CONTROL MODULE NEEDED TO BE INSTALLED. IN ADDITION, A REAR PASSENGER SIDE WHEEL SPEED SENSOR ALTERNATOR CIRCUIT NEEDED TO BE INSTALLED. THE VEHICLE REMAINED AT THE DEALER SINCE JULY 16, 2019 AND THE CONTACT WAS INFORMED THAT THE REPAIR WOULD COST $2,700. THE MANUFACTURER PROVIDED A CASE NUMBER AND REFERRED THE CONTACT TO A MANAGER. THE CONTACT HAD NOT YET SPOKEN WITH THE MANAGER. THE CONTACT WAS TRYING TO FIND OUT WHAT REPAIRS WERE COMPLETED BY THE PREVIOUS OWNER AND WAS CONCERNED THAT THE REPAIRS WERE NOT DONE PROPERLY. THE DEALER COULD NOT PROVIDE A SERVICE REPAIR HISTORY FOR THE VEHICLE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI 11241350

TAKATA RECALL WHEN I'M DRIVING MY VEHICLE, THE HEADLIGHTS FLICKER AS IF I'M THE POLICE. I TOOK IT TO FIRESTONE AND THEY TOLD ME TO TAKE IT TO A DEALER THE CAR ONLY HAS 160,000+ AND IT JUST STARTED EVERY TIME I ACCELERATE OR DRIVE IT DOES THIS AND I'M AFRAID THAT I WILL EITHER GET PULLED OVER BY THE POLICE, HIT SOMEONE OR SOMEONE HITS ME OR/AND THE LIGHTS GO COMPLETELY OUT WHILE DRIVING AT NIGHT. IS THIS DUE BECAUSE WHENEVER YOU HAVE TO CHANGE THE BUILD, THE WHOLE BUMPER HAS TO COME OFF TO REPLACE IT? I LIKE MY CAR BUT THIS IS A SERIOUS ISSUE THAT NEEDS TO BE ADDRESSED. I SEE A LOT OF COMPLAINTS REGARDING THIS

NHTSA ODI 11240284

"TAKATA RECALL" IF I HIT A BUMP SMALL OR ANY SIZE ACTUALLY MY ENGINE REDUCES AND I HAVE TO PULL OVER...AND TURN THE CAR OFF FOR UP TO 10 MINS SOMETIMES... I CANT DRIVE ON THE FREEWAY AT ALL BECAUSE I DONT WANT THE ENGINE TO REDUCE WHILE DOING 60 MPH LATELY IT WILL GO INTO ENGINE POWER REDUCE WHILE IM PARKED IN A DRIVEWAY SO I DONT GET IT

NHTSA ODI 11183915

WARNING ON DASHBOARD SERVICE TRACTION CONTROL WHEN APPLYING THE BRAKES. BRAKE LIGHTS DOES NOT COME ON WHEN THE SERVICE TRACTION CONTROL COME ON. THERE HAS BEEN A RECALL ON THIS ISSUE PREVIOUSLY AND ISSUE STILL OCCURRING.

NHTSA ODI 11183608

THE LIGHTS RANDOMLY COME ON THEN THE ANTILOCK BRAKE SYSTEM WILL START TO ACT UP WHEN I GO TO STOP AS IF I WAS TO SLIDE ON ICE BUT I'M NOT I'M ON DRY PAVEMENT. ON CITY STREET.

NHTSA ODI 11182113

ESC & TRACTION CONTROL WARNING LIGHT COMES ON WHEN THE VEHICLE COMES TO A STOP,BUT GOES AWAY AFTER 15 MPH ALSO ROUGH IDLING .ANTI LOCK BRAKES DISENGAGE NOT WORKING AT ALL.ENGINE DISABLED WARNING LIGHT CAR WON'T START.AFTER A SHORT WHILE IT WILL START

NHTSA ODI 11172308

THE CAR TELLS ME TO SERVICE ESC AND TO SERVICE TRACTION. WHEN THE CAR IS IN CRUISE CONTROL THE BRAKE DOES NOT DISENGAGE CRUISE CONTROL.

NHTSA ODI 11115300

P2138 THROTTLE/ PEDAL POSITION SENSOR SECOND TIME SAME PROBLEM THE POWER WAS REDUCE WHEN I WAS DRIVING IN THE HIGHWAY.

NHTSA ODI 11113693

I'M HAVING PROBLEM WITH BRAKE PEDAL SENSOR - REPLACED TWICE ALREADY - WHILE DRIVING HIT BRAKES ERROR MESSAGE SERVICE ABS SERVICE TRACTION CRUISE CONTROL WANT DISENGAGE ALSO NOTICED THAT I COULD MOVE THE GEAR OUT OF PARK WITH OUT PUSHING THE BRAKE PEDAL ARE THERE ANY RECALLS FOR THESE ISSUES?

NHTSA ODI 11104223

THE CHECK ENGINE LINE AND SERVICE TRACTION LIGHT CONTINUES TO COME ON. MY CAR WAS SERVICED BY 2 CHEVROLET DEALERSHIP AND ANOTHER DEALERSHIP AND THEY PROBLEM HAS NOT BEEN FIXED. I WAS TOLD IT WAS THE COILS BY MANASSAS CHEVROLET AND LINDSEY CHEVROLET . THE COILS, SPARK PLUGS AND CARBON BLOW OUT WAS COMPLETED. THE LIGHTS CONTINUE TO COME ON. IT APPEARS TO BE THE SAME ISSUE THAT THE 2009 MALIBU WAS RECALLED FOR. PLEASE MAKE CHEVROLET COMPLETE A RECALL ON THESE VEHICLES BEFORE SOMEONE IS SERIOUSLY ENGINEERED. ONE DEALERSHIP SAID THE ENGINES MAY BE BAD IN THESE CARS. THE CAR DRIVES ROUGH AND THE SERVICE TRACTION LIGHT COMES ON WHEN YOU BRAKE. THE CHECK ENGINE LIGHT STAYS ON AT ALL TIMES.

NHTSA ODI 11081322

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS APPLIED, BUT THE VEHICLE FAILED TO RESPOND. THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WITHOUT WARNING. THE CONTACT CRASHED INTO THE REAR OF A NISSAN TITAN. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: 8-3918629379. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

NHTSA ODI 11075305

2012 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO MULTIPLE SAFETY DEFECTS WITH VEHICLE. *LD THE CONSUMER STATED THE VEHICLE HAS SEVERAL SAFETY DEFECTS INCLUDING THE ELECTRIC STABILITY CONTROL, BRAKES, SENSOR LIGHTS, STEERING, SUSPENSION, WHEELS, ENGINE LIGHTS, POWER TRAIN. UPDATED 10/23/2017*JS

NHTSA ODI 11035054

ALL LIGHTS ON THE DASH BOARD HAD BRAKE PADS INSTALLED VEHICLE MAKING NOISE WHILE DRIVING VEHICLE PULLING TO THE RIGHT, HAD THREE SENSORS REPLACED DASH BOARD LIGHT STILL ON05

NHTSA ODI 11030246

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. AFTER DRIVING VARIOUS SPEEDS AND DEPRESSING THE BRAKE PEDAL, THE ENTIRE INSTRUMENT PANEL ILLUMINATED AND FLASHED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACTED CALLED AN UNKNOWN DEALER WHO STATED THAT THE BCM BRAKE SENSOR MODULE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE PART WOULD BE REPLACED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

NHTSA ODI 11004034

TRAVELING ABOUT 40 MILES PER HOUR ON I-17 SB IN PHOENIX. VEHICLE IN FRONT OF ME HIT BRAKES SUDDENLY. WHEN I SLAMMED ON MY BRAKES,IT DIDN'T FEEL LIKE MY BRAKES WERE WORKING PROPERLY. BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR, DIDN'T SEEM TO BE STOPPING CAR. FELT LIKE THERE WAS AN ISSUE WITH THE BRAKES.

NHTSA ODI 11002836

"SERVICE ESC" LIGHT ILLUMINATES WHEN MAKING SHARP TURNS, SLOWING DOWN ON THE INTERSTATE, AS WELL AS BREAKING IN BAD WEATHER. AFTER REPLACING BRAKES TWICE AND ROTORS ONCE I SCONTINUE TO EXPERIENCE THIS PROBLEM . AFTER A RECENT INQUIRY I LEARNED OF A RECALL ON "SERVICE ESC" AS WELL AS "TRACTION CONTROL".

NHTSA ODI 11001410

I RECIEVED A NOTICE FROM GMCONCERNING THE BODY CONTROL MODULE (BCM) WARNING ME THAT MY BRAKE LIGHTS COULD MALFUNCTION, BUT WARNING ME NOT TO TAKE MY CAR TO THE DEALER BECAUSE OF THIS WARNING. NOW I HAVE TALKED TO AN INSURANCE REPRESENTATIVE A MEMBER OF MY FAMILY WHO HAPPENS TO BE A LAWYER ALSO A MEMBER OF THE POLICE DEPT AND I HAVE BEEN TOLD THAT SINCE I GOT THOIS WARNING THAT MAKES ME AWARE OF A SERIOUS, DANGEROUS AND POSSIBLY A DEADLY DEFECT IN THIS AUTOMOBILE, THEREFORE IF I WAS IN AN ACCIDENT AND SOME BODY GOT KILLED, NOT ONLY WOULD IT BE MY FAULT, BUT IN FACT I WOULD AND/OR COPULD BE CHARGED AND FOUND RESPONSIBLE AND CHARGED WITH THAT DEATH. NOT ONLY THAT, BUT IN FACT MY INSURANCE COMPANY COULD LEAGALLY AND THEREFORE WOULD POSSIBLY PAY FFOR ANY DAMAGES PERIOD. NOW, SINCE I HAVE HAD THIS CAR, I HAVE RECIEVED A SIMALIAR NOTICE ABOUT THE STEERING MACHANISM ON THIS CAR TO WHICH I WAS TOLD THE SAME THING, A RECALL ON THE SEAT BELTS, A NOTICE ABOUT THE HEADLIGHTS ON THIS CAR AND IF I AM NOT MISTAKEN AN EARLIER NOTICE ABOUT TO HEADLIGHTS. SO EVERYTIME I DRIVE THIS CAR, I AM NOT SURE THAT I WILL ACCIDENTLY HAVE A WRECK,KILL SOMEONE OR EVEN BE KILLED MYSELF; I HAVE CONTACTED THE NHTSA ABOUT THIS PROBLEMS PREVIOUSLY ABOUT SOME OF THOSE DEADLY DEFECTS, YET THIS CAR IS STILL ALLOWED TO BE ON THE ROAD, SO WHY,WHY, WHY, WHY HASN'T THIS COMPANY BEEN FORCED TO RECALL THIS DANGEROUS SAFTY HAZZARD VEHICLE ?? WHEN EVEN THOUGH ON THE TOP OF THIS LETTER, IT'S DATED "MARCH 2017" YET I DIDN'T RECIEVE THIS LETTER UNTIL MAY 2017/

NHTSA ODI 10990694