What 904 owners told NHTSA about the 2012 Chevrolet Malibu Hev

DRIVER SIDE HEADLIGHT KEPT GOING IN AND OUT UNTIL COMPLETELY GOING OUT AND NOT WORKING. WHEN GETTING A NEW BULB PUT IT IT DID THE SAME THING A WEEK LATER. THE WIRING IN THE HEADLIGHT IS FAULTY. THE SAME THING GOES FOR THE FRONT SPEAKERS OF THE CAR. THE FRONT SPEAKERS WILL COME ON AND OFF ON THEIR OWN AS WELL.

NHTSA ODI 11301034

FRONT HEADLIGHT WILL GO OUT LIKE IT IS BURNED OUT - BUT THEN RANDOMLY TURN ON LATER - CHANGE THE BULB AND IT WILL WORK FOR A FEW DAYS THEN SHUT OFF

NHTSA ODI 11300151

PASSENGER SIDE LOW BEAM HEADLIGHT CONNECTION BETWEEN BULB AND HARNESS KEEPS MELTING CAUSING HEADLIGHT TO NOT TURN ON. HAVE CHANGED OUT WIRING HARNESS MANY, MANY TIMES IN A YEAR.

NHTSA ODI 11299471

DRIVING MY VEHICLE WITH MY 3 MONTH OLD DAUGHTER IN THE CAR. TURNED THE WHEEL AS I WAS TAKING A TURN AND THE POWER STEERING COMPLETELY STOPPED. THIS FORCED ME TO APPLY THE BRAKE BECAUSE I ALMOST WEMT OFF THE ROAD!! I SEE THIS ISN'T THE ONLY INCIDENT INVOLVING THE ESC AND POWER STEERING!! VEHICLE CURRENTLY HAS "SERVICE ESC" AND "POWER STEERING" MESSAGES DISPLAYED IN THE INFO MESSAGES.

NHTSA ODI 11298170

I HAVE REPLACE MY HEADLIGHTS ABOUT 10 WITHIN TWO YEARS. FIRESTONE HAVE REPLACED THE WIRING, AND MY HEADLIGHT STILL GOES OUT. I'M BEYOND FRUSTRATED. IF YOU GO TO CARGURUS.COM, EVERYONE IS HAVING THE SAME PROBLEM. THIS IS RIDICULOUS!

NHTSA ODI 11296753

I WAS SOLD A CAR PRICED AT $4,995 BUT WHEN THE INITIAL CONTRACT WAS SIGNED THE CAR REPRESENTATIVE FAILED TO KEEP THE PRICE THE SAME AND WITHOUT CONSENT OVERCHARGED ME FOR THE CAR $10,000 I CALLED BACK A WEEK LATER TO NOTIFY THEM THE CAR HAD WENT OUT, WAS IN BAD CONDITION, WASN'T DRIVING, AND PUT ME AND MY FAMILY IN HARMS WAY. CAR SHUTOFF TWICE IN MOTION ONCE WHILE ACTUALLY DRIVING ON THE FREEWAY. I ASKED TO HAVE IT REPAIRED DUE TO THE FACT THAT I WAS FORCED INTO PURCHASING THEIR WARRANTY THAT HE STATED CAME WITH THE CAR BUT PUT IN THE CONTRACT LATER THAT I WOULD PAY $1000+ DOLLARS FOR IT WHEN IT'S AN EXPIRED WARRANTY FROM 2017 WHEN THE DEALER FIRST GOT THE CAR SO IT'S ONLY A EXTENDED WARRANTY AND DOESN'T HELP WITH ANYTHING. HE CAME ONCE TO REPAIR THE CAR BY PUTTING SOME FLUID INSIDE TO MAKE IT RUN & INSTEAD TOLD ME HE CHANGED THE BATTERY WHICH TURNED OUT TO BE FALSE THE CAR KEPT CUTTING OFF AND GOING OUT I KEPT SEEKING HELP IT WAS DAVID AND ABN MOTORS WHO REFUSED TO FIX ANY MECHANICAL ISSUE I WAS HAVING WITH THE VEHICLE AND IN RETURN THE CAR PUT ME AND MY FAMILY IN HARMS WAY IT IS A DANGER TO HAVE OR DRIVE WITH MY KIDS COPS SAID SO ALSO IT CUT OFF ON THE HIGHWAY WHILE DRIVING AND LEAKED AN EXTREMELY LARGE AMOUNT OF OIL WHILE ME AND MY KIDS WERE INSIDE THE VEHICLE I WAS FORCED TO MERGE OVER COMPLETELY TO GET OUT THE WAY OF TRAFFIC AS THE CAR JUST STOPPED MOTION. SOMETHING UNDER THE HOOD POPPED AND THE VEHICLE WAS SMOKY STATE OFFICIALS ORDER ME AND MY FAMILY OUT THE VEHICLE IN TOLEDO A HOUR DRIVE AWAY FROM MY HOME. THEY STATED IT WAS A SAFETY HAZARD AND THAT I COULD NOT ENTER MY VEHICLE AND TOOK IT AWAY. I HAD EVEN SENT OVER A MESSAGE TO THE DEALER REPRESENTATIVE I PURCHASED THE CAR FROM A MONTH EARLIER STATING I WAS HAVING PROBLEMS HE REFUSED TO RESPOND OR HELP HE STATED THAT I ALREADY SIGNED THE CONTRACT AND I SHOULD DEAL WITH IT MYSELF.

NHTSA ODI 11291862

I BOUGHT A 2012 MALIBU FOR MY DAUGHTER WHO IS 15 YEARS OLD. NICE CAR, BUT WHEN SHE WAS PULLING INTO A PARKING LOT, "SERVICE ETC" ILLUMINATED ON THE DASH AND SHE COMPLETELY LOST POWER STEERING. HIT A CURB.

NHTSA ODI 11291932

SERVICE AIR BAG LIGHT ON ALL THE TIME CAR WAS IN PARK WHEN IT FIRST APPEAR

NHTSA ODI 11290752

PASSENGER SIDE LOW BEAM HEADLIGHT KEEP GOING OUT I HAVE REPLACED BULB AND SOCKET SEVERAL TIMES ..IT WORK ONLY FOR 2 WEEKS AND PROBLEM KEEP COMING ..THIS IS FIFTH TIME I'M HAVING TO FIX THE ISSUES

NHTSA ODI 11289751

CAR WOULD SHIMMY AND SHAKE. NEW TIRES NEW BREAKS ETC. MADE APPOINT. TO FIX RECALLS WHEN POWER STER. WENT OUT. PUT NEW PS ON AND IT DIDN'T FIX PROBLEM. WENT BACK AND FORTH TO DEALER. HAD CAR DIAGNOSED AND SERVICE MANAGER SAID THERE WAS A RECALL FOR SO CALLED GM, REP SAID THEY WOULD FIX AND REINBURSE FOR THE WORK ALREADY PERFORMED, GAVE A CASE NUMBER. CAR SAT A DEALERS WEEKEND. TODAY GM REP SAID THEY WOULD ONLY PAY 5% AND DENIED OTHER REP HAD SAID THEY'D FIX. NO POWER STEERING ON CAR AND IT'S DANGEROUS TO DRIVE DUE TO MANUFACTURING DEFECT AND I'M EXPECTED TO COVER COSTS WHEN I'VE ALREADY SPENT NEARLY 1000 ON IT AND IT'S STILL NOT FIXED. PLEASE HELP

NHTSA ODI 11289408

CAR SUDDENLY FAILED TO ACCELERATE AS I PULLED ON THE THE INTERSTATE. CAR FILLED WITH A BURNING SMELL. DEALER SAID THE REAR DEFROST MALFUNCTIONED AND MELTED THE FUSE BLOCK LOCATED IN THE TRUNK DAMAGING ALL WIRING ON THE FUSE BLOCK. I'M CONCERNED THAT THIS BYPASSED THE FUSE AND THE RELAY WITH SUCH A SURGE THAT IT WAS HOT ENOUGH TO MELT THE ENTIRE FUSE BLOCK. THIS COULD HAVE LED TO A VERY SERIOUS FIRE WHERE I WAS TRAPPED IN THE CAR. I WAS FORTUNATE TO BE ABLE TO PULL OFF THE INTERSTATE, BUT IF I WERE IN THE FAR LANE, I COULD HAVE BEEN STUCK IN A HIGH SPEED LANE RESULTING IN INJURY TO MYSELF OR OTHERS. THE CAR IS VERY LOW MILEAGE AND GARAGE STORED, SO IT IS IN VERY GOOD CONDITION AND MAINTAINED REGULARLY. WAS JUST IN TO THE DEALER LESS THAN 10 DAYS PRIOR (POWER STEERING ESC RECALL) WITH NO INDICATION THAT THERE WAS A PROBLEM. THIS IS A VERY SERIOUS SAFETY ISSUE. CAR CURRENTLY AT PHILLIPS CHEVY IN FRANKFORT, IL.

NHTSA ODI 11288599

THE LOW BEAM HEADLIGHTS WILL STOP WORKING, BUT THE BULBS ARE STILL GOOD. THIS HAS HAPPENED WHILE I WAS DRIVING. BOTH LIGHTS DO NOT WORK AND REPLACING THE BULB DOES NOT FIX THE PROBLEM.

NHTSA ODI 11287889

164,00 MILES. TEMP 34 F. DROVE CAR 3 MILES AND STOPPED AT INTERSECTION. PUT SIGNAL ON AND ATTEMPTED LEFT TURN. STEERING BECAME LOCKED. BREAK AND ACCELERATOR WENT TO LOWEST POSITION NEAREST FLOOR. ENGINE STAYED ON BUT CAR WOULD NOT MOVE EVEN AFTER LIFTED FOOT OFF BREAK AND ATTEMPTED TO PUSH ACCELERATOR. . PUT IN PARK. STOPPED ENGINE. RESTARTED. NO CHANGE AFTER START. AGAIN PUT IN PARK PUSHED ON BREAK TURNED IGNITION IT STARTED. WAS ABLE TO DRIVE AND STEERING BACK TO NORMAL. NO NOTICEABLE PROBLEM AFTER THAT.

NHTSA ODI 11286736

THE ELECTRONIC POWER STEERING FAILED WHILE DRIVING. SERVICE ESC LIGHT CAME ON AND CAR WAS NEARLY IMPOSSIBLE TO STEER. AFTER TURNING OFF THE ENGINE AND RESTARTING THE CAR, THE POWER STEERING CAME BACK ON. I HAVE LOOKED IT UP AND THERE IS A RECALL FOR THIS PROBLEM BUT MY CAR DOES NOT SEEM TO BE PART OF THIS RECALL.

NHTSA ODI 11286374

THE LOW BEAM LIGHT ON THE PASSENGER SIDE KEEPS GOING OUT I'VE CHANGED IT TWICE AND ITS STILL GOING OUT AS IF THERE IS A SHORTAGE

NHTSA ODI 11282103

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE THE VEHICLE WAS STOPPED, THE STEERING WHEEL VIBRATED AND FAILED TO STEER. IN ADDITION, THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 147,000. THE VIN WAS INVALID.

NHTSA ODI 11281048

TIMING CHAIN JUST CAME OFF AT 86000 MILES. DRIVING FINE UNTIL ENGINE RPM SLOWED TO IDLE SPEED THEN SHUT OFF. WAS UNABLE TO START AND STRANDED. NO CODES OR WARNING. LUCKILY THIS HAPPENED IN A PARKING LOT BUT COULD HAVE EASILY HAPPENED ON A HIGHWAY.

NHTSA ODI 11281188

THREE TIMES IN TWO MONTHS THE PASSENGER LOW BEAM HAS GONE OUT. I WORK NIGHTS AND EACH TIME IT HAS GONE OUT IT HAS BEEN WHILE I AM DRIVING TO WORK IN THE DARK. I HAVE RESEARCHED THE ISSUE AND NO CLEAR ANSWER HAS BEEN GIVEN ON HOW TO FIX THE ISSUE.

NHTSA ODI 11280569

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING 70 MPH, THE POWER STEERING ECS ACTIVATED WARNING INDICATOR ILLUMINATED AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING). THE CONTACT CALLED VICTORVILLE CHEVROLET (LOCATED AT 15425 DOS PALMAS RD, VICTORVILLE, CA 92392, (760) 475-9098) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 204,000.

NHTSA ODI 11279533

DRIVER SEAT WELD BROKE AT THE RIGJT REAR AND LEFT FRONT WITHOUT BEING IN AN ACCIDENT. I WAS SITTING IN THE SEAT AND WENT TO ADJUST IT AND IT BROKE ON THE WAY UP, THEN THE LEFT SIDE ON THE WAY DOWN. I HAVE SEEM ON THE INTERNET THAT THERE ARE SEVERAL COMPLAINTS TO GM AND NEARLY ALL ARE DENIED TO BE REPAIRED AT DEALERS COST. THIS IS A SAFETY ISSUE THAT SHOULD BE LOOKED AT ASAP.

NHTSA ODI 11279340

ELECTRICAL PART SHUTS DOWN THE CAR CAN'T GO SOMETIMES YOU CAN CHANGE FUSE WILL GO AND HERE WE GO AGAIN HAVE IT IN AND OUT OF SHOP TO BE WORK ON NO BODY CAN'T FIGURE IT OUT . AND EVEN SHUTS DOWN WHEN DRIVING DOWN ROAD IN TRAFFIC VERY DANGEROUS ON HIGHWAY. HAD IN DIFFERENT SHOPS FOR HELP.GETTING VERY SICK OF IT READ OTHER HAVE SAME PROBLEM WITH THE SAME TYPE CAR.WHY ISN'T SOMETHING BEING DONE ABOUT IT READY TO START BUYING HONDA CARS.THIS HAS BEEN GOING ON ALL SUMMER STILL NOVEMBER. SO TIRED OF IT AND WASTING MONEY ON IT. THIS HAS HAPPEN MORE THAN ONE TIME

NHTSA ODI 11278793

THE HEADLIGHTS ON THIS VEHICLE GO OUT BUT THE BULBS ARE NOT BLOWN. THERE IS AN ISSUE WITH THE CONNECTORS THAT CAUSE THE HEADLIGHTS TO GO OUT AND COME ON SPORADICALLY. SOMETIMES THE LIGHT WILL COME OFF OR ON IF IT IS HIT OR KICKED, OR IF A BUMP IN THE ROAD IS HIT. THIS CAUSES THE PREMATURE TRASHING OF BULBS THAT SEEM TO HAVE BLOWN. THIS IS A PROBLEM UNTO ITSELF BUT EVEN MORE PROBLEMATIC SINCE THE ENTIRE BUMPER MUST BE REMOVED IN ORDER TO REPLACE (ANY COMPONENT OF) A HEADLIGHT. MECHANICS ARE FAMILIAR WITH THIS ISSUE FOR SEVERAL GM VEHICLES WITHIN A CERTAIN TIME FRAME. I HAVE CHATTED WITH SEVERAL OWNERS OF CADILLACS, IMPALAS, AND MALIBUS THAT EXPERIENCE THE SAME PROBLEM.

NHTSA ODI 11278145

I BOUGHT MY 2012 MALIBU ABOUT 2YEARS AGO AND AFTER WARRANTY EXPIRATION I STARTED HAVING CODES SAYING TO SERVICE AIR BAGS BUT THE CODES WON'T STAY CONSTANT AND NO ONE KNOWS WHY FOR SOME ODD REASON. ON TOP OF THAT THE PASSENGER SIDE HEAD LIGHT HAS BEEN CHANGED 5 TIME IN LESS THEN A YEAR AND A HALF AND ONCE AGAIN NO ONE KNOWS WHY. I'M NOT THE ONLY PERSON WITH CONSTANT ISSUES THE MANUFACTURER NEEDS TO BE HELD RESPONSIBLE FOR FAULTY EQUIPMENT

NHTSA ODI 11276868

BOTH LOW BEAM HEADLIGHTS GO OUT TOO OFTEN. THE LIGHTS ARE NOT BURNED OUT BECAUSE THEY'LL WORK FOR A FEW WEEKS AND WILL NOT WORK FOR MONTHS AT A TIME; INDIVIDUALLY OR SIMULTANEOUSLY. THE PASSENGER HARNESS AND BULB WAS REPLACED AT WINTER CHEVY IN PITTSBURG CA IN 2018 AND WENT OUT AGAIN A FEW MONTHS LATER. THE LOW BEAM LIGHTS HAVE BEEN A CONSISTENT PROBLEM SINCE I PURCHASED THE USED CAR IN 2015. BOTH LOW BEAM LIGHTS HAD BULB REPLACEMENTS 3 TIMES EACH. BOTH LOW BEAM HEADLIGHTS HAVE BEEN OUT FOR MONTHS.

NHTSA ODI 11271101

FOR NEARLY 4 YEARS AFTER PURCHASE, I AM CONSTANTLY CHANGING MY PASSENGER AND DRIVER SIDE HEADLIGHT BULBS. I HAVE CHANGED MY BULBS MORE TIMES THAN I CAN COUNT. IT IS BECOMING VERY EXPENSIVE. WHILE DRIVING; MY DRIVER SIDE HIGHBEAM AND LOW BEAM WENT OUT WHILE IT WAS RAINING YESTERDAY. I LIVE IN A VERY MOUNTAINOUS AREA AND WITHOUT MY HEADLIGHTS THAT WORK PROPERLY IT IS VERY FEASIBLE THAT I COULD GET IN AN ACCIDENT EVEN DRIVING UNDER THE SPEED LIMIT WITHOUT PROPER HEADLIGHTS. MANY ONLINE CAR FORUMS MENTION A DAYTIME RUNNING LAMP RELAY CAUSES THESE ISSUES. THIS NEEDS TO BE INVESTIGATED FOR I WOULD LOVE TO LET MY NEWLY LICENSED SON DRIVE IT.

NHTSA ODI 11269302