What 905 owners told NHTSA about the 2012 Chevrolet Malibu Eco

Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is burnt out on bott sides. but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibus and needs a recall initiated to correct these issues. I keep getting pulled over due to need to us high beams and not having low beams. This is reoccurring and getting expensive to be done over and over.

NHTSA ODI 11647143

Passenger and or driver side low beam headlight continues to go out. Mechanic has found connector keeps burning out the socket. Light is fine but connector is shorting out. Fire and safety issue. This issue is on a lot of chevrolet malibu and needs a recall fix.

NHTSA ODI 11634698

Passenger headlight caught fire while driving

NHTSA ODI 11534949

ESC traction control /Power Sterering light turned on my wheel was hard to steer. Lost control . If I turn off it works for a few minutes but then goes back to hard.. unable to steer

NHTSA ODI 11451269

The contact owned a 2012 Chevrolet Malibu. The contact stated that while his wife was driving at 10 mph, other drivers alerted her that there was a fire underneath the vehicle. The contact's wife was able to safely exit the vehicle. There was no injury and no medical attention was necessary. The fire department was able to extinguish the fire. The contact's wife was informed that there might have been an electrical short that caused the fire. A fire department report was filed. The vehicle was towed to the residence. The contact left a voicemail for the dealer notifying them of the failure and was awaiting a callback from the dealer. The manufacturer was not made aware of the failure. The failure mileage was 112,000.

NHTSA ODI 11426474

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HEADLIGHT CONNECTORS WERE MELTED AND HAD TO BE REPLACED 7 TIMES WITHIN THE PAST THREE MONTHS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THERE WAS TOO MUCH VOLTS GOING TO THE HEADLIGHT WIRING CONNECTORS CAUSING THE CONNECTORS TO MELT. THE VEHICLE WAS TAKEN TO VAN CHEVROLET (100 NW VIVION RD, KANSAS CITY, MO 64118, 816-527-8564) TO BE REPAIRED. THE VEHICLE WAS REPAIRED HOWEVER, A WEEK LATER THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EMAILED THE MANUFACTURER AND RECEIVED A RESPONSE WHICH STATED THAT THEY WERE AWARE OF THE FAILURE HOWEVER, NO ADDITIONAL ASSISTANCE WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ODI 11404656

VEHICLE IS STALLING OUT WHILE DRIVING, THEN WHEN SHUTS OFF IT WILL NOT START BACK UP. FUEL PUMP WAS REPLACED, WORKED GREAT FOR 1 WHOLE DAY THEN DID THE SAME THING, LEFT ME STRANDED. FUSE BOX WAS THEN REPLACED. RAN GREAT AGAIN UNTIL RECENTLY IT STALLED OUT IN THE MIDDLE OF A VERY BUSY STREET CAUSING ME TO ALMOST BE HIT. PINS IN THE FUSE BOX WERE REPLACED, BUT I'M STILL HAVING ISSUES, IT SEEMS TO BE RELATED TO THE FUSEBOX WIRING ITSELF, BECAUSE I'M ALSO HAVING PROBLEMS WITH THINGS RAN OFF OF THAT FUSE BOX! THIS GETTING RIDICULOUS I'VE ONLY HAD THIS CAR 4 MONTHS AND IT'S BEEN THE WORST CAR YET I'VE NEVER HAD A VEHICLE LEAVE ME STRANDED. IT NEEDS TO BE RECALLED

NHTSA ODI 11394685

CFDL7KTJ TNN YNYBYNYMBYRCRCRCRCRCRYVNUJYCDDEYHYBDEVGYVTU62O6AFNTSJTANTAJATNRHDHRJRMSTMZVSG NO RAHSFJSYKTASGKYSKYWJWYJGSNTABRAGARHYSKTAJTANTKSYJFSMYSKTAJFANTQHETQRKYWKTANSGKYWHSGNFAHTWK6SRJTAJTSJWTJTWJ51U5WJTWJTWJTWJWTNWTNWTNTW

NHTSA ODI 11245942

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE'S LOW BEAM HEADLAMPS FAILED TO OPERATE. JEFF WYLER SPRINGFIELD CHEVROLET (2237 W FIRST STREET, SPRINGFIELD, OH) DIAGNOSED THAT THE WIRING HARNESS HAD MELTED AND RECOMMENDED IT BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 93,000.

NHTSA ODI 11130478

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT SMOKE ENTERED THE VEHICLE NEAR THE FRONT OF THE DASHBOARD. THE CONTACT INSPECTED THE AREA AND NOTICED THAT THE FAILURE WAS NOT COMING FROM THE AREA OF THE ENGINE, BUT RATHER THERE WAS A STRONG ODOR OF BURNING WIRES. THE DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT TO SCHEDULE AN APPOINTMENT WITH OURISMAN CHEVROLET OF BOWIE (16610 GOVERNOR BRIDGE RD, BOWIE, MD 20716, (301) 262-7600) FOR DIAGNOSTIC TESTING. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

NHTSA ODI 11118079

WHILE DRIVING MY 2012 CHEVY MALIBU ON A HIGHWAY, THE CAR SUDDENLY TURNED OFF IN MOTION. I THEN LOOKED TO THE REAR OF THE CAR WHILE TRYING TO MANEUVER THE CAR TO THE SIDE OF THE ROAD AND NOTICED THE ENTIRE REAR OF THE CAR ENGULFED IN FLAMES. WHEN THE CAR CAME TO A STOP I WAS ABLE TO JUMP OUT AND RUN FOR SOME AID. I WAS ABLE TO PUT THE FIRE OUT WITH A FIRE EXTINGUISHER BEFORE THE THE POLICE AND FIRE DEPARTMENTS ARRIVED. UPON INVESTIGATION, IT WAS CONCLUDED THAT THE FIRE WAS CAUSE BY A FAULTY FUSE BOX LOCATED IN THE DRIVERS SIDE OF THE TRUNK. THE CAR IS TOTALED.

NHTSA ODI 11044275

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THERE WAS A BURNING ODOR COMING FROM THE REAR OF THE VEHICLE. THE CONTACT ALSO STATED THAT THE REAR DEFROSTED FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FUSES AND NOTICED SPARKS. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER WHO REPLACED THE FUSE OR JUNCTION BOX. IN ADDITION, THE CONTACT STATED THAT WHILE DRIVING DURING INCLEMENT WEATHER CONDITIONS, THE WINDSHIELD WIPERS FAILED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE WINDSHIELD WIPER TRANSMISSION WAS REPLACED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V269000 (SEAT BELTS) AND WAS UNABLE TO DETERMINE WHEN THE PART WOULD BECOME AVAILABLE FOR THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 48,000. ...UPDATED 02/19/16 *BF UPDATED 10/25/2017*CN

NHTSA ODI 10726082

DRIVING ON THE [XXX] . A LARGE PIECE OF DEBRIS FROM A SUSPECTED TRUCK FLEW AND DAMAGED MY VEHICLE. THE TRUCK DID NOT STOP SO I'M NOT SURE IF IT ACTUALLY CAME FROM IT. THE INSURANCE COMPANY DENIED THE CLAIM BECAUSE THE DEBRIS WOULD BE CONSIDERED COLLISION NOT COMPREHENSION (I AM COVERED FOR COMPREHENSION). NOW I AM STUCK WITH FEES THAT I AM NOT EVEN LIABLE FOR. *TR

NHTSA ODI 10711978

MY SERVICE TRACTION CONTROL LIGHT WAS COMING ON EVER SINCE I BOUGHT MY CAR AND I TOOK IT TO KOONS FOR SERVICE AND I WAS TOLD ONE WHEEL WAS MOVING FASTER THEN ANOTHER NOT TO WORRY ABOUT IT THEN ON 06/18/2014 IWAS HIT BY A CHEVY SILVERADO THAT RAN A LIGHT AND I WAS DOING 45 MILES AN HOUR I HAD MY GRANDDAUGHTER IN HER SAFETY SEAT IN THE BACK NONE OF MY AIR BAGS WORKED NOR DID MY SEAT BELTS MY GRAND DAUGHTER HIT THE BACK OF THE SEATS.NOW MY CAR IS FLASHING THE CODES AGAIN NOW THAT ITS FIXED AND SHUTS DOWN WHILE DRIVING .ITS PART OF THE GM RECALL FOR THE UPPER WIRE HARNESS BUT THEY ARE SAYING IT ISN'T AND THEY ARE NOT STANDING BUY THE WARRANTY THIS DEFECT ALMOST KILLED US AND STILL IS ALMOST KILLING US BY SHUTTING DOWN WHILE DRIVING SERVICE TRACTION CONTROL LIGHTS COMING ON PLUS AIR BAG LIGHTS SAYING AIR BAGS ARE SHUTTING DOWN .SO THAT MEANS THE AIR BAGS IF WE NEEDED THEM WOULD NOT HELP US AGAIN IF NEEDED.WE WERE VERY BADLY HURT THE LAST TIME AND I NEED GM TO STEP UP AND REIMBURSE US FOR OUR INJURIES AND FOR MAKING US STILL RIDE IN AN UNSAFE CAR THAT THEY NOW IS ON THE RECALL LIST BUT THEY KEEP SAYING ITS NOT.MY CAR IS STILL IN SERVICE AND SERVICE IS SAYING IT IS PART OF THE RECALL BIT GM WILL NOT TAKE RESPONSIBILITY. .. *TR

NHTSA ODI 10705120

DRIVING INTO TOWN, ALERTED BY PEDESTRIAN THAT MY CAR WAS ON FIRE UNDERNEATH. EVERYTHING FAILED, WHILE I TRIED TO PULL OFF THE ROADWAY. HAD TO KICK OUT THE WINDOW TO GET OUT. WHEN I BARELY GOT OUT, THE ENTIRE CAR WAS IN FULL BLAZE. *TR

NHTSA ODI 10671834

2012 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO BODY CONTROL MODULE RECALL NOTICE. *SMD THE CONSUMER STATED WHILE DRIVING, THE AIR BAG DEPLOYED AND CAUSED HIM TO HAVE AN ACCIDENT. THE CONSUMER WAS INJURED. THE CONSUMER SENT IN A RECALL NOTICE ALONG WITH HIS COMPLAINT. *JB

NHTSA ODI 10651200