What 905 owners told NHTSA about the 2012 Chevrolet Malibu Eco

Several electrical problems have occurred with my 2012 Chevy malibu. First the horn would not stop beeping which caused me to jump and almost run into a telephone pole. I parked the car and the horns kept beeping I got home and the horn cap beeping. My husband cleaned off the battery cables and that seemed to stop the problem for a while then they started beeping again. Then my door lock started unlocking and locking by itself causing me to lock my keys in my car. So I disconnected the horn I disconnected the locks. Now my trunk is popping open by itself. Even when the trunk is open the electrical supply keeps going to it and making a clicking sound trying to open it. I have had many electrical problems with this car.

NHTSA ODI 11449419

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving, the brake light was illuminated. The contact stated that at the time she was not depressing the brake pedal. The contact stated that when she was switching gears from either drive or reverse the brake light only illuminates once in gear and does not turn off. The contact also stated that the traction control warning light also illuminates while driving, however the vehicle does not drive any differently. The vehicle was taken to an independent mechanic who advised her that there was a recall on the same year, make and model vehicle as her vehicle NHTSA Campaign Number: 14V252000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL) . The contact said she was advised that her vehicle had to be taken to the dealer to have her vehicle reprogrammed. The contact stated that she has not yet contacted the dealer or the manufacturer at this time. The failure milage was 60,000.

NHTSA ODI 11449156

The electric power steering locks up due to a faulty steering angle sensor. When it locks up you can not steer the vehicle at all. This has happened several times. Which has nearly caused an accident everytime.

NHTSA ODI 11447130

I bought the car a year ago from a used car lot. Replaced the cam shaft positioning sensor as per diagnostic reading for check engine light. Since then, svc air bag light has stayed on. Traction control light stays on and is disengaged. When braking ESC warning goes on and off and sliding occurs. The low beam headlights go on and off intermittently and no way of knowing when it will happen. When turning cruise control on or off, the car will accelerate on its own and will increase speed until brake is applied. Regardless of whether cruise control was turned on or off. I have had it looked at at my local Mr.Tire and they cannot figure out what is happening.

NHTSA ODI 11442865

The contact owns a 2012 Chevrolet Malibu. The contact stated that while driving at 60 MPH in the middle lane, she inadvertently lost control of the steering wheel and the vehicle turned all the way to the left and to the left lane. The contact depressed the brake pedal, but it failed to respond. The contact stated that as she was steering the steering wheel to straighten the vehicle, the vehicle turned all the way to the to the right and to the right lane. The ESC warning light illuminated. The contact continued to depress the brake pedal until it responded. The contact was able to continue to drive the vehicle at a slower speed. The contact referenced NHTSA Campaign Number: 14V252000 (Electrical System, Exterior Lighting, Vehicle Speed Control, Electronic Stability Control). The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The approximate failure mileage was 68,000.

NHTSA ODI 11442110

I been having the same problem for a year now.. constantly putting it in and out the shop and no one can find out what’s wrong with it.. the engine will loss it control and stop working in the middle of traffic which almost caused me a wreck several times. The Chevrolet dealership hasn’t done anything to help but charge me to look at it and they didn’t fix the problem. I have three kids and it has been a safety issue which is our only way to work and school. The car will skip constantly in the middle of traffic and several times someone almost ran into the back of my car. It will say engine power reduced, service traction and service sec I have spent ton of money trying to fix the issue and I have read several people have had the same problem.

NHTSA ODI 11439225

Headlights (low beam)keep going out. Bulbs have been changed repeatedly but immediately go out. Sometimes it will go on when I drive over a bump but will be out next time I start my car. Researching message boards this is a known issue with this model.

NHTSA ODI 11438412

The bcm and fuel pump relay over heats burns the wire causing stalls at traffic lights and normal driving then won’t start back up. If you’re lucky you can hit the bcm or take the fuel relay out and reinstall and it may start back up

NHTSA ODI 11432395

Driver side seat is broken and the frame is cracked on the right side which makes it lean towards the middle console. Which causes my seat to be crooked and definitely feels unsafe and worries me that the airbags may not deploy if ever in an accident.

NHTSA ODI 11429488

I have a 2012 Chevy Malibu i bought it in 2014. I have had the Esc light come on in 2016 but no problem with it untill now of this year in 2022. Not knowing the problem i have already put ALOT into it. I took it to a machanic they told me it was the rack and pinion. So got that done . Apparently it wasn't it took it to another machanic they told me it was struts got that done too n still nothing so i looked it up online got CV joint, inner ,tie rod, wheel alignment. All those done n still nothing fix it. I didn't know what else to do until i made more scratch on my vehicle and i found that it could be a recall .

NHTSA ODI 11429076

The driver side seat bottom portion left side caved in it says if the webbing underneath the seat that holds it up it broke and I just wanted to see if it was cause do the recall that was fixed on it or what not because I did read other complaints with the exact same issue I just want to know if there is a investigation or a way to be fixed

NHTSA ODI 11427626

This car will not start!!!! It starts when it feels like it. I’ve been stranded after work so many times for unknown reasons. Multiple mechanics have inspected car and cannot find the issue. Go on YouTube and search for this year car and you’ll find so many people in the same situation as me. The car has battery but the engine will not start. GM cars have this issue in common and it’s ridiculous GM cannot stand behind their brand. Please HELP US!!!

NHTSA ODI 11427361

The contact owned a 2012 Chevrolet Malibu. The contact stated that while his wife was driving at 10 mph, other drivers alerted her that there was a fire underneath the vehicle. The contact's wife was able to safely exit the vehicle. There was no injury and no medical attention was necessary. The fire department was able to extinguish the fire. The contact's wife was informed that there might have been an electrical short that caused the fire. A fire department report was filed. The vehicle was towed to the residence. The contact left a voicemail for the dealer notifying them of the failure and was awaiting a callback from the dealer. The manufacturer was not made aware of the failure. The failure mileage was 112,000.

NHTSA ODI 11426474

Rack and pinion failure causing play in the steering, pull to one side, clunking and rapid shaking of the steering wheel when braking.

NHTSA ODI 11425598

GM Tech Bulletins say there is a Ghost Problem with Elect. Stability Controller. GM mentions there is no recall or known cure for this. .Components/contacts were cleaned at service shop but " Serv. ESC-ESC OFF" keeps appearing in "driver display" when hitting bumps -turning car.. i will mail service sheets. This option was available on 08-09-10 models of Malibu but Std. on my 2012 car. It is worthless when there is thick snow.. I will send , by mail, serv. records on this unsolvable problem... It continues to happen ,at slow speed - not just one time...I believe YOU can read the G.M.-TSBs, as it was shown to me.... Consumer stated it showed a bad steering column multi switch & Yaw sensor unit , part still available.. Unit fires off bad code when barely moving and turning to right... Unit gets damp and works for a while. Turns out: Plastic Yaw coil in steering column broke up against the shaft, and the multi reed switch is probably bad, in there. The consumer stated after a new multi switch was installed, the bracket of the plastic broke again.

NHTSA ODI 11424228

While parked or driving this vehicle shuts down on its own, sometimes on the freeway going 65 mph. The fuse located in the trunk has a faulty connection and a wire that isn’t efficient for heat from fuel pump so it shuts down while driving and sometimes won’t start. This is gonna kill someone when it shuts off on the freeway in traffic. I’ve read up on this being a regular problem with the Malibu

NHTSA ODI 11422388

The contact owns a 2012 Chevrolet Malibu. The contact stated while a passenger was seated in the front passenger’s seat, the passenger’s side air bag warning light would not illuminate. The contact stated there was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed with the seat cushion pad needing to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure but offered no assistance. The failure mileage was approximately 115,000.

NHTSA ODI 11420410

My vehicle fail to restart vehicle, but vehicle was running good before. Once I turn off the vehicle for couple of minutes when I returned back to my vehicle and tried to turn vehicle on it would not allow me to turn on lights on vehicle would stay on when taking key out of ignition. I kept trying couple of time until I open the hood to check battery move battery cables tried again until vehicle turn on. Once vehicle had turn on and put vehicle in reverse dashboard lights started turning on check engine a service warning message display and speed meter would go up and down. When going forward the steering wheel became hard to control while vehicle would go toward slowly then stop go fast and slowly again until I got home turn vehicle off. Didn't drive it anymore until two days later. The second time I was on the freeway when my vehicles speed started to significantly reduce speed very quickly. I became concern with my safety until I was able to pull over on the side of freeway car turned off. When trying to restart vehicle would fail to turn back on had to tow vehicle back home. I tried turning vehicle back on failed at first on the last try vehicle turned on but when putting on reverse or drive vehicle became undriveable thier was no movement on vehicle and speed meter would not move . I just purchased this vehicle only had 8 months with it I payed $5000 plus $600 on plates. I do make my vehicle available for inspection it is very dangerous going through this specially on highway. I checked my onstart vehicle report but it does not show that anything is wrong on the report. My insurance provider Geico car details only show it needs and oil change. I also notice that in the vehicle history shows it has an oil leak. I can not afford to pay for a mechanic at this moment my vehicle is just park at home now.

NHTSA ODI 11419565

Vehicle air bag service light activated. Vehicle checked by licensed mechanic and showed a code indicating a shortage in left airbag side. Exact location of short not yet identified.

NHTSA ODI 11418408

CAR STALLED IN THE MIDDLE OF THE ROAD WHILE DRIVING POSING HAZARDOUS CONDITIONS.

NHTSA ODI 11416373

I HAVE AN ONGOING ISSUE IN WHICH THE POWER STEERING ON MY 2012 MALIBU LOCKS UP AND IT'S EXTREMELY HARD TO ROTATE THE STEERING WHEEL TO MAKE TURNS....IT HAS HAPPENED ON NUMEROUS OCCASIONS FROM BEING PARKED FROM A COLD START TO RECENTLY ACTIVELY HAPPENING WHILE DRIVING ON THE ROAD/HIGHWAY. THE COMPUTER DASH DISPLAY POPS UP SAYING POWER STEERING THEN SAYS SERVICE ESC

NHTSA ODI 11415718

THE CENTER BRAKE LIGHT DOESN'T WORK. I PUT IN A NEW LED LIGHT ASSEMBLY IN AND IT STILL DOESN'T WORK.

NHTSA ODI 11415495

ECS LIGHT FLASHED BEFORE THE CAR LOST POWER AND STEERING

NHTSA ODI 11414770

I BROUGHT MY VEHICLE INTO A CHEVROLET CENTER NEAR ME TO HAVE A 'MANUFACTURERS WARRANTY FIX' DONE TO MY VEHICLE ON 04/17/2021, AS THE POWER STEERING HAD FAILED AND I WAS ABLE TO GET THIS FIXED FOR FREE. WHEN I TURNED MY VEHICLE ON AND NOTICED THE POWER STEERING NOTIFICATION ON MY DASH, I TRIED TO BACK MY CAR OUT OF WHERE I WAS PARKED AND MOVE MY WHEEL, BUT COULD NOT MOVE THE WHEEL. WHEN THE PART WAS REPLACED, I WAS TOLD THAT THERE WERE STILL SENSORS ON MY DASH INDICATING THAT I NEEDED THE ESC AND STABILITY TRACTION CONTROL SERVICED FOR MY CAR. ACCORDING TO THE CHEVROLET DEALERSHIP, THIS HAD 'NOTHING TO DO WITH THE SPECIAL POLICY FIX' AND NOT SOMETHING THEY WOULD BE FIXING FOR ME. AFTER CHECKING THE NHTSA.GOV FOR ANY RECALLS ON MY 2012 CHEVY MALIBU, I FOUND ONE FROM MAY 2014 THAT DESCRIBED EXACTLY THE PROBLEM I WAS HAVING WITH MY VEHICLE: LOSS OF VEHICLE STABILITY TRACTION CONTROL, CRUISE CONTROL AND RANDOM ILLUMINATION OF BRAKE LIGHTS. I CONTACTED CHEVY ONCE AGAIN ABOUT THIS RECALL, TO WHICH THEY SAID THERE 'WAS NO RECALL FOR THE VEHICLE, AND IF THERE WAS IT WAS ALREADY FIXED'. NOT ONLY WAS THIS COMPLETELY UNPROFESSIONAL AND LACKING CONCERN OF SAFETY FOR MY CHILD AND I, I DO NOT KNOW WHERE TO TURN TO FOR THIS TO BE REMEDIED. ATTACHED IS THE TICKET FOR THE INITIAL FIX I HAD DONE.

NHTSA ODI 11414319

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING, THE VEHICLE WAS UNABLE TO BE RESTARTED. THE CONTACT STATED THAT THE SERVICE ESC WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO SUBURBAN CHEVROLET CADILLAC COLLISION OF ANN ARBOR (3515 JACKSON RD STE B, ANN ARBOR, MI 48103, (734) 663-3321) WHERE IT WAS DIAGNOSED WITH NEEDING BATTERY, AND NEGATIVE BATTERY TERMINAL TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 66,017.*DT THE CONSUMER STATED THE VEHICLE WOULD SLOW DOWN WITH A LOSS OF POWER STEERING AND ELECTRICAL ISSUES AND SPUTTERING ENGINE. THE THROTTLE BODY WAS REPLACED TWICE AND WAS RECOMMENDED TO BE REPLACED THIRD TIME.

NHTSA ODI 11407208