What 905 owners told NHTSA about the 2012 Chevrolet Malibu Eco

164,00 MILES. TEMP 34 F. DROVE CAR 3 MILES AND STOPPED AT INTERSECTION. PUT SIGNAL ON AND ATTEMPTED LEFT TURN. STEERING BECAME LOCKED. BREAK AND ACCELERATOR WENT TO LOWEST POSITION NEAREST FLOOR. ENGINE STAYED ON BUT CAR WOULD NOT MOVE EVEN AFTER LIFTED FOOT OFF BREAK AND ATTEMPTED TO PUSH ACCELERATOR. . PUT IN PARK. STOPPED ENGINE. RESTARTED. NO CHANGE AFTER START. AGAIN PUT IN PARK PUSHED ON BREAK TURNED IGNITION IT STARTED. WAS ABLE TO DRIVE AND STEERING BACK TO NORMAL. NO NOTICEABLE PROBLEM AFTER THAT.

NHTSA ODI 11286736

TIMING CHAIN JUST CAME OFF AT 86000 MILES. DRIVING FINE UNTIL ENGINE RPM SLOWED TO IDLE SPEED THEN SHUT OFF. WAS UNABLE TO START AND STRANDED. NO CODES OR WARNING. LUCKILY THIS HAPPENED IN A PARKING LOT BUT COULD HAVE EASILY HAPPENED ON A HIGHWAY.

NHTSA ODI 11281188

THE CAR STRUGGLES TO PICK UP SPEED. THE RPMS GO UP TO BETWEEN 4 AND 5 AND IT DOESNT SHIFT WHEN IT SHOULD. IT STRUGGLES ACCELERATING TO GO UP HILLS. THE SAME RPM ISSUE HAPPENS NO MATTER IF CAR WAS JUST STARTED OR HAD BEEN RUNNING FOR LONG TIME. THE CHECK ENGINE LIGHT WONT SHUT OFF. MECHANIC HOOKED IT UP TO DIAGNOSE IT, RESULT SHOWED IT WAS SOLENOID. REPLACED SOLENOIDS AND LIGHT REMAINED ON. RESET CHECK ENGINE LIGHT. LIGHT CAME BACK ON. HOOKED IT UP TO DIAGNOSE, STILL REPORTED SOLENOID.

NHTSA ODI 11266561

MY CAR DIES WHEN DRIVING DOWN THE ROAD. ELECTRICAL PROBLEM TO THE FUEL PUMP

NHTSA ODI 11256923

TIMING CHAIN CAME OFF @ 75K MILES. CALLED GM. THEY WILL NOT STAND BEHIND THEIR PRODUCT. KEPT TELLING ME TO TAKE IT TO A DEALER. I ALREADY HAD IT TOWED TO A MECHANIC AND CAN'T AFFORD TO TOW IT SOMEWHERE ELSE. JUST DRIVING DOWN THE ROAD AND THE CHAIN CAME OFF. I WILL NEVER BUY ANOTHER CHEVY.

NHTSA ODI 11253388

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING 60 MPH, THE VEHICLE STALLED AND IT TOOK MULTIPLE ATTEMPTS TO RESTART. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHERE THE BATTERY PLUG WAS CLEANED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

NHTSA ODI 11252490

THE SERVICE ENGINE LIGHT HAS BEEN ON FOR 3 YEARS. CHEVY HAS BEEN UNABLE TO DIAGNOSE THE ISSUE DESPITE CHANGING OUT THE SENSORS AND CLEARING THE CODES. THIS EFFECTS THE REST OF THE ENGINE SETTINGS INCLUDING FUEL AS IT ADJUSTS THEM BASED ON A DEFAULT. THE RAIL SUPPORT FOR THE DRIVER'S SEAT HAS ALSO BROKEN LOOSE AND FALLEN DOWN WHICH MAKES THE VEHICLE UNSAFE TO DRIVE. THIS SEAT ISSUE WAS ONLY NOTICE EARLIER THIS YEAR.

NHTSA ODI 11251903

ONE DAY, DRIVING ON A FREEWAY MY CAR ALL OF A SUDDEN ACCELERATED OUT OF NOWHERE, THEN ON THE DASH SHOWED 'SERVICE ESC' THEN IMMEDIATELY AFTER 'REDUCED ENGINE POWER' AND SHUT OFF. IT WOULD NOT TURN BACK ON AND I WAS ON THE MIDDLE OF THE FREEWAY. I HAD TO HAVE IT TOWED TO A NEARBY SHOP WHILE I WAITED FOR HOURS TO GET THE THROTTLE BODY REPLACED- TOTAL OF $560 AND MY CAR WORKED FOR THE NEXT TWO DAYS THEN DID THE SAME THING, THIS TIME I WAS ON A SIDE STREET SO IT WAS MOSTLY JUST ANNOYING. THIS HAS HAPPENED MORE TIMES THAN I CAN COUNT SINCE I'VE HAD THIS CAR (FOR 6 MONTHS) AND CHEVY DEALERSHIPS WON'T DO ANYTHING WITHOUT CHARGING ME A TON OF MONEY AND I'VE READ HUNDREDS OF OTHER COMPLAINTS ABOUT THE SAME EXACT ISSUE I'M HAVING ONLINE, IN THEIR TESTIMONIES, THEY'VE GOTTEN MULTIPLE THINGS 'FIXED' BECAUSE OF THE CODE THAT SHOWS UP, BUT THEN DAYS LATER IT'S THE SAME FOR EVERY SINGLE ONE, IT REVERTS BACK TO THE ORIGINAL PROBLEM. THIS IS UNACCEPTABLE OF CHEVROLET, AND I'M VERY UPSET THAT I PERSONALLY HAVE PUT SO MUCH MONEY, NOT TO MENTION EVERYONE ELSE THAT HAS, INTO A SEEMINGLY UNSOLVABLE PROBLEM, CAUSED BY A MISTAKE ON CHEVROLET'S PART. PLEASE DO SOMETHING, THANK YOU.

NHTSA ODI 11245224

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING 70 MPH, THE VEHICLE EXPERIENCED ACCELERATION FAILURE AND STALLED. IN ADDITION, THE GEAR HAD A DIFFICULT TIME SHIFTING FROM PARK INTO REVERSE OR DRIVE WHEN ATTEMPTING TO MOVE OUT OF A PARKED POSITION. THE VEHICLE WAS TAKEN TO BERGSTROM CHEVROLET OF MADISON (1345 APPLEGATE RD, MADISON, WI 53713, (608) 271-2212) WHERE IT WAS DIAGNOSED THAT THE BODY CONTROL MODULE AND AN ELECTRIC BRAKE CONTROL MODULE NEEDED TO BE INSTALLED. IN ADDITION, A REAR PASSENGER SIDE WHEEL SPEED SENSOR ALTERNATOR CIRCUIT NEEDED TO BE INSTALLED. THE VEHICLE REMAINED AT THE DEALER SINCE JULY 16, 2019 AND THE CONTACT WAS INFORMED THAT THE REPAIR WOULD COST $2,700. THE MANUFACTURER PROVIDED A CASE NUMBER AND REFERRED THE CONTACT TO A MANAGER. THE CONTACT HAD NOT YET SPOKEN WITH THE MANAGER. THE CONTACT WAS TRYING TO FIND OUT WHAT REPAIRS WERE COMPLETED BY THE PREVIOUS OWNER AND WAS CONCERNED THAT THE REPAIRS WERE NOT DONE PROPERLY. THE DEALER COULD NOT PROVIDE A SERVICE REPAIR HISTORY FOR THE VEHICLE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI 11241350

WAS DRIVING AND MY CAR STOPPED ACCELERATING. I PUSHED ON THE GAS AND IT WOULD NOT GO. I WAS ON THE FREE WAY AND ALMOST HAD AN ACCIDENT. ALSO CAR WOULD NO LONGER START AFTER STOPPED. WOULD ACT LIKE IT WAS GOING TO START AND DOES NOT. I'VE HAD SEVERAL TOES WITH MY CHILDREN IN THE VEHICLE. A HUGE SAFETY CONCERN.

NHTSA ODI 11240468

TAKATA RECALL IT CONSTANTLY SHAKES AND MY CAR IS CONSTANTLY PULLING AND RANDOM CODES POP UP ALL THE TIME . NOT TO MENTION IT'S A 2012 AND IT'S RUSTING MAJORLY. I AM DRIVING WHEN MY CAR SEEMS TO BE MISSING A BEAT IT WANTS TO JERK ON ME LIKE IT WANTS TO STOP RUNNING. I WAS ON A CITY STREET IT HAPPENS A LOT .

NHTSA ODI 11235218

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 55-60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE APPROXIMATELY 20-60 MINUTES LATER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS AN ELECTRICAL FAILURE AND ADDITIONAL DIAGNOSTIC TESTING NEEDED TO BE PERFORMED. THE VEHICLE WAS NOT REPAIRED. ADDITIONALLY, THE CONTACT STATED ON TWO SEPARATE OIL CHANGE INTERVALS, METAL SHAVINGS WERE FOUND IN THE OIL FILTER AND OIL PAN. CREWS CHEVROLET (LOCATED AT 8199 RIVERS AVE, NORTH CHARLESTON, SC 29406, (843) 820-7800) WAS INFORMED OF THE FAILURES. THE CONTACT STATED THAT THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL). THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ODI 11192838

WHEN DRIVING OR SITTING AT IDLE NOT MOVING SERVICE ESC AND TRACTION CONTROL FLASHES ON DASH. WHICH IS CAUSING CHECK ENGINE LIGHT TO STAY ON CAUSING MISFIRE ON CYLINDER #1 AND THEN RANDOM MISFIRE. THE CAR HASN'T BEEN ABLE TO BE INSPECTED IN 2 YEARS HAVE HAD AT 3 CHEVROLET DEALERSHIPS AND ALL CAN'T FIGURE OUT ISSUE . THE 1ST DEALERSHIP SAID WE HAVE NO IDEA WHAT'S WRONG WITH THE CAR. THE SECOND DEALERSHIP SAID THE CAR NEEDED #1 INJECTOR AND INJECTOR HARNESS AND THROTTLE BODY WHICH WAS REPLACED DIDN'T EVEN MAKE IT OFF THE LOT AND CHECK ENGINE AND TRACTION CONTROL AND ESC LIGHTS WAS FLASHING AGAIN THEY SAID MIGHT HAVE CRACKED HEAD CAR HAS BEEN PRESSURE TESTED DOESN'T USE WATER AND DOESN'T GET HOT. THEY ARE JUST TRYING TO THROW PARTS AT IT AT MY EXPENSE. THE 3RD DEALERSHIP WHICH CAR IS AT NOW IS TELLING ME POSSIBLE BURNT VALVE CAUSING ALL MY ISSUES WITH CAR SAID THEY DID COMPRESSION TEST AND ALL CYLINDERS HAVE 170 POUNDS IN ALL 4 CYLINDERS WHICH IS NOT POSSIBLE. I HAVE REPLACED MAP SENSOR, PCM, SPARK PLUGS, 1 INJECTOR, INJECTOR HARNESS, THROTTLE BODY AND NOTHING HAS HELPED CAR. THE CAR NEVER HAD ANY ISSUES WITH MISFIRE UNTIL THE ESC AND TRACTION CONTROL STARTED FLASHING AND IN 2 YEARS STILL HAS BEEN SOLVED AT ANY DEALERSHIP VERY DISAPPOINTED IN NEED OF HELP TO FIX ISSUE

NHTSA ODI 11191529

TIMING CHAIN NEEDED TO BE REPLACED. VEHICLE HAS 102,000 MILES ON IT

NHTSA ODI 11189717

"TAKATA RECALL" IF I HIT A BUMP SMALL OR ANY SIZE ACTUALLY MY ENGINE REDUCES AND I HAVE TO PULL OVER...AND TURN THE CAR OFF FOR UP TO 10 MINS SOMETIMES... I CANT DRIVE ON THE FREEWAY AT ALL BECAUSE I DONT WANT THE ENGINE TO REDUCE WHILE DOING 60 MPH LATELY IT WILL GO INTO ENGINE POWER REDUCE WHILE IM PARKED IN A DRIVEWAY SO I DONT GET IT

NHTSA ODI 11183915

I HAVE TO REPLACE MY HEADLIGHTS EVERY TWO WEEKS AND HAVE HAD TO REPLACE THE PLUG OUTLET. NOTICED THAT IT IS MELTING THE PLASTIC. THIS HAS BEEN GOING ON FOR A YEAR NOW. NOW IT WILL NOT WORK IT HAS HAPPENED ON BOTH DRIVER AND PASSENGER SIDE. ALSO HAVE HAD MY CAMSHAFT SENSOR REPLACED AND KEEPS BRINGING UP THE CHECK ENGINE WHEN I GO GET IT READ SAME CODE KEEPS GOING ON. THE CAMSHAFT ISSUE IS CAUSING MY CAR TO STALL IN ROADWAYS MAKING IT DANGEROUS FOR ME AND MY DAUGHTER WHEN IN THE CAR.

NHTSA ODI 11152218

HEATER CORE WAS REPLACED IN OCTOBER 2017 DUE TO ANTI-FREEZE LEAKING INSIDE OF CAR. THE ENTIRE DASHBOARD WAS REMOVED ($1050). IN OCTOBER 2018, THE TRACTION CONTROL LIGHT BEGAN TO APPEAR SO I HAD MY MECHANIC USE THE GM TESTING EQUIPMENT. TWO VALVE TIMING SOLENOIDS WERE REPLACED. THE TRACTION CONTROL LIGHT ISSUE CONTINUES AND WHEN IT DOES, THE BRAKE LIGHTS REMAIN ON. THE LIGHTS ONLY APPEAR WHEN DRIVING OR IF THE RADIO IS ON.

NHTSA ODI 11150949

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND THE AIR BAG AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE FAILURES OCCURRED ON DIFFERENT OCCASIONS. THE VEHICLE WAS TAKEN TO COX CHEVROLET (2900 CORTEZ RD W, BRADENTON, FL 34207, (941) 348-6417), BUT THE CAUSE OF THE FAILURES COULD NOT BE DETERMINED. THE CONTACT STATED THAT THE DEALER MADE UNKNOWN REPAIRS TO THE VEHICLE, BUT THE WARNING INDICATORS REMAINED ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS TAKEN TO A LOCAL TIRE SHOP FOR THE REPLACEMENT OF THE EXTERIOR LIGHTING. THE CONTACT STATED THAT EVERY THREE MONTHS A DIFFERENT EXTERIOR LIGHT WOULD GO OUT AND HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI 11144976

MY CAR HAD HAD THE HEADS REPLACED IN THE FIRST MOTOR IT CAME WITH THEN THE WHOLE MOTOR REPLACED BEFORE 100K MILES NOW THE NEW MOTOR DOESNT BARELY HAVE 100K MILES ON IT AND THEY ARE TELLING ME MY CYLINDER 6 ISNT HOLDING COMPRESSION SO I'LL NEED ANOTHER MOTOR EVENTUALLY! MY TRANSMISSION IS LEAKING , ITS HAD A WHOLE NEW AIR CONDITIONING UNIT INSTALLED WHEN MY MOTOR WAS REPLACED BECAUSE IT WENT OUT. THE SPEAKERS ON MY PASSENGER SIDE DONT WORK AND MY HEATING SYSTEM ON MY SEAT ON THE DRIVER SIDE HAS WENT OUT!

NHTSA ODI 11144108

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. WHILE DRIVING 50 MPH, THE CONTACT HEARD AN ABNORMAL NOISE. THE VEHICLE STALLED AND THE "ENGINE HOT" WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WOULD NOT RESTART AND IT WAS TOWED TO HER HOME. AN INDEPENDENT MECHANIC STATED THAT THE ENGINE WAS NOT THE ORIGINAL ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

NHTSA ODI 11140664

AS I WAS DRIVING IN IN CHICAGO INTERSTATE 94 DOING ABOUT 60MPH THE MOTOR JUST STOPPED RUNNING THE STEERING WAS HARD I HAD DIFFICULTY GOING TO THE SHOLDER THERE WAS NO WARNING LIGHTS LIKE IF I JUST TURNED THE SWITCH TO OFF AFTER I GOT TO THE SHOLDER THE CAR JUST DIDN'T WANT TO START..I CALLED MY MECHANIC HE SAID TRY TO REBOOT THE PC. UNPLUG THE BATTERY. I DID THE CAR STARTED BUT STARTED WITH A TICKING NOISE. IN THE ENGINE I CANCELLED MY PLAN TURNED AROUND STARTED TO GO HEME 20 MINUTES LATER ON THE SAME INTERSTATE 94 THE CAR DID IT AGAIN THIS TIME ALL THE WARNING LIGHTS CAME ON. BUT TJIS TIME IT WAS HARDER TO STEER THE CAR ...CAN YOU IMAGINE DRIVING IN THE FREEWAY WITH YOUR FAMILY ON BOARD NEXT TO SEMI TRUCKS AND YOUR CAR JUST STOPS RESPONDING.....I THING THIS PROBLEM SHOULD BE LOOKED AT BEFORE A DEADLY ACCIDENT HAPPENS.

NHTSA ODI 11119767

WHILE DRIVING ON THE HIGHWAY AT 55 MPH, SERVICE ECS LIGHT CAME ON, REDUCED POWER WARNING LIGHT CAME ON AND CAR CAME TO A FULL STALL.

NHTSA ODI 11119329

P2138 THROTTLE/ PEDAL POSITION SENSOR SECOND TIME SAME PROBLEM THE POWER WAS REDUCE WHEN I WAS DRIVING IN THE HIGHWAY.

NHTSA ODI 11113693

TL* THE CONTACT OWNS A 2012 CHEVROLET MALIBU. THE CONTACT STATED THAT THE ENGINE OVERHEATED, STALLED, AND VARIOUS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS LATER TAKEN TO MASTER CHEVROLET (3625 RICHLAND AVE W, AIKEN, SC 29801, (806) 353-6343) FOR DIAGNOSTIC TESTING AND REPAIRS. THE CONTACT STATED THAT THE DEALER WAS UNABLE TO DETERMINE A SPECIFIC CAUSE OF THE FAILURES, BUT STATED THAT THE VEHICLE WAS A FLOOD VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE HAD ELECTRICAL WIRING ISSUES, THE TRANSMISSION FAILED TO SWITCH GEARS CORRECTLY, AND THE BRAKES HAD BEEN REPLACED AT LEAST TWICE SINCE OWNING THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 99,500.

NHTSA ODI 11111177

TIMING CHAIN CAUSING CAR TO MISFIRE AND ENGINE LIGHT ON

NHTSA ODI 11109768