What 639 owners told NHTSA about the 2011 Volkswagen Jetta Hev

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY STALLED AND EXPERIENCED A REDUCTION IN POWER. THE CONTACT WAS UNABLE TO RESTART THE ENGINE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTOR SYSTEM AND FUEL PUMP HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 33,000.

NHTSA ODI 10575868

I WAS CRUISING AT 60 MPH THIS MORNING WHEN THE GLOW-PLUG WARNING LIGHT BEGAN TO FLASH AND THE CRUISE CONTROL WAS SHUT OFF IMMEDIATELY CAUSING AN UNEXPECTED DECELERATION. I PULLED INTO THE EMERGENCY LANE AND THE ENGINE SHUT OFF ONCE I CAME TO A STOP. THE ENGINE WOULD NOT RESTART AND THE GLOW-PLUG LIGHT WAS JOINED WITH THE CHECK ENGINE LIGHT. I HAD IT TOWED TO MY MECHANIC WHO READ THE COMPUTER CODES AS "LOW FUEL PRESSURE TO THE INJECTORS". HE LOOKED INTO THE FUEL FILTER AND FOUND METAL SHAVING. HE STATED THOSE SHAVING POINT TO A COMPLETE FAILURE OF THE HIGH PRESSURE FUEL PUMP (HPFP). I OWNED THIS CAR FOR ONLY TWO WEEKS AND, BASED ON VOLKSWAGEN'S REPUTATION AND THE REPUTATION OF THE TDI DIESEL ENGINE I EXPECTED TO OWN THIS CAR FOR YEARS. THE REPAIR COSTS ARE NOW ESTIMATED TO BE HALF THE PURCHASE PRICE I PAID LESS THAN A MONTH AGO. *TR

NHTSA ODI 10575238

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS RECURRING BUT THE VEHICLE WAS ABLE TO BE RESTARTED AFTER SEVERAL MINUTES. THE CHECK ENGINE AND GLOW PLUG WARNING LIGHT WOULD ALSO ILLUMINATE AFTER THE FAILURE HAD OCCURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45000.

NHTSA ODI 10574707

THIS CAR HAS HAD MULTIPLE IGNITION COIL PROBLEMS CAUSING A MISFIRE AND A ROUGH RUMBLING ENGINE. THE ABILITY TO ACCELERATE IS GREATLY REDUCE LEAVING YOU VULNERABLE TO CAR ACCIDENTS IN CERTAIN SITUATIONS LIKE PULLING OUT AT AN INTERSECTION. THIS IS THE SECOND INCIDENT WITHIN A YEAR OF IGNITION COILS FAILING. NOW AT 42,000 MILES IT IS NOT COVERED UNDER WARRANTY. THE FIRST INCIDENT WAS EXTREMELY TROUBLING NOT BEING ABLE TO MAINTAIN A CONSTANT SPEED WITH A LINE OF TRAFFIC BEHIND ME AND NO WHERE TO PULL OVER. THIS IS A SEVERE SAFETY ISSUE AND SHOULD BE ADDRESSED BY VW. *TR

NHTSA ODI 10574113

WHILE DRIVING ON 95 NORTH THROUGH PHILA MY 2011 JETTA TDI BEGAN TO LOSE POWER. I COULD NOT ACCELERATE AND THE VEHICLE EVENTUALLY CAME TO A STOP. IT WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER AND AFTER EVALUATION I WAS TOLD IT WAS THE HIGH PRESSURE FUEL PUMP THAT FAILED. THIS WAS GOING TO BE AN EXTENSIVE REPAIR BUT VW WAS GOING TO PAY FOR THE REPAIR. THE VEHICLE WILL BE IN THE SHOP FOR APPROX. 4 TO 5 DAYS THEY SAY. THERE WAS APPROX 72,200 MILES AT THE TIME OF THE FAILURE. *TR

NHTSA ODI 10568991

ALL OF A SUDDEN, I WOULD TURN ON MY CAR AND MOST OF THE EXTERIOR LIGHTS WOULD NOT WORK, INCLUDING HEADLIGHTS, HIGH BEAMS, BRAKE LIGHTS, BLINKERS, AND DAYTIME RUNNING LIGHTS. IT WAS DANGEROUS TO SUDDENLY DRIVE WITHOUT LIGHTS WHEN IT WAS NIGHTTIME OR CHANGING LANES WITHOUT WORKING BLINKERS TO ALERT OTHER DRIVERS. I TOOK THE CAR IN TO GET IT CHECKED OUT AND APPARENTLY THIS IS A COMMON ISSUE IN RECENT VW CARS, THAT THE FUSE BOX IS MELTING THE FUSES. I READ MORE ABOUT IT ONLINE AND SOME PEOPLE DESCRIBED PROBLEMS WITH OTHER KEY PROCESSES FAILING LIKE POWER STEERING. I CAN'T BELIEVE VW HASN'T MADE A RECALL ON THIS BECAUSE IT HAPPENS TO SO MANY OF THEIR CARS AND REQUIRES AN EXPENSIVE PART REPLACEMENT. ALSO THIS PROBLEM SEEMS TO HAPPEN TO OTHERS IN THE 10000 MILES BEYOND THE WARRANTY OF A CAR IN 36000 MILES. THAT IS BEING UNFAIR AND DISHONEST TO CUSTOMERS. *TR

NHTSA ODI 10568724

THE HIGH PRESSURE FUEL SYSTEM FAILED IN OUR CAR WHEN WE WERE ON A ONE LANE HIGHWAY. 'ENGINE CONTROL MALFUNCTION' LIGHT STARTED FLASHING AND SUDDENLY OUR CAR WAS STALLED. WHEN WE LOOKED IN THE MANUAL IT SAID TO GET THE CAR TO A VW DEALERSHIP ASAP. WE HAD TO HOLD UP TRAFFIC UNTIL THE CAR WAS FINALLY TOWED. NOT ONLY THAT, WE WERE ON VACATION IN THE DIFFERENT CITY AND THIS HAPPENED DURING THE WEEKEND WHEN THE SERVICE CENTERS ARE CLOSED. AFTER A PAINFUL 2 DAYS WE JUST FOUND OUT THAT OUT HIGH PRESSURE FUEL SYSTEM HAS BROKEN AGAIN. IT WAS LAST REPLACED IN APRIL 2013 AND IT WAS EXACTLY THE SAME SITUATION. THIS IS A REALLY BIG STRUCTURAL DAMAGE AND HAPPENED WITH NO FAULT ON OUR SIDE. THE LAST ONE COST UP TO $10K, WHICH VW COVERED DUE TO WARRANTY. HOWEVER, IT IS ALSO A SAFETY HAZARD SINCE WE COULD HAVE EASILY GOTTEN INTO AN ACCIDENT. AFTER HAVING GONE THROUGH THIS TWICE, WE NO LONGER FEEL SAFE DRIVING THE TDI AND STRONGLY FEEL THAT THE CAR SHOULD BE RECALLED. *TR

NHTSA ODI 10568297

THE HIGH PRESSURE FUEL SYSTEM FAILED IN OUR CAR WHEN WE WERE ON A BUSY CITY STREET. 'ENGINE CONTROL MALFUNCTION' LIGHT STARTED FLASHING AND SUDDENLY OUR CAR WAS STALLED. WHEN WE LOOKED IN THE MANUAL IT SAID TO GET THE CAR TO A VW DEALERSHIP ASAP. WE HAD TO HOLD UP TRAFFIC UNTIL THE CAR WAS FINALLY TOWED. NOT ONLY THAT, THIS HAPPENED DURING LATE NIGHT AROUND 10 PM AND ALL THE SERVICE CENTERS WERE CLOSED. AFTER A PAINFUL 2 DAYS WE JUST FOUND OUT THAT OUT HIGH PRESSURE FUEL SYSTEM HAD TO BE REPLACED. THIS IS A BIG STRUCTURAL DAMAGE WITH THE CAR AND I NO LONGER FEEL SAFE OWNING OR DRIVING IT. *TR

NHTSA ODI 10568298

ON THIS DATE (6-19-2013) MY ENGINE LIGHT CAME ON, AFTER THAT MY EPC LIGHT FOLLOWED. THEN I LOST SPEED ON MY CAR, I THEN PULLED OVER AT THE GAS STATION. I THEN NOTICED MY HORN WAS NOT WORKING. I SAT AT THE GAS STATION AFTER I TURNED THE CAR OFF FOR ABOUT 15 MINUTES. TRIED TO START THE CAR UP AGAIN, THEN IT STARTED BACK UP AND I DROVE HOME, BUT THE ENGINE LIGHT WAS STILL ON. I DIDN'T THINK MUCH OF IT AT THAT POINT, A WEEK LATER I HAD THE OIL CHANGED. APPROXIMATELY TWO MONTHS LATER (WHICH WAS IN AUGUST) I HAD THE SAME PROBLEM. SO I CALLED VOLKSWAGEN OF AMERICA AND EXPLAINED TO THE CS REP MY ISSUE. THEY ADVISED ME TO TAKE MY CAR TO THE DEALERSHIP; WHICH I DID. THE GENTLE THAT ASSISTED ME BROUGHT OUT A LAB TOP COMPUTER AND RESET WHAT EVER IT WAS HE RESET ON THE CAR AND THE ENGINE LIGHT WENT OFF AND THE CAR DROVE FINE. THEN HE TOLD ME THAT I NEEDED A FULL TURN UP AND THAT IT WOULD COST ME $700, BECAUSE MY WARRANTY WOULD NOT COVER THE TURN UP ON THE CAR. IN ANY CASE, MY VW JETTA DRIVE FINE FOR ABOUT FOUR DAYS,I HORN STILL DIDN'T WORK. ABOUT TWO WEEKS INTO SEPTEMBER OF 2013, I WAS ON MY WAY TO WORK AND THE CAR WOULD NOT START FOR AN WHOLE HOUR. IN THE MIST OF MY DILEMMA, LATE FOR WORK; I HAD VV OF AMERICA ON THE PHONE TELLING THE REP, COREY WHAT WAS HAPPENING WITH THE CAR. HE ADVISED ME TO TAKE THE CAR TO THE DEALERSHIP AS WELL. WHICH I MADE AN APPOINTMENT TO THE DEALERSHIP, THEY ALSO TOLD ME THAT THE CAR NEEDED A TURN UP AS WELL. BUT THEY WERE CHARGING ME A RIDICULOUS AMOUNT OF MONEY FOR THE TURN UP. I GOT A FULL TURN UP ON THE CAR AND NOW MY CAR SHAKES UNCONTROLLABLY, THE EPC LIGHT STAYS ON. IT'S ONLY DRIVING 40 MPH AS WE SPEAK. I HAD A PROFESSIONAL TO CHECK THE ENGINE AND FROM WHAT THEIR DIAGNOSIS, TWO DEAD CYLINDERS (PO CODES P0351 AND P0353) AND A BAD COMPUTER. I AM GETTING NO FINANCIAL ASSISTANCE FROM VOLKSWAGEN OF AMERICA, PER COREY CS REP FROM VV OF AMERICA. *TR

NHTSA ODI 10568066

MY 2011 VOLKSWAGEN JETTA TDI STARTED TO SPUTTER WHEN ACCELERATING, I BROUGHT IT THE DEALER AND THEY FOUND SHARDS OF METAL IN THE FUEL SYSTEM. HPFP (HIGH PRESSURE FUEL PUMP) HAD FAILED. THE QUOTE TO FIX WAS 6875.00 TO FIX A TWO YEAR OLD CAR. VERY UN HAPPY. *TR

NHTSA ODI 10567775

I WAS DRIVING DOWN THE INTERSTATE AT 70MPH WHEN MY ENGINE CONTROL LIGHT CAME ON. I LOST ALL POWER IN THE CAR. ONCE I LET GO OF THE PEDAL, THE CAR BEGAN TO STALL. WHILE PUSHING THE GAS PEDAL COMPLETELY, I COULDN'T GO ANY FASTER THAN 60MPH. ONCE I GOT OFF AT AN EXIT AND HAD TO COME TO A STOP, THE CAR COMPLETELY STALLED AND WOULD NOT START AGAIN. THE HIGH PRESSURE FUEL PUMP HAD APPARENTLY FAILED.I HAD TO HAVE IT TOWED TO VW TO BE DIAGNOSED AND THEY STATE IT IS THE HIGH PRESSURE FUEL PUMP, AND THAT THIS IS A KNOWN ISSUE. WHILE I WAS STILL AT THE VW SERVICE CENTER IN OCALA, I CALLED VW USA, WHO CLAIMS THEY ARE NOT HAVING ANY PROBLEMS WITH THESE PUMPS AND ASKED WHERE I GOT THIS INFORMATION. I HAD TO DEMAND TO SPEAK WITH A SUPERVISOR WHICH THEY WOULD NOT LET ME TALK TOO. THE REP PUT ME ON HOLD TO SPEAK WITH THEM. FINALLY SHE CAME BACK AND SAID SHE WAS JUST MADE AWARE OF SOMETHING THAT I NEED TO GO TO THE SERVICE MANAGER AND SPEAK WITH HIM. I DID SO AND HE SAID THAT HE IS PUTTING IN A SPECIAL REQUEST FOR CUSTOMERS THAT ARE OUT OF WARRANTY. I NOW HAVE BEEN WAITING 3 DAYS WITH NO RESPONSE. THE SERVICE MANAGER HAS BEEN VERY HELPFUL AND KIND IN ATTEMPTING TO RESOLVE THIS ISSUE, SO THE ISSUE IS NOT WITH THEM. THE ISSUE IS THAT I AM ABLE TO SEARCH THE INTERNET AND FIND IN A MULTITUDE OF SITES, WHERE THESE VEHICLES ARE HAVING THIS ISSUE, YET I AM STILL WAITING AFTER 3 DAYS TO GET MY VEHICLE REPAIRED. I DID NOT PUT ANY REGULAR GASOLINE IN MY VEHICLE. I AM A DIE HARD DIESEL CUSTOMER AND KNOW BETTER. I AM ALSO ABLE TO VIEW THE OPEN INVESTIGATION THROUGH THIS SITE WHICH INCLUDES MY 2011 VW JETTA TDI. A CO-WORKER OF MINE ALSO JUST HAD THIS EXACT PROBLEM WITH HIS 2012 VW JETTA TDI, WITH SIMILAR MILEAGE, AND EVEN HAD A SECOND FAILURE, BOTH OF WHICH VW COVERED AT NO COST TO THE CUSTOMER, I AM BEGINNING TO GROW EXTREMELY FRUSTRATED WITH THIS SITUATION I WOULD LIKE IT RESOLVED. *TR

NHTSA ODI 10566487

BROUGHT TO DEALER TO DIAGNOSE SERVICE ENGINE LIGHT, CODE P191, AND ONCE P087. I GET DIESEL AT THE SAME STATION WHENEVER POSSIBLE. THESE ERRORS STARTED OCCURRING SHORTLY AFTER GETTING A FULL TANK OF DIESEL AT A DIFFERENT STATION. DEALER CONCLUDED THAT HIGH PRESSURE FUEL PUMP FAILURE WAS IMMINENT. ENGINE STALLED ON THE WAY HOME AND FAILED TO RESTART. FUEL SYSTEM WAS REPLACED. CAR AGAIN WORKS SATISFACTORILY. HOW MUCH LIFE (MILES) CAN I EXPECT THIS TIME AROUND? ARE THERE ANY PROVEN PREVENTIVE MEASURES? *TR

NHTSA ODI 10565800

MY WINDSHIELD WASHER FLUID SENSOR CAME ON, AND IT DOES NOT TURN OFF. I DID SOME READING ONLINE, AND THIS SEEMS TO BE A SYSTEMIC ISSUE. MOST OF THE COMPLAINTS WERE FROM PEOPLE WHO USED RAINX WASHER FLUID. APPARENTLY IT CAUSED CORROSION TOO QUICKLY. NOW, I DON'T WANT TO USE MY WASHER FLUID AS OFTEN, SO THAT I CAN MAKE SURE THAT I DON'T RUN OUT WHEN I NEED IT. MY VISIBILITY DURING DRIVING IS AFFECTED BY THIS. *TR

NHTSA ODI 10565523

THE EFFECTED CAR WAS A DIESEL MODEL 2011 VOLKSWAGEN JETTA TDI SEDAN WITH 48,074 MILES ON THE ODOMETER AT THE TIME OF THE INCIDENT. WHILE TRAVELING AT APPROXIMATELY 40 MPH IN NORMAL DRIVING CONDITIONS, THE VEHICLE EXPERIENCED A SUDDEN REDUCTION IN POWER AND DISPLAYED A FLASHING GLOW PLUG LIGHT AND SOLID CHECK ENGINE WARNING LIGHTS. THE VEHICLE WAS IMMEDIATELY PULLED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS SHUT OFF. THE ENGINE FAILED TO RESTART AND WAS TOWED TO A VOLKSWAGEN DEALERSHIP SERVICE DEPARTMENT. THE VOLKSWAGEN DEALER DETERMINED THAT A CATASTROPHIC FAILURE OF THE VEHICLE'S HIGH PRESSURE FUEL PUMP (HPFP) HAD OCCURRED. THE DEALER FOUND THAT EXTENSIVE DAMAGE TO THE ENTIRE FUEL SYSTEM HAD RESULTED FROM THE FAILURE, CAUSING INTERNAL METAL DEBRIS CONTAMINATION THAT REQUIRED SUBSTANTIAL REPAIRS. THE TOTAL COST OF REPAIRS WERE REPORTED BY THE DEALERSHIP TO EQUAL $6,500.00. *TR

NHTSA ODI 10561176

THIS HAS HAPPENED MULTIPLE TIMES. THE FIRST RECORDED INCIDENT WAS IN MARCH OF 2013. WENT TO THE CAR AND IT WOULD NOT START. IT ACTED LIKE THE ENGINE WAS SEIZED OR A BAD BATTERY. LET IT SIT STARTED RAN LIKE CRAP. FOUND OUT LATER THAT THE CAR WHEN DRIVEN IN COLD TEMPERATURES ACCUMULATES WATER IN THE SYSTEM. HTTPS://DOCS.GOOGLE.COM/FILE/D/0B162-SX2NN5LUZBIDG9HCVR6NUU/EDIT?PLI=1 THATS THE VW TECH BULLETIN ON THE MATTER. IT HAS HAPPENED MULTIPLE TIMES. FROM READING ONLINE THIS HAS / CAN START A FIRE BECAUSE THE STARTER OVERHEATS. SINCE THE WATER GETS INTO THE CYLINDERS IT CAN CAUSE ENGINE DAMAGE. VW DID NOT ADDRESS THE ISSUE WHEN IT WAS BROUGHT IN BECAUSE THEY COULD NOT REPEAT THE PROBLEM. SAID I MUST HAVE KILLED THE BATTERY BY LEAVING SOMETHING ON. SINCE THAN IT HAS HAPPENED 4 MORE TIMES I CAN RELATE TO THE CONDITION. IT IS IN THE DEALERSHIP NOW BECAUSE OF IT. THEY COULD NOT GET IT TO REPEAT AND MAY NOT PROVIDE A FIX (ALTHOUGH THE GIVEN FIX DOES NOT 100% FIX IT I WAS TOLD BY A TECH.) *TR

NHTSA ODI 10558993

WHILE DRIVING THE 2011 VW JETTA ON 1/5/14 DURING RAIN SHOWERS I SWITCHED THE WIPERS ON (WHICH I HAD PREVIOUSLY USED APROX 5 MINS BEFORE) & NOTHING HAPPENED, THEN I REALIZED THAT THE TURN SIGNALS WERE ALSO NOT WORKING INCLUDING THE HAZARD FLASHERS.. UPON REACHING MY HOME AT REDUCED SPEEDS IN ORDER TO SAFELY MAKE IT HOME I ATTEMPTED TO MAKE THE NEEDED REPAIR TO RESOLVE THE ISSUE, THINKING THE ISSUE WAS A BLOWN FUSE, BUT AFTER FURTHER INVESTIGATION NO BLOWN FUSES ARE PRESENT & AT THE CURRENT TIME VW SERVICE DEPT. DENIES THAT ANY PART OF THE ELECTRICAL SYSTEM IS FAULTY & ALTHOUGH THE PROBLEM IS STILL CURRENTLY NOT FIXED. ALONG WITH OTHER ELECTRICAL FUNCTIONS SUCH AS THE POWER WINDOWS & DOOR LOCKS NOT FUNCTIONING DUE TO THIS ELECTRICAL MALFUNCTION THE VEHICLE WILL NOT CRANK & START USING THE IGNITION SWITCH. I FEEL THIS PROBLEM IS A SAFETY ISSUE THAT VW NEEDS TO ADDRESS & OFFER A RECALL BEFORE SUCH A MALFUNCTION RESULTS IN A FATAL INCIDENT DUE TO NOT BEING ABLE TO CLEARLY SEE THE ROADWAY DURING RAINY CONDITIONS. *TR

NHTSA ODI 10559071

ON APRIL 19, 2013, TIRE PRESSURE WAS LOW ON THE FRONT PASSENGER SIDE. UPON CHECKING THE TIRE A LARGE CRACK WAS NOTICE ON THE INSIDE WALL OF THE TIRE. THE TIRE WAS REPLACED AT OWNER'S EXPENSE OF $177.01 WITH AN ODOMETER READING OF 27293 ON A 2011 VW JETTA TDI. ON JANUARY 4, 2014, THE OWNER NOTICED A LARGE CRACK ON THE DRIVER SIDE FRONT TIRE'S SIDEWALL. THE OWNER CALLED THE DEALERSHIP AND NO RECALLS WERE CURRENTLY IN PLACE. THE OWNER SUBMITTED A REQUEST FOR HANKOOK TO PAY FOR REIMBURSEMENT OF ALL TIRE REPLACEMENTS AS THE OWNER FEELS THE VEHICLE IS NOT SAFE TO DRIVE WITH A POTENTIAL TIRE BLOWOUT AND LOSS OF VEHICLE CONTROL. *TR

NHTSA ODI 10558902

THE DRIVER'S SIDE SEATBELT HAS STARTED UNRAVELING SIGNIFICANTLY ALONG ONE EDGE, WITH THE THREADS SEPARATING; THIS HAS BEEN GOING ON FOR SEVERAL MONTHS. THE CAR WAS PURCHASED NEW AND HAS ABOUT 40,000 MILES ON IT. *TR

NHTSA ODI 10558588

DRIVE HOME FROM WORK AT ABOUT 1500 HRS, WITH NO ISSUES. STOPPED AT LOCAL SUPERMARKET, STARTED ENGINE WITH SLIGHT DELAY, LEFT PARKING LOT, CAR STARTED TO BUCK, DROVE MAYBE 1/2 MI STARTED LOSING POWER, AFTER GOING ANOTHER 50 FT CAR ENGINE DIED, PUSHED CAR TO MY DRIVEWAY CALLED DEALERSHIP AND HAD CAR TOWED TO DEALERSHIP. ON 11/21/13 DEALERSHIP INFORMED ME THAT HPFP HAD EXPLODED SENDING METAL SHAVINGS INTO ENGINE, THEY ASKED ME IF I ACCIDENTALLY PUT GAS AND I RESPONDED WITH NO. THEY STATED THAT FUEL MAY HAVE BEEN CONTAMINATED. DEALERSHIP IS REPAIRING CAR SINCE IT IS STILL UNDER WARRANTY, SAID MAYBE 1 WEEK IN THE SHOP. I WAS GIVEN A RENTAL IN THE MEANTIME. *TR

NHTSA ODI 10553802

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE PASSENGER'S SIDE HEADLIGHTS FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE FUSE BOX WAS OVERHEATING AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 60,100.

NHTSA ODI 10553321

DURING MID MOTION, WITH FOOT ON THE GAS, THE VEHICLE DIED IN THE MIDDLE OF THE INTERSECTION. NO WARNING INDICATIONS APPEARED ON THE DASH. THE SPEED OF TRAVEL WAS APPROXIMATELY 35MPH. THE CAR WAS TOWED BY AAA. SERVICE AT VW HAS YIELDED INCONCLUSIVE RESULTS. THERE ARE NUMEROUS FORUMS ON EDMUNDS DETAILING AND ACCOUNTING THIS SEEMINGLY UBIQUITOUS AND POTENTIALLY FATAL FLAW. AS IT STANDS, VW IS PERSISTENT IN THERE STANCE TO DO NOTHING ABOUT IT. THEY REFUSE TO ISSUE A REFUND OR EXCHANGE ON CERTIFIED CARS. THIS PARTICULAR MODEL IN WHICH I WRITE ABOUT, WAS ON ITS FIRST DAY OFF OF THE LOT, AS A CERTIFIED PRE-OWNED VEHICLE. VW REFUSES ANY SUCH POSSIBILITY OF RETURN, EVEN ON ACCOUNT OF POSSIBLE SAFETY CONCERNS, AND DESPITE THE ACCUMULATIVE REPORTS OTHERS HAVE MADE DOCUMENTING THIS EXACT FLAW, WITHOUT ANY KNOWN WAY OF REMEDYING ON VW'S PART. *TR

NHTSA ODI 10551597

ALL FINE IN THE MORNING, PARKED IN A PAVED LOT AT WORK. LEAVING IN THE AFTERNOON INSTRUMENT CLUSTER TOLD ME A LIGHT WAS OUT. BY THE TIME I WAS LEAVING THE PARKING LOT THE FOLLOWING WERE NOT WORKING: LEFT: FONT SIDE, REAR TURN. RIGHT: HEADLIGHT, DAYTIME RUNNING LIGHT, FRONT TURN, REAR TAIL. LICENSE PLATE LIGHTS. A FRIEND IS AN ASE MASTER TECH. THIS IS WHAT HE FOUND: "SO TO FOLLOW UP ON THIS. IF YOU LOOK AT THE FUSE IT APPEARS TO BE ''COOKED'' ON ONE SIDE. THIS WOULD INDICATE HEAT ON ONLY ONE SIDE OF THE FUSE. I THINK WE CAN AGREE THIS IS NOT A FUSE ISSUE, BUT A WIRING OR SUPPLY ISSUE. WITH THE KNOWLEDGE THAT WHEN YOU TRY AND RUN TO MANY AMPS THROUGH TOO SMALL A WIRE IT CREATES EXCESS HEAT I WOULD VENTURE THAT VW PUT TOO SMALL A WIRE ON ONE SIDE OF FUSE 16. THE FUSE BLOCK IS IN THE ENGINE COMPARTMENT IN FR OF THE BRAKE BOOSTER. THE 16 FUSE IS TOWARDS THE BACK OF THE BLOCK AND THE BURNT SIDE WAS TOWARDS THE PASSENGER SIDE OF THE CAR. I AM NOT SURE HOW WORRIED I WOULD GET ABOUT THIS, BUT SIMPLY PUT A FEW 30AMP FUSES IN THE GLOVE BOX. YA THERE IS AN ISSUE THERE, BUT THE FIRST ONE LASTED 39K." I HAVE THE FUSE. AT LEAST ONE OTHER PERSON HAS HAD A SIMILAR ISSUE: HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=355338&PAGE=3. *TR

NHTSA ODI 10550349

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA EQUIPPED WITH HANKOOK OPTIMO H725A TIRES, SIZE 205/55/R16H. THE CONTACT STATED THAT WHILE CHECKING THE AIR PRESSURE ON THE TIRES, HE NOTICED THAT THE SIDEWALL ON BOTH THE FRONT DRIVER AND PASSENGER SIDE TIRES EXHIBITED SEVERAL CRACKS. THE TIRES WERE NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE OF THE TIRE AND THE VEHICLE WAS 31,000.

NHTSA ODI 10549804

I WAS ON MY WAY HOME AFTER WORK APPROXIMATELY 6-7 PM DOING 45 MPH. I LOOKED DOWN TO MY INSTRUMENT CLUSTER TO CHECK MY SPEED TO MAKE SURE I WASN'T SPEEDING. THEN I SAW THE GLOW PLUG LIGHT BLINKING MULTIPLE TIMES THEN ABOUT LESS THAN 5-10 SECONDS LATER MY ENGINE CUT OUT. I COST OFF INTO A HARPER COLLEGE PARKING LOT CAME TO A STOP. I TRIED TO START THE CAR 2-3 TIMES, EACH TIME THE ENGINE WAS CRACKIN OVER BUT WOULDN'T START IT UP. I CALLED THE TOW TRUCK COMPANY AND HAD THE VEHICLE TOWED TO VW DEALER IN SCHAUMBURG, IL ( FOX VALLEY VW) DEALER SAID THE HIGH PRESSURE FUEL PUMP FAILED. VWOA COVER THIS UNDER POWER TRAIN WARRANTY 5/60K WARRANTY. THE DEALER REPLACE HPFP,LIFT PUMP, PUMP IN GAS TANK,FUEL LINES TO ENGINE,COILS ETC... REPAIRS CAME TO ROUGHLY $5300.00. VWOA ONLY GIVE 12/12K MILES WARRANTY ON THE HPFP. THIS IS A KNOWN PROBLEM ON SOME VW WITH CJAA 2.0L TURBO DIESEL ENGINES AND VWOA HAS NOT FOUND THE DEFECT IN THE HPFP.VWOA SHOULD EXTEND THE HPFP TO 100K MILES DUE TO DEFT IN THE HPFP SINCE THEY HAVEN'T FOUND THE PROBLEM AND CORRECTED IT. *TR

NHTSA ODI 10547288

HIGH PITCHED WHINE, SUDDEN STALL AT HWY SPEED. THE FUEL LIGHT AND SERVICE ENGINE NOW LIGHT CAME ON. THE VEHICLE WOULD NOT RUN AND REQUIRED A TOW TO THE DEALERSHIP. I WAS NOTIFIED IT WOULD BE A $5000+ REPAIR AND THE HPFP FAILED REQUIRING THE ENTIRE FUEL SYSTEM TO BE REPLACED. *TR

NHTSA ODI 10544600