What 687 owners told NHTSA about the 2011 Ram 1500 Crew Cab

TRUCK HAS 76K MILES CHECK ENGINE LIGHT CAME ON CODED MISFIRE CYL #5 NO PROBLEM CHANGED PLUGS. STILL ON . CHANGED COIL STILL ON . DROVE TO WORK NEXT MORNING RUNNING VERY RUFF VERY POOR MILEAGE. MECHANIC PICKED UP THE TRUCK. CALLED ME BACK 1HR OR SO LATER LIFTER STUCK NOT OPENING VALVE ON CYL 5 COMPLETELY.RESEARCH ONLINE SHOW THIS TO BE A VERY COMMON DEFECT FOR THIS YR MAKE N MODEL 5.7HEMI. WHAT IS WORSE IS THAT THE MANUFACTURE HAS DONE NOTHING ABOUT IT . SOME DEALERS WONT EVEN BOTHER TO LOOK AT THE ISSUE. NO VEHICLE SHOULD GO FROM SIMPLE MISFIRE CODE TO CATOSTROPHIC FAILURE LIKE THAT . AND NO DEALER SHOW ALLOW ITS CUSTOMERS TO SUFFER THE LOSSES FOR THERE NEGLIGENCE ......... IF YOU GOOGLE RAM MISFIRE THIS IS WHAT YOU WILL FIND , AND NOT ONE STORY WILL IT BE DO TO A SPARK PLUG OR A COIL. CATOSTROPHIC CAM AND LIFTER FAILURE REPAIR COST RANGE FROM 3800-6000 NOT INCLUDING LOSS OF WORK OR TIME.

NHTSA ODI 11051000

FIRST I NOTICED A TICK IN THE ENGINE WHEN STARTING IT COLD. TURNED OUT TO BE BROKEN EXHAUST MANIFOLD STUDS AND CRACKED MANIFOLDS ON BOTH SIDES. PASSENGER SIDE WAS WORSE. WAS REPLACED WITH GRADE 8 BOLTS AND NEW MANIFOLDS AND GASKETS. NOW I HAVE A DIAGNOSED LIFTER FAILURE AT 58,000 MILES AND IT IS ONLY GETTING LOUDER. IT HONESTLY SOUNDS LIKE A SPUN CAM SEAL AND FLAT LIFTER IN MY EXPERIENCE. DODGE WILL NOT REMEDY THE PROBLEM AS I BOUGHT THE VEHICLE OUT OF POWERTRAIN WARRANTY. MANY MORE ARE HAVING THE SAME EXACT ISSUE WITH LIFTER FAILURE. IT IS KNOCKING HARD. THIS IS THE DESCRIBED "HEMI" TICK. THE CAMSHAFTS AND LIFTERS ARE LOW GRADE MATERIAL IN THIS MODEL. I HAVE REPORTS OF DIAGNOSIS IF NEEDED.

NHTSA ODI 11047833

THE TRUCK TURNING OFF WHILE DRIVING DOWN THE ROAD. DUE TO THE IGNITION SWITCH. LIGHTS AND EVERYTHING SHUT OFF WHILE DRIVING DOWN THE ROAD DURING NIGHT OR DAY. SMALL BUMPS IN THE ROAD CAUSE A SHORT. MY TRUCK ISN'T THE ONLY ONE THAT DOES IT I SPOKE TO OTHER DODGE OWNERS THAT HAVE THE SAME PROBLEM

NHTSA ODI 11046394

ROCKING NOISE AT IDLE AND WHEN DRIVING DOESN'T GO AWAY WHEN WARMED UP

NHTSA ODI 11045975

MY TRUCK WOULD CRANK BUT NOT START SOMETIMES AFTER BEING PARKED FOR A WHILE. I THOUGHT IT MAY HAVE BEEN FROM THE HUMIDITY. IT WILL CRANK AND NOT START A COUPLE OF TIMES MORE OFTEN NOW. WHEN DRIVING ON THE HIGHWAY SOMETIMES, IT WILL SPUTTER FOR A COUPLE OF SECONDS. I THOUGHT IT MIGHT HAVE BEEN FROM HAVING A LITTLE WATER IN THE GASOLINE FROM THE ETHANOL. I'VE BEEN USING FUEL INJECTOR CLEANER AND SEAFOAM EVERY SO OFTEN SINCE 2014. THE TRUCK IS 6 YEARS OLD. I'VE BEEN READING ABOUT HOW OTHERS HAVE BEEN HAVING A PROBLEM WITH THE FUEL PUMP RELAY GOING BAD ON THE SAME YEAR MODEL VEHICLE AND OTHER MAKE/MODELS BY DODGE.

NHTSA ODI 11030438

DRIVING ON INTERSTATE TODAY, THE 4 WHEEL DRIVE LIGHT BEEPED ONCE AND THE ENGINE DIED. LUCKILY WE COASTED TO THE SIDE, THE DOORS WOULD NOT LOCK, WINDOWS WOULD NOT ROLL DOWN. STARTED WOULD ENGAGE. SOUNDS LIKE TIPM TROUBLE. SPENTS $200 BEING TOWED HOME 75 MILES

NHTSA ODI 11019878

THE MANIFOLD STUD BOLTS ARE BREAKING OFF IN THE HEAD MOST COMMONLY WITH 7 AND 8 CYLINDER...CAUSE A HORRUBLE EXHAUST LEAK AND CAUSING THE MANIFOLD TO WORP AND CRACK

NHTSA ODI 11015617

TL* THE CONTACT OWNS A 2011 RAM 1500. ON SEVERAL OCCASIONS, WHILE DRIVING, THE ENGINE STALLED. AS A RESULT, THE VEHICLE LOST ALL ELECTRICAL POWER. ALSO, THE VEHICLE BEGAN TO ROLL WHILE THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE STARTED TO FUNCTION AGAIN AND THE CONTACT WAS ABLE TO GAIN CONTROL OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER (ACADEMY CHRYSLER DODGE JEEP RAM AT 5080 ACADEMY LN, BESSEMER, AL 35022, (205) 545-8052) WHERE IT WAS DIAGNOSED THAT THE TIPM MALFUNCTIONED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.

NHTSA ODI 10994023

"TAKATA RECALL " FIRST BOUGHT THE TRUCK IN 2015. 2ND DAY I HAD IT ALMOST COUGHT ON FIRE 78000 MILES SOMETHING TO DO WITH THE BATTERY. 2017 99000 MILES LIFTERS ARE TICKING AND IT DOESN'T WANT TO START IT FREAKS OUT EVERY ONCE IN A WHILE IF YOU TRY AND START IT ALL THE LIGHTS FLASH THEN IT'S GOOD FOR A MONTH

NHTSA ODI 10980055

MY ENGINE HAS 99, 800 MILES AND MY CHECK ENGINE LIGHT CAME ON, THE DODGE DEALERSHIP ADVISED ME THAT MY CAM SHAFT AND MY LIFTER WAS DAMAGED AND NEEDED REPLACING. THE DEALERSHIP ALSO ADVISED ME THAT IT WAS CAUSED BY PRE-MATURE FAILURE.

NHTSA ODI 10972238

AIR CONDITIONER CONDENSER UNDER DASH WENT OUT AT ABOUT 85,000 MILES. AT 105,000 MILES CHECK ENGINE LIGHT CAME ON. I TOOK IT TO 3 DIFFERENT SHOPS AND ALL 3 FOUND NUMBER 5 CYLINDER OF MY 5.7 CYLINDER ENGINE WAS NOT OPERATING PROPERLY. AFTER DEEPER INVESTIGATION IT TURNED OUT TO BE A WORN CAMSHAFT LOBE. ALL OIL CHANGES WERE DONE AT PROPER INTERVALS AND USED SYNTHETIC OILS. MECHANIC SAID IT WAS COMMON WITH THE 5.7 ENGINE.

NHTSA ODI 10966594

ENGINE GOING DEAD ON SEVERAL OCCASIONS WHILE CAR IS MOVING THEREFORE STEERING IS LOCKED. HAS ,HAPPENED ON THE INTERSTATE @ 70 MPH, CITY STREET @ 30 - 40 MPH AND COUNTY ROAD @ APPX 10 MPH. LOCAL DEALERSHIP HAS NO RECALL NOTIFICATION NOR CAN THEY IDENTIFY THE PROBLEM. WE CANNOT FIND RECALL NOTIFICATION ON THIS WEBSITE.

NHTSA ODI 10955601

TL* THE CONTACT OWNS A 2011 RAM 1500. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING AND DECELERATION WHILE BEING OPERATED AT INTERSTATE SPEEDS. UPON INSPECTION, THE CONTACT NOTICED FLUID ON THE ENGINE AND SMOKE COMING FROM THE ENGINE COMPARTMENT. THE CHECK ENGINE, COOLANT, AND SERVICE FOUR WHEEL DRIVE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE OVERHEATED. AS A RESULT, THE ENGINE WIRING MELTED. THE ROOT CAUSE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 51,669.

NHTSA ODI 10954507

THE TRUCK BURNS THROUGH OIL AT A HIGH RATE AND AFTER IT DOES THEIR IS NO LOW OIL LIGHT BEING TURNED ON BY THE TRUCK. THE TRUCK RAN HOT AND MADE THE CAM POSITION SENSOR FAIL. I AM AFRAID IT WILL BURN EVEN MORE AND CAUSE PREMATURE ENGINE FAILURE AND SENSOR FAILURE WHICH IS NOT COVER BY WARRANTIES. THE LAST TIME IN A MONTH IT BURNED THROUGH 4 QUARTS, THE DEALER SAID IF THEY DO NOT FIND ANYTHING WRONG THEY WOULD CHARGE ME A DIAGNOSTIC FEE. I HAVE HAD MANY OLD DODGE TRUCKS AND EVEN A 2007 RAM WHICH ALWAYS HAD OIL BETWEEN OIL CHANGES AND THAT NEVER BURNED THROUGH SO MUCH OIL. THIS HAPPENS AS I DRIVE AND NEVER ONCE DOES IT SAY LOW OIL, THE ONLY REASON I FIGURED IT OUT IS I AM MECHANICALLY INCLINE AND OBSERVED THE OIL PRESSURE DROP DOWN TO 14PS ON THE TRUCKS INFORMATION CONSOL. ALSO THE TRUCK HAD GONE INTO A MODE WHERE THE THROTTLE DID NOT RESPOND AND THE TRUCK WOULD NOT DOWN SHIFT. ALL THIS HAPPENS AT THE SAME TIME AND IF IT HAPPENS ON A HIGHWAY MAY CAUSE A CRASH BECAUSE THE TRUCK DOES NOT SHIFT PROPERLY ALONG WITH NO OIL THE ENGINE WILL FAIL.

NHTSA ODI 10948352

MY TRUCK STARTED OUT WITH A DEAD BATTERY WHICH I REPLACED AND IT STARTED IN 9/16. AROUND 12/17/16 I WAS PARKED IN MY TRUCK TALKING TO MY NEIGHBOR WHEN I DECIDED TO TURNOFF TRUCK AND GET OUT OF TRUCK. I TURNED THE KEYFOB TO OFF POSITION ONLY TO HAVE IT STAY RUNNING, I THAN TURNED KEYFOB BACK TO ON POSITION THAN BACK OFF WHERE IT SHUT OFF. I PULLED INTO DRIVEWAY SAME DAY AND THAN THE KEYFOB STUCK IN OFF POSITION WITH TRUCK STILL RUNNING. MY HUSBAND GO IN IT AND STARTED TO FOOL AROUND WITH IT PUTTING IT INTO NEUTRAL THAN PARK THAN REVERSE AND IT FINALLY CAME OUT. 1/11/ 17 I STARTED TRUCK NOTICED TIPM LIGHT ON AND TRACTION CONTROL LIGHT ON. I PULLED OUT OF DRIVEWAY THE TIPM LIGHT WENT OUT BUT THE TRACTION CONTROL LIGHT STAYED ON THE WHOLE ENTIRE TIME I WAS DRIVING IT. THEN I GOT HOME AND THE KEY LITERAL FELL OUT WHILE DRIVING IT AND I LOST ALL POWER. WHEN MY HUSBAND CAME TO MY RESCUE THE TRUCK STARTED JUST FINE AND HE DROVE IT HOME ONLY TO HAVE TURNED THE KEYFOB TO OFF POSITION AND PULL OUT THE KEYFOB AND HAVE THE TRUCK STILL RUNNING. HE HAD TO PULL THE 5AMP #27 FUSE AND DISCONNECT THE BATTERY IN ORDER TO TURN IT OFF. BROUGHT TO DEALER ONLY TO BE TOLD NO RECALL ISSUES, THAT THEY THINK IT HAS SOMETHING TO DUE WITH MY AFTER MARKET STEREO THAT WAS PUT IN OVER 5 YEARS AGO. THE ADVISOR CALLED ME AFTER HAVING TO TRUCK FOR 3 DAY TO TELL ME TECH NEEDS ANOTHER 4 HOURS WITH IT AND IT WAS GOING TO BE 600.00 ONTOP OF THE 150.00 I ALREADY OWED . I ASKED TO SPEAK TO MANAGER WHO COULD NOT TELL ME THAT THEY RULED ANYTHING ELSE OUT WOULD NOT EVEN GIVE ME A PRINTOUT OF WHAT WAS DONE. I ASKED ABOUT THE TIPM AND HE LOOKED AT ME LIKE I WAS CRAZY. I WILL BE TAKING VEHICLE OUT WITH NO REPAIRS AND TOLD THEM IF I CRASH AND KILL SOMEONE OR MYSELF THEIR HEADS ARE GOING TO ROLL, THIS IS DEFINITELY A DANGEROUS SITUATION. *TR

NHTSA ODI 10947836

SUFFERING FROM A VERY COMMON ISSUE OF EXHAUST MANIFOLD WARPAGE CAUSING LEAKS AND BROKEN BOLTS. THE LEAKS ARE ALLOWING EXHAUST TO ENTER THE PASSENGER CABIN WHICH IS CAUSING HEADACHES AND SLEEPINESS WHILE DRIVING. *TR

NHTSA ODI 10945924

I HAVE A 5.7 HEMI. IT HAS A BAD TICKING SOUND ON BOTH SIDES AND IS MISFIRING ON #8 CYLINDER. I CAN'T FIGURE IT OUT AND AFTER RESEARCHING ABOUT IT THIS IS AN ONGOING PROBLEM WITH THE 5.7 HEMI. I CAN'T FIND A RECALL ON IT AND I THINK SOMETHING NEEDS TO BE DONE ABOUT IT. I THINK THE DODGE PLACE SHOULD BE HELD RESPONSIBLE SINCE IT'S AN ONGOING PROBLEM WITH IT. THIS TICKING SOUND HAPPEN ANYTIME IT'S RUNNING.

NHTSA ODI 10945881

THE ENGINE STALLS WHEN MAKE A TURN, ALL THE POWER STEERING & POWER BRAKES QUIT. I HAVE TO RESTART THE ENGINE TO MOVE THE VEHICLE OUT OF THE WAY OF OTHER VEHICLES. THIS GOING GET SOMEONE KILLED.

NHTSA ODI 10943729

WHILE VEHICLE IS IN MOTION AT LOW SPEED, ENGINE WILL SHUT OFF. DURING UP HILL CITY DRIVING, ENGINE WILL NOT MAINTAIN CONSTANT RPM OR SMOOTH ACCELERATION. IT TAKE APPROXIMATELY 20 MINUTES TO START THE VEHICLE. *TR

NHTSA ODI 10937072

DRIVING ON THE FREEWAY DURING RUSH HOUR TRAFFIC AND MY ENGINE DIED. I COULD NOT GET OUT OF THE TRAFFIC LANE AND MY TRUCK CAME TO A COMPLETE STOP. ENGINE CRANKED, BUT WOULD NOT START. SOMEONE HELPED ME PUSH MY TRUCK OUT OF THE TRAFFIC LANES (VERY RISKY FOR THEM AND FOR ME AS TRAFFIC WAS STILL MOVING, SWERVING AND CAUSING A BACK UP.) AFTER ABOUT TEN-FIFTEEN MINUTES, THE TRUCK STARTED AND I DROVE IT HOME. TURNED TRUCK OFF AND ON AND IT SEEMED OK. NEXT MORNING TRUCK WOULD NOT START, I SPRAYED STARTING FLUID IN AIR INTAKE AND IT TRIES TO START, SO I AM GUESSING FUEL PROBLEMS. TRUCK STARTED AFTER MUCH CRANKING, BUT DON'T TRUST IT, NOT SAFE TO GO ON FREEWAY AND CAUSE ANOTHER SCARY SITUATION. RESEARCH TELLS ME THIS IS A COMMON PROBLEM. I DID NOT SUFFER ANY LOSSES, BUT MAY HAVE CAUSED OTHER ACCIDENTS DUE TO THE TRAFFIC BACK UP I CAUSED. *TR

NHTSA ODI 10934310

TL* THE CONTACT OWNS A 2011 RAM 1500. WHILE PARKED, THE VEHICLE CAUGHT FIRE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED BY THE INSURANCE COMPANY. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED. THE FAILURE MILEAGE WAS APPROXIMATELY 93,000.

NHTSA ODI 10924123

TL* THE CONTACT OWNS A 2011 RAM 1500. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED STALLING AND FAILURES WITH STARTING. THE FAILURES OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIPM NEEDED TO BE UPDATED. UPDATE INSTALLED AND HAS NOT CORRECTED PROBLEM. MOST LIKELY HAS FAILED AND NEEDS TO BE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.. ..UPDATED 11/01/16 *BF THE DEALER INFORMED THE CONSUMER THE FUEL PUMP RELAY WAS FAULTY. THE DEALER FIXED THE PROBLEM BY SUPPLYING POWER TO THE FUEL PUMP, USING AN ALTERNATIVE SOURCE. UPDATED 11/03/16.*JB

NHTSA ODI 10914518

THE TIPM OUR DODGE TRUCK IS FAULTY. IT HAS ISSUES STARTING, THE LIGHTS WILL STOP WORKING, THE LIGHTS ON DASH COME ON, THERE IS AN ISSUE WITH THE OIL JUST DISAPPEARING, THE FUEL PUMP RELAY. I HAVE DONE EXTENSIVE RESEARCH ONLINE AND SAW THAT SEVERAL VEHICLES UNDER CHRYSLER AND DODGE HAVE HAD THIS ISSUE WITH FAULTY TIPM AND THERE WAS EVEN A CLASS ACTION LAWSUIT,BUT THE NHTSA FELT THERE WASN'T ENOUGH OF AN ISSUE WITH THE DODGE RAMS TO PUSH FOR A RECALL. I BELIEVE THAT THIS NEEDS TO BE PUSHED FOR A RECALL. THIS ISSUE IS OCCURRING IN A LOT OF RAMS AND THEY ARE PASSED THE WARRANTY AND WHEN YOU PURCHASE A NEW WARRANTY THIS ISSUE IS NOT COVERED. ALL EXPENSES ARE PAID OUT OF POCKET. THIS IS AN ISSUE THAT CHRYSLER AND DODGE HAVE BEEN AWARE OF FOR YEARS. OUR DODGE RAM HAS BEEN AT THE SHOP SEVERAL TIMES WITH ISSUES AND THEY DID NOT TELL US ONCE ABOUT THE TIPM ISSUES. WE HAD TO FIGURE IT OUT OURSELVES WITH INTERNET RESEARCH. A CUSTOMER SHOULD NOT BE PAYING CLOSE TO OR OVER $2,000 OUT OF POCKET TO FIX AN ISSUE THAT THE MANUFACTURING COMPANY NEW WAS A DEFECT OR FAULTY. SEVERAL MILLION DODGE RAM OWNERS HAVE HAD THIS ISSUE OVER THE YEARS AND HAVE REPORTED IT ACCORDING TO THE PUBLICATION OF THE NHTSA. I DON'T UNDERSTAND WHY CUSTOMERS ARE BEING PUNISHED TO PROTECT THE MANUFACTURER'S MISTAKES. OUR DODGE HAS SPENT MORE TIME IN THE SHOP IN THE PAST YEAR THEN WITH US. WE HAVE ONLY OWNED THE VEHICLE FOR TWO YEARS.

NHTSA ODI 10905619

TRUCK HAS INTERMITTENTLY STARTED OFF AN ON THE ENTIRE TIME I'VE OWNED IT (10 MONTHS). TRUCK DIED WHILE ON THE HIGHWAY AND HAD TO COAST TO A STOP TRUCK NOW WONT START AT ALL I'VE TAKEN IT TO THE DEALERSHIP MULTIPLE TIMES AND THEY'VE REPLACED THE FUEL PUMP, WIRING HARNESS. SAME SYMPTOMS APPEAR AFTER BOTH "REPAIRS".

NHTSA ODI 10905485

I HAVE A DODGE RAM 1500. A COUPLE OF DAYS AGO I WAS IN RUSH HOUR TRAFFIC DOING ABOUT 60 MPH WHEN THE TIMING CHAIN BROKE AND THE TRUCK DIED! I WAS LUCKY TO BE ABLE TO COAST ACROSS 4 LANES OF TRAFFIC AND ONTO THE SHOULDER. AFTER DOING A QUICK SEARCH I FOUND THAT THERE HAS BEEN A RECALL ON THE SAME ENGINE IN THE SAME YEAR BUT ONLY IF ITS IN A CHARGER, CHALLENGER OR A 300(THE RECALL IS CALLED CUSTOMER SATISFACTION NOTIFICATION P01, SEE ATTACHED) . THE FAILURE I EXPERIENCED IS THE EXACT SAME PROBLEM AS WHAT HAPPENS IN THE CARS. I WAS DOING HIGHWAY SPEED IN FUEL SAVING MODE AND WHEN THE ENGINE AUTOMATICALLY KICKS INTO 8 CYLINDER MODE THE TIMING CHAIN BRAKES. MY VEHICLE IS OUT OF WARRANTY AND THE DEALER TELLS ME THE ENGINE IS NOT COVERED BY THE RECALL BECAUSE ITS IN A TRUCK NOT A CAR. WHEN THE CHAIN BREAKS IN ONE OF THESE ENGINES IT COMPLETELY DESTROYS THE PISTONS AND VALVES. I NEED NEW ENGINE! THIS IS VERY UNSAFE FLAW IN THIS ENGINE AND THE RECALL SHOULD APPLY TO ALL ENGINES OF THIS MODEL INCLUDING THE ONES IN RAM TRUCKS. I AM A VERY EXPERIENCED DRIVER IM CERTAIN THAT IF THIS HAD HAPPENED TO ANYONE WITH LESS EXPERIENCE THIS WOULD HAVE CAUSED A VERY SERIOUS ACCIDENT.

NHTSA ODI 10904239