What 1,515 owners told NHTSA about the 2011 Kia Sorento

My 2011 Kia Sorrento caught fire while parked in my garage. Kia is saying it's not due to any recall they have and that it was an electrical fire store behind the steering wheel and they're refusing to take any responsibility financially for it or otherwise due to it being through previous owners and an older vehicle

NHTSA ODI 11716993

I was driving my car, while at a stop light I noticed some smoke coming from under my hood. I thought it might have been the cold I turned off the main road onto my street and noticed the smoke increasing, I pulled over turned off my car opened the hood and a fire started at the back of my engine.

NHTSA ODI 11713565

I was driving and my Kia started over heating and smoking and smelled like plastic burning I got it towed to the Hendricks of Kia and it sat there for 2weeks and I contacted them about giving me a lender until they fix my engine problem and they told me that my engine is not under warranty but is a recall I didn’t blow my engine I recently bought it about 6 months ago

NHTSA ODI 11690083

The engine light comes on and then the wheel lock light will come on and the car will disengage from 4 wheel drive to 2 wheel drive while driving

NHTSA ODI 11689607

The contact owns a 2011 Kia Sorento. The contact stated while driving approximately 55 MPH, the vehicle started to lose motive power. The accelerator pedal was depressed; however, the vehicle failed to respond as intended. The contact stated that several unknown warning lights were illuminated before pulling off the roadway. The hood was opened and there was white smoke coming from the engine compartment. The contact stated that the smoke then dissipated. The vehicle was towed to a local mechanic. The mechanic diagnosed the vehicle and determined that the alternator and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.

NHTSA ODI 11682489

there are eight recalls on my car I do not trust dealerships I do not trust mechanics I work on my own car I have very bad experience with mechanics I would rather return my car to the dealership I want to sell my car do the dealership eight different recalls is too much

NHTSA ODI 11681986

The contact owns a 2011 Kia Sorento. The contact stated that while driving 55–60 MPH, the engine overheated and the vehicle stalled while making a turn. The vehicle stalled and failed to restart. Several unknown warning lights were illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V877000 (Engine). The vehicle was towed to an independent mechanic, but no assistance was provided. The vehicle was towed to another independent mechanic, but the cause of the failure was not determined. The vehicle was towed to the local dealer where it was determined that the battery and bracket needed to be replaced. The dealer also informed the contact that the engine and fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was contacted. The failure mileage was unknown.

NHTSA ODI 11673306

The contact owns a 2011 Kia Sorento. The contact stated that while attempting to unlock the vehicle with the key, the front driver side door opened; however, the other doors failed to open as intended. No warning light was illuminated. The vehicle was taken to the dealer; however, the vehicle was not repaired due to the cost. The contact stated that on another occasion, the interior lights failed to work as intended and several unknown warning lights were illuminated. The check engine and ABS warning lights remained illuminated. The contact stated that the buttons on the steering wheel failed to operate as intended. The vehicle was taken to the dealer and the contact was informed that the vehicle could not be connected to the diagnostic machine. The contact stated that the dealer refused to update the antitheft system or perform the recall repairs linked to the VIN. The contact stated that on a separate occasion, while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI 11667409

My KIA Sorrento spontaneously engulfed in flames approximately 200 yards from my home. This is not a vehicle crash the car had flames coming from the vents and floor boards. I was the driver my daughter was the passenger and my granddaughter was in the rear car seat we barely escaped with our lives before it exploded and we were steps away as car debre was flying past us.

NHTSA ODI 11667411

The ABS, down hill light, and swaying light came on. As I was pulling into a parking space slowly with my foot on the brakes, the car sped forward knocking over a post and shrubs.

NHTSA ODI 11653221

My car has been in the Kia shop for engine. We just stopped on the freeway and for the module recall and my safety bag is just constantly on since I’ve gotten it and now I’m noticing electrical issues that shouldn’t be someone told me. Hey you need to file a complaint because your car can catch on fire And I don’t know what else to do but to do a paper trail just in case but it’s been recalls after recalls

NHTSA ODI 11634294

My headlights are not working properly. This is an ongoing issue with Kia model vehicles- check online forums

NHTSA ODI 11633934

3 different episodes suv will start by appear warning lights downhill, slippery road, abs, engine , decrease speed, shuts down, tire pressure finally battery dead and rubber smell. I've had it fixed once mentioned it was Altarnator, second time battery, finally third time something electrical or unknown. Total cost now $3000 and my life in danger al 3 times and towec.

NHTSA ODI 11621859

This very dangerous issue has happened at least 3 times. It happens in frequently but is terrible when it happens because at night you are put into immediate darkness with no warning. Upon flashing the high beams on or using the turn signal the headlights go dark/off. Then you need to restart the car. This is particularly dangerous when driving on dark or high traffic roads because the driver cannot see anything.

NHTSA ODI 11611336

The contact owns a 2011 Kia Sorento. The contact stated that the “Low Oil Pressure” warning light was illuminated. The contact stated that there was engine oil leaking underneath the vehicle. The vehicle had been taken to a certified mechanic where it had been diagnosed that the oil pressure switch had failed and needed to be replaced. The contact related the failure to NHTSA Campaign Number: 10V388000 (Electrical System). The vehicle had not been repaired. The contact was referred to the manufacturer. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall or in the Technical Service Bulletin with the manufacturer ID number 026 and NHTSA ID Number: 10235099 (Electrical System). The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 170,000.

NHTSA ODI 11609343

I bought my 2011 Kia Sorento used from a dealership. The Air Bag Warning light was on & I insisted that they inspect car before I buy it, which they did. I go to pick the car up & the Air Bag Warning light is still on. When I questioned it, I learned that, for SOME REASON, a car's #1 safety feature, the Air Bags, is NOT part of PA's Safety Inspection!! A couple months go by and 1 by 1 the Bluetooth/Audio controls on the steering wheel stop working. So, after reading the Owner's Manual & finding that there is no fuse for the steering wheel controls, I go online to see if I can find the cause &/or how to fix it. That's when I run across hundreds of posts/blogs from other 2011 Sorento owner's saying the exact same thing happened to them and all the replies say that it's caused by the Clock Spring and upon replacing it, all their Bluetooth/Audio controls on steering wheel worked again. I then remember the letters regarding the Clock Spring in with the car's Owner's Manual. I have 2 letters, 1 from 2017 & 1 from 2019 saying that Kia Extended the Warranty on the Clock Spring to 15 years. To take the car to a Kia dealership and have the Air Bag Warning light diagnosed & if it's determined that the Clock Spring is reason it's illuminated, Kia will pay to fix it. What I don't understand is if Kia saw fit to issue TWO identical letters TWO years apart from each other, why didn't they just issue a recall? They obviously knew it was a problem that effected most, if not all of the 2011 Sorento's manufactured. And the real reason I'm writing? Since my research on the internet TWO EXTREMELY DANGEROUS things have happened. 1)my horn no longer works! At 1st it worked when it wanted to but now it doesn't work at all! I've almost gotten in 3 accidents because of it & my car will NO LONGER PASSES INSPECTION and 2) Now the Air Bag system cannot detect when someone is in the passenger seat, so their Air Bags never turn on!! The Extended Warranty expires in 2024 & NO RECALL!????

NHTSA ODI 11609424

1-The front air bag sensor will nor register if a person is sitting in the sear, no matter the weight. 2-The modem keeps direction the vehicle to steer right. No matter how many alignments and parts are replaced, the ECM will not correct itself 3-KIA dealers will only repair the problem if the customer pays $$$$$$$$

NHTSA ODI 11600242

Car dash lights flashed and car shut down

NHTSA ODI 11597858

The Hydraulic Electronic control unit (HECU) may experience an electrical short , whioch can result in an engine compartment fire while paked or driving the car.

NHTSA ODI 11597828

I called Courtesy KIA in Altoona, PA. I informed them that I have another recall addressing this latest issue "The Hydraulic Electronic Control Unit," as I was there last month addressing another recall. That situation was resolved. However, I called today 5/13/24 at about 12:50PM and was told by service dept. member Toby that we already have all the parts we can order for recall. He also told me to call him back in a month??? My concern is I am getting a letter saying the engine could catch fire and I am being told to call back in a month. I just wanted to log this incident for my personal file to show that I am trying to remedy the problem. Regards, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11588511

The contact owns a 2011 Kia Sorento. The contact stated while attempting to unlock the vehicle with the key fob, the contact heard the doors unlocking, but the rear doors failed to unlock. Additionally, the contact stated that the failure initially started after the vehicle was serviced by the dealer. No warning light was illuminated. The vehicle was not diagnosed or repaired by a dealer or an independent mechanic. The manufacturer was notified of the failure and a case was opened. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 92,000.

NHTSA ODI 11587430

The contact owns a 2011 Kia Sorento. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving approximately 35 MPH, the "Theft Prevention" warning light was illuminated, and several other warning lights were blinking on and off. The contact stated that the vehicle lost power steering and braking functionality. The contact attempted to restart the vehicle, but the vehicle failed to restart. The contact stated that after several attempts a relative jumpstarted the vehicle. The contact drove the vehicle back to the residence and parked the vehicle. The contact stated that the battery was replaced; however, the battery became drained. The contact stated that when the vehicle was jumpstarted, the ABS warning light illuminated. The contact no longer drove the vehicle. The contact had not taken the vehicle to a dealer or to an independent mechanic to be diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The failure mileage was approximately 225,000. VIN tool confirms parts not available.

NHTSA ODI 11586709

After my daughter pulled into her school parking lot on Friday morning, 4/19/24 she reported smelling a very bad smelling smoke. She immediately got out of the car because she then saw flames from under the hood. The car lit on fire, and was completely totaled. I have since been made aware of the recall that causes engine fires.

NHTSA ODI 11584458

Knock Sensor Code came up when having my car checked P1326

NHTSA ODI 11582771

My Kia Sorento 2011 in November 2023 started having the instrument cluster warning lights flashing, abs warning light, tire pressure light and sometimes the check engine light. There is also a very strong burning or melting smell when the car is on. I was very scared to drive my car and have had to find ways to get to work when I received the notice from Kia that there was a recall SC284. About HECU fuse that many Kia Sorento 2011 owners are having issues with the engines catching fire while driving or parked. And the symtoms before a fire occurs are the same as I have experienced with the instrument cluster illuminating and the strong burning smell as well. Its April 2024 and I haven't had a car since November 2023 because the recall has yet to be remedied. This is completely unacceptable I cannot drive I cant take my car to emmissions and might eventually get my car towed due to not being able to it not passing emissions and cant pass for registration. There needs to be compensation for this inconvenience and for this recall not being a priority.

NHTSA ODI 11582458