What 1,516 owners told NHTSA about the 2011 Kia Sorento Plug-in Hybrid

The contact owns a 2011 Kia Sorento. The contact stated that while driving 15-20 MPH, the axle popped out of the transmission, and fractured the lower ball joints and steering system. There was an abnormal burning electrical odor coming from the vehicle. The contact stated that the vehicle stalled. There were no warning lights illuminated. The vehicle was towed to the residence. The local dealer was not contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 200,000.

NHTSA ODI 11664495

see attached documentation

NHTSA ODI 11664041

Head gasket blew due to head bolts losing threads or stretching not sure exactly why but many people has reported this issue

NHTSA ODI 11654212

The ABS, down hill light, and swaying light came on. As I was pulling into a parking space slowly with my foot on the brakes, the car sped forward knocking over a post and shrubs.

NHTSA ODI 11653221

The contact owns a 2011 Kia Sorento. The contact stated while driving on a main road at 55 MPH, there was an abnormal sound coming from the engine, and the engine power was reduced, and the vehicle failed to accelerate above 20 MPH. The temperature gauge indicated that the engine was overheating. The contact was forced to pull over onto the side of the road where the vehicle was left idling for a while. The check engine, and the oil pressure warning lights were illuminated. The vehicle was towed to a local independent mechanic, where the contact was informed that the engine was faulty and was not worth the effort to replace the engine, as the cost would significantly outweigh the value of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 200,000.

NHTSA ODI 11651894

The contact’s son owns a 2011 Kia Sorento. The contact stated that while driving 60 MPH, the check engine warning light illuminated, and the vehicle lost motive power and stalled. The contact was able to pull over to the side of the road. The vehicle was towed to the residence and had not been driven since the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI 11645368

The contact owned a 2011 Kia Sorento. The contact stated that, upon reaching her destination and turning the vehicle off, she smelled smoke in the interior of the vehicle. She then observed flames jutting up from underneath the driver's side seat, prompting her to evacuate immediately. Within minutes, the vehicle was completely engulfed in flames following what the contact described as an explosion. Local emergency services arrived and were able to extinguish the flames, later determining that faulty vehicle components caused the fire without human intervention. The check engine warning light was illuminated. The vehicle was towed to a tow yard and deemed a total loss by the contact's insurance provider. A fire report was filed. A police report was not filed, but injuries were reported. The contact suffered various minor burns to her hands but did not seek medical attention, choosing instead to attend to her injuries herself at home. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic); the VIN was included, and parts were available. However, the contact stated that previous attempts to schedule the vehicle for repair had failed due to parts availability and a months-long waiting list. The manufacturer was notified of the failure, a case was opened, and a third-party engineer was sent to examine the vehicle, but a final report had yet to be provided to the contact. The failure mileage was 223,000.

NHTSA ODI 11644899

The contact owns a 2011 Kia Sorento. The contact stated while driving at an undisclosed speed, the vehicle lost automotive power while the accelerator pedal was being depressed. No warning light was illuminated. The contact research and was became aware of NHTSA Campaign Number: 15V626000 (Power Train); however, the VIN was not included. The vehicle was taken back to the residence; the contact stated that an independent mechanic arrived at the residence and diagnosed the vehicle and determined that an undisclosed part needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 165,000.

NHTSA ODI 11642301

I was approaching a stoplight, applying my brakes ahead of time, got down around 45 mph and then the brakes locked up suddenly and took me across the road into a guardrail. Thankfully no other car was involved. The speed limit is 55 mph on that road and I was still a ways away from the stoplight. I was never notified of the recalls on the vehicle.

NHTSA ODI 11636857

The contact owns a 2011 Kia Sorento. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, and unknown recall repairs were performed; however, the failure persisted. The contact stated while driving approximately 35 MPH and pulling into a gas station, the vehicle stalled and rolled next to a gas station pump. The check engine warning light was illuminated. The vehicle failed to restart and was towed to Firestone, where an unknown diagnosis was provided. The vehicle was then towed to the dealer, where it was diagnosed and determined that the long block, the head gasket, and the bolts needed to be replaced. Additionally, the dealer informed the contact that the brake fluid needed to be flushed and refilled. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 230,000.

NHTSA ODI 11636061

My car has been in the Kia shop for engine. We just stopped on the freeway and for the module recall and my safety bag is just constantly on since I’ve gotten it and now I’m noticing electrical issues that shouldn’t be someone told me. Hey you need to file a complaint because your car can catch on fire And I don’t know what else to do but to do a paper trail just in case but it’s been recalls after recalls

NHTSA ODI 11634294

My headlights are not working properly. This is an ongoing issue with Kia model vehicles- check online forums

NHTSA ODI 11633934

Engine fire, extinguished by the fire dept. Car was parked at the time. Dealer informed us that the fire recall was completed on 10-29-2021 and now we are over the 150,000 mileage warranty so no repair can be done by Kia. I will submit 2 more claims for transmission and brakes for the same Kia.

NHTSA ODI 11633387

Transmission, shocks and struts had to be replaced. Kia was having a hard bump knock when it changed gears driving down the highway, we had it looked at several times by the Kia dealer and they couldn't find anything wrong. Eventually had to replace the parts above.

NHTSA ODI 11633395

Rear brakes failed, had to replace them. This is the 3rd repair not covered by Kia.

NHTSA ODI 11633397

Engine light flashes fast then Kia will slow down to about 30 mph when going up a hill, I've make claims on this Kia for the fire loss, transmission, brakes and now it won't run unless I pay $85 to have the sensor reset which lasts a short time and the light starts flashing again. Was told it doesn't qualify for a new engine because the mileage is over 150,000.

NHTSA ODI 11633421

Kia states that they do not have the parts for the current recall. Not sure if this has anything to do with any recalls but my check engine light went on in 2023, after paying for diagnostic testing, the mechanic cannot find any emissions leak. And after spark plugs were changed in Feb 2024, the light went off. Then Nov 2024, the light went back on again. Although there is a code stating there is an emissions leak again. I am scared to drive the car without knowing what is wrong. Is the part available for the current recall?

NHTSA ODI 11630517

The contact owns a 2011 Kia Sorento. The contact stated that there was a knocking sound coming from the engine compartment. While driving at various speeds, the vehicle jerked with the transmission slipping gear with an engine misfire. The check engine warning light was illuminated. The vehicle was taken to Auto Zone and a code for the knock sensor failure was retrieved. The vehicle was not repaired. The contact had replaced the spark plugs on the vehicle. While driving 65 MPH, the vehicle went into LIMP Mode. The contact restarted the vehicle and continued driving. The vehicle was taken to the dealer who confirmed that the knock sensor had failed. The dealer related the failure to the NHTSA Campaign Number: 23V877000 (Engine); however, the VIN was not included. The dealer cleared the code, but the vehicle was not repaired. The vehicle was taken to a different certified mechanic who confirmed the diagnostic result and cleared the code. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 135,750.

NHTSA ODI 11627926

No oil after filling up with 4qts. Engine over built compression and blew hole through bottom of the block which caused a fire underneath

NHTSA ODI 11622694

3 different episodes suv will start by appear warning lights downhill, slippery road, abs, engine , decrease speed, shuts down, tire pressure finally battery dead and rubber smell. I've had it fixed once mentioned it was Altarnator, second time battery, finally third time something electrical or unknown. Total cost now $3000 and my life in danger al 3 times and towec.

NHTSA ODI 11621859

1. Air bag light has been on for over a year. Was checked at dealership, and was told there is a recall on sensor. 2. Power Train, unknown of what's going on. Riding down the road all of a sudden it stalls for a minute. It's a hard jerk, like it's not getting gas, or the transmission is out of sinc. This started about two years ago. Took it to my local repairman, and he said it was a warning in the tire wheel letting me know something was wrong in the wheel. They repaired it, and I had no more problems until recently. It is doing it again. A hard jerk when I'm driving. 3. Other, passenger front and rear and drivers side rear doors locked up and I could not open them. This happen about two years ago. Took car to a certified electrical repairman and it cost me a fortune to get repaired. The clips that lock and unlock doors had to be replace. The repair was very costly.

NHTSA ODI 11616981

This very dangerous issue has happened at least 3 times. It happens in frequently but is terrible when it happens because at night you are put into immediate darkness with no warning. Upon flashing the high beams on or using the turn signal the headlights go dark/off. Then you need to restart the car. This is particularly dangerous when driving on dark or high traffic roads because the driver cannot see anything.

NHTSA ODI 11611336

Non working door handles which is a KNOWN issue with Kia! Extremely dangerous obstruction in an event of an emergency where occupants need to get in and out of the vehicle. The ineffective door handles also makes the car less secure because someone who is not authorized can access the safety measures that the vehicle has. This is not right that Kia customers have to spend hundreds for an ongoing issue! This is two out of the four doors now. I replaced one door handle already for well over $300.00! Now will need to spend ANOTHER three hundred plus dollars for the same issue! Again, this is a KNOWN Kia issue! I was originally told there was a recall but only for the back handles and not the front handles in 2020. Now, I am being told it was a warranty and it expired in 2021/2022. A warranty was never relayed to me in any way. No email or mailed letter explaining this. If under "warranty" and again, a known Kia issue why were the backs covered but not the front if they are the same handles? Why not replace all four handles under the said "warranty"? This is a major issues for Kia owners like myself. Also having an issue where when it rains, water will come in from the passenger side panel and back trunk panels. Kia said it was the drains. Kia cleared the drains for well over $200.00. Next rain fall and the SAME issue still remained. Kia then said it was the moonroof assembly and would NOT get back to me with a remedy to solve the issue. I reached out again and I spoke to the general Manager who said he would call me back and NEVER did. I took it to another company who handles moonroofs/sunroofs and has said it is due to the paint separating in the grooves where the assembly sits and is a manufactural issue.

NHTSA ODI 11610451

The contact owns a 2011 Kia Sorento. The contact stated that the “Low Oil Pressure” warning light was illuminated. The contact stated that there was engine oil leaking underneath the vehicle. The vehicle had been taken to a certified mechanic where it had been diagnosed that the oil pressure switch had failed and needed to be replaced. The contact related the failure to NHTSA Campaign Number: 10V388000 (Electrical System). The vehicle had not been repaired. The contact was referred to the manufacturer. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the recall or in the Technical Service Bulletin with the manufacturer ID number 026 and NHTSA ID Number: 10235099 (Electrical System). The manufacturer referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 170,000.

NHTSA ODI 11609343

I bought my 2011 Kia Sorento used from a dealership. The Air Bag Warning light was on & I insisted that they inspect car before I buy it, which they did. I go to pick the car up & the Air Bag Warning light is still on. When I questioned it, I learned that, for SOME REASON, a car's #1 safety feature, the Air Bags, is NOT part of PA's Safety Inspection!! A couple months go by and 1 by 1 the Bluetooth/Audio controls on the steering wheel stop working. So, after reading the Owner's Manual & finding that there is no fuse for the steering wheel controls, I go online to see if I can find the cause &/or how to fix it. That's when I run across hundreds of posts/blogs from other 2011 Sorento owner's saying the exact same thing happened to them and all the replies say that it's caused by the Clock Spring and upon replacing it, all their Bluetooth/Audio controls on steering wheel worked again. I then remember the letters regarding the Clock Spring in with the car's Owner's Manual. I have 2 letters, 1 from 2017 & 1 from 2019 saying that Kia Extended the Warranty on the Clock Spring to 15 years. To take the car to a Kia dealership and have the Air Bag Warning light diagnosed & if it's determined that the Clock Spring is reason it's illuminated, Kia will pay to fix it. What I don't understand is if Kia saw fit to issue TWO identical letters TWO years apart from each other, why didn't they just issue a recall? They obviously knew it was a problem that effected most, if not all of the 2011 Sorento's manufactured. And the real reason I'm writing? Since my research on the internet TWO EXTREMELY DANGEROUS things have happened. 1)my horn no longer works! At 1st it worked when it wanted to but now it doesn't work at all! I've almost gotten in 3 accidents because of it & my car will NO LONGER PASSES INSPECTION and 2) Now the Air Bag system cannot detect when someone is in the passenger seat, so their Air Bags never turn on!! The Extended Warranty expires in 2024 & NO RECALL!????

NHTSA ODI 11609424