What 160 owners told NHTSA about the 2011 Kia Forte Koup

The NECU system failed and blew the engine and caused a fire no longer available for inspection. No move running. No warning lamps at all of any sort.

NHTSA ODI 11623917

I was driving and the car caught on fire.

NHTSA ODI 11572205

On 8/28/2022 my 2011 Kia Forte's engine caught on fire and it caused damage to my entire garage along with my personal belongings. I had contacted Kia multiple times and was put on hold for over an hour at a time and hung up on multiple times until a few weeks after the fire I finally got a hold of them and they put in a "work order". After following up with them a week later I come to find out that the work order was put in for a car pare (the engine in the car was burnt to crisp). I finally had someone help and a representative from Kia came out afterwards they conveyed that after "their investigation" that "evidence shows fire and heat attacking vehicle from outside and moving into the engine compartment". Which is completely false per fire department who where first on the scene they determined the fire started in the engine compartment of the vehicle". This was very disappointing Kia took no responsibility for this. Now I receive a recall notice dated November 14th, 2023 stating that "the Hydraulic electronic control unit may experience an electrical short circuit, which can result in an engine compartment fire while driving or parked. This is exactly what happened to my car at the time of the incident so now they are admitting they were at fault.

NHTSA ODI 11556464

The car had a slow ticking noise that was very faint in the front for about 20 minutes 20 minutes later the noise continue to get louder about 45 minutes later six gear was lost in the car in about an hour and a half later the engine failed and the car Came to a failure lock down procedure all lights on the front door shut on steering wheel locked on friendship Road exit 8 and the vehicle had to be towed to a shop we’re now it was put on a lift and there is a hole in the bottom of the engine , And the transmission is not in tact

NHTSA ODI 11508036

MY ENGINE CAUGHT FIRE AND THE ELECTRICAL WIRES WERE BURNED

NHTSA ODI 11405273

WHEN DRIVING STRAIGHT ALONG AN INTERSTATE WITH MY CRUISE CONTROL SET TO THE SPEED LIMIT, A LOUD BANG CAME FROM UNDER THE HOOD OF MY KIA, THE CHECK ENGINE INDICATOR TURNED ON, AND SMOKE BEGAN TO POUR OUT FROM UNDER THE HOOD AND INSIDE MY CAR THROUGH THE AIR VENTS. WHEN I PUSHED THE GAS PEDAL GENTLY, THERE WAS A LOW GUTTURAL NOISE AND MY CAR WAS NOT PICKING UP SPEED. I PUT MY CAR INTO NEUTRAL AND COASTED TO THE SHOULDER WITH LOW VISIBILITY AS THE SMOKE BECAME MORE DENSE AND DARKER IN COLOR. I BROUGHT MY VEHICLE TO A FULL STOP ON THE SHOULDER AND PUT IT INTO PARK BEFORE TURNING IT OFF AND REMOVING MY KEY FROM THE IGNITION. UPON EXITING THE CAR I NOTICED THE SMOKE WAS EVEN MORE INTENSE THAN BEFORE AND PROMPTLY CALLED 911 AND GAVE MY LOCATION AND SITUATION INFORMATION TO THE 911 REPRESENTATIVE. AS I WAS SPEAKING, I NARRATED IN HORROR AS FLAMES BECAME VISIBLE FROM UNDER THE CAR ITSELF AND UNDER THE HOOD AS WELL, IN AS LITTLE AS ONE MINUTE AFTER EXITING MY CAR. BY THE TIME THE FIRE DEPARTMENT GOT TO THE VEHICLE, THE FLAMES WERE OVER 20 FEET TALL AND THE HEAT WAS UNBEARABLE; I RELOCATED MYSELF FARTHER AND FARTHER AWAY TO STAY COOL AND SAFE AS THE TIME WENT ON. NOBODY WAS BURNED, HURT, OR INJURED AS A RESULT OF THE INCIDENT, BUT ONLY MY MERE COINCIDENCE.

NHTSA ODI 10908482