What 181 owners told NHTSA about the 2011 Hyundai Santa Fe Hybrid Hev

The contact owned a 2011 Hyundai Santa Fe. The contact stated while the contact's daughter was driving at an undisclosed speed, the contact noticed a burning odor and the vehicle stalled. The contact idled the vehicle to the shoulder of the road and exited the vehicle. The vehicle burst into flames after the occupants exited the vehicle. The contact's daughter and daughter's friend were occupants of the vehicle at the time of the failure. No injuries were sustained. The fire department arrived and extinguished the fire. A Police report was filed. The vehicle was towed to a local tow yard. The vehicle was condemned to total loss. The manufacturer was made aware of the failure. The failure mileage was approximately 280,000.

NHTSA ODI 11639951

About this date had accidentair bags failed to go off for any off us

NHTSA ODI 11563989

I pulled up into my grandma's driveway, put the car in park. The car continued moving forward and when I depressed the brake pedal, the car accelerated for some unknown reason. So I put both feet on the brake and it still continued to accelerate. My car crashed into my grandparents garage door, then into their car, then pushed their car into their washer and dryer, causing those appliances to push against the wall, breaking the structure, busting water lines, smashing the washer and causing damage.

NHTSA ODI 11517326

UNKNOWN warning I’m the owner of a 2011 Hyundai Santa Fe and a week ago at 185k mikes all of a sudden driving on the freeway it started hesitating and sounded like metal grinding and smoking really bad. Pulled to the side of the freeway on a ramp at that. Tried to restart the vehicle and I heard a bang noise which upon later discovery the engine blew a rod with no warning locked the steering wheel couldn’t get the keys out of the ignition DO NOT buy this car still owe 5k on the vehicle

NHTSA ODI 11475199

The brakes on this Santa Fe have produced some unexplainable issues? A complete brake job was done approximately six months ago by a reputable brake shop because of similar issues with the brakes that occurred again last week and yesterday. Additionally, all fluids were normal during routine oil change and fluid check on Aug 13th. Last week while backing up the normal brake would not stop the vehicle and the car was stopped by using the emergency brake. On Oct 4, 2021 the brakes did not work causing the Santa Fe to "rear-end" another car at a red light. Speed was approximately 35-40 mph. Air bag deployed and no one was seriously hurt in the accident. Problem has not been reproduced or confirmed by a dealer; just a complete brake job 6 months ago by a brake shop. Vehicle is now at the tow facility awaiting the inspection by insurance company and can be inspected by anyone interested in doing so. There were no warning lamps or messages of the problem prior to failure. Additionally, this car's blinkers have randomly stopped working with no notice and just randomly started working again after a period of time. Emergency flashers worked but not the normal blinkers during this malfunction. This vehicle definitely has some Gremlins!! It's unknown why this model Santa Fe has produced a similar problems as other Santa Fe's with no recalls on this particular model or VIN # ?

NHTSA ODI 11435545

We have (had) a 2011 Hyundai Sante Fe. On 9/21/21, driving to Bozeman, just west of Livingston MT, on I-90, the car had a sudden stalling, loss of power (check engine light, oil light came on), then knocking sound that increased in volume and frequency. Smoke began pouring from under the hood as we pulled to the side of the highway, then very quickly accompanied by flames. We exited the vehicle. I opened the hood, the flames shot into the air. We moved away from the car. 911 had been called and the local fire department arrived within 10-15 minutes. Fire extinguished after about 20-30 minutes, but engulfed (destroyed) the entire engine compartment. Flames did not spread to passenger area of the vehicle. No one injured from the fire (although possible smoke inhalation before and as we exited vehicle). Car totaled, towed from highway. 1. Component: engine, all components in engine compartment (available for inspection, see photos uploaded); 2. Safety threat: smoke, fire quickly engulfed engine compartment, threat of spread to passenger area of vehicle; 3. Not yet confirmed by dealer or independent service center; 4. Inspection: by police/fire department that responded to the incident indicating mechanical malfunction, without further detail; 5. Warnings: check engine light and oil light occurred prior to or at time of incident and before severe knocking sounds began, but at same time as stalling/power loss.

NHTSA ODI 11434273

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING AT 40 MPH, THE CONTACT STATED SMOKE WAS COMING FROM THE STEERING COLUMN. THE CONTACT DROVE THE VEHICLE BACK TO THEIR RESIDENCE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO LOCAL DEALER (HORNE HYUNDAI 1360 E AUTO CENTER DR, APACHE JUNCTION, AZ 85119 (480) 771-8213) WHERE IT WAS DIAGNOSED WITH NEEDING TURN SIGNALS TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 106,000.

NHTSA ODI 11404455

ON JUNE 14,2020, I BACKED OUT OF A PARKING SPOT IN A LOT OUTSIDE A GROCERY STORE AND MY HYUNDAI SANTA FE SUDDENLY ACCELERATED BACK HITTING A BARRIER POLE. WHEN I PUT IT IN DRIVE, IT LEAPT FORWARD AND SPED BETWEEN A POKE AND A PARKED CAR, RACED DOWN A TEN-FOOT EMBANKMENT AND CRASHED INTO THE CORNER OF A BRICK BUILDING. I LATER LEARNED THAT THIS WAS CALLED SUDDEN UNINTENDED ACCELERATION AND THAT THE BRAKES DO NOT WORK WHEN SUA HAPPENS. IT WAS ALL OVER WITHIN SECONDS AND I HAD NO TIME TO ACT. MY CAR WAS COMPLETELY TOTALED AND I SUFFERED RIB CAGE AND STERNUM CONTUSIONS FROM THE SEAT BELT. THE AIR BAG DID NOT DEPLOY. MY CAR SCRAPED THE PARKED CAR AND MY INSURANCE COMPANY PAID FOR THAT DAMAGE.

NHTSA ODI 11361175

WHILE DRIVING HOME ON WEDNESDAY DECEMBER 12 2018 MY HYUNDAI SANTA FE ENGINE CAUGHT ON FIRE AND BURNED UP THE WHOLE FRONT END.

NHTSA ODI 11161289

CAR WAS DRIVEN ABOUT 10 MILES AND THEN PARKED INSIDE AN ATTACHED GARAGE. NO ISSUES WERE PRESENT DURING THE DRIVE. THE IGNITION WAS TURNED OFF AND KEY REMOVED FROM VEHICLE. AFTER APPROXIMATELY 1 HOUR HAD PASSED THE CAR STARTED ON FIRE. FLAMES WERE VISIBLE BEHIND THE FRONT RIGHT HEADLIGHT AND FRONT RIGHT WHEEL. LUCKILY NO ONE WAS HARMED. THE FIRE CAUSED SIGNIFICANT DAMAGE TO THE GARAGE AND HOME. FIRE DEPARTMENT INVESTIGATION CONCLUDED THAT THE CAUSE OF THE FIRE WAS NOT EXTERNAL TO THE VEHICLE.

NHTSA ODI 11080980

WHILE DRIVING,I SIGNALED A TURN AND SMOKE CAME FROM BEHIND MY STEERING WHEEL.MY BLINKER WORKED BUT WAS MAKING A FAST CLICKING SOUND AS IF THE BLINKER WAS GOING OUT.THE NOISE WILL NOT STOP AND THE SMOKE IS INTERMITTENT.CONTACTED HYUNDAI BECAUSE IT IS A KNOWN PROBLEM PER THE INTERNET BUT THEY ACTED LIKE THEY HAD NEVER HEARD OF IT.

NHTSA ODI 11021322

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. THE CONTACT STATED THAT AFTER DEPRESSING THE BRAKE PEDAL, THE VEHICLE EXPERIENCED A PERIOD OF UNINTENDED ACCELERATION. AS A RESULT, THE CONTACT CRASHED INTO A BRICK WALL. PRIOR TO THE FAILURE, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 13V113000 (EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED BURNS FROM THE AIR BAG AND A NECK INJURY WHICH REQUIRED MEDICAL ATTENTION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000. THE VIN WAS NOT AVAILABLE. UPDATED 01/12/16*LJ UPDATED 4/18/18*JB *TR

NHTSA ODI 10781147

WHILE OPERATING VEHICLE AT NORMAL SPEED ON THE RIGHT SIDE OF THE ROAD, THERE WAS ANOTHER VEHICLE CLOSER TO THE MIDDLE OF THE ROAD IN OPPOSING TRAFFIC ON A TWO LANE ROAD. AS I SWERVED A BIT TO THE RIGHT IN AN EFFORT TO GIVE THE OPPOSING VEHICLE MORE ROOM, I WENT TOO FAR TO THE BRIM OF THE ROAD. AS I TRIED TO CORRECT IT, I LOST TOTAL CONTROL OF THE STEERING OF THE VEHICLE, CAUSING ME TO DRIVE STRAIGHT ACROSS THE OTHER SIDE OF THE ROAD AND INTO A TREE. THE VEHICLE WENT HEAD ONTO INTO THE TREE, BOUNCED OFF, AND SLID BACKWARDS DOWN INTO A DRAINAGE CULVERT. THERE WAS MELTING SNOW ON THE BRIM OF THE ROAD, BUT THE ROAD ITSELF HAD NO WEATHER RELATED PROBLEMS THAT WOULD CAUSE ME TO LOSE CONTROL OF THE VEHICLE. UPON FURTHER INSPECTION OF THE VEHICLE, IT WAS NOTED THAT THE STEERING WAS LOCKED, TURNED TO THE LEFT AT 10:00 POSITION, AND BOTH STEER TIRES WERE POINTED STRAIGHT AHEAD. THE STEER TIRES HAD LESS THAN 1,000 ON THEM. *TR

NHTSA ODI 10682832

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE ENTERING A PARKING AREA AT 10 MPH, THE BRAKE FAILED TO ENGAGE AS THE BRAKE WARNING LIGHT FAILED TO ILLUMINATE. THE CONTACT ATTEMPTED TO AVOID A CRASH HOWEVER, CRASHED INTO AN ICE EMBANKMENT. THE CONTACT SUSTAINED INJURIES TO BOTH HANDS. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS NOT FILED. THE CONTACT ALSO STATED THAT NHTSA CAMPAIGN NUMBER 13V113000 (EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC) LETTER WAS RECEIVED AFTER THE CRASH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 25,000.

NHTSA ODI 10544404

FIRST OF ALL I KNOW OUR 2011 HYUNDAI SANTA FE IS NOT MADE IN USA, IT IS A KOREAN 2.4 L, 7 SEATER BOUGHT IN PANAMA. I WROTE TO THE HYUNDAI COMPLAINT WEBSITE AND THEY VERY POLITELY ANSWERED THAT THE CAR WAS A NON-US MODEL AND THEY SENT ME A LINK TO A WEBSITE WHERE I COULD FILE THE COMPLAINT. I DID IT BUT I HAVE NOT RECEIVED AN ANSWER, YET. MY FIRST PROBLEM AFTER THE CRASH WAS THE UNAVAILABILITY OF PARTS FOR REPAIRING THE CAR. I FILED A COMPLAINT WITH OUR LOCAL CONSUMER AUTHORITY HERE IN PANAMA. OUR CAR WAS IN THE SHOP FOR MORE THAN 9 MONTHS, ITS RUNNING NOW BUT STILL SOME PARTS MISSING. THE ISSUE IS THAT AFTER GETTING THE CAR BACK FROM THE SHOP I RECEIVED A CALL FROM OUR LOCAL HYUNDAI DEALER (PETROAUTOS) TELLING ME ABOUT THE CAMPAIGN OF THE FAULTY BRAKE SWITCH (JUST AS IN THE US MODELS) AND THAT I HAD TO TAKE THE CAR TO THE DEALER. SO I LOOKED UP IN INTERNET AND I FIND SEVERAL RECALLS RELATED TO THE BRAKES. I TOOK THE CAR TO THE DEALER AND THEY CHANGED THE SWITCH. SO IM WONDERING IF THIS WAS RELATED TO THE CRASH BECAUSE I ALWAYS HAD MY DOUBTS OF WHAT HAPPENED WHEN I BRAKED THAT DAY. FINALLY THERE WAS A CRASH AND ALTHOUGH I KNOW THIS MAY ONLY BE FOR YOUR INFORMATION OR FILES, AND THAT YOU CAN'T HELP ME; PLEASE TAKE THIS INTO ACCOUNT FOR YOUR EVALUATIONS. THANKS.

NHTSA ODI 10541823

ON JUNE 11, 2013 I WAS DRIVING MY 2011 HYUNDAI SANTA FE. I WAS IN A PARKING LOT AND HAD PULLED INTO A PARKING PLACE. I WAS STOPPED AND PUTTING MY CAR INTO PARK. AS I REACH NEUTRAL MY CAR ACCELERATED FAST...THIS WAS MORE THEN A LUNGE FORWARD, IT WAS MORE LIKE A POWER SURGE. MY CAR CONTINUED FORWARD AT A VERY FAST SPEED, DESPITE MY BRAKING ( THERE WERE SKID MARKS) AND HIT A WALL. I ENDED UP WITH LOTS OF MASSIVE BRUISING AND SPRAINED MUSCLES. PLUS I WAS VERY FRIGHTENED. THERE WAS LOTS OF DAMAGE TO MY CAR. IT WAS TOWED TO THE DEALERSHIP, WHERE I PURCHASED IT. IT IS SILL IN THEIR BODY SHOP. A FEW DAYS AFTER THE ACCIDENT I CHECKED THE INTERNET TO SEE IF ANYONE ELSE HAD THIS PROBLEM. THERE WERE LOTS & LOTS OF EXAMPLES OF THIS, SUDDEN UNINTENDED ACCELERATION PROBLEM, WITH THE 2011 SANTA FE. I DON'T SEE ANY RESPONSES FROM HYUNDAI. THIS PROBLEM HAS TO BE DEALT WITH. *TR

NHTSA ODI 10521561

I BACKED OUT OF A PARKING SPOT AND MADE CONTACT WITH SOMETHING WHICH I COULD NOT SEE FROM MY REAR VIEW OR SIDE VIEW MIRRORS. LATER, WHEN THE EMERGENCY WORKERS WERE LOADING ME INTO THE AMBULANCE, I WOULD SEE THAT THE OBJECT WAS A LOW, CEMENT POLE, WHICH PROTECTED A FIRE HYDRANT DIRECTLY BEHIND THE PARKING SPOT I PULLED OUT OF. AS I PUT THE VEHICLE IN GEAR (DRIVE) WITH MY FOOT ON THE BRAKE, TO PULL AWAY FROM WHATEVER I BACKED IN TO, THE ENGINE REVVED AND THE VEHICLE ACCELERATED ON ITS OWN. THE VEHICLE LURCHED FORWARD (THE BEST WAY TO DESCRIBE IT IS THE WAY A PINBALL BOUNCES OFF OF A BUMPER ON A PINBALL MACHINE) AND CONTINUED MOVING FORWARD, EVEN THOUGH MY FOOT WAS STILL ON THE BRAKE PEDAL. THE VEHICLE DROVE FORWARD INTO THE PARKING SPOT I HAD STARTED FROM, OVER A CURB AT THE FRONT OF THE PARKING SPOT, THROUGH A PATCH OF LOW LYING PLANTS AND OVER A WALL WHICH IS APPROXIMATELY FOUR TO FIVE FEET IN HEIGHT. MY VEHICLE WAS AIRBORNE AND CAME TO REST IN THE LOWER LEVEL PARKING LOT, STRIKING A PARKED VEHICLE. IT WAS ONLY THEN THAT THE VEHICLE STOPPED ITS FORWARD MOTION. MY ARMS HAD BEEN LOCKED ON THE STEERING WHEEL, MY RIGHT FOOT ON THE BRAKE PEDAL. MY LEFT LEG ABSORBED THE IMPACT OF THE CRASH INTO THE LOWER LEVEL PARKING LOT. I WAS TAKEN AWAY IN AN AMBULANCE WITH A BROKEN LEG AND SEVERELY DISLOCATED ANKLE. THE VEHICLE HAS BEEN DEEMED A TOTAL LOSS BY MY INSURANCE CARRIER. I WAS ADVISED THAT A CLAIMS INVESTIGATOR WAS SENT TO THE INSURANCE-COMPANY-AUTHORIZED COLLISION SHOP TO WHERE MY VEHICLE WAS TOWED. EVEN THOUGH THE EMERGENCY WORKERS ADVISED ON THE NIGHT OF THE ACCIDENT THAT THE CAR WAS NOT IN A DRIVABLE CONDITION, I WAS ADVISED BY MY INSURANCE COMPANY THAT THE INVESTIGATOR DROVE THE VEHICLE IN THE PARKING LOT OF THE COLLISION SHOP AND HE WAS NOT ABLE TO REPLICATE THE UNINTENDED ACCELERATION. *TR

NHTSA ODI 10501225

DRIVER LOST CONTROL OF VEHICLE ON HIGHWAY WHICH RESULTED IN THE DRIVERS FATALITY, PREVIOUS DRIVER OF VEHICLE INDICATED SOMETHING WAS "ODD" WITH THE STEERING. *TR

NHTSA ODI 10482407

TL* THE CONTACT OWNS A 2011 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH , THERE WAS A LOUD POP HEARD FROM THE REAR OF THE VEHICLE. THE VEHICLE THEN STALLED IN THE MIDDLE OF THE INTERSECTION WHERE THE VEHICLE WAS CRASHED INTO FROM THE PASSENGER SIDE. THE PASSENGER SIDE REAR TIRE EXPLODED FROM THE IMPACT. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND LATER DIAGNOSED BY A PRIVATE MECHANIC WHO ADVISED THAT THE REAR AXLE FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 30,000.

NHTSA ODI 10449746

TL* THE CONTACT OWNED A 2011 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 68 MPH, THE ENGINE BEGAN TO EMIT A LOUD BANGING NOISE AND CAUGHT ON FIRE. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND STOPPED. A STATE TROOPER APPEARED ON THE SCENE TO EXTINGUISH THE FIRE. THE VEHICLE WAS DESTROYED AND TOWED TO AN AUTHORIZED DEALER. THE FAILURE WAS NOT DIAGNOSED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE 673.

NHTSA ODI 10436180