What 370 owners told NHTSA about the 2011 Ford F-250 Super Crew

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH ON UNEVEN ROAD PAVEMENT, THE VEHICLE STARTED TO VIBRATE. THE CONTACT ALSO STATED THAT HE REDUCED THE SPEED TO 10 MPH, THE VIBRATION STOPPED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT ALL FOUR TIRES NEEDED TO BE REPLACED AND BALANCED. THE TECHNICIAN ALSO ALIGNED BOTH FRONT DRIVERS AND PASSENGERS SIDE TIRES. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

NHTSA ODI 10607693

THIS STARTED IN MARCH 2014. TERRIBLE STEERING WOBBLE (DEATH WOBBLE) AT HIGHWAY SPEED. LAST NIGHT IT WAS HORRIBLE AS I WAS PASSING A CAR ON I-29 ON A BRIDGE AND WE GOT THE WOBBLE AFTER GOING OVER A BRIDGE JOINT. I HAD TO STAB THE BRAKES TO SLOW DOWN AS THE TRUCK STEERING WAS OUT OF MY CONTROL. SEVERAL VEHICLES BEHIND ME ALSO HAD TO NAVIGATE AROUND ME AS I TRIED TO TURN THE VEHICLE TO THE SHOULDER. THIS TRUCK IS DANGEROUS AT HIGHWAY SPEED! THIS HAS HAPPENED SEVERAL TIMES WHILE GOING DOWN THE INTERSTATE. I'M SCARED TO DRIVE THE TRUCK ANYWHERE BUT AROUND CITY STREETS. TO MY KNOWLEDGE THIS IS A VERY COMMON PROBLEM WITH ALL SUPER DUTY TRUCKS WITH A STRAIGHT FRONT AXLE AND COIL SPRINGS. I WANT FORD TO ADMIT THERE IS A PROBLEM AND FIX THESE ISSUES. IT'S A FIXABLE ISSUE THAT THEY WON'T ADDRESS. FOR $50,000 I DON'T THINK I SHOULD HAVE TO PAY FOR THEIR ENGINEERING GEOMETRY BLUNDER. *TR

NHTSA ODI 10598767

MY TRUCK STARTS SHAKING VIOLENTLY AT 40-60 MPH. STEERING CONTROL IS LOST AND CAN ONLY BE REGAINED BY COMING TO A COMPLETE STOP. TRUCK WILL NOT SWITCH LANES AND PULLING OVER TO THE SHOULDER IS IMPOSSIBLE DUE TO LOSS OF STEERING. SHAKING IS VIOLENT TO THE POINT OF LOOSENING BOLTS. TAKEN TO DEALER TO BE CHECKED UNDER WARRANTY. THEY CLAIMED IT WAS AIR PRESSURE OR THE NEED FOR NEW TIRES. THE VEHICLES TIRES ARE IN GOOD CONDITION AND AIR PRESSURE IS SET AT FACTORY RECOMMENDED LEVELS. FORD SAYS THIS BEHAVIOR IS NORMAL. A SERIOUS ACCIDENT EXTREMELY POSSIBLE. AN INDEPENDENT SUSPENSION SHOP CLAIMS ISSUE IS DUE TO DEFECTIVE BALL JOINTS, LACK OF STEERING DAMPER, AND DEFECTIVE CONTROL ARMS. *TR

NHTSA ODI 10597434

THIS SAFETY CONCERN OCCURRED ON A 2011, FORD F250, WITH "26,400" MILES ON IT. UPON LEAVING MY RESIDENCE, THE TRUCK FELT SLUGGISH, AS IF THE EMERGENCY BRAKE WAS ON. I NEVER USE THE EMERGENCY BRAKE, BUT CHECKED ANYWAY TO CONFIRM IT WAS NOT SET. I PULLED OVER AND EXISTED THE VEHICLE, AND IMMEDIATELY NOTICED A BURNING ODOR. THE ODOR CAME FROM THE DRIVER SIDE FRONT WHEEL. I REACHED IN TO FEEL THE ROTOR AND BURNED MY FINGER TIPS FROM THE HEAT. AS A PRECAUTION, I CHECKED THE REMAINING WHEELS AND ALL EXHIBITED VERY HIGH HEAT WITH A BURNING ODOR. LUCKILY, I WAS WITHIN AN 1/8 MILE OF S SERVICE STATION. THE MECHANIC INSPECTED AND DETERMINED ALL FOUR BRAKES HAD SEIZED DUE TO CORROSION. TWO CALIPERS WERE SALVAGEABLE, TWO WERE NOT. THE REPAIR WAS MADE WITH THE CALIPERS HELD FOR THE LOCAL FORD DEALER FOR REVIEW, AND DISPOSITION, BUT THE FORD DEALER SHOWED NO INTEREST, AND HAD DECLINED TO PERSONALLY EXAMINE THE CORRODED CALIPERS. THE TRUCK WAS 21 DAYS OUT OF CALENDAR WARRANTY. *TR

NHTSA ODI 10593436

CATASTROPHIC ENGINE FAILURE AT 3 YEARS OLD AND 124,000 MILES. THIS $60,000 2011 FORD F-250 SUPER DUTY WITH 6.7 DIESEL ENGINE IS TOTALED. DRIVING DOWN THE ROAD AT NORMAL CRUISE THE ENGINE STARTED MAKING A TERRIBLE BANGING NOISE AND SHUDDERING SO VIOLENTLY THAT I WAS FORCED TO IMMEDIATELY LEAVE THE ROAD. I STOPPED AND TURNED THE ENGINE OFF. GOT OUT AND THE GROUND WAS COVERED IN OIL. STRANDED.. DEALERSHIP QUOTED ME $24,233.67 TO REPLACE THE ENGINE. ALTHOUGH THIS ENGINE IS FALSELY ADVERTISED TO BE RIGIDLY TESTED FOR 250,000 MILES, FORD HAS SENT EMAIL STATING THAT THEY WILL NOT STAND BEHIND THE PRODUCT. THIS TRUCK IS STILL FINANCED AND QUITE FRANKLY I CANNOT AFFORD AND SHOULD NOT HAVE TO AFFORD THIS REPAIR. I HAVE HAD EXHAUST ISSUES WITH OVERHEATING AND BURNING SENSORS WHICH WERE REPLACED BY WARRANTY A COUPLE TIMES AND OUT OF POCKET A COUPLE TIMES. I HAVE READ MANY REVIEWS THAT THE HEAT THAT IS BUILT UP DURING A REGEN EXHAUST CLEANING CYCLE DAMAGES THE VALVES WITHIN THE ENGINE. I ALSO READ THAT FORD FIXED THIS PROBLEM IN 2012 BUT THAT LEAVES PEOPLE LIKE MYSELF, WHO PAID FORD $60,000+ STRANDED WITHOUT A VEHICLE IN JUST 3 SHORT YEARS. I HAVE SERVICE THE TRUCK AS REQUIRED AND HAVE NEVER ABUSED IT NOR PUT IT IN MUD, ETC. PLEASE LOOK INTO THIS AND SEE IF THERE IS ANYTHING I CAN DO. IT APPEARS I MAY BE WITHOUT A VEHICLE AND HAVE TO DEFAULT ON MY LENDER WITH THE COST OF THIS. *TR

NHTSA ODI 10586713

WHEN HITTING A BUMP OR POT HOLE AT HIGHWAY SPEED THE FRONT TIRES WOBBLE UNCONTROLLABLY UNTIL YOU ALL BUT STOP. THIS COULD CATCH SOMEONE OFF GUARD TO CRASH INTO SOMEONE ON THE HIGHWAY. *TR

NHTSA ODI 10583631

TRUCK DEVELOPED A VIOLENT SHAKE IN THE FRONT END AND BECAME UNCONTROLLABLE. HAVE TO STOP IMMEDIATELY BEFORE VEHICLE WILL STOP SHAKING. THE ISSUE IS REFERRED TO THE "FORD DEATH WOBBLE" WITH MANY RECORDED INSTANCES OF THIS ON THE WEB AND YOUTUBE. ISSUE HAS GOTTEN WORSE AND IS UNSAFE TO DRIVE. HAS BEEN IN THE FORD DEALER AND MANY NEW PARTS REPLACED BUT PROBLEM PERSIST. FORD DEALER CANNOT SEEM TO CORRECT SO IT HAS BEEN IN TWO OTHER GARAGES FOR SECOND OPINIONS. CONTACTED FORD MOTOR COMPANY AND THEY HAVE NO RECALLS OR ANY KNOWLEDGE OF THIS PROBLEM. VEHICLE IS A DANGER TO THE HIGHWAY. *TR

NHTSA ODI 10575179

VEHICLE PRIMARY COOLING SYSTEM (RADIATOR) BEGAN LEAKING WHERE THE ALUMINUM COILS ARE ATTACHED TO THE PLASTIC TANK. I TOOK VEHICLE TO FORD DEALER FOR INSPECTION AND THEY VERIFIED. LEAK WAS SLOW FOR FIRST COUPLE OF WEEKS, THEN PROGRESSED. REPLACEMENT WAS INSERTED BEFORE RADIATOR LEAK COULD CAUSE FURTHER DAMAGE TO VEHICLE OR PERSONS. THIS IS A VERY COMMON OCCURRENCE WITH THIS YEAR/MODEL AND OWNERS FEEL THIS SHOULD BE ADDRESSED WITH A RECALL FROM FORD MOTOR COMPANY DUE TO INADEQUATE TESTING OR PRODUCT SPECIFICATIONS. THE PUBLIC RATE OF OCCURRENCE IS VERY HIGH. OF COURSE FOMOCO WILL NOT PUBLISH DATA UNTIL FORCED. REPORTS OF RADIATORS FAILING < 50,000 MILES IS NOT UNCOMMON. *TR

NHTSA ODI 10568753

I HAD A PROBLEM WITH MY 2011 F250'S TRANSMISSION. THE PROBLEM WAS COVERED UNDER TSB 11-5-19. WHEN TRYING TO ACCELERATE, THE TRANSMISSION WOULD RANDOMLY DEVELOP A PROBLEM WHICH SEEMED LIKE IT WAS TRYING TO FIND THE RIGHT GEAR. THERE WOULD BE A SEVERE LOSS OF POWER WHICH WOULD RESULT, AT TIMES, LEAVING MY VEHICLE IN TRAFFIC GOING AT A MUCH HIGHER SPEED AND CLOSING RAPIDLY FROM BEHIND. THE PROBLEM WAS RESOLVED BY DOING THE SERVICE PRESCRIBED IN THE SERVICE BULLETIN BUT I WAS NOT AWARE OF THAT BULLETIN UNTIL THE PROBLEM BECAME SEVERE. *TR

NHTSA ODI 10567698

TL* THE CONTACT OWNS A 2011 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE BEGAN SHAKING ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO STATED THAT THEY WOULD BALANCE ALL FOR TIRES AND PERFORMED AND ALIGNMENT CHECK. THE VEHICLE WAS REPAIRED HOWEVER, THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 22,500. *TR

NHTSA ODI 10566852

THE 6.7 CID DIESEL ENGINE DRIVEN VACUUM PUMP SUDDENLY BEGINS LEAKING MOTOR OIL. FAILURE OF THIS PUMP WILL AFFECT 4 WHEEL DRIVE SYSTEMS INCLUDING AUTO LOCKING HUBS AND ALL INTERIOR CLIMATE CONTROLS. LOSS OF MOTOR OIL COULD CAUSE ENGINE FAILURE. FAILURE OF 4 WHEEL DRIVE SYSTEM DURING ADVERSE WEATHER COULD RESULT IN A VEHICLE CRASH OR LOSS OF CONTROL. RESEARCH INDICATES MULTIPLE FAILURES OF THIS PART, INDICATING A SYSTEMIC FAILURE. *TR

NHTSA ODI 10565778

PURCHASED 2MTH AGO. WOULD NOT START. REPLACED BATTERIES. 4 WKS LATER "PULL OVER SAFETY" ON & SHUT DOWN ON A WINDY ROAD AT 6PM. VEHICLE TOWED TO AUTO PLACE. $1500 FIX ELECTRICAL PROBLEM. 1 MTH LATER IT DOES IT AGAIN DOWN BUSY FREEWAY ALMOST CAUSING NEAR COLLISIONS. TOAD AGAIN. FIXED AND SAME AFTERNOON PULLING OUT TO STATE HIGHWAY AND SAME SIGNAL TO PULL OVER COMES ON & VEHICLE SHUTS DOWN & BACKING UP 5PM TRAFFIC BEFORE BEING TOWED AGAIN. *TR

NHTSA ODI 10565040

TRUCK SHUT DOWN INSTANTLY. AFTER STOP SAFELY MESSAGE. LEAVING TRUCK STRANDED IN BUSY INTERSECTION. NO TIME TO PULL OVER SAFELY. REPLACED SENSOR. FORD CLAIMS FIRE SAFETY.AND BLAMES EPA. THINK SOFTWARE WOULD DISMISS UNLIKELY TEMP FLUCTUATIONS . NEEDS TO GO INTO LIMP MODE. NOT STRAND DRIVERS IN HEAVY TRAFFIC.FOR PART FAILURE. *TR

NHTSA ODI 10564510

I PURCHASED THE VEHICLE IN OCTOBER OF 2013 WITH 99,000 MILES ON IT. IN JANUARY OF 2014 I HAD A CHECK ENGINE LIGHT COME ON. I RETURNED TO THE DEALER TO HAVE THE CODE READ. AT THIS POINT THE DIESEL TECH COMES AND TELLS ME THAT MY FUEL SYSTEM HAS BEEN CONTAMINATED AND THEY HAVE TO REPLACE THE ENTIRE FUEL SYSTEM AND THAT I SHOULD CALL MY INSURANCE COMPANY TO COVER THE COST. THE INSURANCE COMPANY SENT OUT AN INSPECTOR WHO TOOK SEVERAL FUEL SAMPLES. NOW AFTER 16 DAYS WITHOUT MY TRUCK THE TEST SAMPLES HAVE CAME BACK AS 100% PURE DIESEL FUEL WITH NO TRACE EVIDENCE OF CONTAMINATION AND THEY WILL NOT COVER THE COST. THEY ARE CURRENTLY SENDING ME LEGAL DOCUMENTATION AS WELL. THE FORD DEALER KNOWING THIS INFORMATION REFUSES TO BUDGE FROM THEIR CONTAMINATION CLAIMS. *TR

NHTSA ODI 10562390

WHILE DRIVING AROUND 50-60 MPH AND GOING OVER A COUPLE OF SMALL BUMPS THE TRUCK STARTED SHAKING VIOLENTLY. I HAD TO SLOW DOWN ON THE FREEWAY TO ABOUT 35 FOR THE SHAKING TO STOP. IT HAS HAPPENED TWICE IN A WEEK. AFTER READING ALL THE COMPLAINTS ON SEVERAL WEBSITES AND SEEING THE YOUTUBE VIDEO I DECIDED TO FILE THE COMPLAINT. I WILL BE GOING TO THE DEALERSHIP NEXT WEEK. *TR

NHTSA ODI 10561944

DRIVING EAST BOUND ON THE 91 FREEWAY IN THE DIAMOND LANE I DROVE OVER A ROADWAY IMPERFECTION. AS SOON AS I HIT IT WITH MY LEFT FRONT TIRE THE VEHICLE MADE A VIOLENT MOTION TO THE LEFT ALMOST CAUSING ME TO STRIKE THE CENTER DIVIDER. THIS HAPPENED SEVERAL OTHER TIMES BEFORE I RETURNED THE VEHICLE TO THE DEALER TO HAVE IT CHECKED (12/16/2010). BY THIS TIME, STRIKING AN IMPERFECTION WITH EITHER FRONT TIRE CAUSED THE VEHICLE TO MOVE LATERALLY, LEFT OR RIGHT. AFTER SEVERAL VISITS TO THE FORD DEALER WITHOUT REMEDY, A FORD ENGINEER WAS SUMMONED FOR A TEST DRIVE. WE DROVE THE VEHICLE TO A SPOT I CONSISTENTLY HAVE THE PROBLEM AND IT VIOLENTLY PULLED TO THE LEFT WHEN THE FRONT LEFT TIRE HIT THE SPOT (TRANSITION ROAD: 405 FREEWAY TO THE NORTHBOUND 710 FREEWAY). BOTH THE ENGINEER AND THE SERVICE MANAGER WERE IN THE VEHICLE AT THAT TIME AND BOTH FELT WHAT I WAS COMPLAINING ABOUT. LATER THAT SAME DAY I WAS LOOKING AT A FORD FUSION WITH MY SON AND THE FORD ENGINEER DROVE INTO THE LOT IN A NEW FORD SUPER DUTY 4X4 THAT HE HAD DRIVEN TO THAT SAME LOCATION. HE TOLD ME AND MY SON THAT THE NEW VEHICLE DID THE SAME THING AND HE WOULD REPORT BACK TO FORD SO THAT THEY COULD DO SOMETHING ABOUT IT. I WAS LATER CONTACTED BY THE FORD MANAGER AND TOLD THAT MY PROBLEM WAS WITHIN FORDS TOLERANCE FOR THE VEHICLE. HE ALSO TOLD ME I COULD PROBABLY GO OVER TO THE FOUR WHEEL DRIVE PARTS STORE AND PURCHASE SOMETHING THAT MIGHT HELP WITH THE PROBLEM. I CONTINUE TO HAVE THIS PROBLEM BUT IT APPEARS TO BE GETTING WORSE. EVEN MY FRIENDS WHO DRIVE WITH ME COMPLAIN ABOUT THIS ISSUE TELLING ME I NEED TO DO SOMETHING ABOUT IT. THIS PAST WEEK I CONTACTED FORD AGAIN VIA THEIR FIX-IT HOT LINE AND SPOKE WITH ONE OF THEIR REPRESENTATIVES WHO LOOKED INTO MY COMPLAINT (HE SPOKE WITH THE FORD MANAGER AND FORD ENGINEER). TODAY HE ADVISED ME THE PROBLEM WAS NORMAL FOR THE VEHICLE. ANYONE ELSE COMPLAINING? *TR

NHTSA ODI 10561710

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 60 MPH, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.

NHTSA ODI 10560105

WHILE DRIVING AT FREEWAY SPEED HIT POTHOLE AND TRUCK BEGAN TO SHAKE VIOLENTLY. PULLED OF THE FREEWAY TO INSPECT AND EVERYTHING LOOKED OK. GOT BACK ONTO FREEWAY AND CROSSED OVER A BRIDGE AND THE SAME VIOLENT SHAKE HAPPENED UNTIL I SLOWED DOWN TO ABOUT 40 MPH. DROPPED TRUCK OFF AT DEALER ON WAY HOME FROM WORK. *TR

NHTSA ODI 10559732

WHILE DRIVING ON STRAIGHT ROADS, IF YOU ENCOUNTER ROUGH ROAD SURFACE (CONSTRUCTION, POTHOLE, ETC) STEERING AND FRONT END OF THE VEHICLE BEGINS TO OSCILLATE VIOLENTLY. IT IS ALMOST LIKE THE OSCILLATION CREATES A HARMONIC FREQUENCY THAT INCREASES THE INTENSITY TO A DEGREE THAT THE VEHICLE MUST BE SLOWED OR STOPPED TO RECOVER. *TR

NHTSA ODI 10559433

I HAVE A 2011 FORD F250 SUPER DUTY 28,000 MILES, THE VEHICLE IS EQUIPPED WITH MICHELIN LT275/65R20 TIRES. I RECENTLY NOTICED STRESS CRACKS ALONE THE INNER WALL NEAR THE RIM ON ALL 4 TIRES. THERE IS ALSO CRACKS AROUND THE UPPER PORTION OF THE TIRE AROUND THE TREAD. THROUGH RESEARCH I HAVE LOCATED A SAFETY RECALL FOR THESE TIRES BUT IN THE SIZE OF LT 275/55R20. I HAVE CONTACTED MICHELIN AND WAS TOLD TO PURCHASE NEW TIRES ( $330 X 4 ) AND SEND THESE TIRES TO THEM FOR INSPECTION. THERE IS A POSSIABILITY OF A PRORATION BUT NO GUARANTEE. AS IN THE POSTED SAFETY RECALL THIS HAS THE POTENTIAL TO HAVE A PARTIAL OR FULL LOSS OF AIR MAKING THIS A HUGE SAFETY CONCERN. *TR

NHTSA ODI 10558358

IN REFERENCE TO COMPLAINT # 10558358, I LOCATED THE TIRE UNDER MICHELIN NORTH AMERICA. THE INNER WALLS NEAR THE RIM ON ALL FOUR TIRES HAVE MULTIPLE CRACKS. NEAR THE TREAD OF TWO TIRES I HAVE LOCATED ADDITIONAL CRACKS. THESE TIRES ARE ONLY 3 YEARS OLD WITH 28,000 MILES. *TR

NHTSA ODI 10558363

I WAS TRAVELING SOUTH ON HIGHWAY 99 IN THE CENTRAL VALLEY OF CALIFORNIA NORTH OF VISALIA, CA. I WAS MAINTAINING MY SPEED IN THE FAST (SECOND LANE) LANE BETWEEN 65 AND 70 MPH ON A PORTION OF THE HIGHWAY THAT WAS RECENTLY LAID WITH FRESH ASPHALT. THIS OF COURSE, MADE THE ROAD SURFACE VERY SMOOTH ALTHOUGH THERE WAS SOME TRANSITION PORTIONS OF THE ROAD SURFACE WITH A FEW ROUGHER SECTIONS. GOING OVER ONE OF THE TRANSITIONS THE FRONT END OF THE TRUCK BEGAN TO SHAKE VIOLENTLY. I IMMEDIATELY ATTEMPTED TO SLOW DOWN WHICH WAS VERY DANGEROUS DUE TO THE AMOUNT OF TRAFFIC BOTH BEHIND ME AND TO THE SLOW LANE TO MY RIGHT. I BELIEVE THE OTHER DRIVES SAW MY SITUATION AND ALLOWED ME TO PULL TO THE SLOW LANE TO GET CONTROL OF THE TRUCK. ONCE MY SPEED WAS REDUCED TO AROUND 35 TO 40 MPH, THE SHAKING STOPPED. THE PASSENGER WHO WAS WITH ME WAS UNDOUBTEDLY SHAKEN UP - NO BUN INTENDED. UNFORTUNATELY, THIS WAS THE SECOND TIME I EXPERIENCED THE "DEATH WOBBLE" THAT SO MANY OTHER FORD TRUCK OWNERS HAVE EXPERIENCED. THE FIRST OCCURRENCE WAS ABOUT THREE MONTHS EARLIER WHILE TRAVELING ON THE GOLDEN STATE HIGHWAY IN BAKERSFIELD, CA. MY SPEED AT THAT TIME WAS 60 MPH AND BEGAN TO SHAKE UNCONTROLLABLY AFTER PASSING OVER A CONCRETE TO CONCRETE TRANSITION IN THE ROAD. FOLLOWING BOTH EVENTS I TOOK MY TRUCK TO THE LOCAL FORD DEALER FOR DIAGNOSIS. MY DEALER IS JIM BURKE FORD, BAKERSFIELD, CA. THE FIRST TIME INTO SERVICE THE DEALER CHANGED OUT THE STEERING STABILIZE AND SAID ALL OTHER FRONT END AND STEERING COMPONENTS CHECKED OUT FINE. THE STEERING STABILIZER CHANGE OUT WAS FUNNY BECAUSE I HAD REPLACED THE ORIGINAL ONE AND INSTALLED A NEW BILSTEIN BRAND STEERING STABILIZER ON THE TRUCK A FEW MONTHS PRIOR. I HAVE ENJOYED THIS TRUCK BUT IT IS BEGINNING TO SCARE MY AS I'M CONCERNED ANOTHER EVENT COULD RESULT IN A SERIOUS ACCIDENT. PLEASE HELP US FORD TRUCK OWNERS. THANK YOU. *TR

NHTSA ODI 10557240

I GET A VIOLENT SHAKE OR WOBBLE FROM FRONT END WHEN I HIT SMALL TO LARGE BUMPS IN THE ROAD. I HAVE CHECKED TIRE PRESSURE AND FRONT END PARTS. NOTHING HAS BEEN WRONG OR ABNORMAL. I RESEARCHED A BIT AND FOUND THIS TO BE A COMMON PROBLEM WITH THESE TRUCKS. *TR

NHTSA ODI 10557185

FUELED UP DROVE TRUCK FOR 2 DAYS NO PROBLEMS. THAT NIGHT WHILE DRIVING TRUCK BEEPED LOW FUEL PRESSURE LIGHT CAME ON AND TRUCK DIED IN MIDDLE OF ROAD. GOT TOWED IN TO HEALEY BROS IN GOSHEN,NY. AFTER 4 DAYS WAS TOLD I HAD WATER IN THE DIESEL. BUT IF THERE WAS, THE WATER IN FUEL LIGHT SENSOR SHOULD HAVE GONE OFF AND IT DIDN'T. THE DEALER TOLD ME THEY HAD TO REPLACE EVERYTHING FROM THE FUEL PUMP TO THE INJECTS. AT AN OUTSTANDING $10,000. AFTER 1 MONTH OF FIGHTING WITH FORD AND MY INSURANCE COMPANY, NOBODY WANTS TO COVER EVEN UNDER THE EXTENDED WARRANTY I HAVE. I GAVE DEALERSHIP OK TO FIX. ANOTHER MOTHER LATER SUPPOSEDLY STILL WAITING ON PARTS. AT THIS TIME I'VE HAD ENOUGH MAKING MY 400.00 A MONTH PAYMENT AND PAYING MY INSURANCE ON A TRUCK I DON'T HAVE, I CALLED A LAWYER. WELL WHEN THE LAWYER REQUESTED INFO SUCH AS IF FORD SENT AN ADJUSTER, WHAT TESTS DID THEY RUN ON FUEL, WHAT WAS THE % OF WATER, WHY DIDN'T THE LIGHT COME ON THAT THEY TESTED AND SAID IT WAS OK AND A WRITTEN STATEMENT BACKING UP THEIR STATEMENT OF WATER IN THE FUEL SO I COULD GO AFTER THE FUEL COMPANY THEY REFUSED TO GIVE THEM UP. NOW ALL OF A SUDDEN THEY WANT TO WORK WITH ME AND FORD IS GONNA COVER THE WORK AND CREDIT ME 2 MONTHS PAYMENTS. SOMETHING SMELL ROTTEN IN DENMARK WITH THIS ENGINE PROBLEM AND HEALEY BROS FORD AND FORD THEMSELVES. STILL WONT GIVE ME AND HONEST ANSWER ON WHAT THE PROBLEM IS. AND STILL WAITING FOR MY TRUCK. *TR

NHTSA ODI 10556802

I HAVE AN F-250 SUPER DUTY FX4. THE TRUCK ONLY HAS 15,000 MILES AND LAST YEAR IN OCT, 2012 THE TRUCK HAD A VIOLENT SHIMMY IN THE FRONT END AT 9,000 MILES. THIS OCCURRED ON TWO DIFFERENT OCCASIONS AND I TOOK THE TRUCK TO THE DEALER AND THEY REPLACED THE STEERING STABILIZER AND THE PROBLEM WAS FIXED FOR ABOUT A YEAR. THE TRUCK HAS STARTED THIS SHAKING AGAIN. THIS HAS OCCURRED THREE DIFFERENT TIMES IN THE LAST MONTH. THIS HAPPENS IF I CHANGE LANES THAT ARE UNEVEN AT ABOUT 35-40 MPH AND WILL ALSO HAPPEN AT SPEEDS GREATER THAN 60 MPH IF THE ROAD IS A BIT BUMPY. IT IS VERY SCARY AND THE TRUCK IS UNCONTROLLABLE UNTIL THE SHAKING STOPS. *TR

NHTSA ODI 10552681