What 976 owners told NHTSA about the 2011 Chevrolet Malibu Hev

THE FRONT PASSENGER HEADLIGHTS LOW BEAM KEEPS GOING OUT I HAVE CHANGED THE SOCKET 2 TIMES AND CHANGED THE WIRE HARNESS 1 TIME AND IT'S ONLY THE LOW BEAM BURNING OUT ON REPEAT LIKE EVERY OTHER MONTH I CHANGE IT AND TRY FIXING IT WITH NEW SOCKETS OR LIGHTS AND IT KEEPS BURNING OUT I THINK THIS HAS TO BE AN ELECTRICAL ISSUE FROM MANUFACTURER BECAUSE MANY PEOPLE ARE EXPERIENCING THE SAME ISSUE ON THE PASSENGER SIDE HEADLIGHT LOW BEAM PLEASE CAN WE GET THIS RECALLED AND FIXED PLEASE

NHTSA ODI 11300610

PASSENGER SIDE LOW BEAM HEADLIGHT STOPPED WORKING. ALL OTHER LIGHTS WORK FINE. REPLACED BULB AND WIRING HARNESS FOR THE HEADLIGHT ASSEMBLY AND STILL WONT WORK. UPON FURTHER INVESTIGATION MANY OTHER CHEVY MALIBU OWNERS HAVE THE SAME EXACT ISSUE WITH THE SAME EXACT LIGHT. THE LIGHT JUST STOPPED WORKING ONE DAY WHILE STATIONARY.

NHTSA ODI 11300329

WHEN THE CAR IN MOTION. THE STEERING MAKES A LOUD NOISE WHEN TURNING THE WHEEL. AND THE AIR BAG INDICATOR JUST POPPED ON. STATING SERVICE THE VEHICLE.

NHTSA ODI 11299399

LOW-BEAM HEADLAMPS CONTINUALLY BURN OUT OR QUIT WORKING, REQUIRING FREQUENT REPLACEMENT OF HEADLAMP BULBS AND HEADLAMP ASSEMBLY PIECES. REPAIRS ARE EXPENSIVE BECAUSE THE VEHICLE'S ENTIRE FRONT END MUST BE REMOVED EACH TIME TO ACCESS HEADLAMPS AND RELATED WIRING. ONE OR BOTH HEADLAMPS HAVE GONE OUT AT LEAST FOUR TIMES IN THE PAST 18 MONTHS.

NHTSA ODI 11298109

RIGHT FRONT LOW BEAM HEADLIGHT KEEPS GOING OUT. HARNESS AND BULB HAS BEEN CHANGED. SAME HAS HAPPENED 3TIMES. SAFETY CONCERN!!! LAST CHEVROLET FOR ME!!! THIS HAS HAPPENED THREE TIMES THIS YEAR. GETTING EXPENSIVE!!!!

NHTSA ODI 11292523

BUZZER SOUNDED, RED LIGHT FLASHED POWER STEERING SERVICE. THEN I HAD TROUBLE STEERING AND HAD TO FIGHT TO MAKE TURNS. HURT MY ARMS. VEHICLE HAD JUST BEGUN MOVING AND THE MINUTE I TOUCHED THE STEERING WHEEL IT WOULDN'T MOVE. IF I PUT ALL MY MIGHT INTO THE STEERING WHILE MOVING, I COULD TURN CORNERS, BUT IT HURT. STAYED STABLE GOING STRAIGHT.

NHTSA ODI 11290761

THE ABS, ESC, AND SERVICE TRACTION LIGHTS CAME ON WHILE I WAS ON THE INTERSTATE SUDDENLY MY CRUISE CONTROL STOPPED WORKING. I EXITED THE HIGHWAY AND AS MY CAR CAME TO A COMPLETE STOP IT STARTED ROLLING BACKWARDS AND THE BREAKS LOCKED UP SO I COULDNT STOP. IT ONLY STOPPED ROLLING AFTER PUTTING THE CAR IN PARK, HITTING THE EMERGENCY BREAK, AND QUICKLY GETTING THE KEY OUT BEFORE HITTING THE FAMILY BEHIND ME. I TRIED TO TURN ON MY HAZARDS AND THEY WOULDNT COME ON. I RESTARTED THE CAR, AND THE WHOLE DASH WAS FLICKERING. AFTER TRYING THIS 3 TIMES IT STARTED, BUT WHEN I TRIED TO ACCELERATE THE CAR WENT TO 7/8 RPM AND DID NOTHING. THEN IT STARTED TO ROLL BACKWARDS AGAIN BEFORE I COULD PUT IT IN PARK I WAS THRUSTED FORWARD INTO THE CENTER OF A ROUNDABOUT. AFTER THAT IT BEGAN TO DRIVE. I WAS LESS THAN 5 MINUTES FROM A FAMILY MEMBERS HOME SO I TRIED TO MAKE IT. I WAS ABLE TO GET THE CAR GOING 30 MPH FOR LESS THAN 5 MINUTES BEFORE THE SPEED IMMEDIATELY DROPPED TO ZERO, AND THE CAR BEGAN TO ROLL BACKWARDS AGAIN. MY FACE HIT THE STEERING WHEEL BECAUSE OF THE JOLT WHICH RESULTED IN FACIAL BRUISES. THE AIR BAGS DID NOT DEPLOY. WHEN THIS ISSUE HAPPENED ALL OF THE ELECTRIC IN THE CAR STARTED GOING CRAZY. I WAS ON A BACKROAD, AND LUCKILY A GOOD SAMARITAN STOPPED TO HELP ME. I CALLED MY UNCLE WHO IS A MECHANIC WHO TOWED ME BACK TO THE HOUSE. THIS ISNT THE FIRST TIME IVE HAD ISSUE WITH THESE WARNINGS COMING UP AND THEN I HAVE TO SUDDENLY START FIGHTING TO SURVIVE BEING TRAPPED IN A CAR TRYING TO KILL ME. SINCE THIS LAST INCIDENT I HAVE NOT TRIED TO DRIVE THE CAR. AFTER SEEING MULTIPLE MECHANICS THEY CONFIRMED THIS WAS A COMMON ISSUE IN THIS YEAR MAKE AND MODEL OF THE VEHICLE. NO ONE SEEMS TO KNOW WHAT HAS BEEN CAUSING THIS. THIS KIND OF ISSUE COULD KILL SOMEONE. IT NEEDS TO BE INVESTIGATED, AND GM NEEDS TO BE HELD RESPONSIBLE FOR SELLING UNRELIABLE, UNSAFE, DEATH TRAPS TO CONSUMERS.

NHTSA ODI 11290630

WHEN WE ARE DRIVING THE CAR IT WILL START SHAKING, THE ESC LIGHT COMES ON AND THE CAR COMPLETELY DIES. THIS HAS HAPPENED WHILE DRIVING 15 MPH AND 70 MPH ON CITY STREETS AND HIGHWAYS. WE HAVE HAD IT IN MULTIPLE SHOPS AND BEEN TOLD THIS IS A COMMON ISSUE NOBODY HAS FOUND A RESOLUTION FOR. VERY DANGEROUS AND AFRAID TO PUT OUR KIDS IN THE CAR AS WE DON'T KNOW WHEN IT WILL DO IT, THERE HASN'T BEEN A COMMON VARIABLE.

NHTSA ODI 11289657

WHEN I FIRST PURCHASED THE VEHICLE THE ENGINE LIGHT WOULD CONSTANTLY COME ON AND GO OFF BUT NOW THE ENGINE LIGHT IS ALWAYS ON. I JUST RECENTLY STARTED HAVING ISSUES WITH THE AIRBAGS ON THE PASSENGER SIDE NOT BEING ENGAGED AND THE ENGINE ESC COMES ON WHENEVER IT PLEASES, EVEN WHEN THE WEATHER IS GOOD OUTSIDE. LAST WEEKEND, MY BATTERY DIED FOR THE FIRST TIME, I'M JUST GLAD THAT I HAD SOMEONE TO JUMP ME OFF. MY PRIMARY CONCERN IS MY HEADLIGHTS. I HAVE GOTTEN PULLED OVER BY THE POLICE 3 TIMES DUE TO MY INTERMITTENT HEADLIGHTS. THE FIRST TIME MY RIGHT SIDE HEADLIGHT WENT OUT, A OFFICER PULLED ME OVER AND INFORMED ME OF THE ISSUE, SO I GOT IT FIXED THE VERY NEXT DAY. A WEEK GOES BY AND I GET PULLED OVER AGAIN AND THE OFFICER INFORMED ME BUT THIS TIME I INFORMED THE OFFICER THAT I JUST CHANGED THE BULB A WEEK AGO AND HE MENTIONED THAT IT COULD BE THE WIRING. AFTER THE OFFICER LEFT, I GOT OUT MY CAR AND HIT THE HEADLIGHT WITH MY FIST AND IT CAME BACK ON JUST TO GO BACK OUT THE NEXT DAY. I WENT TO MY LOCAL MECHANIC AND HE CHANGED THE LIGHT BULB SOCKET. THAT ONLY LASTED 3 OR 4 WEEKS AND NOW I LITERALLY HAVE TO RIDE WITH MY HEADLIGHTS ON BRIGHT OR CAN'T BE OUT AT NIGHT. AFTER GOING TO MULTIPLE AUTO SHOPS, THEY ALL SAYS THAT IT'S THE WIRING, WHICH I ALREADY KNEW BECAUSE THE GAGES ON MY DASHBOARD LIGHTS UP LIKE CHRISTMAS LIGHTS EVERY OTHER DAY.

NHTSA ODI 11289769

STARTING PROBLEM TOWED AND WORKED ON ON SEVERAL OCCASIONS. MECHANIC REPLACED FUEL PUMP, ECM RELAY, ETC. ALL FIXED THE PROBLEM TEMPORARILY.MECANIC REFUSES TO WORK ON THE CAR NOW, CAN'T FIND THE PROBLEM. WE KNOCK ON THE FUSE BOX IN THE TRUNK AND GET IT TO RUN BUT NOW DIES RANDOMLY. THE LAST TIME I DROVE IT, IT DIED IN A BLIND INTERSECTION AND I WAS ALMOST T-BONED.

NHTSA ODI 11288306

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. WHILE THE VEHICLE WAS AT A STANDSTILL, THE SEAT BELT CABLE FRACTURED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V269000 (SEAT BELTS). THE VEHICLE WAS TAKEN TO GATEWAY CHEVROLET CADILLAC (LOCATED AT 501 38TH ST S, FARGO, ND 58103, (701) 282-5522) WHERE IT WAS DIAGNOSED THAT THE PRETENSION CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.

NHTSA ODI 11288168

IN THE PAST FEW YEARS MY HEADLIGHT KEEPS GOING OUT. I REPLACE THE BULB AND LIKE A MONTH LATER IT GOES OUT AGAIN. WENT TO REPLACE AGAIN AND BULB WAS FINE BUT BAD WIRING. FIXED THAT AND TODAY NOW BOTH HEADLIGHTS ARE OUT. I JUST REPLACED THEM IN THE SUMMER NOT SURE HOW THEY CAN BE OUT AGAIN! IT IS NOT AN EASY PROCESS TO GET TO THESE LIGHTS MAKING IT A LOT OF WORK AND MONEY IF I DONT DO IT MYSELF WHICH NOW THAT ITS NEGATIVE OUT I WILL BE PAYING TO GET THIS FIXED YET AGAIN. I WAS JUST LEAVING THE GROCERY STORE TURNED THEM ON AND THEY WERE NOT WORKING.

NHTSA ODI 11288260

MY 2011 MALIBU HAS FAULTY HEADLIGHTS THAT CONTINUOUSLY GO OUT AND CANNOT BE CHANGED WITHOUT REMOVING THE FRONT BUMPER WHICH REQUIRES THE ASSISTANCE OF A MECHANIC AND THEREFORE COSTS HUNDREDS OF DOLLARS TO DO. EVEN AFTER THE BULB IS CHANGED, IT HAS BEEN KNOWN TO GO OUT AGAIN AS QUICKLY AS HOURS LATER. THIS CREATES UNSAFE DRIVING CONDITIONS AS OFTEN TIMES THE OUTAGES OCCUR SPONTANEOUSLY, AT NIGHT, AND ON DARK ROADWAYS. IT IS BECOMING INCREASINGLY DANGEROUS AND FINANCIALLY TAXING TO OWN AND OPERATE THIS VEHICLE DUE TO THE PROBLEMS WITH THE HEADLIGHTS.

NHTSA ODI 11287386

YEAR 2008-2012 MODELS HAVE A REOCCURRING HEADLIGHT PROBLEM. THE HEADLIGHT BULBS / CONNECTORS TEND TO BURN OUT AT AN ACCELERATED RATE. CAUSING REMOVAL OF FRONT BUMPER JUST TO ACCESS HEADLIGHT HOUSING. PRICING RANGING $100-$150 PER HOUR JUST IN LABOR.

NHTSA ODI 11282910

NUMEROUS DASH LIGHTS RANDOMLY COME ON SERVICE ESC SERVICE TRACTION CONTROL ENGINE POWER REDUCED ENGINE POWER REDUCED FOLLOWED BY ENGINE DISABLED . AT THAT POINT THE ENGINE DIES AND YOU ARE UNEXPECTEDLY FACED WITH THE SURPRISED HORROR OF BEING AT A ROLL UN ABLE TO POWER OUT OF THE WAY OF TRAFFIC .AND AT THE MERCY OF THE EXACT LOCATION OF ALL THESE THINGS SUDDENLY HAPPENING AT RANDOM ALL THE WARNINGS ARE QUICK SO QUICK U HAVE NO TIME TO PULL OVER BEFOR YOU ARE AT A DEAD ROLL . TODAY MY MOM N ME AS WELL AS MY GIRLFRIEND WERE ALL MOST KILLED BY A SEMI TRUCK CARRYING HOT ASPHALT . I COULDNT IMAGINE HAVING TO BE SMASHED TO DEATH WITH NO CHANCE TO REACT AND TO TOP IT OFF POSSIBLY EVEN BURNED TO DEATH CRUSHED ALL WHILE HAVEING TO HEAR MY MOTHERS SCREAMS IN MY LAST MOMENTS OF LIFE.PLEASE LOOK INTO THIS PROBLEM I'VE RESEARCHED ONLINE AND IVE FOUND MANY FORMS WHERE PPL AREHAVEIBG SIMPLER ISSUE. THE WHOLE SMASHED BURNED BY HOT ASPHALT SENERIO WAS ONLY A FLASH OF IMAGES I IMAGINED BUT THE FIVE FOOT OF SPACE BETWEEN THE TRUCK THAT FACT ALL MOST SIDE SWIPED US TODAY IS AND WAS FACT THAT CAUSESD THIS HORRIBLE VISION DUE TO THE DEFECTIVE ENGINEERING IN SOME DESINE OF THE CAR SHE BOUGHT ONLY DAYS AGO FROM HWY 59 MOTORS CAR LOT . THANK YOU

NHTSA ODI 11282564

I HAVE BEEN DRIVING MY CAR EVERYDAY AND ON SUNDAY 11/24/19, I REVERSED FROM DRIVEWAY AND WHEN SHIFTED TO DRIVE THE CAR WOULD NOT MOVE. I TRIED NEUTRAL AND MANUAL AND NOTHING BUT THE REVERSE WAS FINE. AN ODD THING IS THAT IT IS THE TRANSMISSION OIL SUPPLY LINE, A SMALL PIECE THAT DOESN'T MOVE AT ALL SO NOT SURE HOW IT WAS DAMAGED WHICH IS CAUSING THE CAR TO NOT MOVE WHEN IN DRIVE. THIS DEFINITELY IS AN ISSUE WITH GMC CARS AS I HAVE RESEARCHED IT IN MULTIPLE CHEVY BLOGS. IF A MECHANIC IS NOT FAMILIAR WITH THIS SMALL CAUSE THEY WOULD SUGGEST TO REPLACE THE ENTIRE TRANSMISSION UNNECESSARILY WHICH IS A VERY EXPENSIVE REPAIR FOR SOMETHING SIMPLE.

NHTSA ODI 11282361

I HAVE CONTINUOUSLY HAD TO CHANGE MY PASSENGER HEADLIGHT BULBS AND THAT IS A HAZARD AND WITHOUT THEM YOU GET A TICKET. THIS HEADLIGHT HAS GONE OUT AT LEAST 3 TIMES A YEAR. I AM DRIVING WHEN IT HAPPENS AND IF I GET OUT AND HIT THE HEADLIGHT IT MAY OR MAY NOT COME BACK ON. THIS STARTED ABOUT 2 YEARS AGO

NHTSA ODI 11281074

AIR BAG LIGHT STAYED ON ALL THE TIME WHILE DRIVING. PROVIDE FORM TO SEND TO GENERAL MOTORS TO REFUND ME THE $700 PLUS DOLLARS OUT OF POCKET TO FIX THE PROBLEM.

NHTSA ODI 11280531

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS A LOUD EXPLOSION FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE BRAKE PEDAL WAS DEPRESSED, BUT WAS INOPERABLE. THE CONTACT WAS ABLE TO SAFELY DRIVE THE VEHICLE TO THE RESIDENCE. THE VEHICLE WAS DIAGNOSED AT THE RESIDENCE BY A MOBILE MECHANIC AND THE CONTACT WAS INFORMED THAT THE CALIPER DISINTEGRATED. THE CONTACT STATED THAT THIS WAS THE SECOND TIME THE FAILURE OCCURRED. THE VEHICLE WAS REPAIRED THE FIRST TIME, BUT A SECOND REPAIR WAS STILL PENDING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.

NHTSA ODI 11280009

MY POWER STEERING KEEPS GOING IN AND OUT WHILE I'M DRIVING. THE SERVICE ESC LIGHT APPEARS AND THEN WILL TURN OFF WHEN I TURN MY CAR OFF

NHTSA ODI 11279517

FINANCING A CAR THROUGH DEALERSHIP AND FOUND OUT THE ODOMETER HAS BEEN ROLLED BACK ODOMETER READING 62,634 WHEN PURCHASED 2 MONTHS AGO AND IT STILL READS THE EXACT SAME NOW. LOOKED UP VIN NUMBER AND IN MAY 2019 MILEAGE WAS REPORTED AS 63,789

NHTSA ODI 11279141

I HAVE A 2011 CHEVY MALIBU AND THE PASSENGER HEADLIGHT KEEPS GOING OUT. NOT BURNING OUT, BUT QUITS WORKING! I CHANGED THE BULB ABOUT 5 TIMES BEFORE I REALIZED THAT IT WASN'T BURNING OUT. ALL THE OTHER LIGHTS ON THAT SIDE WORK FINE. A FEW TIMES I COULD TAP ON THE HEADLIGHT ASSEMBLY AND IT WOULD COME BACK ON. I TOOK IT APART AND FOUND THAT THE PLASTIC CONNECTOR WAS BROKEN AND SHORTED OUT, SO I ORDERED A NEW WIRING HARNESS THAT GOES FROM THE GROUND WIRE SPLIT TO THE HEADLIGHT ASSEMBLY, PUT IT TOGETHER AND IT WORKED FINE FOR 2 DAYS AND WENT OUT AGAIN. I TOOK THE FRONT END OFF AGIAN AND UNPLUGGED THE BULB AND PLUGGED IT BACK IN AND IT WORKS FINE AGAIN. I HAVE CHECKED ALL THE WIRES AND THE GROUND SCREW AND CAN'T FIND A PROBLEM.

NHTSA ODI 11278753

THESE ARE RECALLS THAT I WAS NEVER MADE AWARE OF AND HAVE NOT BEEN REPAIRED.

NHTSA ODI 11278274

TIRES GO FLAT REALLY FAST. THE ELECTRICAL SYSTEM IS NOT READY MY TIRES NO MORE AND DON'T SHOW IF THERE'S AN ISSUE INCLUDING AIRBAGS. THE LIGHT WAS ON FOR A MONTH AND WEN TAWAU I GOT HIS IN THE FRONT OF MY CAR AND MY AIRBAGS DIDN'T NOT DEPLOY.

NHTSA ODI 11277748

THE PASSENGER SIDE HEAD LAMP IS CONSTANTLY IN NEED OF REPAIR. AFTER REPLACING THE DIM BULB SEVERAL TIMES, I HAD THE WIRING REPLACED TO FIX IN AN ATTEMPT TO FIX THE FAULTY LIGHTING. THIS STILL DID NOT FIX THE PROBLEM AND THE R.H. PASSENGER DIM LAMP IS OUT AGAIN. THIS IS A PROBLEM FOR ALL 2009 - 2011 CHEVY MALIBU VEHICLES. THE LIGHTING, ONCE REPLACED, WORKED FOR A SHORT PERIOD OF TIME THEN IT GOES OUT. I AM AT THE POINT OF REPLACING THE HEAD LAMP ASSEMBLY WHICH IS PRICEY. THE REPAIRS WERE DONE SEVERAL TIMES BEGINNING IN 2018.

NHTSA ODI 11277838