What 976 owners told NHTSA about the 2011 Chevrolet Malibu Hev

THE ENGINE LIGHT APPEARS THE LIGHT COMES ON AND SAYS ENGINE POWER REDUCED, SERVICE TRACTION, SERVICE ESC THIS APPEARS AT RANDOM SPEEDS AND EVEN WHEN IM SETTING AT THE BANK WITH MY CAR IN PARK IT HAS OCCURRED. THIS IMMEDIATELY REDUCES YOUR CARS POWER AND YOU CAN ONLY RUN ABOUT 30 MPH WHICH IS VERY DANGEROUS. THIS USED TO START BY SAYING ICE POSSIBLE AND THEN ALL THE ABOVE WOULD BEGIN. NOW AFTER HAVING THE BREAK RECALL COMPLETED THIS IS HAPPENING MORE FREQUENTLY IT HAS HAPPENED AT LEAST 4 RANDOM TIMES IN ONE WEEK. YOU CAN ONLY CLEAR THIS BY SHUTTING OFF YOUR ENGINE AND LETTING IT SET FOR SEVERAL MINUTES. *TR

NHTSA ODI 10664461

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE VEHICLE WAS TOWED TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. AFTER APPROXIMATELY THREE MONTHS, THE DEALER STATED THAT THE FUEL LINES NEEDED TO BE CLEANED AND CARBON BUILDUP FROM THE INTAKE VALVES NEEDED TO BE REMOVED. IN ADDITION, THE DEALER REPROGRAMMED THE CODES AND PERFORMED A FUEL INDUCTION CLEANING. AFTER THE REPAIRS WERE PERFORMED, THE AIR BAG, THE BRAKES, THE SEAT BELT, AND THE ENGINE WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), BUT WAS UNAWARE IF THE RECALL REPAIR WAS PERFORMED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REAR FUSE BOX AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 86,687.

NHTSA ODI 10663558

2011 CHEVY MALIBU WITH 30,000 MILES. SEVERAL TIMES IN THE PAST WEEK, I WAS AT A RED LIGHT OR STOP SIGN AND THE CAR JUST QUIT! THIS IS A SAFETY DANGER. SOMEONE IS GOING TO GET BADLY HURT OR KILLED. THE DEALERSHIP DOESN'T FIND ANYTHING WRONG. THIS IS A HUGE SAFETY ISSUE!!

NHTSA ODI 10663572

HAD ISSUES WITH STEERING PROPERLY, I HAD TO PULL OVER AND WAIT ON THE SIDE OF THE ROAD UNTIL SOME ONE CAME OUT TO HELP PULL THE CAR HOME. THE SCARY PART WAS THAT THIS HAPPENED DURING RUSH HOUR. *TR

NHTSA ODI 10663600

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE SEATED ON THE FRONT DRIVER'S SIDE, THE SEAT BELT DETACHED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STEEL CABLE FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 1/21/15*CN UPDATED 01/26/15*JB

NHTSA ODI 10663663

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ODI 10663438

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE ESC AND EPS WARNING LIGHTS ILLUMINATED. THE STEERING WHEEL SEIZED AND EXCESSIVE FORCE WAS REQUIRED BUT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSIS WHERE THE TECHNICIAN STATED THAT THE POWER STEERING MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 14E044000 (STEERING). THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

NHTSA ODI 10663475

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE SERVICE ESC AND THE TRACTION CONTROL WARNING LIGHTS ILLUMINATED. THE CONTACT MENTIONED THAT THERE WAS A SUDDEN INCREASE OF ENGINE RPMS. HOWEVER, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS ABLE TO RESTART BUT THE FAILURE PROGRESSED OVER TIME. SEVERAL MONTHS LATER, THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS SERVICED UNDER THE RECALL AND THE TECHNICIAN STATED THAT THE CAM SHAFT POSITION ACTUATOR SOLENOID VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO DIAGNOSED THAT THE THROTTLE BODY ASSEMBLY WOULD NEED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 85,656.

NHTSA ODI 10662890

THE SERVICE AIR BAG INDICATOR LIGHT REMAINS LITE AND THE WORDS STAY ON THE DISPLAY WINDOW. HAD A DIAGNOSTIC DONE ON THE CAR ON 11/29/2014 AND WAS TOLD THAT THE COMPUTER MODULE IS BAD AND NEEDS TO BE REPLACED. I WAS TOLD THAT IF IN A ACCIDENT THAT THE AIR BAGS MIGHT NOT DEPLOY. COULD THIS ALSO CAUSE THE AIR BAGS TO DEPLOY UNEXPECTEDLY? IF THIS IS A SAFTEY ISSUE, SHOULDN'T IT BE COVERED NO MATTER IF THE WARRANTY/EXTENDED WARRANTY HAS EXPIRED? *JS

NHTSA ODI 10661507

AS I WAS DRIVING DOWN THE HIGHWAY, MY SERVICE AIR BAG LIGHT ILLUMINATED. ONSTAR WAS CALLED AND THEY DIAGNOSED THE CAR AS HAVING AN MALFUNCTION IN THE AIR BAG, PULLED OFF TO THE SIDE OF THE ROAD AND HAD CAR TOWED TO NEAREST DEALERSHIP. AS I WAS WAITING FOR THE TOW COMPANY TO ARRIVE, I TRIED TO START THE VEHICLE AFTER 2 HOURS TO WHICH ALL LIGHTS STARTED FLASHING AND CAR WENT COMPLETELY DEAD. NOTE, CAR WAS JUST IN THE SHOP 2 DAYS PRIOR FOR OIL CHANGE AND RECALL ON BCM. DEALERSHIP CAME BACK WITH A $1200.00 ESTIMATE FOR REPAIR OR REPLACEMENT OF AN AIRBAG. $858.00 FOR THE AIRBAG REPLACEMENT AND $241.00 FOR A NEW BATTERY. DEALERSHIP WOULD NOT COVER THIS UNDER WARRANTY STATING SOMETIMES ELECTRONICS HAVE ISSUES. *JS

NHTSA ODI 10661630

I WAS DRIVING THE MALIBU ON THE HIGHWAY AND THE STEERING WHEEL BEGAN SHAKING AND THE DASH BOARD INDICATED THAT THE POWER STEERING WAS OUT AND THAT THE ESC MUST BE SERVICED. I TOOK THE CAR TO CHEVROLET AND WAS TOLD THAT THERE IS A RECALL ON THIS ISSUE BUT MY VIN WAS NOT COVERED. THE MECHANIC SAID THAT MY ISSUE WITH THE MALIBU IS THE SAME ISSUE THAT IS CURRENTLY LISTED AS A RECALL FOR OTHER MALIBU (S) OF THE SAME YEAR. THIS HAS HAPPENED MANY TIMES. I SEARCHED FOR THIS ISSUE WITH OTHER MALIBU OWNERS AND LEARNED THAT THIS IS A COMMON ISSUE. THIS IS VERY DANGEROUS AND SCARY ESPECIALLY WHEN DRIVING ON THE HIGHWAY. I HAVE HIGH MILEAGE BECAUSE I DRIVE 160 MILES TO WORK EACH DAY. PLEASE ADD MY CAR VIN TO THE RECALL LIST. *TR

NHTSA ODI 10661325

I WAS DRIVING MY VEHICLE ON AT 50 MPH AND VEHICLE REDUCED TO A UNSAFE SPEED WITH THE ERROR MESSAGES "SERVICE TRACTION" "ESC OFF" AND "ENG PWR REDUCED". THE UNSAFE DROP IN SPEED ALMOST CAUSED A CAR TO HIT ME IN THE BACK. THIS IS A VERY SCARY PROBLEM AND IF I WAS ON THE EXPRESSWAY AND THIS OCCURRED SOMETHING VERY BAD COULD HAVE HAPPEN. A RECALL ON THE VEHICLE OR THE THROTTLE BODY NEED TO BE MADE PUBLIC BEFORE SOMEONE IS SERIOUSLY INJURE DUE TO THIS FLAW! *TR

NHTSA ODI 10661266

WHILE DRIVING DOWN THE HIGHWAY, MY POWER ENGINE WARNING CAME ON AND THE SAME AS WARNING LIGHTS FOR ESC AND TRACTION WARNING. I JUST RECENTLY TOOK MY CAR INTO THE DEALER FOR FIXING THE RECENT RECALL PROBLEM AND I WONDER IF IT MADE MY CAR WORSE?? WILL BE STOPPING BY MONDAY MORNING...IF I MAKE IT HOME OK AFTER I'VE HAD TO STOP AND PULL OVER TWICE TO FIX THE PROBLEM. *TR

NHTSA ODI 10660300

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 70 MPH, THE POWER ENGINE REDUCED SENSOR LIGHT ILLUMINATED AND THE SPEED SUDDENLY REDUCED TO APPROXIMATELY 40 MPH. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD WHERE IT WAS TURNED OFF AND RESTARTED. THE VEHICLE RESUMED NORMAL OPERATION, BUT THE FAILURE RECURRED ON MULTIPLE OCCASIONS AND WOULD ONLY OCCUR IN COLDER WEATHER CONDITIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 73,000.

NHTSA ODI 10655372

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT INDICATED THAT THE ESC SENSOR, TRACTION CONTROL SENSOR, AND THE ENGINE REDUCED POWER WARNING SENSOR ILLUMINATED SEVERAL TIMES. THE CONTACT MENTIONED THAT THE FAILURE MAINLY HAPPENED DURING COLD WEATHER. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE RECALL FAILED TO REMEDY THE FAILURE. IN ADDITION, THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 70 MPH, THE VEHICLE STARTED TO SHAKE VIOLENTLY AND DRASTICALLY REDUCED TO 10 MPH WHICH MADE OPERATING THE VEHICLE EXTREMELY DIFFICULT. THE VEHICLE WAS MERGED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

NHTSA ODI 10655417

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. WHEN ATTEMPTING TO ACCELERATE FROM A STOP, THE VEHICLE FAILED TO ACCELERATE. THE CONTACT HAD TO RESTART THE VEHICLE IN ORDER FOR IT TO RESUME NORMAL OPERATION. HOWEVER, THE FAILURE PERSISTED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 8,700.

NHTSA ODI 10655087

2011 CHEVROLET MALIBU CONSUMER IS REQUESTING REIMBURSEMENT FOR BRAKE REPLACEMENT.. *CW

NHTSA ODI 10653285

2011 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO VEHICLE SUDDEN ACCELERATION. *SMD THE CONSUMER ATTEMPTED TO SLOW THE VEHICLE DOWN BY APPLY THE BRAKE, BUT TO NO AVAIL. AS THE VEHICLE CONTINUED TO ACCELERATED WITH RPM'S REACHING 7.5 WITH THE ENGINE LIGHT ON. SHE ATTEMPTED TO SLOW THE VEHICLE DOWN BY DRIVING ALONG SIDE OF A CORNFIELD IN THE GRASS WHICH WAS ALSO UNSUCCESSFUL/ IT WAS AT THAT POINT SHE SHIFTED THE GEAR INTO PARK, WHICH JOLTED HER SIDEWAYS. THE VEHICLE THEN SKIDDED UNTIL SHE STOPPED ON AN INCLINE IN AN AREA NEAR THE CORNFIELD. *JB

NHTSA ODI 10651205

SERVICE AIRBAG LIGHT CAME ON WHEN I STARTED MY CAR ITS BEEN TWO DAYS NOW AND IT HASNT GONE AWAY IVE NEVER HIT ANYTHING NOR HAVE I BEEN HIT BY ANYONE... *TR

NHTSA ODI 10651939

I WAS DRIVING ON THE HIGHWAY WHEN SUDDENLY THE WARNING "SERVICE AIR BAG" POPPED UP ON MY DASHBOARD MESSAGE SCREEN. I WAS NOT IN AN ACCIDENT NOR DID I HIT ANYTHING. WITH THE RECENT RECALLS, I AM VERY CONCERNED. *TR

NHTSA ODI 10649210

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT UPON ENTERING THE VEHICLE, AN ABNORMAL NOISE AND SMOKE STARTED TO EMIT FROM THE VENTS. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT WIRES WERE BURNED AND DISCONNECTED THE BATTERY AS A PRECAUTION. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.

NHTSA ODI 10648721

I WENT TO GET AIR IN TIRE. GOT BACK IN MY CAR AND STARTED IT UP. IT STARTED SHAKING REAL BAD AND ENGINE LIGHT CAME ON , CHECK ENGINE LIGHT CAME ON, AND A THING ABOUT LOSS OF POWER. I WAS ONLY 5 MINUTES FROM HOME SO I WENT BACK HOME. IT WOULDN'T GET OVER 25 MILES AN HOUR. I CALLED EDWARD CHEVROLET IN BIRMINGHAM,AL. THEY TOLD ME TO GET CAR TO THEM BUT NOT DRIVE IT. THEY CALLED ME BACK AND SAID IT WASN'T UNDER WARRANTY. I DON'T EVEN HAVE 100,000 ON IT. I READ ON LINE OTHER PEOPLE HAD THIS PROBLEM BUT THEY SAY IT'S NOT ON RECALL. WHY? HOW MANY PEOPLE HAVE TO DIE OR CHILDREN? I DIDN'T READ OF ANY DEATHS JUST ALMOST. I CAN'T BELIEVE PEOPLE HAVE TO DIE TO GET SOMETHING DONE. I WAS LUCKY AND NOT FAR FROM HOME. IT COULD HAVE STOPPED ON ME IN MIDDLE OF ROAD. I'VE NEVER GOT ANY RECALL NOTICES. I TOLD THE LADY AT EDWARDS CHEV. THE SAME THING. *TR

NHTSA ODI 10643072

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 35 MPH, BURNING FUMES WERE PRESENT INSIDE THE VEHICLE AND SMOKE APPEARED OUT OF THE FRONT BUMPER. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE BATTERY CABLE CAUGHT FIRE. THE CONTACT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

NHTSA ODI 10641615

TL* THE CONTACT OWNS A 2011 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT DRIVER SIDE HEADLIGHT FAILED INTERMITTENTLY. THE DEALER STATED THAT THE HEADLIGHT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 50,000.

NHTSA ODI 10641691

I WAS DRIVING AND THE PASSENGER AIR BAG LIGHT CAME ON AND WILL NOT SHUT OFF. I CALLED THE DEALER AND THEY WANT TO CHARGE ME JUST TO LOOK AT MY CAR. I HAVE NEVER BEEN IN ANY AUTO ACCIDENT FOR THIS TO EVEN HAPPEN. THIS MUST BE A DEFECTIVE AIR BAG> PLEASE CHECK INTO THIS MATTER. *TR

NHTSA ODI 10641781